Professional Documents
Culture Documents
Center of
NPS O.D. of Run
Nozzle O.D. to O.D.
to
OF to of Nozzle
End of Nozzle
NOZZLE End of Run C
B
A
2½ 114 76 76
3 127 89 89
Center of
NPS O.D. of Run
Nozzle O.D. to O.D.
to
OF to of Nozzle
End of Nozzle
NOZZLE End of Run C
B
A
2½ 152 114 152
Center of
NPS O.D. of Run
Nozzle O.D. to O.D.
to
OF to of Nozzle
End of Nozzle
NOZZLE End of Run C
B
A
2½ 140 76
3 152 76
4 178 89
5 203 102
6 254 127
8 305 152
MFR
10 356
Standard
178
12 406 216
14 432 229
16 483 254
18 533 279
20 584 305
24 660 356
TABLE 3 - 3
Notes:
1. MFR = Manufacturer
2. All nozzle welds should be checked for compliance with the applicable code requirements.
3. It is preferred that multiple branch openings of in-line nozzles be spaced so that their reinforcement
zones do not overlap. If closer specing is necessary, the reinforcement requirements of the applicable
construction code shall be met.
4. Some con gurations of integrally reinforced nozzles in combination with certain header sizes may
present a problem in the radiographic examination of the attachment weld due to inability to meet the
geometric unsharpness requirements of the construction code.
5. Where attachments such as anges, ttings valve and pipe insulation are involved, minimum dimensions
tabulated may have to be increased to allow for required clearances.
6. In special cases, it may be possible to reduce the dimensions given in the tables. Such design should then
be submitted to the fabricator for individual considerations, as close spacing may involve additional shop
operation to prevent, or correct distortion.
7. Integrally reinforced nozzles are considered to be the commercially available types.
http://www.wermac.org/documents/spacing-welded-nozzles.html 1/2
10/7/2018 Minimum Length and Spacing for Welded Nozzles
8. In cases of di erent nozzle diameters, dimension C, should be determinded on the basis of the larger of
the two of adjacted nozzles.
EXPLORE the WORLD of PIPING Certain materials and combinations of nozzle and header pipe size and wall thickness together Menu ☰
with multiple branch openings welded to a header may result in distortion of the header pipe.
http://www.wermac.org/documents/spacing-welded-nozzles.html 2/2