Professional Documents
Culture Documents
Design Power Diode Three Phase Half Wave and Full Wave Controlled
Rectifiers
Lab Safety Rules:
o Be sure of the condition of the equipment.
o Never rely on safety devices.
o Grounding should be done.
o Circuit should be clean avoid cluttered environment.
o Floor should not be wet.
o Use if possible one hand for practically performing.
o Never use ring etc.
o Never talk during the performing.
o Be slowly or cool and calm in lab.
o Resistors can burn your skin be aware of it.
o Discharge capacitors.
Lab Objectives:
When you completed this lab, you will be familiar with,
o Three Phase half and full wave Controlled Rectifiers.
o The waveforms of the voltages and currents present in these Rectifiers.
o How to calculate the average dc voltages provided by each type of rectifier.
o Advantages of three phase rectifiers over single phase rectifiers and about dual polarity dc
power supply.
Introduction:
A three phase half and full wave controlled rectifier with a positive polarity output converts
three phase ac voltage into positive dc voltages. The half wave rectifier consists of three
thyristors connected between a three phase ac power source and a load and full wave consists
of six thyristors connected between three ac power source without a neutral terminal both
circuit diagrams are given below.
A T1
B T2
L
C O
T3
A
D
N
Three Phase
Power Source Three Phase Half Wave Controlled Rectifier
C T6 T4 T2
Three Phase
Power Supply
Simulation:
Half Wave Rectifier:
Circuit Diagram:
X1
2N1595
V1 = 0 V4 V
V1 V2 = 5
VOFF = 0 V TD = 1.67m
VAMPL = 311 TR = 0.001u
FREQ = 50 TF = 0.001u
AC = PW = 2m 0
PER = 20m
X2
OUTPUT
2N1595
V2 V
VOFF = 0 V V1 = 0 V5 V
VAMPL = 311 V2 = 5
FREQ = 50 TD = 8.33m
AC = TR = 0.001u
TF = 0.001u R1
PW = 2m 0 1100
PER = 20m
X3
V3 2N1595
VOFF = 0 V
VAMPL = 311 V1 = 0 V6
FREQ = 50 V2 = 5 V
AC = TD = 15m
TR = 0.001u
TF = 0.001u
PW = 2m 0
PER = 20m
0
Output Waveform:
V1 = 0 V4
V2 = 5 V1 = 0 V6 V1 = 0 V9
VOFF = 0 V1 TD = 1.67m V2 = 5 V2 = 5
TR = 0 TD = 1.67m TD = 1.67m
VAMPL = 220 TF = 0 TR = 0 TR = 0
FREQ = 50 PW = 1ms 0 TF = 0 TF = 0
AC = PER = 20ms PW = 1ms 0 PW = 1ms 0
0 PER = 20ms PER = 20ms
V2 R1
VOFF = 0 1k
VAMPL = 220
FREQ = 50
AC =
0
V3
VAMPL = 220
VOFF = 0
FREQ = 50 X2 X4 X6
AC = 2N1595 2N1595 2N1595
0
V1 = 0 V5
V2 = 5 V1 = 0 V7 V1 = 0 V8
TD = 1.67m V2 = 5 V2 = 5
TR = 0 TD = 1.67m TD = 1.67m
TF = 0 TR = 0 TR = 0
PW = 1ms 0 TF = 0 TF = 0
PER = 20ms PW = 1ms 0 PW = 1ms 0
PER = 20ms PER = 20ms
Output Waveforms:
Question Answers: