Professional Documents
Culture Documents
1. For a given water-cement ratio in concrete with passage of time, the ‘permeability’
[a] increases [b] decreases
[c] does not change
[d] first increases and then decreases
[e] none of the above
6. Which of the following types of concrete mixers is most commonly used in precast
concrete factories?
[a] truck mounted mixer
[b] dual alumina mixer
[c] dual drum mixer
[d] tilting alumina mixer
[e] pan type mixer
Page 1 of 10
Diploma-Civil
11. In case of timber structures, the form factor for solid circular cross-section is taken
as ?
[a] 1.18 [b] 1.414
[c] 1.67 [d] 1.81
[e] 1.76
13. The bracing provided in the plane of end posts is called ___________ ?
[a] sway bracing
[b] rapid bracing
[c] top lateral bracing
[d] bottom lateral bracing
[e] portal bracing
15. What is the mix ratio of Cement : Sand : Aggregate for M 20 mix ?
[a] 1:2:4 [b] 1:3:6
[c] 1:4:8 [d] 1:2:3
[e] 1 : 1.5 : 3
16. When a uniformly distributed load, shorter than the span of the girder, moves from
left to right, then the conditions for maximum bending moment at a section is that
[a] the head of the total reaches the section
[b] the tail of the load reaches the section
[c] the load position should be such that the section divides it equally on both
sides
[d] the load position should be such that the section divides the load in the
same ratio as it divides the span
Page 2 of 10
Diploma-Civil
17. When a uniformly distributed load, longer than the span of the girder, moves from
left to right, then the maximum bending moment at mid section of span occurs
when the uniformly distributed load occupies
[a] less than the left half span
[b] whole of left half span
[c] more than the left half span
[d] equal to the left half span
[e] whole span
21. A stone was thrown vertically upwards from the ground with a velocity of 50 m/sec.
After 5 seconds another stone was thrown vertically upwards from the same place.
If both the stones strike the ground at the same time, what is the velocity with
which the second stone was thrown ? (Assume g = 10 m/s)
[a] 15 m/sec [b] 25 m/sec
[c] 30 m/sec [d] 40 m/sec
[e] 50 m/sec
24. The stage of river carrying a discharge of Q m 3/sec at a point is 10 m and slope of
water surface is (1/4000). The discharge of a flood at the same point and same
stage of 10 m with a water surface slope of (1/1000) will be ?
[a] √2 Q m3/sec [b] 0.5 Q m3/sec
[c] 1.5 Q m3/sec [d] 2.0 Q m3/sec
[e] 4.0 Q m3/sec
Page 3 of 10
Diploma-Civil
25. Which of the following methods of theodolite traversing is suitable for locating the
details which are far away from transit stations ?
[a] by measuring angle and distance from one transit station
[b] by measuring angles to the point from at least two stations
[c] by measuring angle at one station and distance from other
[d] by measuring distance from two points on traverse line
[e] by measuring distance from two transit stations
28. Which of the following is considered to be the highest quality construction in the
group of black top pavements?
[a] mastic asphalt [b] sheet asphalt
[c] bituminous carpet [d] bituminous concrete
[e] none of the above
29. Expansion joints in cement concrete pavements are provided at an interval of ______?
[a] 10 m [b] 15 m
[c] 18 m to 21 m [d] 20 m to 25 m
[e] 25 m to 30 m
30. To carryout normal consistency test, Vicot apparatus plunger ‘Diameter’ is kept ?
[a] 1 mm [b] 5 mm
[c] 10 mm [d] 15 mm
[e] 20 mm
31. A hill road is one which passes through a terrain with a cross slope of ?
[a] 0 to 10% [b] 10 to 25%
[c] 20 to 40% [d] 30 to 50%
[e] 25 to 60%
32. The minimum design speed for hairpin bends in hill roads is taken as ?
[a] 10 kmph [b] 20 kmph
[c] 30 kmph [d] 40 kmph
[e] 50 kmph
Page 4 of 10
Diploma-Civil
34. Which of the following devices is used to transfer the wagons or locomotives, to and
from parallel tracks without any necessity of shunting ?
[a] triangle [b] turn table
[c] traverser [d] scotch block
[e] square block
40. From the point of view of maximum ‘day light’, the windows in a room should be
located on
[a] eastern side
[b] western side
[c] northern side
[d] southern side
[e] does not depend on side
41. Half turn stairs are the stairs, which change their direction through ________ ?
Page 5 of 10
Diploma-Civil
42. The minimum number of holdfasts recommended on each side of a door frame and a
window frame respectively are __________ ?
[a] 2 and 1 [b] 1 and 2
[c] 2 and 2 [d] 2 and 3
[e] 3 and 2
45. The property of metal which allows it to deform continuously at slow rate without
any further increase in stress is known as ?
[a] resilience [b] fatigue
[c] plasticity [d] creep
[e] toughness
47. Which one of the following help in fusion and provide red/yellow colour to the bricks ?
[a] Silica [b] Lime
[c] Alumina [d] Oxide of Iron
[e] Carbon
48. Over burnt, dark colour & irregular shape of bricks are classified as ____________ ?
[a] Second Class [b] First Class
[c] Fourth Class [d] Third Class
[e] Fifth Class
Page 6 of 10
Diploma-Civil
NON-TECHNICAL
51. If ‘a’ means ‘multiplied by’, ‘b’ means ‘divided by’, ‘c’ means ‘plus’ and ‘d’ means
‘minus’ , then
21 c 3 d 6 a 8 b 2 = ?
[a] 72 [b] 0
[c] 48 [d] 1
[e] None of the above
52. In a certain code “NOBLE” is written as “QREOH”. How is “PLATE” written in that
code ?
53. Introducing a woman, a man said, ‘Her father’s only son is my father’. How is the
man related to the woman ?
54. Golu is the son of Bhola. Surma is the daughter of Golu. Chunni is the daughter of
Dabu and Dabu is the brother of Bhola. What relation does Chunni bear to Surma ?
55. How many 8’s are there in the following number series which are exactly divisible by
its immediately preceding and immediately succeeding numbers ?
7838481285481483882482858483
[a] 4 [b] 3
[c] 2 [d] 5
[e] None of the above
56. If every second Saturday and all Sundays are holidays in a 30 day month beginning
on Saturday, how many working days will be there in the month ?
[a] 22 [b] 20
[c] 23 [d] 21
[e] 24
57. Amar ranked 9th from the first and 14th from the last in Class VI. He ranked
5th from the first and 11th from the last among all those passed from Class VI.
How many students failed in Class VI ?
[a] 7 [b] 6
[c] 5 [d] 8
[e] Cannot be determined
Page 7 of 10
Diploma-Civil
58. If all the numbers from 1 – 21 exactly divisible by 2 are arranged in a series,
which would come at the sixth place counting from your right ?
[a] 8 [b] 12
[c] 6 [d] 14
[e] None of the above
59. If White is called Red, Red is called Yellow, Yellow is called Green and
Green is called Blue, which of the following will be the colour of turmeric ?
60. If the following words are arranged as in a dictionary, which would be third ?
Direction: The items in this part have four underlined words or phrases. You must
identify the one underlined expression – A, B, C or D – that must be changed for the sentence
to be correct. Then fill in the space on your answer sheet that matches the letter of the
answer that you have selected.
62. On nights when is the sky clear and the air calm, the earth’s surface rapidly radiates
A B C
heat into the atmosphere.
D
Page 8 of 10
Diploma-Civil
68. Six persons A, B, C, D, E and F sitting forming a circle and one is facing other front to front.
B is between A and C. E is between F and D. F is sitting straight opposite to A and right to E.
D is between which of the following pairs ?
[a] EF [b] AE
[c] AB [d] CF
[e] AF
In the following diagram there are three squares interlocking each other. Each square
represents a certain class. Study the diagram and answer the questions that follows :-
TEACHERS a
b
POETS
d c f
e
SINGERS g
69. Which letter represents poets and singers who are not teachers ?
70. Teachers who are poets but not singers are represented by letter ?
71. Which letter represents teachers who are poets as well as singers ?
72. Which letter represents teachers who are singers but not poets ?
73. Poets who are neither teachers nor singers are represented by letter ?
Page 9 of 10
Diploma-Civil
76. Who is the author of the book “My Experiments with Truth” ?
[a] Mohandas Karamchand Gandhi [b] Jawahar Lal Nehru
[c] Salman Rushdie [d] Vikram Seth
[e] Rabindra Nath Tagore
77. Rs.16000 are to be distributed between B and A such that B gets Rs.4000 less than
A. The ratio of the amount received by A to that received by B is ?
[a] 3 : 5 (b) 5 : 3
(c) 6 : 1 (d) 1 : 3
[e] 3 : 4
78. The greatest number of four digits which when divided by 3, 5, 7, 9 leaves
remainders 1, 3, 5, 7 respectively is ?
79. If the sum of two numbers exceeds their difference by 10, then the smaller of the
two numbers is ?
[a] 3 [b] 5
[c] 8 [d] 13
[e] 15
Page 10 of 10