Professional Documents
Culture Documents
00
IO-0210
GRAY/BINARY CODE TRANSFORMER CARD
HARDWARE MANUAL
IO-0210 Hardware Manual V1.00
This document has been created to be a guide for Arkel customers. Reproduction, transfer, distribution or storage of part or all
of the contents in this document in any form without the prior written permission of Arkel is prohibited. Arkel reserves the right
to make changes and improvements to any of the products described in this document without prior notice.
Arkel is not responsible for those mistakes that may be found in this manual and for the damages that they may cause.
IO-0210 Hardware Manual V1.00
1. IO-0210 Board
In some cases, programmable inputs and outputs cannot be enough. Then, this IO-0210 board would be useful. This board gives
2 inputs and 10 transistor outputs to the user.
Other 6 dipswitches (from 3(MSB) to 8(LSB)) works with a binary logic. For example;
MSB: Most Significant Bit (3rd dip-switch)
LSB: Least Significant Bit (8th dip-switch)
You can program 64 different IO-0210 boards for inputs.
IO-0210 Hardware Manual V1.00
2) MCU: By observing the behaviour of this LED, You can understand whether this board is working well or not. It should blink
synchronously. (If MCU is blinking with 1 long, 1 short time, the version of Arcode and IO-0210 are not proper. It needs to be
updated from –AREM “tools -> firmware update” after connected all units to CANbus line. Then, they will blink synchronously.)
3) 100 LED: This should give out a stable green light. If it is ON, 24V supply is good. If it is OFF, there is no 24 V supply.
4) X-CB1 and X-CB2 sockets are CANbus connections of the board. (Big and small size)
5) VCC LED: If it is stable green light, it means that the board is supplied well.
6) PROGRAMMABLE OUTPUTS: As mentioned above, this board gives 10 transistor outputs. You can adjust them from
parameter. (Tools → device parameters → programmable outputs → IO0210 board outputs) The number of group outputs are
adjusted with dip-switches 1 and 2.
7) PI INPUTS: IO-0210 board has 2 inputs. According to the dip-switches you adjusted, you can use it. (Tools → device
parameters → programmable inputs → IO-0210 board inputs)