Professional Documents
Culture Documents
Lighting arrestors
Vibration damper
Jumpers
1. SUPPORT
Support :
Pole, Tower, etc., which depends on the
size and height of the processing voltage.
SUPPORT – WOODEN, STEEL POLES
WOODEN POLES STEEL POLES
SUPPORT – RCC POLES
SUPPORT – TOWERS
2. CROSS ARM AND CLAMP
3. INSULATORS
Stays poll over his use of the guy wire clamp power
guys and the Insulator. transmission line fittings
5. CONDUCTOR
copper, Aluminium, or A.C.S.R Through a line of electric coductor power one place to
another must be in place.
Protective grounding jumper installation for two-pole and three-pole structures (grounded
structures). OGW denotes overhead ground wire. OGWs must be bonded to the worksite
grounding system if within reach of linemen. OGWs may be bonded to the cluster bars or to
the grounded phase conductors with protective grounds.
8. CONTINOUS EARTH WIRE
The most effective method of providing protection to transmission lines against direct
lightning strokes is by use of overhead ground wires as shown in Fig 6. For simplicity, one
ground wire and one line conductor are shown. The ground wires are placed above the line
conductors at such positions that practically all lightning strokes are intercepted by them (i.
e. ground wires). The ground wires are grounded at each tower or pole through a low
resistance as possible. Due to their proper location, the ground wires will take up all the
lightning strokes instead of allowing them to line conductors. The degree of protection
provided by the ground wires depends upon the footing resistance of the tower.
for easy handling of the jumper set by rubber gloves or hot-line tools
INSULATORS
Transmission and distribution system leak overhead line of the
by chance current can not flow, so that the line from the Earth, the
Insulator is used for the line. Insulator important role in system
operation.
Transmission line insulators are devices used to contain,
separate or support electrical conductors on high voltage electricity
supply networks. Transmission insulators come in various shapes
and types, including individual or strings of disks, line posts or long
rods. They are made of polymers, glass and porcelain--each with
different densities, tensile strengths and performing properties in
adverse conditions
TYPES OF INSULATORS
There are several types of insulators but the most commonly used
are pin type, suspension type, strain insulator and shackle insulator.
PIN TYPE INSULATORS