Professional Documents
Culture Documents
1. Drive/Show clearly with assumptions the flow rate between parallel stationary plates is
ℎ ( − )
=
12ɳ
2. Reservoirs A and B are connected by a capillary of bore 1.25mm and length of capillary
is 1250mm. as shown in fig 1. Pressure in reservoir A is 40N/cm2 and that of reservoir B
is 20 N/cm2. Calculate the rate of flow between the reservoirs is the tanks are filled with
an oil of viscosity 180 centi poise.
Fig. 1
3. Drive the Reynold’s equation for velocity and discharge in two dimensions with neat
sketch? And also Considering discharge through the element drive the expression for the
velocity and discharge?
4. A lightly loaded journal bearing has the following specifications:
Diameter of journal = 50mm
Bearing length =80mm
Viscosity of lubricant =10cP
Speed =4000rpm
Diametrical clearance ratio =0.002
Radial load =750 N
Determine frictional torque on the journal, Coefficient of friction, and Power loss
1
5. A full journal bearing has the following specification
Shaft diameter =70mm
Bearing length =80mm
Radial load 1=KN
Diametral clearance =0.1mm
Coefficient of friction =0.042
Oil used SAE 60 at 600c
Determine Speed of the journal, and Power loss
Note:
Maximum number of the group is Seven
Show each step clearly with neat sketches
Your hand writing should be clear and readable
Direct copy will not be allowed between the groups.