Professional Documents
Culture Documents
Transferability at Feeding Emboss Paper
Transferability at Feeding Emboss Paper
2. Cause
・lack of electric field at concave parts of paper
The electric current, which tends to flow into the convex part of paper and reduced flowing to
the concave part, causes failure of toner transportation at the concave part.
3. Solution
It is necessary to optimize electric field of concave parts between paper surface and transfer belt.
It must not exceed discharge starting voltage.
Caution1
Increase output current of the 2nd taransfer-Rear edge(177gsm and more than)
It is necessary to increase output current of the 2nd taransfer-rear edge due to offset of rear edge.
[Paper Setting] => [Process Adjustment] => [2nd transfer-rear edge(Front) or (Back)] => Input to [-20]
If toner density of rear edge gets lighter, input to [-25]
(change 5 steps at a time < [-25] => [-30] => >)
□Side effect:There is possibility that if solid color (more than 2 layered YMCK toners) gets lighter.
Caution2
If solid color (more than 2 layered YMCK toners) gets lighter, input to [+40] in [2nd transfer output
Adj.(Front) or (Back)].
(change 10 steps at a time < [+40] =>[+30] => >)
[2nd transfer-rear edfe(Front) or (Back) ]does not need to change.
-1-
KONICA MINOLTA Confidential
□Side effect:There is possibility that color registration and shock noise get worse.
□Side effect:There is possibility that fusing failure and line like ripple occur。
Caution
If fusing failure occur after density adjustment of toner amount, execute below.
Lower Speed setting (If the effct of [Upper Fusing Roller Temprature] is not sufficient.)
[Paper Setting] => [Weight] => [Speed Setting] => [Middle or Low]
Weight : 176gsm and less than => Execute to [Middle]
Weight : 177gsm - 256gsm => Execute to [Low]
When changing the setting from [Speed] which is the default, to [Better Quality] or [Best Quality],
productivity decreases.
-2-