Continuation of Block 8 of FAA Form 337 as attached
Dallas Aircraft Services Instructions for Continued Airworthiness for
'5025 Voyager Drive, Dallas Exec. Airport (C-10S Transponder Antenna Installation
Dallas, Texas 75237
CI-105 Transponder Antenna Doubler Installation
Instructions for Continued Airworthiness
For
N7IIBL Piper PA46-350P S/N 4636310
Dated 12-14-2005
Rev. Original
DAS Doc. 05121401
12-14-2005 Page 1 of 5Continuation of Block 8 of FAA Form 337 as attached
Dallas Aircraft Services Instructions for Continued Airworthiness for
5025 Voyager Drive, Dallas Exec. Airport (CI-105 Transponder Antenna Installation
Dallas, Texas 75237
Log of Revisions
Dated Pi Approved by
Original All
NOTE: All changes are indicated by a black line along the right margin.
DAS Doc. 05121401
12-14-2005 Page 2 of 5Continuation of Block 8 of FAA Form 337 as attached
Dallas Aircraft Services Instructions for Continued Airworthiness for
'5025 Voyager Drive, Dallas Exec. Airport ‘C1105 Transponder Antenna Installation
Dallas, Texas 75237
TABLE OF CONTENTS/LIST OF EFFECTIVE PAGES
SECTION PAGE
Cover Page... i
Record of Revision. 2
‘Table of Contents 3
1. Introduction.
2. Alteration Descriptio
3, Operation and Control
4, Servieing Information
5. Maintenance and Inspections.
6, Troubleshooting Information.
7. Removal and Replacement Information.
8, Diagrams.
9. Special Inspection Requirements...
10, Protective Treatments,
11, Structural Fastener Data...
12, Special Tools. — —- ns oS
13, Miscellaneous data.
14, Recommended Overhaul Periods...
15, Airworthiness Limitations...
16, Procedure for Revision
DAS Doe. 05121401
12-14-2005 Page 3 of 5Continuation of Block 8 of FAA Form 337 as attached
Dallas Aireraft Services Instructions for Continued Airworthiness for
5025 Voyager Drive, Dallas Exee, Airport (1-105 Transponder Antenna Installation
Dallas, Texas 75237
Section 1: Introduction
Introduction
“The purpose ofthis Document is to provide follow-on Instructions for Continued Airworthiness for the
Major Alteration made to this airframe of the equipment identified on the cover.
‘These are the Instructions for Continued Airworthiness for the Alterations performed by Dallas Aieraft
Services to the following aireraft:
Manufacturer: Piper
Model No: PA46-350P
Serial No: 4636310
Applicable Documents,
‘The manuals listed below are required for compliance with these ICA's. Dallas Aircraft Services has
received the manufacturer's permission to reference any manuals listed that contains proprietary
information,
Federal Aviation Administration Advisory Circular 43.13-1B
Federal Aviation Administration Advisory Cireular 43.13-24
FAA Form 8110-3 dated 8 December 2005 issued by Daniel J. Utterson DER.
Garmin GTX-330 Mode S Transponder Installation Manual P/N 190-00207-02 Rev. K dated Jun 2005 (or
later).
Piper PA46-350P Maintenance Manual P/N 761 783 Rev. CR980701 dated July 1, 1998 oF later
“The Owner/Operator is responsible for ensuring that all reference materials utilized while completing this
ICA is ata current revision status, Federal Aviation Administration approved Repair Stations are required
to maintain current publications for each unit on which it performs maintenance.
Section 2: Alteration Description
Refer to Garmin GTX-330 Mode S Transponder Installation Manual P/N 190-00207-02 Rev. K dated Jun
2005 (or later).and standard practices outlined in AC 43.13-1B & 2A,
Section
NA
: Operation and Control
Section 4: Servicing Information
Each Antenna described in these Instructions for Continued Airworthiness shall be maintained LAW the
‘Manufacturers Maintenance data
Refer to Garmin GTX-330 Mode $ Transponder Installation Manual P/N 190-00207-02 Rev. K dated Jun
2005 (or later).
FAA Form 8110-3 dated 8 November 2005 issued by Daniel J. Utterson DER.
Section 5: Maintenance and Inspections
Refer to Garmin GTX-330 Mode § Transponder Installation Manual P/N 190-00207-02 Rev. K dated Jun
2005 (or later).
Maintenance and Inspection intervals and procedures tobe completed IAW data outlined in:
Section 6: Troubleshooting information
Refer to Garmin GTX-330 Mode § Transponder Installation Manual P/N 190-00207-02 Rev. K dated Jun
2005 (or later).
DAS Doe. 05121401
12-14-2005 Page 4 of SContinuation of Block 8 of FAA Form 337 as attached
Dallas Aircraft Services Instructions for Continued Airworthiness for
'5025 Voyager Drive, Dallas Exec. Airport (C1-105 Transponder Antenna Installation
Dallas, Texas 75237
Section 7: Removal and Replacement Information
Refer to Garmin GTX-330 Mode § Transponder Installation Manual P/N 190-00207-02 Rev. K dated Jun
2005 (or later)
Section
jagrams
0 Mode S Transponder Installation Manual P/N 190-00207-02 Rev. K dated Jun
Refer to Garmin GTX~
2008 (or later).
FAA Form 8110-3 dated 8 November 2005 issued by Daniel J. Uterson DER.
Section 9: Special Inspection requirements
No change to the Inspection Intervals are required by this alteration. The existing inspection Intervals are
outlined in Piper PA46-350P Maintenance Manual P/N 761 783 Rev. CR980701 dated July 1, 1998 or later
are to be completed utilizing standard practices
Section 10: Protective Treatments
Zine Chromate Primer PIN A-7 6889 Yellow manufactured by Tempo Products was used for corrosion
prevention,
Section 11: Structural Fastener Data:
Reference Federal Aviation Administration Advisory Circular 43.1
‘Administration Advisory Circular 43.13-2A for common practices.
1B and Federal Aviation
Section 12: Special Tools
NIA
Section 13: Miscellancous data
NA
Section 14: Recommended Overhaul Periods
NIA
Section 15: Airworthiness Limitations
NA
Section 16: Procedure for Revision
‘The following procedure shall be complied with when revising this ICA.
A letter will be submitted to the local FSDO with a copy of the revised FAA Form 337 and revised ICA.
‘The FAA Inspector accepts the change by signing Block 3 and including the following statement:
“The atached revised/new Instructions for Continued Airworthiness (date _) for
the above aireraft or component major alteration have been accepted by the FAA,
superceding the Instructions for Continued Airworthiness (date__)."_ Once the
revision has been accepted, a maintenance record entry will be made, identifying the
revision, its location, date ofthe Form 337.
DAS Doc. 05121401
12-14-2005 Page 5 of 5