Professional Documents
Culture Documents
http://creativecommons.org/licenses/by-nc-sa/4.0/.
Notes
Subwoofer
• 18mm plywood to be used
• Optimised for Oberton 12B450, but the 18 Sound 12LW800 works too
• HPF 35hz BUT48 – LPF 90hz BUT24
• Wire in parallel for 4 ohm load
• Speakon cutout is the Penn Elcom D0941K-NLT4
• Caster bolt pattern spacing for the Penn Elcom W0098-FM caster
mounting place
• It is recommended to well dampen both rear chambers
• M6 bolts for drivers
• M5 CSK for access hatch
Midbass
• 12mm plywood to be used
• Optimised for the Oberton 10MB200, but the 18 Sound 10MB400 works
too
• HPF 90hz BUT24 – LPF 160hz BUT24
• Wire parallel for 4 ohm load
• Speakon cutout is the Penn Elcom D0941K-NLT4
• Handle cutout is for the Penn Elcom H1105
• It is recommended to well dampen the rear chamber
• Port cutout is for the Monacor BR-50HP
Calum Audio Ltd
Unit 12F Vincent Works
Tell. 0114 698 3986
calum@calumaudio.co.uk
www.calumaudio.co.uk
20/10/2022
High mid
• 12mm plywood to be used
• Only designed for the B&C 8NSW64
• HPF 160hz BUT24 – LPF 1200hz BUT24
• Wire in parallel for 4 ohm load
• Speakon cutout is the Penn Elcom D0941K-NLT4
• M5 bolts for drivers
HF
• 12mm plywood to be used
• Only designed for the 18 Sound AMT200P mounted on the XMT200
• HPF 1200hz BUT24
• Speakon cutout is the Penn Elcom D0941K-NLT4
• M5 bolts for drivers
EQ
• You need to gain structure, EQ and delay the system to the spec drivers
you have chosen. It is beyond the scope of this document to supply
optimisation settings for every possible combination of drivers
calum@calumaudio.co.uk
www.calumaudio.co.uk