The document provides guidance for addressing requirements in a welding procedure qualification record, including not allowing single passes over 13mm thick, adding a statement about allowable temperature measurement methods, addressing a reference to thermal processing as not applicable, mentioning the welding process and type used, and addressing the maximum heat input achieved during qualification by calculating it from the welding parameters and including the maximum value.
The document provides guidance for addressing requirements in a welding procedure qualification record, including not allowing single passes over 13mm thick, adding a statement about allowable temperature measurement methods, addressing a reference to thermal processing as not applicable, mentioning the welding process and type used, and addressing the maximum heat input achieved during qualification by calculating it from the welding parameters and including the maximum value.
The document provides guidance for addressing requirements in a welding procedure qualification record, including not allowing single passes over 13mm thick, adding a statement about allowable temperature measurement methods, addressing a reference to thermal processing as not applicable, mentioning the welding process and type used, and addressing the maximum heat input achieved during qualification by calculating it from the welding parameters and including the maximum value.
Add the following 'Digital thermometer may be used for preheat & interpass temperature measurements. Thermal chalks are not allowed to use.'
Address QW-410.64 use of
thermal process. say 'N/A'. Mention the welding process & type used. i.e. SMAW & Manual
No single Pass >13mm thick
Address the max heat input achieved during qualification. value shall be calculated from the welding parameter sheet and the max value in the table shall be addressed here. Doesn't comply FMS20B105