Professional Documents
Culture Documents
(a) 5 – 10 Mt/sec.
(b) 20 – 30 Mt/Sec
(c) 2.5 – 3.2 Mt./sec
(d) 0.5 to 1 Mt/sec.
(a) Nylon/Nylon Belt 4 ply, Tensile strength 200 KN/Mt width / Ply
(b) Best strength – 800 KN/Mt width/ply
(c) Steel cord belt with belt strength 800 KN/Mt. Width
(d) None of the above.
(a) Linear heat sensing cable (b) Line heating system cable
(c ) Left hand side cable (d) None of the above
1
(d) All of the above
13. In Hot vulcanizing of NN Belt, the temperature of the spliced area is raised upto –
(a) To reduce the Air Flow to avoid fire Hazard (b) To reduce the height of the pile
(b) To increase the capacity of stockyard (d) None of the above
(a) Increasing the height of boom (b) Reducing the height of moon
(c) Raising/lowering of boom (d) None of the above
(d) take care of elongation of the belt as well as to adjust the tension during starting of
conveyor.
2
18 Skirt rubber in conveyors is used
(a) To prevent the leakage of Coal/ Dust between skirt board and belt
(b) To increase friction of belt
(c) To reduce the speed of conveyor
(d) To increase the volume of chute
19 If Breaker is closed in Service and the ammeter is showing current and the bulb is not glowing
(a) Power is isolated & control supply is in service
(b) Power & Control supply is in service
(c) Power is in service & control supply is off
(d) ON bulb will be fused
(a) Reduce the carry over of lignite slurry (b) Increase the friction
3
a) 2 b) 3 c) 4 d) 5
30 Reheater coils are placed in
a)FBHE 1 b) FBHE - 2 c) FBHE - 3 d)FBHE - 4
31 Heat rate of Unit at SLPP is between
a) 2500 – 2600 b) 2700 – 2800 c) 2900 – 3000 d) 2300 – 2400
32 Specific lignite consumption unit is
a) kCal / kg hr (b) kg/kWhr c) kWh/kg d) kg hr / Kcal
33 Specific lignite consumption at SLPP is
a) 0.9 - 1 b) 1-2 c) 1.5 - 2 d) morethan 2
34 Sulphar capture in the combustor is generally
a) morethan 80% b) morethan 85% c) morethan 90% d)100%
35 The maximum losses in the boiler due to
a) dry flue gas b) moisture c) unburnt d) radiation & unaccounted losses
36 Average daily station coal consumption 100% MCR is
a)3000 tonnes b)4000 tons c) 5000 tons d) 6000 tons
4
50 Commercial declaration of SLPP is from
a) August 15, 2000 b) February 15 , 1999
c) February 15 ,2000 d) August 15 1999