..THE ESTABLISHED LEADER IN E.E. REVIEW" Manlla REGISTERED ELECTRICAL ENGINEERS Pre-Board Examination Sunday, January 26,2014 8:00 a.m. - 2:00 p.m.
PROFESqpNAL ELEGTR!C"&'. E N ctNEERt NG SU BJECTS
A.5 O LLrrS O C.20 Q D.25 rl 3 side of the transfomner is maintained at 240 v, what ls the seegyrdary impedance? A.0.676 CI 8.0.776 O &).S20 O D. 0.876 O 18. What is the counterpart of ryragnetic flux in an electlc circuit? A. voltage Sunent C. resistance D. conductance 19. ln a parallel circuit the potential difference across the resistance A. varies is sometimes constant B. is differentfrom the applied voltage is always constant 20. The rms value of a sinusoi{gl wave is equal to _ of maximum rralue. A.0.637 (U0.707 C.0.506 D. 1.414 21. When one coil of a magnetically coupled pair has a cunent of 5 A, the resulting fluxes O1 snd (D12 are 0.4 and 0.8 mWb, respectively. lf the tums are Nr = 500 and Nz = 1,500, fDC Lr. A.530 mH B. 540 mH C. 1,060 mH QJ t,OaO mn 22.lntwo-wattmeter niethod, the readings of the wattmeters will be identicalwhen ft load in one of the phases is zero C. powerfactor is 0.5 (pfower factor is unity D. neutral is earthed 23. The positive, negative, and zero-sequence reactanc,es af a 2O MVA, 31.2 kV sync*rronous generator are 0.3 pu, 0.2 pu, and 0.1 pu, respectively. The generator is solidly grounded and ls not loaded. A line to ground fault occurs on pfqse a. Neglecting allthe resistances, detennine the fault cunent. A. 2,916 A 8i4,374 A C. 2,525 A D. 5,050 A 24. What is tha maximum distance between two receptacles in a single family dwelling unit? A 1.5 m B. 1.6 m $1.8 m D. 2.0 m 25. What is the minimum clearance between the recessed incandescent fixture and the nearest point of a storage space of a doset? A. 100 mm - - C.200 mm D.250 mm tP 150 mm 26. What is the derating factor in each of 7 to g condu{ors in a raceway? A.8o% B.8s% glzov. D. 75% 27. What is the maximum number of conductors in a raceway that does not need to be derated? A.z Ss c.4 D.s 28. Two electrons llave a force of 3.46 x 10s N. What is the distance between them? A.8.1 x10-7m B. 1.8x10-7m St., x10-1Em O. i.ax 10-1Em 29. A wire 36 inches long is carrying a current of 1,200 A. Find the flux density in gauss at a iloint 12 incfres from the wire. A.2.40 ffit.at c.6.31 D.5.52 30. Four resistances of 10, 20, 30 and 40 ohms are connected ln paraltel. What is the equivalent resistance? A" 100 o B. e.6 o c. 3.6 o @.a o 31. A factory works at 400-kW, 0.7 pf lagging. A 200 HP synchronous motor is connected to the plant to correct the pf to 75% laggirlg. what should be the pf of the synchronous motop A.80o/o &,'89% .91o/o D.95% 32. A transformer has an impedance of 67o. The )(/R ratio is 16. Find the per g{t admittance G + jB. A. 10.3963 + j1.6634 B. 1.0396 +i16.6342 C. 10.3963- jl.6634 @f T.OSSO -i16.63!42 33. A 120 v dc motor draws 225 Afrom the supply at a distance of 350 m using two copper conductors of diameter 0.5 inch and resistiv{tV lO.a ohm-cnril/ft. Find the voltage of the slpply. A. 126 v B. 1ss v C. 138 v &Dt+z v