Professional Documents
Culture Documents
407 MM CH11
407 MM CH11
TABLE OF CONTENTS
FIGURES
Figure Page
Number Title Number
11-00-00
ECCN EAR99 8 APR 2011 Rev. 30 Page 1/2
BHT-407-MM-2
11-00-00
ECCN EAR99 8 APR 2011 Rev. 30 Page 3
BHT-407-MM-2
NOTE
NOTE
A clear polyurethane enamel (C-233) may
For application of large decals, use a be used to seal decals applied to all types
plastic squeegee with firm pressure. of exterior finishes.
e. While you continue to remove the adhesive b. For the sealing of exterior decals, apply the
protection, apply finger pressure to the remaining part same material used for the exterior painting. For
example, if the exterior paint is polyurethane enamel,
of the decal until the entire decal is applied. For best
then use a clear polyurethane enamel (C-233).
results, hold the opposite edge away from the surface
until the entire decal is applied. c. For the sealing of interior decals, apply a clear
edge sealer (C-349).
f. Make sure there are no air bubbles trapped
under the decal. Otherwise, make a hole in the bubble d. Remove the masking tape (C-426) from
with a pin and press with your finger or a squeegee to around the decal when the coating is dry.
remove the air.
11-3. INSTRUMENT PANEL PLACARDS
3. Edge seal or fully coat the decal with the AND MARKINGS
applicable coating as follows:
Put the placards and markings on the instrument panel
as shown in Figure 11-1 and refer to the applicable
a. Apply masking tape (C-426) 1/8 inch (3 mm) Flight Manual (BHT-407-FM-1 or BHT-407-FM-2) for
away from the edge and all around the decal. correct configuration.
11-00-00
Page 4 Rev. 30 8 APR 2011 ECCN EAR99
BHT-407-MM-2
3 4
1
11 11
9
5 6 7
8
10
C
A B
10
6
9
11 2 11
TOP VIEW
NOTE
Align red blade with master spline on mast.
SEE DETAIL I
12
M 13
SEE DETAIL E H J
D D 15
F L M
K K
16
17 14
19 18
H J 20
22 21
LEFT SIDE VIEW
SEE DETAIL G
SEE DETAIL N
23 24
16
SEE DETAIL Q
P
O SEE DETAIL S
R
W T
Y
X
26 17
77 1 16 W
SEE DETAIL AA
SEE DETAIL Z 22
T
V V SEE DETAIL U
RIGHT SIDE VIEW
407_MM_11_0001a
11-00-00
ECCN EAR99 8 APR 2011 Rev. 30 Page 5
BHT-407-MM-2
34
37 33
35
VIEW C
LOOKING INBOARD ON RIGHT SIDE
OF OVERHEAD PANEL
28
29
30
27
76
31
FRONT VIEW
FWD
VIEW D
VIEW LOOKING UP
32 (FOR HELICOPTERS 54300 AND SUBSEQUENT)
VIEW A
LOOKING OUTBOARD ON RIGHT DOOR
(LEFT DOOR OPPOSITE)
FWD
76 75
32
VIEW B
LOOKING OUTBOARD ON RIGHT DOOR DETAIL E
(LEFT DOOR OPPOSITE) LEFT-HAND SIDE SHOWN
(FOR HELICOPTERS 54300 AND SUBSEQUENT)
407_MM_11_0001b
11-00-00
Page 6 Rev. 30 8 APR 2011 ECCN EAR99
BHT-407-MM-2
FLOAT FLOAT BAGGAGE L/FUEL R/FUEL FADEC FADEC ENGINE BATTERY BATTERY ENGINE C/W
GEN FAIL
TEST ARM DOOR BOOST BOOST FAULT FAIL CHIP RLY HOT OUT
ON
AUTO LITTER L/FUEL R/FUEL RESTART FADEC XMSN XMSN OIL XMSN OIL ENGINE PEDAL A
E
41
RELIGHT DOOR XFR XFR FAULT DEGRADED CHIP PRESS TEMP OVSPD STOP
U
L
ENGINE HEATER FUEL FUEL FUEL FADEC T/R CHECK HYD CYCLIC T
START RPM T
ANTI-ICE OVERTEMP FILTER VALVE LOW MANUAL CHIP INSTR SYSTEM CENTERING LT TEST O
FLOAT RESET
TEST
6 7
8 0
5
O.A.T VOLTS
9 20 FEET
L 150 I H 100
4
C N O 9 1
3 10 FEET
D S R 100
0
FEE
2 40 T N 100
00
1 % X 10
11 T AIRSPEED R 8 2
0 E M 299
S C U
42 DAVTRON
T
100
KNOTS
60
H
K
T
E
7
6 4
80 PU
L
5
L
3 FOR
8 QUICK
20 7
T
6
E
R E C
16 5
2 4 9
12
3
FUEL
PSI
AMPS 8 2 NR
1 1 0 1
~C X 100 NAV
S
HDG
2
15
4 0 10 10
120
NP GS
21 GS 5 1000 FT
3
X 10 0
12
PER MIN
20 UP PEDAL STOP
110 PTT
24
0
4
ENGAGED
DOWN
E
30
T
100
W
5 3
1 2
6
4 5 7 8 % RPM 40 NAV
30
6 9 90
R
3 6 3 33 GPS
7 5 10 80 50 N
2 4 70 60
8 3
KING
1 9 2
QTY LBS 10 1 RPM 11
FUEL CAPACITY FUEL QTY X100 % X 10
BASIC 869 LBS 0 11 0 AVOID CONT OPS 68.4% TO 87.1% NP
12
WITH AUX 1005 LBS
(JET A AT 15° C)
33 N
30 N 33 3
6
30
FWD TANK
3
FADEC 2 MIN TURN
12 15
15
20
24
OVSPD HORN 10
E
6
8 15
FADEC
21
6 10
~C 10 ~C MODE
12
PSI PSI
24
ON
E
10
4
TEST TEST X 10
5
X 10
5 S 12 15 FUEL
2 15 21 AUTO
5 HDG S VALVE
FADEC SOFTWARE VERSION 5.358 0 0 0 0 OBS MAN
WITH DIRECT REVERSION TO
MANUAL INSTALLED, REFER TO OFF
FLIGHT MANUAL FOR OPERATION. THIS HELICOPTER MUST BE OPERATED IN
COMPLIANCE WITH THE OPERATING LIMITATIONS
47 46
48 36 36
40
49 45 43
44
0.25 IN. (6 mm)
(FOR HELICOPTERS S/N 53000 THROUGH 54299)
81
86 82 44 78
80 79
42
36 36 83 3
VIEW F
NOTE
Refer to the Flight Manual (BHT-407-FM-1 or BHT-407-FM-2) for correct configuration.
407_MM_11_0001c_c01
11-00-00
ECCN EAR99 11 JUL 2011 Rev. 31 Page 7
BHT-407-MM-2
BL
0.00
54
53
87
18.0 IN. (457 mm)
APPROX.
DETAIL G
DUAL CONTROL ONLY 42
VIEW H 55
LOOKING FORWARD ON AFT
FACING SEATS
BL
42 0.00
42
54
1.0 IN. 61 54
(25.4 mm)
WL 56
55.0
62
DETAIL I
LOOKING OUTBOARD ON LEFT-HAND SIDE VIEW J
LOOKING AFT ON AFT ROW SEATS
51 52
6.0 IN.
(152.4 mm)
APPROXIMATELY
57
VIEW K
VIEW THROUGH LITTER DOOR TRIM ON LEFT SIDE
(RIGHT SIDE OPPOSITE EXCEPT THROUGH FIXED TRIM)
VIEW L
LOOKING AFT ON BULKHEAD
407_MM_11_0001d
11-00-00
Page 8 Rev. 30 8 APR 2011 ECCN EAR99