Professional Documents
Culture Documents
1.If the combustion process is normal, the maximum pressure drops rapidly when the
crank throw has moved down, thus, most of the useful work is done during
approximately_________ of crankshaft movement.
Ans. 180
3.How many cylinder operated, when crankshaft rotate 1 revolution ( of six cylinder )
Ans. 3 2 lev a cycle
=
6.For internal combustion engine, when cylinder is filled with F/A mixture and the
piston moves up, the volume of the mixture will
Ans. Decrease but the pressure will incease Fred ja v&P9
:
7.The ratio of useful work done by an engine to the heat energy of the fuel ituses,
expressed in work or heat unit, is called the engine
Ans. Thermal efficiency
9.
Ans. *
10
Ans. *
11. The following types are the propeller shaft EXCEPT…
Ans. Bevel type
14.What is occurred when there is combustion with in cylinder before time spark jump
across spark plug terminal
Ans. pre ignition / overheat
18.
Ans. *
22.What is meant of interference fit and shrunk fit for valve seat and cylinder head
Ans. The cylinder is heated to expand the hole and valve seat is chilled
31.Camshaft speed
Ans.
34. The purpose of a baffle on the top of two stroke-cycle engine is..
Ans. Helped scavenging the exhaust gases
36.Radial engine 9 cylinders, ใ"#รอบในการ to complete cycle 720 องศา 2 รอบ crankshaft
Ans. 10
39.The volume of piston displacement within an engine cylinder is expressed in what unit of
measurement for most American-made Engine
Ans. Cubic inches
40.What cooling
A.oli b.water c.fuel d.oil and water *
Ans. water ethylene glycol
t
43. What is the relationship between the pressure existing within the throat of a venturi and
the velocity of the air passing through the venturi
Ans. The pressure is inversely proportional to the velocity
44. When the pressure through the venturi of a carburetor, What three change occur
Ans.Velocity increases, temperature decreases, and pressure decreases
45. Select the correct statement concerning the idle system of a conventional float type
caburator
Ans The low pressure between the edges of the throttle valve and the throttle body pulls the
from the idle passage
Ans.
46.The economizer system of a float type carburetor performs which of the following
functions
Ans. It supplies and regulates the additional fuel required for all engine speeds above cruising
47.How will the mixture of an engine be affected if the bellows of the automatic mixture
control (AMC) in a pressure carburetor ruptures while the engine is operating at altitude
Ans. It will become richer
48.The fuel level within the float chamber of a properly adjusted float type carburetor will
be:…
Ans. Slightly lower than the discharge nozzle outlet
49.The primary purpose of the air bleed openings used the continuous flow fuel injector
nozzles is to:
Ans. Aid in proper fuel vaporization.
51.The continental fuel injection systems primarily differs from the RSA system in that the
continental system measure…………….while the RSA system measure the flow
of…………
Ans. Fuel pressure, Air
53.Within an RSA fuel injection system, the greatest air pressure is from…………and the
greatest fuel pressure is from…………
Ans. Incoming impact air, Unmetered fuel
54.The density of air is very important when mixing fuel and air to obtain a correct fuel to
air ratio. Which of the following weight the most
Ans. 100 parts of dry air
57.What the dually redundant sensors are both defective, the FADEC Powerlink
system…….
Ans. Use synthetic software default values
59.FADEC is…
Ans. ECU including its peripheral
62.
Ans.
63.
Ans.
64.During an ignition check the pilot placed the ignition switch on the “OFF” engine
continue to operate normally. The probable cause was………
Ans. An open “P” lead
66.When the ignition switch is turned to the “OFF” position during an ignition check, the
engines continue to run normally. The probable cause is……
Ans. An open ground lead
68.When does battery current flow through a primary circuit to a ignition coil
Ans.
71.If the breaker point in the magneto closed the result will be..
Ans. High tension wire leakage
79.Straight-oil grade
Ans. Used when breaking-in a new or overhauled engine
80.Aircraft piston engine fuel (Gasoline) is expressed as percentage of….
Ans. Isooctane in the mixture
81.To increase Anti-knock rating (resistance against detonation), the fuel usually added…
Ans. TEL-Tetra ethyl lead
82.Fuel volatility is
Ans. The tendency for fuel to evaporate
84.Avgas100 is…
Ans Gasoline fuel, high lead, colored green
86.The unit used to remove any contamination from the oil system is…
Ans. Oil filter
87.The unit used to prevent any damage from excessive pressure to the oil system is…
Ans. Pressure relief valve
88. According to wet sump system, the oil return to the tank by
Ans. Gravity force
0
98.Fuel pressure indicator carburetor-engine is installed at
Ans. Carburetor inlet
:
99.Fuel pressure indicator for carburettor-engine is installed at…
Ans. The line to the flow divider
104.If the ignition switch is moved from BOTH either LEFT ,RIGHT during and engine ground
check, normal operation is usually indicated by a
Ans. Slight drop in RPM
106.On a 14 cylinders engine the number 8 distributor wire of left magneto leads to the…
Ans. Rear plug on number 8 cylinder
107.The proper serving of an engine requires oil priming (pre-oiling) prior to operation after
Ans. Engine installaion
109.What carburetor component actually limits desired maximum airflow to the engine at full
throttle
Ans. Throttle valve
110.What is the relationship between the pressure existing within the throat of a venturi and
the velocity of the air passing through the venturi
Ans. The pressure is inversely proportional to the velocity
:
111 .When the pressure through the venturi of a carburetor, What three change occur
Ans.Velocity increases, temperature decreases, and pressure decreases
112. Select the correct statement concerning the idle system of a conventional float type
caburator
Ans The low pressure between the edges of the throttle valve and the throttle body pulls the
from the idle passage
113. The economizer system of a float type carburetor performs which of the following
functions A
Ans It supplies and regulates the additional fuel required for all engine speeds above cruising
114. How will the mixture of an engine be affected if the bellows of the automatic mixture
control (AMC) in a pressure carburetor ruptures while the engine is operating at altitude
Ans. It will become richer
:
115. The fuel level within the float chamber of a properly adjusted float type carburetor will
be:…
Ans. Slightly lower than the discharge nozzle outlet
116.
117.
118.
Ans.
119.
Ans.
120.
Ans.
Sum Piston
1.If the combustion process is normal, the maximum pressure drops rapidly when the
crank throw has moved down, thus, most of the useful work is done during
approximately_________ of crankshaft movement.
Ans. 180
Ans.*
3
%0f-tg-o-e-oo-t.gg
2.Check valve of two-stroke operated by__________.
Ans. Operate by pressure close by spring and pressure
3.How many cylinder operated, when crankshaft rotate 1 revolution ( of six cylinder )
,, , ya ,
,
6.For internal combustion engine, when cylinder is filled with F/A mixture and the
piston moves up, the volume of the mixture will
One-to-one
Ans. Decrease but the pressure will incease director vk.PT
7.The ratio of useful work done by an engine to the heat energy of the fuel ituses,
expressed in work or heat unit, is called the engine
Ans. One-to-one
Thermal efficiency
get-together
Ans. Mechanical efficiency
9.
Ans.
10
Ans.
*o--o-og
Ans. Provide for balance and eliminate vibration greatest extent possible
18.
Ans.
two-To-one
Ans. Flat, peaked or spherical
22.What is meant of interference fit and shrunk fit for valve seat and cylinder head
One-to-one
Ans. The cylinder is heated to expand the hole and valve seat is chilled
Dogtooth
Ans. To balance the crankshaft
31.Camshaft speed
Ans.
Dogtooth
32.Piston ring made of cast iron because
one-to-one
Ans. Not lose elasticity (resilient) เอามาจากสไล*
33.Valve face and ground made of
Ans.
34. The purpose of a baffle on the top of two stroke-cycle engine is..
Ans. Helped scavenging the exhaust gases
36.Radial engine 9 cylinders, ใ"#รอบในการ to complete cycle 720 องศา 2 รอบ crankshaft
Ans. *
39.The volume of piston displacement within an engine cylinder is expressed in what unit of
measurement for most American-made Engine
Ans. Cubic inches
40.What cooling
A.oli b.water c.fuel d.oil and water *
Ans.
43. What is the relationship between the pressure existing within the throat of a venturi and
the velocity of the air passing through the venturi
Ans. The pressure is inversely proportional to the velocity
44. When the pressure through the venturi of a carburetor, What three change occur
Ans.Velocity increases, temperature decreases, and pressure decreases
45. Select the correct statement concerning the idle system of a conventional float type
caburator
Ans The low pressure between the edges of the throttle valve and the throttle body pulls the
from the idle passage
Ans.
46.The economizer system of a float type carburetor performs which of the following
functions
Ans. It supplies and regulates the additional fuel required for all engine speeds above cruising
47.How will the mixture of an engine be affected if the bellows of the automatic mixture
control (AMC) in a pressure carburetor ruptures while the engine is operating at altitude
Ans. It will become richer
48.The fuel level within the float chamber of a properly adjusted float type carburetor will
be:…
Ans. Slightly lower than the discharge nozzle outlet
49.The primary purpose of the air bleed openings used the continuous flow fuel injector
nozzles is to:
Ans. Aid in proper fuel vaporization.
51.The continental fuel injection systems primarily differs from the RSA system in that the
continental system measure…………….while the RSA system measure the flow
of…………
Ans. Fuel pressure, Air
53.Within an RSA fuel injection system, the greatest air pressure is from…………and the
greatest fuel pressure is from…………
Ans. Incoming impact air, Unmetered fuel
54.The density of air is very important when mixing fuel and air to obtain a correct fuel to
air ratio. Which of the following weight the most
Ans. 100 parts of dry air
57.What the dually redundant sensors are both defective, the FADEC Powerlink
system…….
Ans. Use synthetic software default values
59.FADEC is…
Ans. ECU including its peripheral
62.
Ans.
63.
Ans.
64.During an ignition check the pilot placed the ignition switch on the “OFF” engine
continue to operate normally. The probable cause was………
Ans. An open “P” lead
66.When the ignition switch is turned to the “OFF” position during an ignition check, the
engines continue to run normally. The probable cause is……
Ans. An open ground lead
68.When does battery current flow through a primary circuit to a ignition coil
Ans.
71.If the breaker point in the magneto closed the result will be..
Ans. High tension wire leakage
79.Straight-oil grade
Ans. Used when breaking-in a new or overhauled engine
80.Aircraft piston engine fuel (Gasoline) is expressed as percentage of….
Ans. Isooctane in the mixture
81.To increase Anti-knock rating (resistance against detonation), the fuel usually added…
Ans. TEL-Tetra ethyl lead
82.Fuel volatility is
Ans. The tendency for fuel to evaporate
84.Avgas100 is…
Ans Gasoline fuel, high lead, colored green
86.The unit used to remove any contamination from the oil system is…
Ans. Oil filter
87.The unit used to prevent any damage from excessive pressure to the oil system is…
Ans. Pressure relief valve
88. According to wet sump system, the oil return to the tank by
Ans. Gravity force
0
98.Fuel pressure indicator carburetor-engine is installed at
Ans. Carburetor inlet
:
99.Fuel pressure indicator for carburettor-engine is installed at…
Ans. The line to the flow divider
104.If the ignition switch is moved from BOTH either LEFT ,RIGHT during and engine ground
check, normal operation is usually indicated by a
Ans. Slight drop in RPM
106.On a 14 cylinders engine the number 8 distributor wire of left magneto leads to the…
Ans. Rear plug on number 8 cylinder
107.The proper serving of an engine requires oil priming (pre-oiling) prior to operation after
Ans. Engine installaion
109.What carburetor component actually limits desired maximum airflow to the engine at full
throttle
Ans. Throttle valve
110.What is the relationship between the pressure existing within the throat of a venturi and
the velocity of the air passing through the venturi
Ans. The pressure is inversely proportional to the velocity
:
111 .When the pressure through the venturi of a carburetor, What three change occur
Ans.Velocity increases, temperature decreases, and pressure decreases
112. Select the correct statement concerning the idle system of a conventional float type
caburator
Ans The low pressure between the edges of the throttle valve and the throttle body pulls the
from the idle passage
113. The economizer system of a float type carburetor performs which of the following
functions A
Ans It supplies and regulates the additional fuel required for all engine speeds above cruising
114. How will the mixture of an engine be affected if the bellows of the automatic mixture
control (AMC) in a pressure carburetor ruptures while the engine is operating at altitude
Ans. It will become richer
:
115. The fuel level within the float chamber of a properly adjusted float type carburetor will
be:…
Ans. Slightly lower than the discharge nozzle outlet
116.
117.
118.
Ans.
119.
Ans.
120.
Ans.