Professional Documents
Culture Documents
VENDOR'S APPROVAL
REV. NO DATE
(NAME AND SIGNATURE)
02 04/09/2012
VENDOR'S OWN
DOCUMENT NO 03 23/10/2012
Submitted For :
PACKAGE DESCRIPTION:
REVIEW DOES NOT CONSTITUTE ACCEPTANCE OF DESIGN
2.
ACCEPTED, PROCEED WITH WORK & VENDOR NAME:
INCORPORATE COMMENTS & RE-SUBMIT
ITALGRU SRL
3. NOT ACCEPTED, REVISE AND RE-SUBMIT
TECHNICAL CALCULATION
C1515/16
Commessa / Job No.
7
OGGETTO/TITLE :
2012/52
10
9
8
7
6
5
4
3 23/10/12 General revision R.T. G.B. F.N.
2 04/09/12 General revision C.C. G.B. F.N.
1 21/03/12 General revision C.C. G.B. F.N.
rev. data/date descrizione/description pag. Comp./Compiled Cont./Cheched Approv.
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 1/158
SCOPE:
The following document is the general calculation note of a Fixed Boom Crane intended for Vessel use.
The calculation is based on API 2C 6th_2004 Specification for Offshore Pedestal Mounted Cranes.
DEFINITION:
API American Petroleum Institute
UNITS:
SI – Units system
APPLICABLE CODES AND STANDARDS:
International codes and standards:
• API 2C 6th_2004 Specification for Offshore Pedestal Mounted Cranes (September 2004)
www.italgru.com
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 2/158
INDEX
REFERENCE SYSTEM
LOAD CHART
API 2C REFERENCES
API 2C TABLES
ROPES
MATERIALS
GENERAL DATA
Geometric parameters 13
STATIC FORCES ON THE MAIN STRUCTURAL COMPONENTS DUE TO DEAD LOAD ONLY
Static forces on the main structural components due to dead load only 16
www.italgru.com
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 3/158
Dynamic load combination with inertial forces and wind 46
ANNEX
Conical adaptor 93
Conical pedestal adaptor analysis 101
Boom 105
Luffing cylinders 136
Slew bearing 142
Reduction gears 149
Design fail safe 158
www.italgru.com
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 4/158
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 5/158
Crane model TC500 DH
Destination HSD
NOTES:
1‐ Radius "L" and "La" are intended from the slewing center to center line of the suspended load
d " " d" " d df h l l f h d dl d
2‐ The angle "θ" is referred from the main boom axis in refer to the horizontal line
3‐ Load capacity P is under hook (all lifting devices included)
4‐ All data compliance with API 2C sixth edition: sept. 2004
A,B,C Main hook ‐ E,F Auxiliary hook ‐ G Man Riding
LOAD COND. A B LOAD CONDITION E F G
Wave Height (m) 1 2.5 Wave Height (m) 1 2.5 1÷2.5
Wind Speed (m/s) 25 25 Wind Speed (m/s) 25 25 25
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 6/158
DESIGN CALCULATION GUIDE ‐ API 2C REFERENCES
DESCRIPTION API 2C REFERENCE
GENERAL DATA
The model of the crane is described by 3 reference systems:
1 Local reference system xloc‐zloc fixed on the boom hinge
2 Bearing reference system x1‐z1 fixed on the slew bearing
3 Interface reference system x2‐z2 fixed at the crane interface
The table contains the main geometrical data in function of the radius.
HOISTING ROPE AND AUX HOISTING ROPES
Design breaking load Par. 7.2.4.1
Calculation of the minimum design breaking load, the design factor shall not be less
than 2.5*Cv or 5, whichever is greater.
LUFFING CYLINDERS DATA
STATIC FORCES ON THE MAIN STRUCTURAL COMPONENTS DUE TO THE DEAD
LOAD ONLY
The input data are the weight of the boom and the cylinders. The tables contain the
forces on the cylinders and on the boom hinge due to the dead load in function of
the radius.
STATIC AND DYNAMIC FORCES NO ROPES AND CYLINDERS
Crane vertical stiffness K Par. 4.3.1
The crane ratings can be classified in terms of:
‐hooks: main/auxiliary hook
‐lifting conditions: on‐board/off‐board lift
Basing on this classification the load cases are divided in this way:
A, B, C, D main hoisting off‐board
E, F main hoisting on‐board
G, H auxiliary hoisting off‐board
I auxiliary hoisting on board
Every load case is characterized by a load chart and a significant wave height.
In the case of the off‐board lifts the crane vertical stiffness is calculated in function
of the radius in order to get the dynamic coefficient Cv.
VERTICAL DYNAMIC COEFFICIENT Cv Par. 4.3.1
Supply boat velocity Table 2
Crane boom tip velocity Table 2
The lifting speeds are charged in the program in function of the type of hook and
the capacity.
The tables contain the dynamic coefficient in function of the radius for every load
case.
HORIZONTAL FORCES ON LIFTED LOAD DUE TO SUPPLY BOAT MOTION, CRANE
INCLINATIO AND CRANE MOTION
Design crane dynamic horizontal acceleration Table 4
Design crane static angle Table 4
Offlead and sidelead angle Par. 4.3.2.a
The tables contain the calculation of the horizontal load generated on the lifted load
by 3 causes:
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 7/158
‐Supply boat motion, only for off‐board lift
‐Crane static inclination, for both off‐board and on‐board lift
‐Crane static motion, for both off‐board and on‐board lift
The tables also contain the force produced on the luffing cylinders due to these
horizontal forces.
DYNAMIC FORCES ON DEAD LOADS DUE TO CRANE INCLINATION AND CRANE
MOTION
Crane dynamic vertical acceleration Table 5
Calculation of the inertial forces on the structure due to the crane inclination and
the crane motion. The tables also contain the effects of these forces on the luffing
cylinders.
WIND FORCES ACTING ON STRUCTURE AND LIFTED LOADS Par. 4.5.1
The input data are the wind forces acting on the main component of the crane. The
tables also contain the effects of these forces on the luffing cylinders.
FORCES ON LUFFING CYLINDERS
Calculation of the forces on the luffing cylinders in the following load combination:
‐Static equivalent load combination D+Cvc*L
‐Dynamic load combination D+Cv*L
‐Dynamic load combination with inertial forces D+Cv*L+I
‐Dynamic load combination with inertial forces and with wind D+Cv*L+I+W
Legend:
‐D dead load
‐L lifted load
‐I inertial forces
‐W wind forces
‐Cvc dynamic coefficient used for static equivalent load combination only
‐Cv dynamic coefficient
FORCES ACTING ON THE BOOM HINGES
Calculation of the forces on the boom hinges in the following load combination:
‐Static equivalent load combination D+Cvc*L
‐Dynamic load combination D+Cv*L
‐Dynamic load combination with inertial forces D+Cv*L+I
Legend:
‐D dead load
‐L lifted load
‐I inertial forces
‐Cvc dynamic coefficient used for static equivalent load combination only
‐Cv dynamic coefficient
SLEW BEARING FORCES
Design platform connection load condition (with or w/o wind depending on Cv) Par. 5.2
Ultimate limit strength condition Par. 9.2.1.4
Calculation of the forces acting on the slew bearing for every load case in function
of the radius for the following load combination:
‐Static equivalent load combination D+Cvc*L
‐Dynamic load combination with inertial forces D+Cv*L+I
‐Dynamic load combination with inertial forces and with wind D+Cv*L+I+W
‐Ultimate limit strength condition
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 8/158
‐Design platform connection load condition (with or without wind depending on Cv)
ref. 5.2 API 2C rules
‐Test conditions
Calculation of the forces and couples acting on the swing mechanism in accordance
with par 9.1.2 API 2C rules for every load case in function of the radius.
Legend:
‐D dead load
‐L lifted load
‐I inertial forces
‐W wind forces
‐Cvc dynamic coefficient used for static equivalent load combination only
‐Cv dynamic coefficient
INTERFACE WITH BATTERY LIMIT SUPPORT STRUCTURE
Design platform connection load condition (with or w/o wind depending on Cv) Par. 5.2
Calculation of the forces acting at the crane interface for every load case in function
of the radius for the following load combination:
‐Static equivalent load combination D+Cvc*L
‐Dynamic load combination with inertial forces D+Cv*L+I
‐Dynamic load combination with inertial forces and with wind D+Cv*L+I+W
‐Design platform connection load condition (with or without wind depending on Cv)
ref. 5.2 API 2C rules
‐Test conditions
Legend:
‐D dead load
‐L lifted load
‐I inertial forces
‐W wind forces
‐Cvc dynamic coefficient used for static equivalent load combination only
‐Cv dynamic coefficient
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 9/158
API 2C TABLES
TABLE 2 – VERTICAL VELOCITY FOR DYNAMIC COEFFICIENT CALCULATIONS
Supply boat velocity vd = 0 m/s
Crane boom tip velocity vc = 0 m/s
TABLE 3 ONBOARD LIFT DYNAMIC COEFFICIENTS
Dynamic coefficient Cv = 1.33
TABLE 4 CRANE BASE INCLINATIONS AND ACCELERATIONS
Crane dynamic horizontal acceleration ah = 0.294 m/s2 = 3%g
TABLE 5 VERTICAL DYNAMIC ACCELERATIONS TO BE APPLIED TO CRANE COMPONENTS
Vertical acceleration av = 0.686 m/s2 = 7%g
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 10/158
ROPES
HOISTING ROPE
Flexible rotation resistant
Metallic core plastic coated
Minimum breaking load 540 kN
HOISTING ROPE
Flexible rotation resistant
Metallic core plastic coated
Minimum breaking load 275 kN
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 11/158
C1515‐16 ‐ MATERIALS AND CHARACTERISTICS
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 12/158
GENERAL DATA
Calculations in accordance with both : "Vessel Specific Method" and " General Method" of API 2C rule
Type of crane : fixed(FX), tension leg(TL), spar(SP), semisub(SS), drillship(DR), floating prod.(FP) FX min dyn. coefficient in accordance to API 2c Cv 1,33
Geometric data of LUFFING BOOM referred to the local boom system X - Z cylinder
boom baryc, wind application luffing cyl barycentre arm
Prog Radius Radius Luffing angle q joint B joint C joint D joint E joint F joint G joint H joint I joint M joint MW joint R joint P joint Q angle aB angle b Q angle b QA angle a1 length AB dbo
q L[m] La [m] [deg] [rad] X [m] Z [m] X [m] Z [m] X [m] Z [m] X [m] Z [m] X [m] Z [m] X [m] Z [m] X [m] Z [m] X [m] Z [m] X [m] Z [m] X [m] Z [m] X [m] Z [m] X [m] Z [m] X [m] Z [m] [deg] [rad] [deg] [rad] [deg] [rad] [deg] [rad] [m] [m]
1 4,00 5,45 82,440 1,43886 1,863 5,412 3,127 23,565 2,693 26,183 5,215 26,308 4,000 23,680 4,235 23,680 5,450 26,308 1,928 23,615 1,305 10,708 1,580 12,722 1,492 1,107 -0,756 3,934 -1,413 2,205 85,073 1,48481 81,129 1,41596 81,188 1,41700 80,412 1,40345 8,642 1,392
2 6,00 7,67 77,560 1,35368 2,317 5,234 5,121 23,214 4,911 25,859 7,434 25,768 6,000 23,253 6,235 23,253 7,669 25,768 3,930 23,365 2,211 10,559 2,656 12,541 1,719 1,018 -0,419 3,984 -1,220 2,317 81,928 1,42991 76,249 1,33079 76,308 1,33183 75,532 1,31828 8,516 1,559
3 7,50 9,33 73,830 1,28858 2,652 5,072 6,620 22,832 6,583 25,485 9,095 25,230 7,500 22,814 7,735 22,814 9,330 25,230 5,442 23,060 2,894 10,392 3,467 12,342 1,887 0,937 -0,159 4,003 -1,067 2,392 79,509 1,38770 72,519 1,26569 72,578 1,26673 71,802 1,25318 8,411 1,685
4 9,00 10,99 70,019 1,22205 2,984 4,884 8,123 22,341 8,262 24,991 10,752 24,570 9,000 22,265 9,235 22,265 10,987 24,570 6,963 22,647 3,578 10,177 4,279 12,084 2,052 0,843 0,108 4,004 -0,906 2,457 77,022 1,34429 68,707 1,19916 68,766 1,20020 67,990 1,18665 8,294 1,811
5 10,00 12,09 67,421 1,17671 3,202 4,744 9,128 21,950 9,387 24,591 11,855 24,057 10,000 21,834 10,235 21,834 12,090 24,057 7,982 22,308 4,036 10,004 4,823 11,878 2,162 0,773 0,289 3,995 -0,793 2,496 75,317 1,31453 66,109 1,15382 66,168 1,15486 65,392 1,14131 8,210 1,895
6 11,50 13,74 63,417 1,10684 3,525 4,509 10,638 21,259 11,080 23,875 13,506 23,171 11,500 21,083 11,735 21,083 13,741 23,171 9,520 21,696 4,724 9,698 5,640 11,512 2,323 0,656 0,567 3,965 -0,617 2,545 72,673 1,26838 62,105 1,08394 62,165 1,08498 61,389 1,07143 8,073 2,023
7 13,00 15,39 59,254 1,03418 3,843 4,241 12,153 20,431 12,784 23,008 15,152 22,129 13,000 20,192 13,235 20,192 15,387 22,129 11,070 20,948 5,416 9,330 6,461 11,072 2,482 0,522 0,854 3,914 -0,431 2,583 69,899 1,21998 57,943 1,01129 58,002 1,01233 57,226 0,99878 7,922 2,152
8 14,50 17,03 54,887 0,95795 4,155 3,936 13,674 19,446 14,499 21,968 16,793 20,911 14,500 19,143 14,735 19,143 17,028 20,911 12,633 20,044 6,111 8,890 7,285 10,548 2,638 0,369 1,149 3,837 -0,233 2,609 66,959 1,16866 53,575 0,93506 53,635 0,93610 52,858 0,92255 7,753 2,283
9 16,0 18,66 50,250 0,87703 4,460 3,587 15,201 18,277 16,228 20,724 18,428 19,485 16,000 17,909 16,235 17,909 18,663 19,485 14,212 18,957 6,809 8,367 8,114 9,925 2,790 0,195 1,456 3,732 -0,021 2,619 63,800 1,11352 48,939 0,85414 48,998 0,85518 48,222 0,84163 7,562 2,418
10 17,5 20,29 45,250 0,78976 4,756 3,185 16,736 16,883 17,972 19,231 20,057 17,805 17,500 16,446 17,735 16,446 20,292 17,805 15,810 17,646 7,513 7,742 8,948 9,180 2,938 -0,006 1,775 3,591 0,207 2,611 60,342 1,05317 43,938 0,76687 43,998 0,76791 43,222 0,75436 7,345 2,557
11 19,0 21,91 39,733 0,69348 5,040 2,713 18,281 15,195 19,738 17,414 21,675 15,794 19,000 14,687 19,235 14,687 21,910 15,794 17,434 16,045 8,222 6,984 9,789 8,277 3,080 -0,242 2,112 3,403 0,457 2,579 56,458 0,98538 38,422 0,67059 38,481 0,67162 37,705 0,65808 7,092 2,701
12 21,0 24,05 31,048 0,54189 5,392 1,921 20,366 12,261 22,141 14,234 23,812 12,340 21,000 11,650 21,235 11,650 24,047 12,340 19,657 13,228 9,182 5,662 10,927 6,704 3,256 -0,638 2,602 3,045 0,841 2,480 50,163 0,87550 29,737 0,51900 29,796 0,52004 29,020 0,50649 6,667 2,909
13 22,8 25,93 20,332 0,35486 5,655 0,885 22,291 8,260 24,401 9,868 25,691 7,697 22,800 7,542 23,035 7,542 25,926 7,697 21,773 9,343 10,075 3,856 11,983 4,555 3,388 -1,157 3,123 2,508 1,288 2,281 42,005 0,73312 19,021 0,33197 19,080 0,33301 18,304 0,31946 6,101 3,127
14 24,0 27,05 4,057 0,07080 5,676 -0,735 23,712 1,682 26,189 2,634 26,819 0,189 24,000 0,850 24,235 0,850 27,054 0,189 23,519 2,866 10,752 0,878 12,779 1,014 3,399 -1,967 3,701 1,533 1,875 1,828 28,397 0,49562 2,745 0,04791 2,805 0,04895 2,028 0,03540 5,178 3,346
15 24,0 27,05 4,057 0,07080 5,676 -0,735 23,712 1,682 26,189 2,634 26,819 0,189 24,000 0,850 24,235 0,850 27,054 0,189 23,519 2,866 10,752 0,878 12,779 1,014 3,399 -1,967 3,701 1,533 1,875 1,828 28,397 0,49562 2,745 0,04791 2,805 0,04895 2,028 0,03540 5,178 3,346
16 24,0 27,05 4,057 0,07080 5,676 -0,735 23,712 1,682 26,189 2,634 26,819 0,189 24,000 0,850 24,235 0,850 27,054 0,189 23,519 2,866 10,752 0,878 12,779 1,014 3,399 -1,967 3,701 1,533 1,875 1,828 28,397 0,49562 2,745 0,04791 2,805 0,04895 2,028 0,03540 5,178 3,346
17 24,0 27,05 4,057 0,07080 5,676 -0,735 23,712 1,682 26,189 2,634 26,819 0,189 24,000 0,850 24,235 0,850 27,054 0,189 23,519 2,866 10,752 0,878 12,779 1,014 3,399 -1,967 3,701 1,533 1,875 1,828 28,397 0,49562 2,745 0,04791 2,805 0,04895 2,028 0,03540 5,178 3,346
18 24,0 27,05 4,057 0,07080 5,676 -0,735 23,712 1,682 26,189 2,634 26,819 0,189 24,000 0,850 24,235 0,850 27,054 0,189 23,519 2,866 10,752 0,878 12,779 1,014 3,399 -1,967 3,701 1,533 1,875 1,828 28,397 0,49562 2,745 0,04791 2,805 0,04895 2,028 0,03540 5,178 3,346
19 24,0 27,05 4,057 0,07080 5,676 -0,735 23,712 1,682 26,189 2,634 26,819 0,189 24,000 0,850 24,235 0,850 27,054 0,189 23,519 2,866 10,752 0,878 12,779 1,014 3,399 -1,967 3,701 1,533 1,875 1,828 28,397 0,49562 2,745 0,04791 2,805 0,04895 2,028 0,03540 5,178 3,346
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 13/158
HOISTING ROPE (equal number of tackles, fixed point on the boom pulley)
horn hook boza 0,40 [ton] radius P-D Length tot. Length LOAD CASES
hoist hook tackle 1 Prog. La [m] LP-D Lta G - Aux H - Aux I - Aux
1 5,45 22,515 96,4 265 265 265
Young modulus E2r 1,000E+08 [kPa] 2 7,67 22,515 96,4 265 265 265
3 9,33 22,515 96,4 265 265 265
hoisting rope' diameter dra 20 [mm] 0,02 [m] 4 10,99 22,515 96,4 265 265 265
rope unit weight phra 1,67 [kg/m] 0,016 [kN/m] 5 12,09 22,515 96,4 265 265 265
2
rope' area a2r 1,665E-04 [m ] 6 13,74 22,515 96,4 265 265 265
7 15,39 22,515 96,4 265 265 265
auxiliary pulley radius rba 0,235 [m] 8 17,03 22,515 96,4 265 265 265
hook height d1ha 0,650 [m] 9 18,66 22,515 96,4 265 265 265
drum diameter (2th. layer) dta 0,655 [m] 10 20,29 22,515 96,4 265 265 265
min rope' turns n° on drum gfa 5 11 21,91 22,515 96,4 265 265 265
12 24,05 22,515 96,4 265 265 265
dist. betw. hook - boom pulleys d5d 3,00 [m] (min 3 m) 13 25,93 22,515 96,4 265 265 265
length of fixed rope on drum leDA 10,289 [m] 14 27,05 22,515 96,4 265 265 265
rope. betw. joints D and H dDH 2,578 [m] 15 27,05 22,515 96,4 265 265 265
16 27,05 22,515 96,4 265 265 265
17 27,05 22,515 96,4 265 265 265
18 27,05 22,515 96,4 265 265 265
19 27,05 22,515 96,4 265 265 265
max value 265 kN
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 14/158
LUFFING CYLINDERS DATA
Oil volume for each of luffing cylinder
number of luffing cylinders nbc 2 angle jacket side rod side cylinder radial comp. in z
cylinder bore (alesaggio) dicb 240 mm (fondello) (stelo) angle speed of speed
external diameter of rod derb 200 mm Prog q [deg] [lt] [lt] aB [deg] wRL pz
internal diameter of rod dirb 150 mm [rad/1'] [m/1']
cylinder length (closed) ltcb 4,550 m 1 82,4 246,1 -8,9 85,1 0,039 4,667
stroke strob 3450 mm 2 77,6 240,4 -7,1 81,9 0,064 4,589
cylinders' span (Y dir.) ibc 1,180 m 3 73,8 235,6 -5,7 79,5 0,083 4,505
(for only one cylinder input 0) 4 70,0 230,4 -4,1 77,0 0,102 4,397
5 67,4 226,6 -2,9 75,3 0,115 4,311
jacket side (fondello) oil area Afb 4,5239 dm2 6 63,4 220,4 -1,0 72,7 0,135 4,160
rod (stelo) oil area Asb 1,3823 dm2 7 59,3 213,5 1,1 69,9 0,155 3,981
oil volume inside the rod virb 61,0 lt 8 54,9 205,9 3,4 67,0 0,176 3,770
9 50,3 197,2 6,0 63,8 0,197 3,523
compressive modulus of oil ocm 1,380E+06 kN/m2 10 45,3 187,4 9,0 60,3 0,219 3,232
11 39,7 176,0 12,5 56,5 0,242 2,885
total pump size Psize 190 cm3 12 31,0 156,7 18,4 50,2 0,275 2,297
pump speed wp 2338 rpm 13 20,3 131,1 26,2 42,0 0,310 1,522
ratio of luffing power (1 = 100%) % 1,000 14 4,1 89,4 39,0 28,4 0,346 0,304
pump flow Qp 426,5 lt/1' 15 4,1 89,4 39,0 28,4 0,346 0,304
rod output speed ros 4,7 m/1' 16 4,1 89,4 39,0 28,4 0,346 0,304
luffing outcoming time tout 44,1 sec 17 4,1 89,4 39,0 28,4 0,346 0,304
18 4,1 89,4 39,0 28,4 0,346 0,304
19 4,1 89,4 39,0 28,4 0,346 0,304
ratios between the vertical displacements of boom and correspondent abscisse (to estimate the structure stiffeness)
luffing boom ratio : (abscissa joint C) / (displacement in Z ) defb 300 (1/300 span)
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 15/158
STATIC FORCES ON THE MAIN STRUCTURAL COMPONENTS DUE TO THE DEAD LOAD ONLY
Luffing cylinder forces (each cylinder) [kN] Boom hinges forces (each hinge) [kN]
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 16/158
STATIC AND DYNAMIC FORCES ON ROPES AND CYLINDERS ( DUE TO ONLY VERTICAL LIFTING LOAD)
LOAD CASE A "Off board Lifts" wave height Hsig1 [m] 1 [ft] 3,281
Hook forces Lifting rope forces Luffing cylinder Boom Crane vertical stiffness
Radius Capacity static dyn static dyn static dyn luffing added total
Prog luffing angle q L P F1z F1z F2 Dz1 F2dyn Fbc Dl3 Dz3 Fbdyn Dz5 Dz6 DzTOT spring rate K
[deg] [rad] [m] [tons] [kN] [kN] [kN] [mm] [kN] [kN] [mm] [mm] [kN] [mm] [mm] [mm] kN/m lb/ft
1 82,44 1,43886 4,00 20,0 -205,9 -273,9 103,0 190,3 137,0 296,0 25,8 110,3 393,7 10,4 1,0 312,0 660,0 45226
2 77,56 1,35368 6,00 20,0 -205,9 -273,9 103,0 190,3 137,0 396,3 33,7 173,0 527,1 17,1 1,0 381,3 540,1 37007
3 73,83 1,28858 7,50 20,0 -205,9 -273,9 103,0 190,3 137,0 458,5 38,2 212,7 609,8 22,1 1,0 426,0 483,4 33125
4 70,02 1,22205 9,00 20,0 -205,9 -273,9 103,0 190,3 137,0 511,9 41,7 245,4 680,8 27,1 1,0 463,8 444,1 30428
5 67,42 1,17671 10,00 20,0 -205,9 -273,9 103,0 190,3 137,0 543,4 43,6 263,4 722,7 30,4 1,0 485,1 424,6 29092
6 63,42 1,10684 11,50 20,0 -205,9 -273,9 103,0 190,3 137,0 585,5 45,7 284,5 778,7 35,5 1,0 511,2 402,8 27603
7 59,25 1,03418 13,00 20,0 -205,9 -273,9 103,0 190,3 137,0 622,1 47,0 298,8 827,4 40,5 1,0 530,5 388,2 26599
8 54,89 0,95795 14,50 18,0 -186,3 -247,8 93,2 172,2 123,9 591,7 43,1 277,0 786,9 45,6 1,0 495,7 375,9 25758
9 50,25 0,87703 16,00 15,5 -161,8 -215,2 80,9 149,5 107,6 535,4 37,4 240,7 712,1 50,7 1,0 441,9 366,2 25091
10 45,25 0,78976 17,50 14,5 -152,0 -202,2 76,0 140,4 101,1 520,3 34,5 220,8 691,9 55,8 1,0 418,0 363,6 24916
11 39,73 0,69348 19,00 13,7 -144,2 -191,7 72,1 133,2 95,9 507,0 31,6 198,5 674,3 60,9 1,0 393,6 366,2 25095
12 31,05 0,54189 21,00 10,0 -107,9 -147,9 53,9 99,7 74,0 389,3 21,6 129,2 533,9 67,9 1,0 297,8 362,3 24824
13 20,33 0,35486 22,80 8,0 -88,3 -130,4 44,1 81,5 65,2 321,8 14,9 80,6 475,4 74,3 1,0 237,5 371,6 25466
14 4,06 0,07080 24,00 7,0 -78,5 -123,3 39,2 72,5 61,7 281,3 8,9 35,8 442,3 79,0 1,0 188,3 416,6 28544
15 4,06 0,07080 24,00 7,0 -78,5 -123,3 39,2 72,5 61,7 281,3 8,9 35,8 442,3 79,0 1,0 188,3 416,6 28544
16 4,06 0,07080 24,00 7,0 -78,5 -123,3 39,2 72,5 61,7 281,3 8,9 35,8 442,3 79,0 1,0 188,3 416,6 28544
17 4,06 0,07080 24,00 7,0 -78,5 -123,3 39,2 72,5 61,7 281,3 8,9 35,8 442,3 79,0 1,0 188,3 416,6 28544
18 4,06 0,07080 24,00 7,0 -78,5 -123,3 39,2 72,5 61,7 281,3 8,9 35,8 442,3 79,0 1,0 188,3 416,6 28544
19 4,06 0,07080 24,00 7,0 -78,5 -123,3 39,2 72,5 61,7 281,3 8,9 35,8 442,3 79,0 1,0 188,3 416,6 28544
LOAD CASE B "Off board Lifts" wave height Hsig2 [m] 2,5 [ft] 8,202
Hook forces Lifting rope forces Luffing cylinder Boom Crane vertical stiffness
Radius Capacity static dyn static dyn static dyn luffing added total
Prog luffing angle q L P F1z F1z F2 Dz1 F2dyn Fbc Dl3 Dz3 Fbdyn Dz5 Dz6 DzTOT spring rate K
[deg] [rad] [m] [tons] [kN] [kN] [kN] [mm] [kN] [kN] [mm] [mm] [kN] [mm] [mm] [mm] kN/m lb/ft
1 82,44 1,43886 4,00 20,0 -205,9 -273,9 103,0 190,3 137,0 296,0 25,8 110,3 393,7 10,4 1,0 312,0 660,0 45226
2 77,56 1,35368 6,00 20,0 -205,9 -273,9 103,0 190,3 137,0 396,3 33,7 173,0 527,1 17,1 1,0 381,3 540,1 37007
3 73,83 1,28858 7,50 20,0 -205,9 -273,9 103,0 190,3 137,0 458,5 38,2 212,7 609,8 22,1 1,0 426,0 483,4 33125
4 70,02 1,22205 9,00 20,0 -205,9 -273,9 103,0 190,3 137,0 511,9 41,7 245,4 680,8 27,1 1,0 463,8 444,1 30428
5 67,42 1,17671 10,00 20,0 -205,9 -273,9 103,0 190,3 137,0 543,4 43,6 263,4 722,7 30,4 1,0 485,1 424,6 29092
6 63,42 1,10684 11,50 17,5 -181,4 -241,3 90,7 167,6 120,7 515,8 40,2 250,6 686,0 35,5 1,0 454,7 399,0 27340
7 59,25 1,03418 13,00 15,0 -156,9 -208,7 78,5 145,0 104,3 474,0 35,8 227,6 630,4 40,5 1,0 414,1 378,9 25964
8 54,89 0,95795 14,50 13,0 -137,3 -182,6 68,6 126,8 91,3 436,0 31,8 204,1 579,8 45,6 1,0 377,5 363,7 24921
9 50,25 0,87703 16,00 11,0 -117,7 -156,5 58,8 108,7 78,3 389,4 27,2 175,1 517,9 50,7 1,0 335,5 350,8 24037
10 45,25 0,78976 17,50 10,0 -107,9 -145,6 53,9 99,7 72,8 369,2 24,5 156,7 498,2 55,8 1,0 313,2 344,5 23604
11 39,73 0,69348 19,00 8,5 -93,2 -131,8 46,6 86,1 65,9 327,6 20,4 128,3 463,4 60,9 1,0 276,3 337,2 23105
12 31,05 0,54189 21,00 7,5 -83,4 -123,0 41,7 77,0 61,5 300,8 16,7 99,9 443,8 67,9 1,0 245,8 339,2 23242
13 20,33 0,35486 22,80 6,5 -73,6 -114,3 36,8 68,0 57,1 268,2 12,5 67,2 416,6 74,3 1,0 210,5 349,5 23947
14 4,06 0,07080 24,00 6,0 -68,6 -111,9 34,3 63,4 56,0 246,2 7,8 31,3 401,3 79,0 1,0 174,8 392,7 26910
15 4,06 0,07080 24,00 6,0 -68,6 -111,9 34,3 63,4 56,0 246,2 7,8 31,3 401,3 79,0 1,0 174,8 392,7 26910
16 4,06 0,07080 24,00 6,0 -68,6 -111,9 34,3 63,4 56,0 246,2 7,8 31,3 401,3 79,0 1,0 174,8 392,7 26910
17 4,06 0,07080 24,00 6,0 -68,6 -111,9 34,3 63,4 56,0 246,2 7,8 31,3 401,3 79,0 1,0 174,8 392,7 26910
18 4,06 0,07080 24,00 6,0 -68,6 -111,9 34,3 63,4 56,0 246,2 7,8 31,3 401,3 79,0 1,0 174,8 392,7 26910
19 4,06 0,07080 24,00 6,0 -68,6 -111,9 34,3 63,4 56,0 246,2 7,8 31,3 401,3 79,0 1,0 174,8 392,7 26910
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 17/158
LOAD CASE C "Off board Lifts" wave height Hsig3 [m] 0 [ft] 0,000
Hook forces Lifting rope forces Luffing cylinder Boom Crane vertical stiffness
Radius Capacity static dyn static dyn static dyn luffing added total
Prog luffing angle q L P F1z F1z F2 Dz1 F2dyn Fbc Dl3 Dz3 Fbdyn Dz5 Dz6 DzTOT spring rate K
[deg] [rad] [m] [tons] [kN] [kN] [kN] [mm] [kN] [kN] [mm] [mm] [kN] [mm] [mm] [mm] kN/m lb/ft
1 82,44 1,43886 4,00 0,00 -9,8 -29,8 4,9 9,1 14,9 14,1 1,2 5,3 42,8 10,4 1,0 25,7 381,0 26108
2 77,56 1,35368 6,00 0,0 -9,8 -27,1 4,9 9,1 13,6 18,9 1,6 8,2 52,2 17,1 1,0 35,4 277,3 19000
3 73,83 1,28858 7,50 0,0 -9,8 -25,8 4,9 9,1 12,9 21,8 1,8 10,1 57,4 22,1 1,0 42,3 232,1 15903
4 70,02 1,22205 9,00 0,0 -9,8 -24,8 4,9 9,1 12,4 24,4 2,0 11,7 61,6 27,1 1,0 48,8 200,9 13763
5 67,42 1,17671 10,00 0,0 -9,8 -24,3 4,9 9,1 12,1 25,9 2,1 12,5 64,1 30,4 1,0 53,0 184,9 12673
6 63,42 1,10684 11,50 0,0 -9,8 -23,6 4,9 9,1 11,8 27,9 2,2 13,5 67,2 35,5 1,0 59,1 166,0 11377
7 59,25 1,03418 13,00 0,0 -9,8 -23,1 4,9 9,1 11,6 29,6 2,2 14,2 69,9 40,5 1,0 64,8 151,3 10371
8 54,89 0,95795 14,50 0,0 -9,8 -22,7 4,9 9,1 11,4 31,1 2,3 14,6 72,2 45,6 1,0 70,2 139,7 9570
9 50,25 0,87703 16,00 0,0 -9,8 -22,4 4,9 9,1 11,2 32,4 2,3 14,6 74,2 50,7 1,0 75,3 130,2 8922
10 45,25 0,78976 17,50 0,0 -9,8 -22,2 4,9 9,1 11,1 33,6 2,2 14,2 75,9 55,8 1,0 80,1 122,4 8390
11 39,73 0,69348 19,00 0,0 -9,8 -22,0 4,9 9,1 11,0 34,5 2,1 13,5 77,3 60,9 1,0 84,5 116,1 7952
12 31,05 0,54189 21,00 0,0 -9,8 -21,8 4,9 9,1 10,9 35,4 2,0 11,7 78,8 67,9 1,0 89,7 109,3 7492
13 20,33 0,35486 22,80 0,0 -9,8 -21,8 4,9 9,1 10,9 35,8 1,7 9,0 79,6 74,3 1,0 93,3 105,1 7201
14 4,06 0,07080 24,00 0,0 -9,8 -22,0 4,9 9,1 11,0 35,2 1,1 4,5 78,9 79,0 1,0 93,6 104,8 7181
15 4,06 0,07080 24,00 0,0 -9,8 -22,0 4,9 9,1 11,0 35,2 1,1 4,5 78,9 79,0 1,0 93,6 104,8 7181
16 4,06 0,07080 24,00 0,00 -9,8 -22,0 4,9 9,1 11,0 35,2 1,1 4,5 78,9 79,0 1,0 93,6 104,8 7181
17 4,06 0,07080 24,00 0,0 -9,8 -22,0 4,9 9,1 11,0 35,2 1,1 4,5 78,9 79,0 1,0 93,6 104,8 7181
18 4,06 0,07080 24,00 0,0 -9,8 -22,0 4,9 9,1 11,0 35,2 1,1 4,5 78,9 79,0 1,0 93,6 104,8 7181
19 4,06 0,07080 24,00 0,0 -9,8 -22,0 4,9 9,1 11,0 35,2 1,1 4,5 78,9 79,0 1,0 93,6 104,8 7181
LOAD CASE D "Off board Lifts" wave height Hsig4 [m] 0 [ft] 0,000
Hook forces Lifting rope forces Luffing cylinder Boom Crane vertical stiffness
Radius Capacity static dyn static dyn static dyn luffing added total
Prog luffing angle q L P F1z F1z F2 Dz1 F2dyn Fbc Dl3 Dz3 Fbdyn Dz5 Dz6 DzTOT spring rate K
[deg] [rad] [m] [tons] [kN] [kN] [kN] [mm] [kN] [kN] [mm] [mm] [kN] [mm] [mm] [mm] kN/m lb/ft
1 82,44 1,43886 4,00 0,00 -9,8 -30,2 4,9 9,1 15,1 14,1 1,2 5,3 43,4 10,4 0,0 24,7 396,4 27163
2 77,56 1,35368 6,00 0,0 -9,8 -27,4 4,9 9,1 13,7 18,9 1,6 8,2 52,6 17,1 0,0 34,4 285,4 19553
3 73,83 1,28858 7,50 0,0 -9,8 -26,0 4,9 9,1 13,0 21,8 1,8 10,1 57,8 22,1 0,0 41,3 237,7 16289
4 70,02 1,22205 9,00 0,0 -9,8 -24,9 4,9 9,1 12,5 24,4 2,0 11,7 62,0 27,1 0,0 47,8 205,1 14051
5 67,42 1,17671 10,00 0,0 -9,8 -24,4 4,9 9,1 12,2 25,9 2,1 12,5 64,4 30,4 0,0 52,0 188,5 12916
6 63,42 1,10684 11,50 0,0 -9,8 -23,7 4,9 9,1 11,9 27,9 2,2 13,5 67,5 35,5 0,0 58,1 168,9 11573
7 59,25 1,03418 13,00 0,0 -9,8 -23,2 4,9 9,1 11,6 29,6 2,2 14,2 70,2 40,5 0,0 63,8 153,7 10533
8 54,89 0,95795 14,50 0,0 -9,8 -22,8 4,9 9,1 11,4 31,1 2,3 14,6 72,5 45,6 0,0 69,2 141,7 9709
9 50,25 0,87703 16,00 0,0 -9,8 -22,5 4,9 9,1 11,2 32,4 2,3 14,6 74,4 50,7 0,0 74,3 132,0 9042
10 45,25 0,78976 17,50 0,0 -9,8 -22,2 4,9 9,1 11,1 33,6 2,2 14,2 76,1 55,8 0,0 79,1 124,0 8496
11 39,73 0,69348 19,00 0,0 -9,8 -22,1 4,9 9,1 11,0 34,5 2,1 13,5 77,6 60,9 0,0 83,5 117,4 8048
12 31,05 0,54189 21,00 0,0 -9,8 -21,9 4,9 9,1 11,0 35,4 2,0 11,7 79,1 67,9 0,0 88,7 110,6 7576
13 20,33 0,35486 22,80 0,0 -9,8 -21,9 4,9 9,1 10,9 35,8 1,7 9,0 79,8 74,3 0,0 92,3 106,2 7279
14 4,06 0,07080 24,00 0,0 -9,8 -22,1 4,9 9,1 11,0 35,2 1,1 4,5 79,2 79,0 0,0 92,6 105,9 7259
15 4,06 0,07080 24,00 0,0 -9,8 -22,1 4,9 9,1 11,0 35,2 1,1 4,5 79,2 79,0 0,0 92,6 105,9 7259
16 4,06 0,07080 24,00 0,00 -9,8 -22,1 4,9 9,1 11,0 35,2 1,1 4,5 79,2 79,0 0,0 92,6 105,9 7259
17 4,06 0,07080 24,00 0,0 -9,8 -22,1 4,9 9,1 11,0 35,2 1,1 4,5 79,2 79,0 0,0 92,6 105,9 7259
18 4,06 0,07080 24,00 0,0 -9,8 -22,1 4,9 9,1 11,0 35,2 1,1 4,5 79,2 79,0 0,0 92,6 105,9 7259
19 4,06 0,07080 24,00 0,0 -9,8 -22,1 4,9 9,1 11,0 35,2 1,1 4,5 79,2 79,0 0,0 92,6 105,9 7259
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 18/158
LOAD CASE E "On board " wave height Hsig5 [m] 0 [ft] 0,000
LOAD CASE F "On board " wave height Hsig6 [m] 0 [ft] 0,000
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 19/158
LOAD CASE G - Aux "Off board Lifts" wave height Hsig7 [m] 1 [ft] 3,281
Hook forces Lifting rope forces Luffing cylinder Boom Crane vertical stiffness
Radius Capacity static dyn static dyn static dyn luffing added total
Prog luffing angle q La P F1z F1z F2 Dz1 F2dyn Fbc Dl3 Dz3 Fbdyn Dz5 Dz6 DzTOT spring rate K
[deg] [rad] [m] [tons] [kN] [kN] [kN] [mm] [kN] [kN] [mm] [mm] [kN] [mm] [mm] [mm] kN/m lb/ft
1 82,44 1,43886 5,45 5,00 -53,0 -99,0 53,0 203,9 99,0 76,1 6,6 28,4 142,3 9,0 1,0 242,2 218,7 14982
2 77,56 1,35368 7,67 5,00 -53,0 -97,1 53,0 203,9 97,1 101,9 8,7 44,5 186,8 16,4 1,0 265,7 199,3 13657
3 73,83 1,28858 9,33 5,00 -53,0 -95,9 53,0 203,9 95,9 117,9 9,8 54,7 213,6 21,9 1,0 281,5 188,1 12892
4 70,02 1,22205 10,99 5,00 -53,0 -95,1 53,0 203,9 95,1 131,6 10,7 63,1 236,3 27,5 1,0 295,5 179,2 12280
5 67,42 1,17671 12,09 5,00 -53,0 -94,6 53,0 203,9 94,6 139,7 11,2 67,7 249,7 31,3 1,0 303,9 174,3 11942
6 63,42 1,10684 13,74 5,00 -53,0 -94,1 53,0 203,9 94,1 150,6 11,7 73,2 267,5 36,9 1,0 314,9 168,1 11522
7 59,25 1,03418 15,39 5,00 -53,0 -93,7 53,0 203,9 93,7 160,0 12,1 76,8 283,2 42,6 1,0 324,3 163,3 11190
8 54,89 0,95795 17,03 5,00 -53,0 -93,5 53,0 203,9 93,5 168,2 12,3 78,7 297,0 48,3 1,0 331,9 159,6 10933
9 50,25 0,87703 18,66 5,00 -53,0 -93,5 53,0 203,9 93,5 175,2 12,2 78,8 309,4 54,1 1,0 337,7 156,8 10745
10 45,25 0,78976 20,29 5,00 -53,0 -93,6 53,0 203,9 93,6 181,3 12,0 76,9 320,4 59,9 1,0 341,7 155,0 10620
11 39,73 0,69348 21,91 5,00 -53,0 -93,9 53,0 203,9 93,9 186,2 11,6 72,9 330,2 65,8 1,0 343,6 154,1 10562
12 31,05 0,54189 24,05 5,00 -53,0 -94,6 53,0 203,9 94,6 191,1 10,6 63,4 341,3 73,8 1,0 342,1 154,8 10608
13 20,33 0,35486 25,93 5,00 -53,0 -95,7 53,0 203,9 95,7 193,1 9,0 48,4 349,0 81,3 1,0 334,6 158,3 10846
14 4,06 0,07080 27,05 5,00 -53,0 -97,6 53,0 203,9 97,6 189,9 6,0 24,2 350,0 87,3 1,0 316,3 167,4 11472
15 4,06 0,07080 27,05 5,00 -53,0 -97,6 53,0 203,9 97,6 189,9 6,0 24,2 350,0 87,3 1,0 316,3 167,4 11472
16 4,06 0,07080 27,05 5,00 -53,0 -97,6 53,0 203,9 97,6 189,9 6,0 24,2 350,0 87,3 1,0 316,3 167,4 11472
17 4,06 0,07080 27,05 5,00 -53,0 -97,6 53,0 203,9 97,6 189,9 6,0 24,2 350,0 87,3 1,0 316,3 167,4 11472
18 4,06 0,07080 27,05 5,00 -53,0 -97,6 53,0 203,9 97,6 189,9 6,0 24,2 350,0 87,3 1,0 316,3 167,4 11472
19 4,06 0,07080 27,05 5,00 -53,0 -97,6 53,0 203,9 97,6 189,9 6,0 24,2 350,0 87,3 1,0 316,3 167,4 11472
LOAD CASE H - Aux "Off board Lifts" wave height Hsig8 [m] 2,5 [ft] 8,202
Hook forces Lifting rope forces Luffing cylinder Boom Crane vertical stiffness
Radius Capacity static dyn static dyn static dyn luffing added total
Prog luffing angle q La P F1z F1z F2 Dz1 F2dyn Fbc Dl3 Dz3 Fbdyn Dz5 Dz6 DzTOT spring rate K
[deg] [rad] [m] [tons] [kN] [kN] [kN] [mm] [kN] [kN] [mm] [mm] [kN] [mm] [mm] [mm] kN/m lb/ft
1 82,44 1,43886 5,45 5,00 -53,0 -99,0 53,0 203,9 99,0 76,1 6,6 28,4 142,3 9,0 1,0 242,2 218,7 14982
2 77,56 1,35368 7,67 5,00 -53,0 -97,1 53,0 203,9 97,1 101,9 8,7 44,5 186,8 16,4 1,0 265,7 199,3 13657
3 73,83 1,28858 9,33 5,00 -53,0 -95,9 53,0 203,9 95,9 117,9 9,8 54,7 213,6 21,9 1,0 281,5 188,1 12892
4 70,02 1,22205 10,99 5,00 -53,0 -95,1 53,0 203,9 95,1 131,6 10,7 63,1 236,3 27,5 1,0 295,5 179,2 12280
5 67,42 1,17671 12,09 5,00 -53,0 -94,6 53,0 203,9 94,6 139,7 11,2 67,7 249,7 31,3 1,0 303,9 174,3 11942
6 63,42 1,10684 13,74 5,00 -53,0 -94,1 53,0 203,9 94,1 150,6 11,7 73,2 267,5 36,9 1,0 314,9 168,1 11522
7 59,25 1,03418 15,39 5,00 -53,0 -93,7 53,0 203,9 93,7 160,0 12,1 76,8 283,2 42,6 1,0 324,3 163,3 11190
8 54,89 0,95795 17,03 5,00 -53,0 -93,5 53,0 203,9 93,5 168,2 12,3 78,7 297,0 48,3 1,0 331,9 159,6 10933
9 50,25 0,87703 18,66 5,00 -53,0 -93,5 53,0 203,9 93,5 175,2 12,2 78,8 309,4 54,1 1,0 337,7 156,8 10745
10 45,25 0,78976 20,29 5,00 -53,0 -93,6 53,0 203,9 93,6 181,3 12,0 76,9 320,4 59,9 1,0 341,7 155,0 10620
11 39,73 0,69348 21,91 5,00 -53,0 -93,9 53,0 203,9 93,9 186,2 11,6 72,9 330,2 65,8 1,0 343,6 154,1 10562
12 31,05 0,54189 24,05 5,00 -53,0 -94,6 53,0 203,9 94,6 191,1 10,6 63,4 341,3 73,8 1,0 342,1 154,8 10608
13 20,33 0,35486 25,93 5,00 -53,0 -95,7 53,0 203,9 95,7 193,1 9,0 48,4 349,0 81,3 1,0 334,6 158,3 10846
14 4,06 0,07080 27,05 5,00 -53,0 -97,6 53,0 203,9 97,6 189,9 6,0 24,2 350,0 87,3 1,0 316,3 167,4 11472
15 4,06 0,07080 27,05 5,00 -53,0 -97,6 53,0 203,9 97,6 189,9 6,0 24,2 350,0 87,3 1,0 316,3 167,4 11472
16 4,06 0,07080 27,05 5,00 -53,0 -97,6 53,0 203,9 97,6 189,9 6,0 24,2 350,0 87,3 1,0 316,3 167,4 11472
17 4,06 0,07080 27,05 5,00 -53,0 -97,6 53,0 203,9 97,6 189,9 6,0 24,2 350,0 87,3 1,0 316,3 167,4 11472
18 4,06 0,07080 27,05 5,00 -53,0 -97,6 53,0 203,9 97,6 189,9 6,0 24,2 350,0 87,3 1,0 316,3 167,4 11472
19 4,06 0,07080 27,05 5,00 -53,0 -97,6 53,0 203,9 97,6 189,9 6,0 24,2 350,0 87,3 1,0 316,3 167,4 11472
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 20/158
LOAD CASE I - Aux "On board " wave height Hsig9 [m] 0 [ft] 0,000
Static forces acting on each luffing cylinders (bothY<0 and Y>0) : L Dynamic forces acting on each luffing cylinders (bothY<0 and Y>0) : Cv * L
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 21/158
Static forces acting on the BOOM HINGES (each hinge) [kN] : L
Main Aux
Radius A B C D E F G - Aux H - Aux I - Aux Radius
Prog. L[m] Fx Fz Fx Fz Fx Fz Fx Fz Fx Fz Fx Fz Fx Fz Fx Fz Fx Fz La [m]
1 4,00 25,4 191,9 25,4 191,9 1,2 9,1 1,2 9,1 25,4 191,9 1,2 9,1 6,5 49,4 6,5 49,4 6,5 49,4 5,45
2 6,00 55,7 289,4 55,7 289,4 2,7 13,8 2,7 13,8 55,7 289,4 2,7 13,8 14,3 74,4 14,3 74,4 14,3 74,4 7,67
3 7,50 83,5 347,8 83,5 347,8 4,0 16,6 4,0 16,6 83,5 347,8 4,0 16,6 21,5 89,4 21,5 89,4 21,5 89,4 9,33
4 9,00 115,0 395,8 115,0 395,8 5,5 18,8 5,5 18,8 115,0 395,8 5,5 18,8 29,6 101,8 29,6 101,8 29,6 101,8 10,99
5 10,00 137,7 422,7 137,7 422,7 6,6 20,1 6,6 20,1 108,2 332,1 6,6 20,1 35,4 108,7 35,4 108,7 35,4 108,7 12,09
6 11,50 174,4 455,9 153,6 401,7 8,3 21,7 8,3 21,7 122,1 319,2 8,3 21,7 44,8 117,2 44,8 117,2 44,8 117,2 13,74
7 13,00 213,8 481,3 162,9 366,7 10,2 22,9 10,2 22,9 112,0 252,1 10,2 22,9 55,0 123,8 55,0 123,8 55,0 123,8 15,39
8 14,50 231,6 451,3 170,6 332,5 12,2 23,8 12,2 23,8 109,7 213,8 12,2 23,8 65,8 128,3 65,8 128,3 65,8 128,3 17,03
9 16,00 236,4 399,5 171,9 290,5 14,3 24,2 14,3 24,2 114,6 193,7 14,3 24,2 77,4 130,7 77,4 130,7 77,4 130,7 18,66
10 17,50 257,4 376,1 182,7 266,9 16,6 24,3 16,6 24,3 132,9 194,1 16,6 24,3 89,7 131,0 89,7 131,0 89,7 131,0 20,29
11 19,00 280,1 350,5 181,0 226,5 19,1 23,8 19,1 23,8 152,5 190,7 19,1 23,8 102,9 128,7 102,9 128,7 102,9 128,7 21,91
12 21,00 249,4 245,0 192,7 189,3 22,7 22,3 22,7 22,3 181,4 178,2 22,7 22,3 122,4 120,3 122,4 120,3 122,4 120,3 24,05
13 22,80 239,1 171,2 199,3 142,7 26,6 19,0 26,6 19,0 212,6 152,2 26,6 19,0 143,5 102,7 143,5 102,7 143,5 102,7 25,93
14 24,00 247,5 94,6 216,6 82,8 30,9 11,8 30,9 11,8 247,5 94,6 30,9 11,8 167,1 63,8 167,1 63,8 167,1 63,8 27,05
15 24,00 247,5 94,6 216,6 82,8 30,9 11,8 30,9 11,8 247,5 94,6 30,9 11,8 167,1 63,8 167,1 63,8 167,1 63,8 27,05
16 24,00 247,5 94,6 216,6 82,8 30,9 11,8 30,9 11,8 247,5 94,6 30,9 11,8 167,1 63,8 167,1 63,8 167,1 63,8 27,05
17 24,00 247,5 94,6 216,6 82,8 30,9 11,8 30,9 11,8 247,5 94,6 30,9 11,8 167,1 63,8 167,1 63,8 167,1 63,8 27,05
18 24,00 247,5 94,6 216,6 82,8 30,9 11,8 30,9 11,8 247,5 94,6 30,9 11,8 167,1 63,8 167,1 63,8 167,1 63,8 27,05
19 24,00 247,5 94,6 216,6 82,8 30,9 11,8 30,9 11,8 247,5 94,6 30,9 11,8 167,1 63,8 167,1 63,8 167,1 63,8 27,05
Main Aux
Radius A B C D E F G - Aux H - Aux I - Aux Radius
Prog. L[m] Fx Fz Fx Fz Fx Fz Fx Fz Fx Fz Fx Fz Fx Fz Fx Fz Fx Fz La [m]
1 4,00 33,8 255,3 33,8 255,3 3,7 27,8 3,7 28,1 33,8 255,3 1,6 12,2 12,2 92,3 12,2 92,3 8,7 65,6 5,45
2 6,00 74,0 384,9 74,0 384,9 7,3 38,1 7,4 38,4 74,0 384,9 3,5 18,3 26,2 136,4 26,2 136,4 19,0 99,0 7,67
3 7,50 111,0 462,6 111,0 462,6 10,5 43,6 10,5 43,9 111,0 462,6 5,3 22,0 38,9 162,0 38,9 162,0 28,5 119,0 9,33
4 9,00 152,9 526,4 152,9 526,4 13,8 47,7 13,9 47,9 152,9 526,4 7,3 25,1 53,1 182,7 53,1 182,7 39,3 135,4 10,99
5 10,00 183,2 562,2 183,2 562,2 16,2 49,8 16,3 50,1 143,9 441,7 8,7 26,8 63,3 194,2 63,3 194,2 47,1 144,6 12,09
6 11,50 231,9 606,4 204,3 534,2 20,0 52,3 20,1 52,6 162,3 424,5 11,0 28,9 79,7 208,3 79,7 208,3 59,6 155,9 13,74
7 13,00 284,4 640,1 216,7 487,7 24,0 54,1 24,1 54,3 148,9 335,3 13,5 30,5 97,3 219,0 97,3 219,0 73,1 164,6 15,39
8 14,50 308,0 600,2 226,9 442,3 28,2 55,1 28,4 55,3 145,9 284,3 16,2 31,6 116,3 226,6 116,3 226,6 87,5 170,6 17,03
9 16,00 314,4 531,3 228,7 386,4 32,7 55,3 32,9 55,5 152,4 257,6 19,1 32,2 136,6 230,8 136,6 230,8 102,9 173,9 18,66
10 17,50 342,4 500,2 246,5 360,2 37,5 54,8 37,7 55,0 176,7 258,2 22,1 32,3 158,5 231,6 158,5 231,6 119,3 174,3 20,29
11 19,00 372,6 466,1 256,0 320,3 42,7 53,5 42,9 53,6 202,8 253,7 25,3 31,7 182,4 228,3 182,4 228,3 136,9 171,2 21,91
12 21,00 342,0 336,0 284,3 279,3 50,5 49,6 50,6 49,8 241,2 237,0 30,2 29,6 218,7 214,8 218,7 214,8 162,8 160,0 24,05
13 22,80 353,3 253,0 309,6 221,7 59,1 42,3 59,3 42,5 282,7 202,4 35,3 25,3 259,3 185,7 259,3 185,7 190,8 136,6 25,93
14 24,00 389,1 148,7 353,0 134,9 69,4 26,5 69,6 26,6 329,2 125,8 41,1 15,7 307,9 117,6 307,9 117,6 222,2 84,9 27,05
15 24,00 389,1 148,7 353,0 134,9 69,4 26,5 69,6 26,6 329,2 125,8 41,1 15,7 307,9 117,6 307,9 117,6 222,2 84,9 27,05
16 24,00 389,1 148,7 353,0 134,9 69,4 26,5 69,6 26,6 329,2 125,8 41,1 15,7 307,9 117,6 307,9 117,6 222,2 84,9 27,05
17 24,00 389,1 148,7 353,0 134,9 69,4 26,5 69,6 26,6 329,2 125,8 41,1 15,7 307,9 117,6 307,9 117,6 222,2 84,9 27,05
18 24,00 389,1 148,7 353,0 134,9 69,4 26,5 69,6 26,6 329,2 125,8 41,1 15,7 307,9 117,6 307,9 117,6 222,2 84,9 27,05
19 24,00 389,1 148,7 353,0 134,9 69,4 26,5 69,6 26,6 329,2 125,8 41,1 15,7 307,9 117,6 307,9 117,6 222,2 84,9 27,05
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 22/158
VERTICAL DYNAMIC COEFFICIENTS "Cv"
LOAD CASE A "Off board Lifts" wave height Hsig1 [m] 1 [ft] 3,281
purchaser data (for vessel specific method only) min design hoist speed Vhmin1 [m/1'] 12,035 [ft/sec] 0,658
boom tip velocity Vcpa [ft/s] (if no data leave blank) crane boom tip velocity V1c [m/1'] 0,000 [ft/sec] 0,000 0,000
boat deck velocity Vdpa [ft/s] (if no data leave blank) supply boat velocity V1d [m/1'] 0,000 [ft/sec] 1,968 0,000
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 23/158
LOAD CASE B "Off board Lifts" wave height Hsig2 [m] 2,5 [ft] 8,202
purchaser data (for vessel specific method only) min design hoist speed Vhmin2 [m/1'] 21,035 [ft/sec] 1,150
boom tip velocity Vcpb [ft/s] (if no data leave blank) crane boom tip velocity V2c [m/1'] 0,000 [ft/sec] 0,000 0,000
boat deck velocity Vdpb [ft/s] (if no data leave blank) supply boat velocity V2d [m/1'] 0,000 [ft/sec] 4,921 0,000
LOAD CASE C "Off board Lifts" wave height Hsig3 [m] 0 [ft] 0,000
purchaser data (for vessel specific method only) min design hoist speed Vhmin3 [m/1'] 6,035 [ft/sec] 0,330
boom tip velocity Vcpc [ft/s] (if no data leave blank) crane boom tip velocity V3c [m/1'] 0,000 [ft/sec] 0,000 0,000
boat deck velocity Vdpc [ft/s] (if no data leave blank) supply boat velocity V3d [m/1'] 0,000 [ft/sec] 0,000 0,000
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 24/158
LOAD CASE D "Off board Lifts" wave height Hsig4 [m] 0 [ft] 0,000
purchaser data (for vessel specific method only) min design hoist speed Vhmin4 [m/1'] 6,035 [ft/sec] 0,330
boom tip velocity Vcpd [ft/s] (if no data leave blank) crane boom tip velocity V4c [m/1'] 0,000 [ft/sec] 0,000 0,000
boat deck velocity Vdpd [ft/s] (if no data leave blank) supply boat velocity V4d [m/1'] 0,000 [ft/sec] 0,000 0,000
LOAD CASE E "On board " wave height Hsig5 [m] 0 [ft] 0,000
purchaser data (for vessel specific method only)
dynamic coeff. Cvpe (if no data leave blank) design on- board dynamic coefficient Cv on5 1,330 1,330
LOAD CASE F "On board " wave height Hsig6 [m] 0 [ft] 0,000
purchaser data (for vessel specific method only)
dynamic coeff. Cvpf (if no data leave blank) design on- board dynamic coefficient Cv on6 1,330 1,330
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 25/158
LOAD CASE G - Aux "Off board Lifts" wave height Hsig7 [m] 1 [ft] 3,281
purchaser data (for vessel specific method only) min design hoist speed Vhmin7 [m/1'] 12,035 [ft/sec] 0,658
boom tip velocity Vcpg [ft/s] (if no data leave blank) crane boom tip velocity V7c [m/1'] 0,000 [ft/sec] 0,000 0,000
boat deck velocity Vdpg [ft/s] (if no data leave blank) supply boat velocity V7d [m/1'] 0,000 [ft/sec] 1,968 0,000
LOAD CASE H - Aux "Off board Lifts" wave height Hsig8 [m] 2,5 [ft] 8,202
purchaser data (for vessel specific method only) min design hoist speed Vhmin8 [m/1'] 21,035 [ft/sec] 1,150
boom tip velocity Vcph [ft/s] (if no data leave blank) crane boom tip velocity V8c [m/1'] 0,000 [ft/sec] 0,000 0,000
boat deck velocity Vdph [ft/s] (if no data leave blank) supply boat velocity V8d [m/1'] 0,000 [ft/sec] 4,921 0,000
LOAD CASE I - Aux "On board " wave height Hsig9 [m] 0 [ft] 0,000
purchaser data (for vessel specific method only)
dynamic coeff. Cvpi (if no data leave blank) design on- board dynamic coefficient Cv on9 1,330 1,330
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 26/158
HORIZONTAL FORCES ON LIFTED LOAD DUE TO SUPPLY BOAT MOTION (SB forces), CRANE INCLINATION (CI forces) and CRANE MOTION (CM forces)
LOAD CASE A "Off board Lifts" wave height Hsig1 [m] 1 [ft] 3,281
Purchaser data (for vessel specific method only) The side coefficients are used to divide the out of plane forces between booms and cylinders hinges. They have been carried out by simplified FEA models
2
crane dyn. horiz. accel. a1hp [m/s ] (if no data leave blank) design crane dynamic horz acceleration a1h [m/s2] 0,000 0,294
supply boat motion - off. angle l1off [deg] (if no data leave blank) design crane static inclination angle (heel) q1s [deg] 0,500 0,500
supply boat motion - side angle l1sid [deg] (if no data leave blank) crane base angle (0° only offlead ; 90° only sidelead) j1A = [deg] 0,00 rad 0,00000
vessel static inclination angle q1SP [deg] (if no data leave blank)
offlead and sidelead due to suply boat motion stat. crane crane total horiz. loads D forces produced on Luffing cylinders Forces produced on Luffing Boom Hinges
capacity by API off and side forces inclin. motion for base angle j 1A offllead movement side coeff. sidelead movement off+side mouv. offlead mov. sidelead mouvements offlead + sidelead mouvements
Radius P loff_SB lsid_SB W off_SB W sid_SB W smin_SB W sid_CI W ho_CM W off_T W sid_T Y<0 Y>0 luffing cylinders Y<0 Y>0 Y<0 Y>0 each hinge Y <0 Luffing Hinge Y < 0 Luffing Hinge Y < 0 Luffing Hinge Y > 0
Prog. L[m] [ton] [deg] [deg] [kN] [kN] [kN] [kN] [kN] [kN] [kN] [kN] [kN] calc. used [kN] [kN] [kN] [kN] Fx [kN] Fz [kN] Fx [kN] Fy [kN] Fz [kN] Fx [kN] Fy [kN] Fz [kN] Fx [kN] Fy [kN] Fz [kN]
1 4,00 20,0 6,17 3,09 29,63 14,77 14,77 2,39 8,22 30,75 17,16 261,61 261,61 0,049 0,049 -12,94 12,94 248,7 274,5 37,8 260,6 42,1 8,6 244,5 79,9 8,6 505,1 -4,2 8,6 16,2
2 6,00 20,0 6,17 3,09 29,63 14,77 14,77 2,39 8,22 30,75 17,16 229,31 229,31 0,043 0,043 -11,36 11,36 217,9 240,7 47,6 228,5 63,2 8,6 241,1 110,7 8,6 469,6 -15,6 8,6 -12,7
3 7,50 20,0 6,17 3,09 29,63 14,77 14,77 2,39 8,22 30,75 17,16 208,20 208,20 0,036 0,036 -9,51 9,51 198,7 217,7 53,3 207,4 79,2 8,6 237,8 132,4 8,6 445,2 -25,9 8,6 -30,4
4 9,00 20,0 6,17 3,09 29,63 14,77 14,77 2,39 8,22 30,75 17,16 189,05 189,05 0,033 0,033 -8,72 8,72 180,3 197,8 57,8 188,3 95,1 8,6 232,5 152,9 8,6 420,9 -37,3 8,6 -44,2
5 10,00 20,0 6,17 3,09 29,63 14,77 14,77 2,39 8,22 30,75 17,16 177,13 177,13 0,030 0,030 -7,92 7,92 169,2 185,1 60,3 176,5 105,8 8,6 228,5 166,0 8,6 405,0 -45,5 8,6 -52,1
6 11,50 20,0 6,17 3,09 29,63 14,77 14,77 2,39 8,22 30,75 17,16 160,24 160,24 0,023 0,023 -6,08 6,08 154,2 166,3 63,1 159,7 122,0 8,6 221,8 185,1 8,6 381,5 -58,9 8,6 -62,2
7 13,00 20,0 6,17 3,09 29,63 14,77 14,77 2,39 8,22 30,75 17,16 144,26 144,26 0,017 0,017 -4,49 4,49 139,8 148,8 65,0 143,7 138,3 8,6 213,5 203,2 8,6 357,2 -73,3 8,6 -69,7
8 14,50 18,0 6,17 3,09 26,81 13,36 13,36 2,16 7,43 27,82 15,53 116,62 116,62 0,016 0,016 -3,82 3,82 112,8 120,4 59,6 116,2 139,6 7,8 183,2 199,2 7,8 299,4 -80,1 7,8 -67,0
9 16,00 15,5 6,17 3,09 23,28 11,61 11,61 1,88 6,46 24,16 13,48 89,47 89,47 0,015 0,015 -3,11 3,11 86,4 92,6 51,6 89,1 133,8 6,7 148,9 185,4 6,7 238,0 -82,2 6,7 -59,7
10 17,50 14,5 6,17 3,09 21,87 10,90 10,90 1,76 6,07 22,69 12,67 72,99 72,99 0,016 0,016 -3,12 3,12 69,9 76,1 47,5 72,7 137,4 6,3 128,2 184,9 6,3 200,9 -89,9 6,3 -55,5
11 19,00 13,7 6,17 3,09 20,74 10,34 10,34 1,67 5,75 21,52 12,01 58,51 58,51 0,016 0,016 -2,96 2,96 55,6 61,5 43,1 58,3 141,4 6,0 108,5 184,5 6,0 166,7 -98,4 6,0 -50,2
12 21,00 10,0 6,17 3,09 16,00 7,98 7,98 1,29 4,44 16,61 9,27 33,25 33,25 0,016 0,016 -2,28 2,28 31,0 35,5 29,6 33,1 120,6 4,6 66,2 150,2 4,6 99,3 -91,0 4,6 -33,1
13 22,80 8,0 6,17 3,09 14,10 7,03 7,03 1,14 3,91 14,64 8,17 17,65 17,65 0,017 0,017 -2,14 2,14 15,5 19,8 20,4 17,6 115,2 4,1 37,5 135,7 4,1 55,0 -94,8 4,1 -19,9
14 24,00 7,0 6,17 3,09 13,34 6,65 6,65 1,08 3,70 13,84 7,73 1,76 1,76 0,019 0,019 -2,26 2,26 -0,5 4,0 8,5 1,8 114,4 3,9 3,3 122,9 3,9 5,1 -106,0 3,9 -1,6
15 24,00 7,0 6,17 3,09 13,34 6,65 6,65 1,08 3,70 13,84 7,73 1,76 1,76 0,019 0,019 -2,26 2,26 -0,5 4,0 8,5 1,8 114,4 3,9 3,3 122,9 3,9 5,1 -106,0 3,9 -1,6
16 24,00 7,0 6,17 3,09 13,34 6,65 6,65 1,08 3,70 13,84 7,73 1,76 1,76 0,019 0,019 -2,26 2,26 -0,5 4,0 8,5 1,8 114,4 3,9 3,3 122,9 3,9 5,1 -106,0 3,9 -1,6
17 24,00 7,0 6,17 3,09 13,34 6,65 6,65 1,08 3,70 13,84 7,73 1,76 1,76 0,019 0,019 -2,26 2,26 -0,5 4,0 8,5 1,8 114,4 3,9 3,3 122,9 3,9 5,1 -106,0 3,9 -1,6
18 24,00 7,0 6,17 3,09 13,34 6,65 6,65 1,08 3,70 13,84 7,73 1,76 1,76 0,019 0,019 -2,26 2,26 -0,5 4,0 8,5 1,8 114,4 3,9 3,3 122,9 3,9 5,1 -106,0 3,9 -1,6
19 24,00 7,0 6,17 3,09 13,34 6,65 6,65 1,08 3,70 13,84 7,73 1,76 1,76 0,019 0,019 -2,26 2,26 -0,5 4,0 8,5 1,8 114,4 3,9 3,3 122,9 3,9 5,1 -106,0 3,9 -1,6
LOAD CASE B "Off board Lifts" wave height Hsig2 [m] 2,5 [ft] 8,202
Purchaser data (for vessel specific method only) The side coefficients are used to divide the out of plane forces between booms and cylinders hinges. They have been carried out by simplified FEA models
crane dyn. horiz. accel. a2hp [m/s2] (if no data leave blank) design crane dynamic horz acceleration a2h [m/s2] 0,000 0,294
supply boat motion - off. angle l2off [deg] (if no data leave blank) design crane static inclination angle (heel) q2s [deg] 0,500 0,500
supply boat motion - side angle l2sid [deg] (if no data leave blank)
vessel static inclination angle q2SP [deg] (if no data leave blank)
offlead and sidelead due to suply boat motion stat. crane crane total horiz. loads D forces produced on Luffing cylinders Forces produced on Luffing Boom Hinges
capacity by API off and side forces inclin. motion for base angle j 1A offllead movement side coeff. sidelead movement off+side mouv. offlead mouv. sidelead mouvements offlead + sidelead mouvements
Radius P loff_SB lsid_SB W off_SB W sid_SB W smin_SB W sid_CI W ho_CM W off_T W sid_T Y<0 Y>0 luffing cylinders Y<0 Y>0 Y<0 Y>0 each hinge Y <0 Luffing Hinge Y < 0 Luffing Hinge Y < 0 Luffing Hinge Y > 0
Prog. L[m] [ton] [deg] [deg] [kN] [kN] [kN] [kN] [kN] [kN] [kN] [kN] [kN] calc. used [kN] [kN] [kN] [kN] Fx [kN] Fz [kN] Fx [kN] Fy [kN] Fz [kN] Fx [kN] Fy [kN] Fz [kN] Fx [kN] Fy [kN] Fz [kN]
1 4,00 20,0 9,59 4,80 46,29 22,98 22,98 2,39 8,22 47,01 25,37 400,01 400,01 0,049 0,049 -19,13 19,13 380,9 419,1 57,9 398,5 62,2 12,7 361,4 120,1 12,7 760,0 -4,4 12,7 37,1
2 6,00 20,0 9,59 4,80 46,29 22,98 22,98 2,39 8,22 47,01 25,37 350,62 350,62 0,043 0,043 -16,79 16,79 333,8 367,4 72,7 347,1 93,4 12,7 356,5 166,1 12,7 703,6 -20,7 12,7 -9,3
3 7,50 20,0 9,59 4,80 46,29 22,98 22,98 2,39 8,22 47,01 25,37 318,34 318,34 0,036 0,036 -14,06 14,06 304,3 332,4 81,5 313,0 117,0 12,7 351,6 198,5 12,7 664,6 -35,6 12,7 -38,6
4 9,00 20,0 9,59 4,80 46,29 22,98 22,98 2,39 8,22 47,01 25,37 289,06 289,06 0,033 0,033 -12,89 12,89 276,2 301,9 88,4 281,7 140,6 12,7 343,8 229,0 12,7 625,5 -52,2 12,7 -62,1
5 10,00 20,0 9,59 4,80 46,29 22,98 22,98 2,39 8,22 47,01 25,37 270,84 270,84 0,030 0,030 -11,72 11,72 259,1 282,6 92,2 262,0 156,4 12,7 337,9 248,5 12,7 599,9 -64,2 12,7 -75,9
6 11,50 17,5 9,59 4,80 40,78 20,25 20,25 2,11 7,24 41,42 22,35 215,85 215,85 0,023 0,023 -7,91 7,91 207,9 223,8 85,0 206,1 158,9 11,2 288,9 243,9 11,2 495,0 -73,9 11,2 -82,9
7 13,00 15,0 9,59 4,80 35,27 17,51 17,51 1,82 6,26 35,82 19,33 168,06 168,06 0,017 0,017 -5,06 5,06 163,0 173,1 75,7 157,8 155,8 9,7 240,5 231,4 9,7 398,3 -80,1 9,7 -82,6
8 14,50 13,0 9,59 4,80 30,86 15,32 15,32 1,59 5,48 31,34 16,91 131,39 131,39 0,016 0,016 -4,17 4,17 127,2 135,6 67,1 120,9 152,1 8,5 199,5 219,2 8,5 320,5 -85,0 8,5 -78,6
9 16,00 11,0 9,59 4,80 26,45 13,13 13,13 1,37 4,70 26,86 14,50 99,49 99,49 0,015 0,015 -3,35 3,35 96,1 102,8 57,4 89,3 143,9 7,2 160,1 201,3 7,2 249,3 -86,5 7,2 -70,8
10 17,50 10,0 9,59 4,80 24,60 12,21 12,21 1,27 4,37 24,98 13,48 80,36 80,36 0,016 0,016 -3,32 3,32 77,0 83,7 52,3 69,8 146,3 6,7 136,5 198,5 6,7 206,3 -94,0 6,7 -66,6
11 19,00 8,5 9,59 4,80 22,27 11,05 11,05 1,15 3,95 22,61 12,20 61,48 61,48 0,016 0,016 -3,01 3,01 58,5 64,5 45,3 51,2 143,7 6,1 110,2 189,0 6,1 161,4 -98,4 6,1 -58,9
12 21,00 7,5 9,59 4,80 20,78 10,32 10,32 1,07 3,69 21,11 11,39 42,26 42,26 0,016 0,016 -2,81 2,81 39,5 45,1 37,6 32,4 148,2 5,7 81,3 185,8 5,7 113,8 -110,6 5,7 -48,9
13 22,80 6,5 9,59 4,80 19,31 9,59 9,59 1,00 3,43 19,61 10,58 23,65 23,65 0,017 0,017 -2,77 2,77 20,9 26,4 27,4 15,8 149,3 5,3 48,5 176,7 5,3 64,3 -121,9 5,3 -32,7
14 24,00 6,0 9,59 4,80 18,91 9,39 9,39 0,98 3,36 19,21 10,37 2,44 2,44 0,019 0,019 -3,03 3,03 -0,6 5,5 11,7 1,2 153,5 5,2 4,4 165,3 5,2 5,6 -141,8 5,2 -3,3
15 24,00 6,0 9,59 4,80 18,91 9,39 9,39 0,98 3,36 19,21 10,37 2,44 2,44 0,019 0,019 -3,03 3,03 -0,6 5,5 11,7 1,2 153,5 5,2 4,4 165,3 5,2 5,6 -141,8 5,2 -3,3
16 24,00 6,0 9,59 4,80 18,91 9,39 9,39 0,98 3,36 19,21 10,37 2,44 2,44 0,019 0,019 -3,03 3,03 -0,6 5,5 11,7 1,2 153,5 5,2 4,4 165,3 5,2 5,6 -141,8 5,2 -3,3
17 24,00 6,0 9,59 4,80 18,91 9,39 9,39 0,98 3,36 19,21 10,37 2,44 2,44 0,019 0,019 -3,03 3,03 -0,6 5,5 11,7 1,2 153,5 5,2 4,4 165,3 5,2 5,6 -141,8 5,2 -3,3
18 24,00 6,0 9,59 4,80 18,91 9,39 9,39 0,98 3,36 19,21 10,37 2,44 2,44 0,019 0,019 -3,03 3,03 -0,6 5,5 11,7 1,2 153,5 5,2 4,4 165,3 5,2 5,6 -141,8 5,2 -3,3
19 24,00 6,0 9,59 4,80 18,91 9,39 9,39 0,98 3,36 19,21 10,37 2,44 2,44 0,019 0,019 -3,03 3,03 -0,6 5,5 11,7 1,2 153,5 5,2 4,4 165,3 5,2 5,6 -141,8 5,2 -3,3
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 27/158
LOAD CASE C "Off board Lifts" wave height Hsig3 [m] 0 [ft] 0,000
Purchaser data (for vessel specific method only) The side coefficients are used to divide the out of plane forces between booms and cylinders hinges. They have been carried out by simplified FEA models
crane dyn. horiz. accel. a3hp [m/s2] (if no data leave blank) design crane dynamic horz acceleration a3h [m/s2] 0,000 0,294
supply boat motion - off. angle l3off [deg] (if no data leave blank) design crane static inclination angle (heel) q3s [deg] 0,500 0,500
supply boat motion - side angle l3sid [deg] (if no data leave blank)
vessel static inclination angle q3SP [deg] (if no data leave blank)
offlead and sidelead due to suply boat motion stat. crane crane total horiz. loads D forces produced on Luffing cylinders Forces produced on Luffing Boom Hinges
capacity by API off and side forces inclin. motion for base angle j 1A offllead movement side coeff. sidelead movement off+side mouv. offlead mouv. sidelead mouvements offlead + sidelead mouvements
Radius P loff_SB lsid_SB W off_SB W sid_SB W smin_SB W sid_CI W ho_CM W off_T W sid_T Y<0 Y>0 luffing cylinders Y<0 Y>0 Y<0 Y>0 each hinge Y <0 Luffing Hinge Y < 0 Luffing Hinge Y < 0 Luffing Hinge Y > 0
Prog. L[m] [ton] [deg] [deg] [kN] [kN] [kN] [kN] [kN] [kN] [kN] [kN] [kN] calc. used [kN] [kN] [kN] [kN] Fx [kN] Fz [kN] Fx [kN] Fy [kN] Fz [kN] Fx [kN] Fy [kN] Fz [kN] Fx [kN] Fy [kN] Fz [kN]
1 4,00 0,0 3,87 1,93 2,02 1,01 1,01 0,26 0,89 2,21 1,27 18,76 18,76 0,049 0,049 -0,96 0,96 17,8 19,7 2,7 18,7 3,1 0,6 18,0 5,8 0,6 36,7 -0,4 0,6 0,6
2 6,00 0,0 3,87 1,93 1,83 0,92 0,92 0,24 0,81 2,01 1,15 14,96 14,96 0,043 0,043 -0,76 0,76 14,2 15,7 3,1 14,8 4,2 0,6 16,2 7,3 0,6 31,0 -1,1 0,6 -1,4
3 7,50 0,0 3,87 1,93 1,74 0,87 0,87 0,23 0,77 1,91 1,10 12,92 12,92 0,036 0,036 -0,61 0,61 12,3 13,5 3,3 12,7 5,1 0,5 15,2 8,4 0,5 27,9 -1,7 0,5 -2,5
4 9,00 0,0 3,87 1,93 1,68 0,84 0,84 0,22 0,74 1,83 1,05 11,28 11,28 0,033 0,033 -0,54 0,54 10,7 11,8 3,5 11,0 5,8 0,5 14,3 9,3 0,5 25,3 -2,4 0,5 -3,3
5 10,00 0,0 3,87 1,93 1,64 0,82 0,82 0,21 0,73 1,80 1,03 10,35 10,35 0,030 0,030 -0,48 0,48 9,9 10,8 3,5 10,0 6,4 0,5 13,7 9,9 0,5 23,7 -2,8 0,5 -3,7
6 11,50 0,0 3,87 1,93 1,60 0,80 0,80 0,21 0,71 1,75 1,00 9,11 9,11 0,023 0,023 -0,36 0,36 8,8 9,5 3,6 8,7 7,1 0,5 13,0 10,7 0,5 21,7 -3,6 0,5 -4,3
7 13,00 0,0 3,87 1,93 1,56 0,78 0,78 0,20 0,69 1,71 0,98 8,03 8,03 0,017 0,017 -0,26 0,26 7,8 8,3 3,6 7,5 7,9 0,5 12,2 11,5 0,5 19,8 -4,3 0,5 -4,7
8 14,50 0,0 3,87 1,93 1,54 0,77 0,77 0,20 0,68 1,68 0,97 7,05 7,05 0,016 0,016 -0,24 0,24 6,8 7,3 3,6 6,5 8,7 0,5 11,4 12,3 0,5 17,9 -5,1 0,5 -4,9
9 16,00 0,0 3,87 1,93 1,52 0,76 0,76 0,20 0,67 1,66 0,95 6,14 6,14 0,015 0,015 -0,22 0,22 5,9 6,4 3,5 5,5 9,5 0,5 10,5 13,0 0,5 16,0 -5,9 0,5 -5,0
10 17,50 0,0 3,87 1,93 1,50 0,75 0,75 0,19 0,67 1,64 0,94 5,27 5,27 0,016 0,016 -0,23 0,23 5,0 5,5 3,4 4,6 10,2 0,5 9,5 13,6 0,5 14,1 -6,8 0,5 -5,0
11 19,00 0,0 3,87 1,93 1,49 0,74 0,74 0,19 0,66 1,63 0,93 4,42 4,42 0,016 0,016 -0,23 0,23 4,2 4,7 3,3 3,7 11,0 0,5 8,4 14,3 0,5 12,1 -7,7 0,5 -4,8
12 21,00 0,0 3,87 1,93 1,48 0,74 0,74 0,19 0,66 1,62 0,93 3,23 3,23 0,016 0,016 -0,23 0,23 3,0 3,5 2,9 2,5 12,1 0,5 6,6 15,0 0,5 9,1 -9,2 0,5 -4,1
13 22,80 0,0 3,87 1,93 1,48 0,74 0,74 0,19 0,65 1,61 0,93 1,95 1,95 0,017 0,017 -0,24 0,24 1,7 2,2 2,3 1,3 13,1 0,5 4,3 15,3 0,5 5,6 -10,8 0,5 -2,9
14 24,00 0,0 3,87 1,93 1,49 0,74 0,74 0,19 0,66 1,63 0,94 0,21 0,21 0,019 0,019 -0,27 0,27 -0,1 0,5 1,0 0,1 13,9 0,5 0,4 14,9 0,5 0,5 -12,9 0,5 -0,3
15 24,00 0,0 3,87 1,93 1,49 0,74 0,74 0,19 0,66 1,63 0,94 0,21 0,21 0,019 0,019 -0,27 0,27 -0,1 0,5 1,0 0,1 13,9 0,5 0,4 14,9 0,5 0,5 -12,9 0,5 -0,3
16 24,00 0,0 3,87 1,93 1,49 0,74 0,74 0,19 0,66 1,63 0,94 0,21 0,21 0,019 0,019 -0,27 0,27 -0,1 0,5 1,0 0,1 13,9 0,5 0,4 14,9 0,5 0,5 -12,9 0,5 -0,3
17 24,00 0,0 3,87 1,93 1,49 0,74 0,74 0,19 0,66 1,63 0,94 0,21 0,21 0,019 0,019 -0,27 0,27 -0,1 0,5 1,0 0,1 13,9 0,5 0,4 14,9 0,5 0,5 -12,9 0,5 -0,3
18 24,00 0,0 3,87 1,93 1,49 0,74 0,74 0,19 0,66 1,63 0,94 0,21 0,21 0,019 0,019 -0,27 0,27 -0,1 0,5 1,0 0,1 13,9 0,5 0,4 14,9 0,5 0,5 -12,9 0,5 -0,3
19 24,00 0,0 3,87 1,93 1,49 0,74 0,74 0,19 0,66 1,63 0,94 0,21 0,21 0,019 0,019 -0,27 0,27 -0,1 0,5 1,0 0,1 13,9 0,5 0,4 14,9 0,5 0,5 -12,9 0,5 -0,3
LOAD CASE D "Off board Lifts" wave height Hsig4 [m] 0 [ft] 0,000
Purchaser data (for vessel specific method only) The side coefficients are used to divide the out of plane forces between booms and cylinders hinges. They have been carried out by simplified FEA models
2
crane dyn. horiz. accel. a4hp [m/s ] (if no data leave blank) design crane dynamic horz acceleration a4h [m/s2] 0,000 0,294
supply boat motion - off. angle l4off [deg] (if no data leave blank) design crane static inclination angle (heel) q4s [deg] 0,500 0,500
supply boat motion - side angle l4sid [deg] (if no data leave blank)
vessel static inclination angle q4SP [deg] (if no data leave blank)
offlead and sidelead due to suply boat motion stat. crane crane total horiz. loads D forces produced on Luffing cylinders Forces produced on Luffing Boom Hinges
capacity by API off and side forces inclin. motion for base angle j 1A offllead movement side coeff. sidelead movement off+side mouv. offlead mouv. sidelead mouvements offlead + sidelead mouvements
Radius P loff_SB lsid_SB W off_SB W sid_SB W smin_SB W sid_CI W ho_CM W off_T W sid_T Y<0 Y>0 luffing cylinders Y<0 Y>0 Y<0 Y>0 each hinge Y <0 Luffing Hinge Y < 0 Luffing Hinge Y < 0 Luffing Hinge Y > 0
Prog. L[m] [ton] [deg] [deg] [kN] [kN] [kN] [kN] [kN] [kN] [kN] [kN] [kN] calc. used [kN] [kN] [kN] [kN] Fx [kN] Fz [kN] Fx [kN] Fy [kN] Fz [kN] Fx [kN] Fy [kN] Fz [kN] Fx [kN] Fy [kN] Fz [kN]
1 4,00 0,0 3,87 1,93 2,04 1,02 1,02 0,26 0,91 2,23 1,28 19,00 19,00 0,049 0,049 -0,97 0,97 18,0 20,0 2,7 18,9 3,1 0,6 18,3 5,9 0,6 37,2 -0,4 0,6 0,7
2 6,00 0,0 3,87 1,93 1,85 0,92 0,92 0,24 0,82 2,02 1,16 15,09 15,09 0,043 0,043 -0,77 0,77 14,3 15,9 3,1 14,9 4,3 0,6 16,3 7,4 0,6 31,3 -1,1 0,6 -1,4
3 7,50 0,0 3,87 1,93 1,76 0,88 0,88 0,23 0,78 1,92 1,10 13,01 13,01 0,036 0,036 -0,61 0,61 12,4 13,6 3,3 12,8 5,1 0,6 15,3 8,4 0,6 28,1 -1,8 0,6 -2,5
4 9,00 0,0 3,87 1,93 1,69 0,84 0,84 0,22 0,75 1,85 1,06 11,35 11,35 0,033 0,033 -0,54 0,54 10,8 11,9 3,5 11,1 5,9 0,5 14,4 9,3 0,5 25,4 -2,4 0,5 -3,3
5 10,00 0,0 3,87 1,93 1,65 0,82 0,82 0,21 0,73 1,81 1,04 10,40 10,40 0,030 0,030 -0,48 0,48 9,9 10,9 3,5 10,1 6,4 0,5 13,8 9,9 0,5 23,9 -2,9 0,5 -3,8
6 11,50 0,0 3,87 1,93 1,61 0,80 0,80 0,21 0,71 1,76 1,01 9,16 9,16 0,023 0,023 -0,36 0,36 8,8 9,5 3,6 8,7 7,2 0,5 13,0 10,8 0,5 21,8 -3,6 0,5 -4,3
7 13,00 0,0 3,87 1,93 1,57 0,78 0,78 0,20 0,70 1,72 0,99 8,06 8,06 0,017 0,017 -0,26 0,26 7,8 8,3 3,6 7,6 8,0 0,5 12,3 11,6 0,5 19,9 -4,3 0,5 -4,7
8 14,50 0,0 3,87 1,93 1,54 0,77 0,77 0,20 0,68 1,69 0,97 7,08 7,08 0,016 0,016 -0,24 0,24 6,8 7,3 3,6 6,5 8,7 0,5 11,4 12,3 0,5 18,0 -5,1 0,5 -4,9
9 16,00 0,0 3,87 1,93 1,52 0,76 0,76 0,20 0,67 1,66 0,96 6,16 6,16 0,015 0,015 -0,22 0,22 5,9 6,4 3,6 5,5 9,5 0,5 10,6 13,0 0,5 16,1 -5,9 0,5 -5,0
10 17,50 0,0 3,87 1,93 1,50 0,75 0,75 0,19 0,67 1,65 0,95 5,29 5,29 0,016 0,016 -0,23 0,23 5,1 5,5 3,4 4,6 10,3 0,5 9,6 13,7 0,5 14,2 -6,8 0,5 -5,0
11 19,00 0,0 3,87 1,93 1,49 0,74 0,74 0,19 0,66 1,63 0,94 4,44 4,44 0,016 0,016 -0,23 0,23 4,2 4,7 3,3 3,7 11,0 0,5 8,5 14,3 0,5 12,2 -7,8 0,5 -4,8
12 21,00 0,0 3,87 1,93 1,48 0,74 0,74 0,19 0,66 1,62 0,93 3,24 3,24 0,016 0,016 -0,23 0,23 3,0 3,5 2,9 2,5 12,1 0,5 6,6 15,0 0,5 9,1 -9,2 0,5 -4,2
13 22,80 0,0 3,87 1,93 1,48 0,74 0,74 0,19 0,66 1,62 0,93 1,95 1,95 0,017 0,017 -0,24 0,24 1,7 2,2 2,3 1,3 13,1 0,5 4,3 15,4 0,5 5,6 -10,9 0,5 -3,0
14 24,00 0,0 3,87 1,93 1,49 0,75 0,75 0,19 0,66 1,63 0,94 0,21 0,21 0,019 0,019 -0,27 0,27 -0,1 0,5 1,0 0,1 13,9 0,5 0,4 14,9 0,5 0,5 -12,9 0,5 -0,3
15 24,00 0,0 3,87 1,93 1,49 0,75 0,75 0,19 0,66 1,63 0,94 0,21 0,21 0,019 0,019 -0,27 0,27 -0,1 0,5 1,0 0,1 13,9 0,5 0,4 14,9 0,5 0,5 -12,9 0,5 -0,3
16 24,00 0,0 3,87 1,93 1,49 0,75 0,75 0,19 0,66 1,63 0,94 0,21 0,21 0,019 0,019 -0,27 0,27 -0,1 0,5 1,0 0,1 13,9 0,5 0,4 14,9 0,5 0,5 -12,9 0,5 -0,3
17 24,00 0,0 3,87 1,93 1,49 0,75 0,75 0,19 0,66 1,63 0,94 0,21 0,21 0,019 0,019 -0,27 0,27 -0,1 0,5 1,0 0,1 13,9 0,5 0,4 14,9 0,5 0,5 -12,9 0,5 -0,3
18 24,00 0,0 3,87 1,93 1,49 0,75 0,75 0,19 0,66 1,63 0,94 0,21 0,21 0,019 0,019 -0,27 0,27 -0,1 0,5 1,0 0,1 13,9 0,5 0,4 14,9 0,5 0,5 -12,9 0,5 -0,3
19 24,00 0,0 3,87 1,93 1,49 0,75 0,75 0,19 0,66 1,63 0,94 0,21 0,21 0,019 0,019 -0,27 0,27 -0,1 0,5 1,0 0,1 13,9 0,5 0,4 14,9 0,5 0,5 -12,9 0,5 -0,3
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 28/158
LOAD CASE E "On board " wave height Hsig5 [m] 0 [ft] 0,000
Purchaser data (for vessel specific method only) The side coefficients are used to divide the out of plane forces between booms and cylinders hinges. They have been carried out by simplified FEA models
2
crane dyn. horiz. accel. a5hp [m/s ] (if no data leave blank) design crane dynamic horz acceleration a5h [m/s2] 0,000 0,294
vessel static inclination angle q5SP [deg] (if no data leave blank) design crane static inclination angle (heel) q5s [deg] 0,500 0,500
stat. crane crane total horiz. loads D forces produced on Luffing cylinders Forces produced on Luffing Boom Hinges
capacity inclin. motion for base angle j 1A offllead movement side coeff. sidelead movement off+side mouv. offlead mouv. sidelead mouvements offlead + sidelead mouvements
Radius P W sid_CI W ho_CM W off_T W sid_T Y<0 Y>0 luffing cylinders Y<0 Y>0 Y<0 Y>0 each hinge Y <0 Luffing Hinge Y < 0 Luffing Hinge Y < 0 Luffing Hinge Y > 0
Prog. L[m] [ton] [kN] [kN] [kN] [kN] [kN] [kN] calc. used [kN] [kN] [kN] [kN] Fx [kN] Fz [kN] Fx [kN] Fy [kN] Fz [kN] Fx [kN] Fy [kN] Fz [kN] Fx [kN] Fy [kN] Fz [kN]
1 4,00 20,0 2,39 8,22 8,22 2,39 69,92 69,92 0,049 0,049 -1,80 1,80 68,1 71,7 10,1 69,7 5,9 1,2 34,1 16,0 1,2 103,7 4,3 1,2 35,6
2 6,00 20,0 2,39 8,22 8,22 2,39 61,28 61,28 0,043 0,043 -1,58 1,58 59,7 62,9 12,7 60,7 8,8 1,2 33,6 21,5 1,2 94,3 3,9 1,2 27,1
3 7,50 20,0 2,39 8,22 8,22 2,39 55,64 55,64 0,036 0,036 -1,32 1,32 54,3 57,0 14,2 54,7 11,0 1,2 33,1 25,3 1,2 87,8 3,2 1,2 21,6
4 9,00 20,0 2,39 8,22 8,22 2,39 50,52 50,52 0,033 0,033 -1,21 1,21 49,3 51,7 15,5 49,2 13,2 1,2 32,4 28,7 1,2 81,6 2,2 1,2 16,8
5 10,00 15,5 1,88 6,46 6,46 1,88 37,20 37,20 0,030 0,030 -0,87 0,87 36,3 38,1 12,7 36,0 11,6 0,9 25,0 24,2 0,9 61,0 1,1 0,9 11,0
6 11,50 13,7 1,67 5,75 5,75 1,67 29,98 29,98 0,023 0,023 -0,59 0,59 29,4 30,6 11,8 28,6 11,9 0,8 21,6 23,7 0,8 50,2 -0,1 0,8 7,0
7 13,00 10,0 1,25 4,30 4,30 1,25 20,20 20,20 0,017 0,017 -0,33 0,33 19,9 20,5 9,1 19,0 10,1 0,6 15,6 19,2 0,6 34,5 -1,0 0,6 3,4
8 14,50 8,0 1,02 3,52 3,52 1,02 14,76 14,76 0,016 0,016 -0,25 0,25 14,5 15,0 7,5 13,6 9,2 0,5 12,1 16,8 0,5 25,7 -1,7 0,5 1,5
9 16,00 7,0 0,91 3,13 3,13 0,91 11,59 11,59 0,015 0,015 -0,21 0,21 11,4 11,8 6,7 10,4 9,0 0,5 10,1 15,7 0,5 20,5 -2,4 0,5 0,3
10 17,50 7,0 0,91 3,13 3,13 0,91 10,07 10,07 0,016 0,016 -0,22 0,22 9,8 10,3 6,5 8,7 9,9 0,5 9,2 16,4 0,5 18,0 -3,3 0,5 -0,5
11 19,00 7,0 0,91 3,13 3,13 0,91 8,51 8,51 0,016 0,016 -0,22 0,22 8,3 8,7 6,3 7,1 10,7 0,5 8,2 17,0 0,5 15,3 -4,5 0,5 -1,1
12 21,00 7,0 0,91 3,13 3,13 0,91 6,27 6,27 0,016 0,016 -0,22 0,22 6,0 6,5 5,6 4,8 11,8 0,5 6,5 17,4 0,5 11,3 -6,3 0,5 -1,7
13 22,80 7,0 0,91 3,13 3,13 0,91 3,78 3,78 0,017 0,017 -0,24 0,24 3,5 4,0 4,4 2,5 12,8 0,5 4,2 17,2 0,5 6,7 -8,5 0,5 -1,6
14 24,00 7,0 0,91 3,13 3,13 0,91 0,40 0,40 0,019 0,019 -0,27 0,27 0,1 0,7 1,9 0,2 13,5 0,5 0,4 15,4 0,5 0,6 -11,6 0,5 -0,2
15 24,00 7,0 0,91 3,13 3,13 0,91 0,40 0,40 0,019 0,019 -0,27 0,27 0,1 0,7 1,9 0,2 13,5 0,5 0,4 15,4 0,5 0,6 -11,6 0,5 -0,2
16 24,00 7,0 0,91 3,13 3,13 0,91 0,40 0,40 0,019 0,019 -0,27 0,27 0,1 0,7 1,9 0,2 13,5 0,5 0,4 15,4 0,5 0,6 -11,6 0,5 -0,2
17 24,00 7,0 0,91 3,13 3,13 0,91 0,40 0,40 0,019 0,019 -0,27 0,27 0,1 0,7 1,9 0,2 13,5 0,5 0,4 15,4 0,5 0,6 -11,6 0,5 -0,2
18 24,00 7,0 0,91 3,13 3,13 0,91 0,40 0,40 0,019 0,019 -0,27 0,27 0,1 0,7 1,9 0,2 13,5 0,5 0,4 15,4 0,5 0,6 -11,6 0,5 -0,2
19 24,00 7,0 0,91 3,13 3,13 0,91 0,40 0,40 0,019 0,019 -0,27 0,27 0,1 0,7 1,9 0,2 13,5 0,5 0,4 15,4 0,5 0,6 -11,6 0,5 -0,2
LOAD CASE F "On board " wave height Hsig6 [m] 0 [ft] 0,000
Purchaser data (for vessel specific method only) The side coefficients are used to divide the out of plane forces between booms and cylinders hinges. They have been carried out by simplified FEA models
crane dyn. horiz. accel. a6hp [m/s2] (if no data leave blank) design crane dynamic horz acceleration a6h [m/s2] 0,000 0,294
vessel static inclination angle q6SP [deg] (if no data leave blank) design crane static inclination angle (heel) q6s [deg] 0,500 0,500
stat. crane crane total horiz. loads D forces produced on Luffing cylinders Forces produced on Luffing Boom Hinges
capacity inclin. motion for base angle j 1A offllead movement side coeff. sidelead movement off+side mouv. offlead mouv. sidelead mouvements offlead + sidelead mouvements
Radius P W sid_CI W ho_CM W off_T W sid_T Y<0 Y>0 luffing cylinders Y<0 Y>0 Y<0 Y>0 each hinge Y <0 Luffing Hinge Y < 0 Luffing Hinge Y < 0 Luffing Hinge Y > 0
Prog. L[m] [ton] [kN] [kN] [kN] [kN] [kN] [kN] calc. used [kN] [kN] [kN] [kN] Fx [kN] Fz [kN] Fx [kN] Fy [kN] Fz [kN] Fx [kN] Fy [kN] Fz [kN] Fx [kN] Fy [kN] Fz [kN]
1 4,00 0,0 0,11 0,39 0,39 0,11 3,33 3,33 0,049 0,049 -0,09 0,09 3,2 3,4 0,5 3,3 0,3 0,1 1,6 0,8 0,1 4,9 0,2 0,1 1,7
2 6,00 0,0 0,11 0,39 0,39 0,11 2,92 2,92 0,043 0,043 -0,08 0,08 2,8 3,0 0,6 2,9 0,4 0,1 1,6 1,0 0,1 4,5 0,2 0,1 1,3
3 7,50 0,0 0,11 0,39 0,39 0,11 2,65 2,65 0,036 0,036 -0,06 0,06 2,6 2,7 0,7 2,6 0,5 0,1 1,6 1,2 0,1 4,2 0,2 0,1 1,0
4 9,00 0,0 0,11 0,39 0,39 0,11 2,41 2,41 0,033 0,033 -0,06 0,06 2,3 2,5 0,7 2,3 0,6 0,1 1,5 1,4 0,1 3,9 0,1 0,1 0,8
5 10,00 0,0 0,11 0,39 0,39 0,11 2,25 2,25 0,030 0,030 -0,05 0,05 2,2 2,3 0,8 2,2 0,7 0,1 1,5 1,5 0,1 3,7 0,1 0,1 0,7
6 11,50 0,0 0,11 0,39 0,39 0,11 2,04 2,04 0,023 0,023 -0,04 0,04 2,0 2,1 0,8 1,9 0,8 0,1 1,5 1,6 0,1 3,4 0,0 0,1 0,5
7 13,00 0,0 0,11 0,39 0,39 0,11 1,84 1,84 0,017 0,017 -0,03 0,03 1,8 1,9 0,8 1,7 0,9 0,1 1,4 1,7 0,1 3,1 -0,1 0,1 0,3
8 14,50 0,0 0,11 0,39 0,39 0,11 1,64 1,64 0,016 0,016 -0,03 0,03 1,6 1,7 0,8 1,5 1,0 0,1 1,3 1,9 0,1 2,9 -0,2 0,1 0,2
9 16,00 0,0 0,11 0,39 0,39 0,11 1,45 1,45 0,015 0,015 -0,03 0,03 1,4 1,5 0,8 1,3 1,1 0,1 1,3 2,0 0,1 2,6 -0,3 0,1 0,0
10 17,50 0,0 0,11 0,39 0,39 0,11 1,26 1,26 0,016 0,016 -0,03 0,03 1,2 1,3 0,8 1,1 1,2 0,1 1,2 2,1 0,1 2,2 -0,4 0,1 -0,1
11 19,00 0,0 0,11 0,39 0,39 0,11 1,06 1,06 0,016 0,016 -0,03 0,03 1,0 1,1 0,8 0,9 1,3 0,1 1,0 2,1 0,1 1,9 -0,6 0,1 -0,1
12 21,00 0,0 0,11 0,39 0,39 0,11 0,78 0,78 0,016 0,016 -0,03 0,03 0,8 0,8 0,7 0,6 1,5 0,1 0,8 2,2 0,1 1,4 -0,8 0,1 -0,2
13 22,80 0,0 0,11 0,39 0,39 0,11 0,47 0,47 0,017 0,017 -0,03 0,03 0,4 0,5 0,5 0,3 1,6 0,1 0,5 2,2 0,1 0,8 -1,1 0,1 -0,2
14 24,00 0,0 0,11 0,39 0,39 0,11 0,05 0,05 0,019 0,019 -0,03 0,03 0,0 0,1 0,2 0,0 1,7 0,1 0,0 1,9 0,1 0,1 -1,4 0,1 0,0
15 24,00 0,0 0,11 0,39 0,39 0,11 0,05 0,05 0,019 0,019 -0,03 0,03 0,0 0,1 0,2 0,0 1,7 0,1 0,0 1,9 0,1 0,1 -1,4 0,1 0,0
16 24,00 0,0 0,11 0,39 0,39 0,11 0,05 0,05 0,019 0,019 -0,03 0,03 0,0 0,1 0,2 0,0 1,7 0,1 0,0 1,9 0,1 0,1 -1,4 0,1 0,0
17 24,00 0,0 0,11 0,39 0,39 0,11 0,05 0,05 0,019 0,019 -0,03 0,03 0,0 0,1 0,2 0,0 1,7 0,1 0,0 1,9 0,1 0,1 -1,4 0,1 0,0
18 24,00 0,0 0,11 0,39 0,39 0,11 0,05 0,05 0,019 0,019 -0,03 0,03 0,0 0,1 0,2 0,0 1,7 0,1 0,0 1,9 0,1 0,1 -1,4 0,1 0,0
19 24,00 0,0 0,11 0,39 0,39 0,11 0,05 0,05 0,019 0,019 -0,03 0,03 0,0 0,1 0,2 0,0 1,7 0,1 0,0 1,9 0,1 0,1 -1,4 0,1 0,0
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 29/158
LOAD CASE G - Aux "Off board Lifts" wave height Hsig7 [m] 1 [ft] 3,281
Purchaser data (for vessel specific method only) The side coefficients are used to divide the out of plane forces between booms and cylinders hinges. They have been carried out by simplified FEA models
2
crane dyn. horiz. accel. a7hp [m/s ] (if no data leave blank) design crane dynamic horz acceleration a7h [m/s2] 0,000 0,294
supply boat motion - off. angle l7off [deg] (if no data leave blank) design crane static inclination angle (heel) q7s [deg] 0,500 0,500
supply boat motion - side angle l7sid [deg] (if no data leave blank)
vessel static inclination angle q7SP [deg] (if no data leave blank)
offlead and sidelead due to suply boat motion stat. crane crane total horiz. loads D forces produced on Luffing cylinders Forces produced on Luffing Boom Hinges
capacity by API off and side forces inclin. motion for base angle j 1A offllead movement side coeff. sidelead movement off+side mouv. offlead mouv. sidelead mouvements offlead + sidelead mouvements
Radius P loff_SB lsid_SB W off_SB W sid_SB W smin_SB W sid_CI W ho_CM W off_T W sid_T Y<0 Y>0 luffing cylinders Y<0 Y>0 Y<0 Y>0 each hinge Y <0 Luffing Hinge Y < 0 Luffing Hinge Y < 0 Luffing Hinge Y > 0
Prog. La [m] [ton] [deg] [deg] [kN] [kN] [kN] [kN] [kN] [kN] [kN] [kN] [kN] calc. used [kN] [kN] [kN] [kN] Fx [kN] Fz [kN] Fx [kN] Fy [kN] Fz [kN] Fx [kN] Fy [kN] Fz [kN] Fx [kN] Fy [kN] Fz [kN]
1 5,45 5,0 6,22 3,11 10,80 5,38 5,38 0,86 2,97 11,20 6,25 105,86 105,86 0,049 0,049 -5,49 5,49 100,4 111,4 14,7 105,5 20,0 3,1 98,7 34,7 3,1 204,2 -5,3 3,1 6,8
2 7,67 5,0 6,22 3,11 10,59 5,28 5,28 0,94 2,91 10,98 6,22 90,73 90,73 0,043 0,043 -4,79 4,79 85,9 95,5 18,2 89,8 28,4 3,1 96,6 46,6 3,1 186,5 -10,2 3,1 -6,8
3 9,33 5,0 6,22 3,11 10,46 5,22 5,22 0,93 2,88 10,85 6,15 81,27 81,27 0,036 0,036 -3,97 3,97 77,3 85,2 20,2 79,9 34,4 3,1 94,0 54,6 3,1 174,0 -14,2 3,1 -14,1
4 10,99 5,0 6,22 3,11 10,37 5,17 5,17 0,92 2,85 10,75 6,09 72,96 72,96 0,033 0,033 -3,60 3,60 69,4 76,6 21,8 71,1 40,3 3,0 90,9 62,1 3,0 162,0 -18,6 3,0 -19,8
5 12,09 5,0 6,22 3,11 10,32 5,14 5,14 0,92 2,84 10,70 6,06 67,93 67,93 0,030 0,030 -3,26 3,26 64,7 71,2 22,6 65,7 44,3 3,0 88,8 66,9 3,0 154,5 -21,7 3,0 -23,1
6 13,74 5,0 6,22 3,11 10,26 5,12 5,12 0,91 2,82 10,64 6,03 60,96 60,96 0,023 0,023 -2,49 2,49 58,5 63,4 23,5 58,2 50,3 3,0 85,5 73,8 3,0 143,7 -26,9 3,0 -27,3
7 15,39 5,0 6,22 3,11 10,22 5,10 5,10 0,91 2,81 10,60 6,00 54,52 54,52 0,017 0,017 -1,83 1,83 52,7 56,3 24,0 51,2 56,4 3,0 81,8 80,4 3,0 133,0 -32,4 3,0 -30,6
8 17,03 5,0 6,22 3,11 10,20 5,09 5,09 0,91 2,81 10,58 5,99 48,45 48,45 0,016 0,016 -1,72 1,72 46,7 50,2 24,3 44,6 62,4 3,0 77,2 86,7 3,0 121,7 -38,1 3,0 -32,6
9 18,66 5,0 6,22 3,11 10,20 5,08 5,08 0,91 2,81 10,58 5,99 42,61 42,61 0,015 0,015 -1,61 1,61 41,0 44,2 24,1 38,2 68,5 3,0 71,9 92,6 3,0 110,1 -44,4 3,0 -33,6
10 20,29 5,0 6,22 3,11 10,21 5,09 5,09 0,91 2,81 10,59 6,00 36,87 36,87 0,016 0,016 -1,72 1,72 35,1 38,6 23,5 32,0 74,5 3,0 65,6 98,1 3,0 97,7 -51,0 3,0 -33,6
11 21,91 5,0 6,22 3,11 10,24 5,10 5,10 0,91 2,82 10,62 6,01 31,04 31,04 0,016 0,016 -1,73 1,73 29,3 32,8 22,5 25,9 80,8 3,0 58,3 103,2 3,0 84,2 -58,3 3,0 -32,4
12 24,05 5,0 6,22 3,11 10,31 5,14 5,14 0,92 2,84 10,70 6,06 22,69 22,69 0,016 0,016 -1,74 1,74 20,9 24,4 19,9 17,4 89,4 3,0 45,7 109,2 3,0 63,2 -69,5 3,0 -28,3
13 25,93 5,0 6,22 3,11 10,44 5,20 5,20 0,93 2,87 10,83 6,13 13,33 13,33 0,017 0,017 -1,87 1,87 11,5 15,2 15,3 8,9 97,4 3,1 28,6 112,7 3,1 37,5 -82,1 3,1 -19,7
14 27,05 5,0 6,22 3,11 10,64 5,31 5,31 0,95 2,93 11,04 6,25 0,31 0,31 0,019 0,019 -2,13 2,13 -1,8 2,4 5,8 0,1 103,4 3,1 0,0 109,2 3,1 0,1 -97,6 3,1 0,2
15 27,05 5,0 6,22 3,11 10,64 5,31 5,31 0,95 2,93 11,04 6,25 0,31 0,31 0,019 0,019 -2,13 2,13 -1,8 2,4 5,8 0,1 103,4 3,1 0,0 109,2 3,1 0,1 -97,6 3,1 0,2
16 27,05 5,0 6,22 3,11 10,64 5,31 5,31 0,95 2,93 11,04 6,25 0,31 0,31 0,019 0,019 -2,13 2,13 -1,8 2,4 5,8 0,1 103,4 3,1 0,0 109,2 3,1 0,1 -97,6 3,1 0,2
17 27,05 5,0 6,22 3,11 10,64 5,31 5,31 0,95 2,93 11,04 6,25 0,31 0,31 0,019 0,019 -2,13 2,13 -1,8 2,4 5,8 0,1 103,4 3,1 0,0 109,2 3,1 0,1 -97,6 3,1 0,2
18 27,05 5,0 6,22 3,11 10,64 5,31 5,31 0,95 2,93 11,04 6,25 0,31 0,31 0,019 0,019 -2,13 2,13 -1,8 2,4 5,8 0,1 103,4 3,1 0,0 109,2 3,1 0,1 -97,6 3,1 0,2
19 27,05 5,0 6,22 3,11 10,64 5,31 5,31 0,95 2,93 11,04 6,25 0,31 0,31 0,019 0,019 -2,13 2,13 -1,8 2,4 5,8 0,1 103,4 3,1 0,0 109,2 3,1 0,1 -97,6 3,1 0,2
LOAD CASE H - Aux "Off board Lifts" wave height Hsig8 [m] 2,5 [ft] 8,202
Purchaser data (for vessel specific method only) The side coefficients are used to divide the out of plane forces between booms and cylinders hinges. They have been carried out by simplified FEA models
crane dyn. horiz. accel. a8hp [m/s2] (if no data leave blank) design crane dynamic horz acceleration a8h [m/s2] 0,000 0,294
supply boat motion - off. angle l8off [deg] (if no data leave blank) design crane static inclination angle (heel) q8s [deg] 0,500 0,500
supply boat motion - side angle l8sid [deg] (if no data leave blank)
vessel static inclination angle q8SP [deg] (if no data leave blank)
offlead and sidelead due to suply boat motion stat. crane crane total horiz. loads D forces produced on Luffing cylinders Forces produced on Luffing Boom Hinges
capacity by API off and side forces inclin. motion for base angle j 1A offllead movement side coeff. sidelead movement off+side mouv. offlead mouv. sidelead mouvements offlead + sidelead mouvements
Radius P loff_SB lsid_SB W off_SB W sid_SB W smin_SB W sid_CI W ho_CM W off_T W sid_T Y<0 Y>0 luffing cylinders Y<0 Y>0 Y<0 Y>0 each hinge Y <0 Luffing Hinge Y < 0 Luffing Hinge Y < 0 Luffing Hinge Y > 0
Prog. La [m] [ton] [deg] [deg] [kN] [kN] [kN] [kN] [kN] [kN] [kN] [kN] [kN] calc. used [kN] [kN] [kN] [kN] Fx [kN] Fz [kN] Fx [kN] Fy [kN] Fz [kN] Fx [kN] Fy [kN] Fz [kN] Fx [kN] Fy [kN] Fz [kN]
1 5,45 5,0 9,67 4,83 16,87 8,37 8,37 0,86 2,97 17,13 9,24 161,92 161,92 0,049 0,049 -8,12 8,12 153,8 170,0 22,5 161,3 29,6 4,6 145,9 52,1 4,6 307,3 -7,1 4,6 15,4
2 7,67 5,0 9,67 4,83 16,54 8,21 8,21 0,85 2,91 16,79 9,06 138,78 138,78 0,043 0,043 -6,98 6,98 131,8 145,8 27,9 137,4 41,4 4,5 140,8 69,2 4,5 278,2 -13,5 4,5 -3,4
3 9,33 5,0 9,67 4,83 16,35 8,11 8,11 0,84 2,88 16,60 8,95 124,30 124,30 0,036 0,036 -5,78 5,78 118,5 130,1 30,9 122,2 50,1 4,5 137,0 81,0 4,5 259,2 -19,2 4,5 -14,8
4 10,99 5,0 9,67 4,83 16,20 8,04 8,04 0,83 2,85 16,45 8,87 111,60 111,60 0,033 0,033 -5,25 5,25 106,4 116,9 33,3 108,8 58,7 4,4 132,5 92,0 4,4 241,2 -25,5 4,4 -23,7
5 12,09 5,0 9,67 4,83 16,12 8,00 8,00 0,83 2,84 16,37 8,83 103,90 103,90 0,030 0,030 -4,75 4,75 99,2 108,7 34,5 100,5 64,5 4,4 129,4 99,0 4,4 229,9 -30,0 4,4 -28,8
6 13,74 5,0 9,67 4,83 16,03 7,96 7,96 0,82 2,82 16,28 8,78 93,24 93,24 0,023 0,023 -3,62 3,62 89,6 96,9 35,9 89,0 73,3 4,4 124,6 109,2 4,4 213,6 -37,4 4,4 -35,6
7 15,39 5,0 9,67 4,83 15,97 7,93 7,93 0,82 2,81 16,22 8,75 83,39 83,39 0,017 0,017 -2,67 2,67 80,7 86,1 36,8 78,3 82,2 4,4 119,1 118,9 4,4 197,4 -45,4 4,4 -40,8
8 17,03 5,0 9,67 4,83 15,94 7,91 7,91 0,82 2,81 16,18 8,73 74,11 74,11 0,016 0,016 -2,50 2,50 71,6 76,6 37,1 68,2 90,9 4,4 112,4 128,0 4,4 180,6 -53,8 4,4 -44,2
9 18,66 5,0 9,67 4,83 15,93 7,91 7,91 0,82 2,81 16,18 8,72 65,18 65,18 0,015 0,015 -2,35 2,35 62,8 67,5 36,9 58,5 99,7 4,4 104,7 136,6 4,4 163,2 -62,9 4,4 -46,2
10 20,29 5,0 9,67 4,83 15,95 7,92 7,92 0,82 2,81 16,19 8,73 56,39 56,39 0,016 0,016 -2,51 2,51 53,9 58,9 36,0 49,0 108,6 4,4 95,6 144,6 4,4 144,6 -72,6 4,4 -46,6
11 21,91 5,0 9,67 4,83 16,00 7,94 7,94 0,82 2,82 16,24 8,76 47,48 47,48 0,016 0,016 -2,51 2,51 45,0 50,0 34,4 39,6 117,7 4,4 84,9 152,0 4,4 124,5 -83,3 4,4 -45,4
12 24,05 5,0 9,67 4,83 16,11 8,00 8,00 0,83 2,84 16,36 8,83 34,70 34,70 0,016 0,016 -2,53 2,53 32,2 37,2 30,4 26,6 130,1 4,4 66,6 160,6 4,4 93,3 -99,7 4,4 -40,0
13 25,93 5,0 9,67 4,83 16,31 8,10 8,10 0,84 2,87 16,56 8,93 20,38 20,38 0,017 0,017 -2,72 2,72 17,7 23,1 23,4 13,6 141,9 4,5 41,6 165,3 4,5 55,3 -118,5 4,5 -28,0
14 27,05 5,0 9,67 4,83 16,63 8,25 8,25 0,85 2,93 16,88 9,11 0,48 0,48 0,019 0,019 -3,10 3,10 -2,6 3,6 8,9 0,2 150,6 4,6 0,0 159,5 4,6 0,2 -141,8 4,6 0,2
15 27,05 5,0 9,67 4,83 16,63 8,25 8,25 0,85 2,93 16,88 9,11 0,48 0,48 0,019 0,019 -3,10 3,10 -2,6 3,6 8,9 0,2 150,6 4,6 0,0 159,5 4,6 0,2 -141,8 4,6 0,2
16 27,05 5,0 9,67 4,83 16,63 8,25 8,25 0,85 2,93 16,88 9,11 0,48 0,48 0,019 0,019 -3,10 3,10 -2,6 3,6 8,9 0,2 150,6 4,6 0,0 159,5 4,6 0,2 -141,8 4,6 0,2
17 27,05 5,0 9,67 4,83 16,63 8,25 8,25 0,85 2,93 16,88 9,11 0,48 0,48 0,019 0,019 -3,10 3,10 -2,6 3,6 8,9 0,2 150,6 4,6 0,0 159,5 4,6 0,2 -141,8 4,6 0,2
18 27,05 5,0 9,67 4,83 16,63 8,25 8,25 0,85 2,93 16,88 9,11 0,48 0,48 0,019 0,019 -3,10 3,10 -2,6 3,6 8,9 0,2 150,6 4,6 0,0 159,5 4,6 0,2 -141,8 4,6 0,2
19 27,05 5,0 9,67 4,83 16,63 8,25 8,25 0,85 2,93 16,88 9,11 0,48 0,48 0,019 0,019 -3,10 3,10 -2,6 3,6 8,9 0,2 150,6 4,6 0,0 159,5 4,6 0,2 -141,8 4,6 0,2
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 30/158
LOAD CASE I - Aux "On board " wave height Hsig9 [m] 0 [ft] 0,000
Purchaser data (for vessel specific method only) The side coefficients are used to divide the out of plane forces between booms and cylinders hinges. They have been carried out by simplified FEA models
crane dyn. horiz. accel. a9hp [m/s2] (if no data leave blank) design crane dynamic horz acceleration a9h [m/s2] 0,000 0,294
vessel static inclination angle q9SP [deg] (if no data leave blank) design crane static inclination angle (heel) q9s [deg] 0,500 0,500
stat. crane crane total horiz. loads D forces produced on Luffing cylinders Forces produced on Luffing Boom Hinges
capacity inclin. motion for base angle j 1A offllead movement side coeff. sidelead movement off+side mouv. offlead mouv. sidelead mouvements offlead + sidelead mouvements
Radius P W sid_CI W ho_CM W off_T W sid_T Y<0 Y>0 luffing cylinders Y<0 Y>0 Y<0 Y>0 each hinge Y <0 Luffing Hinge Y < 0 Luffing Hinge Y < 0 Luffing Hinge Y > 0
Prog. La [m] [ton] [kN] [kN] [kN] [kN] [kN] [kN] calc. used [kN] [kN] [kN] [kN] Fx [kN] Fz [kN] Fx [kN] Fy [kN] Fz [kN] Fx [kN] Fy [kN] Fz [kN] Fx [kN] Fy [kN] Fz [kN]
1 5,45 5,0 0,61 2,11 2,11 0,61 19,97 19,97 0,049 0,049 -0,54 0,54 19,4 20,5 2,8 19,9 2,0 0,3 9,7 4,7 0,3 29,6 0,8 0,3 10,2
2 7,67 5,0 0,61 2,11 2,11 0,61 17,46 17,46 0,043 0,043 -0,47 0,47 17,0 17,9 3,5 17,3 2,8 0,3 9,6 6,3 0,3 26,8 0,7 0,3 7,7
3 9,33 5,0 0,61 2,11 2,11 0,61 15,82 15,82 0,036 0,036 -0,40 0,40 15,4 16,2 3,9 15,6 3,4 0,3 9,4 7,4 0,3 25,0 0,5 0,3 6,2
4 10,99 5,0 0,61 2,11 2,11 0,61 14,34 14,34 0,033 0,033 -0,36 0,36 14,0 14,7 4,3 14,0 4,1 0,3 9,2 8,3 0,3 23,1 0,2 0,3 4,8
5 12,09 5,0 0,61 2,11 2,11 0,61 13,41 13,41 0,030 0,030 -0,33 0,33 13,1 13,7 4,5 13,0 4,5 0,3 9,0 8,9 0,3 22,0 0,0 0,3 4,0
6 13,74 5,0 0,61 2,11 2,11 0,61 12,10 12,10 0,023 0,023 -0,25 0,25 11,9 12,4 4,7 11,6 5,1 0,3 8,7 9,8 0,3 20,3 -0,5 0,3 2,8
7 15,39 5,0 0,61 2,11 2,11 0,61 10,87 10,87 0,017 0,017 -0,19 0,19 10,7 11,1 4,8 10,2 5,8 0,3 8,4 10,6 0,3 18,6 -1,0 0,3 1,8
8 17,03 5,0 0,61 2,11 2,11 0,61 9,68 9,68 0,016 0,016 -0,18 0,18 9,5 9,9 4,8 8,9 6,4 0,3 7,9 11,2 0,3 16,8 -1,6 0,3 1,0
9 18,66 5,0 0,61 2,11 2,11 0,61 8,51 8,51 0,015 0,015 -0,17 0,17 8,3 8,7 4,8 7,6 7,0 0,3 7,4 11,8 0,3 15,0 -2,2 0,3 0,3
10 20,29 5,0 0,61 2,11 2,11 0,61 7,36 7,36 0,016 0,016 -0,18 0,18 7,2 7,5 4,7 6,4 7,6 0,3 6,7 12,3 0,3 13,1 -2,9 0,3 -0,3
11 21,91 5,0 0,61 2,11 2,11 0,61 6,18 6,18 0,016 0,016 -0,18 0,18 6,0 6,4 4,5 5,1 8,3 0,3 6,0 12,7 0,3 11,1 -3,8 0,3 -0,8
12 24,05 5,0 0,61 2,11 2,11 0,61 4,48 4,48 0,016 0,016 -0,18 0,18 4,3 4,7 3,9 3,4 9,1 0,3 4,6 13,0 0,3 8,1 -5,1 0,3 -1,2
13 25,93 5,0 0,61 2,11 2,11 0,61 2,60 2,60 0,017 0,017 -0,19 0,19 2,4 2,8 3,0 1,7 9,8 0,3 2,9 12,8 0,3 4,6 -6,8 0,3 -1,1
14 27,05 5,0 0,61 2,11 2,11 0,61 0,06 0,06 0,019 0,019 -0,21 0,21 -0,1 0,3 1,1 0,0 10,2 0,3 0,0 11,3 0,3 0,0 -9,1 0,3 0,0
15 27,05 5,0 0,61 2,11 2,11 0,61 0,06 0,06 0,019 0,019 -0,21 0,21 -0,1 0,3 1,1 0,0 10,2 0,3 0,0 11,3 0,3 0,0 -9,1 0,3 0,0
16 27,05 5,0 0,61 2,11 2,11 0,61 0,06 0,06 0,019 0,019 -0,21 0,21 -0,1 0,3 1,1 0,0 10,2 0,3 0,0 11,3 0,3 0,0 -9,1 0,3 0,0
17 27,05 5,0 0,61 2,11 2,11 0,61 0,06 0,06 0,019 0,019 -0,21 0,21 -0,1 0,3 1,1 0,0 10,2 0,3 0,0 11,3 0,3 0,0 -9,1 0,3 0,0
18 27,05 5,0 0,61 2,11 2,11 0,61 0,06 0,06 0,019 0,019 -0,21 0,21 -0,1 0,3 1,1 0,0 10,2 0,3 0,0 11,3 0,3 0,0 -9,1 0,3 0,0
19 27,05 5,0 0,61 2,11 2,11 0,61 0,06 0,06 0,019 0,019 -0,21 0,21 -0,1 0,3 1,1 0,0 10,2 0,3 0,0 11,3 0,3 0,0 -9,1 0,3 0,0
Luffing cylinder in Y<0 inertial forces due to lifted load [kN] Luffing cylinder in Y>0 inertial forces due to lifted load [kN]
1 4,00 248,7 380,9 17,8 18,0 68,1 3,2 100,4 153,8 19,4 5,45 1 4,00 274,5 419,1 19,7 20,0 71,7 3,4 111,4 170,0 20,5 5,45
2 6,00 217,9 333,8 14,2 14,3 59,7 2,8 85,9 131,8 17,0 7,67 2 6,00 240,7 367,4 15,7 15,9 62,9 3,0 95,5 145,8 17,9 7,67
3 7,50 198,7 304,3 12,3 12,4 54,3 2,6 77,3 118,5 15,4 9,33 3 7,50 217,7 332,4 13,5 13,6 57,0 2,7 85,2 130,1 16,2 9,33
4 9,00 180,3 276,2 10,7 10,8 49,3 2,3 69,4 106,4 14,0 10,99 4 9,00 197,8 301,9 11,8 11,9 51,7 2,5 76,6 116,9 14,7 10,99
5 10,00 169,2 259,1 9,9 9,9 36,3 2,2 64,7 99,2 13,1 12,09 5 10,00 185,1 282,6 10,8 10,9 38,1 2,3 71,2 108,7 13,7 12,09
6 11,50 154,2 207,9 8,8 8,8 29,4 2,0 58,5 89,6 11,9 13,74 6 11,50 166,3 223,8 9,5 9,5 30,6 2,1 63,4 96,9 12,4 13,74
7 13,00 139,8 163,0 7,8 7,8 19,9 1,8 52,7 80,7 10,7 15,39 7 13,00 148,8 173,1 8,3 8,3 20,5 1,9 56,3 86,1 11,1 15,39
8 14,50 112,8 127,2 6,8 6,8 14,5 1,6 46,7 71,6 9,5 17,03 8 14,50 120,4 135,6 7,3 7,3 15,0 1,7 50,2 76,6 9,9 17,03
9 16,00 86,4 96,1 5,9 5,9 11,4 1,4 41,0 62,8 8,3 18,66 9 16,00 92,6 102,8 6,4 6,4 11,8 1,5 44,2 67,5 8,7 18,66
10 17,50 69,9 77,0 5,0 5,1 9,8 1,2 35,1 53,9 7,2 20,29 10 17,50 76,1 83,7 5,5 5,5 10,3 1,3 38,6 58,9 7,5 20,29
11 19,00 55,6 58,5 4,2 4,2 8,3 1,0 29,3 45,0 6,0 21,91 11 19,00 61,5 64,5 4,7 4,7 8,7 1,1 32,8 50,0 6,4 21,91
12 21,00 31,0 39,5 3,0 3,0 6,0 0,8 20,9 32,2 4,3 24,05 12 21,00 35,5 45,1 3,5 3,5 6,5 0,8 24,4 37,2 4,7 24,05
13 22,80 15,5 20,9 1,7 1,7 3,5 0,4 11,5 17,7 2,4 25,93 13 22,80 19,8 26,4 2,2 2,2 4,0 0,5 15,2 23,1 2,8 25,93
14 24,00 -0,5 -0,6 -0,1 -0,1 0,1 0,0 -1,8 -2,6 -0,1 27,05 14 24,00 4,0 5,5 0,5 0,5 0,7 0,1 2,4 3,6 0,3 27,05
15 24,00 -0,5 -0,6 -0,1 -0,1 0,1 0,0 -1,8 -2,6 -0,1 27,05 15 24,00 4,0 5,5 0,5 0,5 0,7 0,1 2,4 3,6 0,3 27,05
16 24,00 -0,5 -0,6 -0,1 -0,1 0,1 0,0 -1,8 -2,6 -0,1 27,05 16 24,00 4,0 5,5 0,5 0,5 0,7 0,1 2,4 3,6 0,3 27,05
17 24,00 -0,5 -0,6 -0,1 -0,1 0,1 0,0 -1,8 -2,6 -0,1 27,05 17 24,00 4,0 5,5 0,5 0,5 0,7 0,1 2,4 3,6 0,3 27,05
18 24,00 -0,5 -0,6 -0,1 -0,1 0,1 0,0 -1,8 -2,6 -0,1 27,05 18 24,00 4,0 5,5 0,5 0,5 0,7 0,1 2,4 3,6 0,3 27,05
19 24,00 -0,5 -0,6 -0,1 -0,1 0,1 0,0 -1,8 -2,6 -0,1 27,05 19 24,00 4,0 5,5 0,5 0,5 0,7 0,1 2,4 3,6 0,3 27,05
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 31/158
DYNAMIC FORCES ON DEAD LOADS DUE TO CRANE INCLINATION (CI forces) and CRANE MOTION (CM forces)
Prog. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19
q [deg] 82,44 77,56 73,83 70,02 67,42 63,42 59,25 54,89 50,25 45,25 39,73 31,05 20,33 4,06 4,06 4,06 4,06 4,06 4,06
F [kN] 8,70 12,69 15,18 17,32 18,59 20,30 21,79 23,10 24,25 25,25 26,10 27,00 27,49 27,32 27,32 27,32 27,32 27,32 27,32
LOAD CASE A "Off board Lifts" wave height [m] 1 [ft] 3,281
LOAD CASE B "Off board Lifts" wave height [m] 2,5 [ft] 8,202
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 32/158
LOAD CASE C "Off board Lifts" wave height [m] 0 [ft] 0,000
LOAD CASE D "Off board Lifts" wave height [m] 0 [ft] 0,000
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 33/158
LOAD CASE E "On board " wave height [m] 0 [ft] 0,000
purchaser data (for vessel specific method only) design crane dynamic horz acceleration a5h [m/s2] 0,294
2
crane dyn. horiz. accel. a5hp [m/s ] 0 design crane static inclination angle (heel) q5s [deg] 0,500
crane base angle (0° only offlead ; 90° only sidelead) j1A = [deg] 0,00
vessel static inclination angle q5SP [deg] 0 crane dynamic vertical acceleration a5v [m/s2] 0,000 0,686
LOAD CASE F "On board " wave height [m] 0 [ft] 0,000
purchaser data (for vessel specific method only) design crane dynamic horz acceleration a6h [m/s2] 0,294
2
crane dyn. horiz. accel. a6hp [m/s ] 0 design crane static inclination angle (heel) q6s [deg] 0,500
crane base angle (0° only offlead ; 90° only sidelead) j1A = [deg] 0,00
vessel static inclination angle q6SP [deg] 0 crane dynamic vertical acceleration a6v [m/s2] 0,000 0,686
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 34/158
LOAD CASE G - Aux "Off board Lifts" wave height [m] 1 [ft] 3,281
LOAD CASE H - Aux "Off board Lifts" wave height [m] 2,5 [ft] 8,202
1 27,98 27,98 0,05 0,05 -0,05 28,03 27,93 6,2 27,9 1,9 1,1 14,2 8,9 1,1 41,8 5,1 1,1 13,4
2 24,60 24,60 0,04 0,01 -0,01 24,61 24,59 7,3 24,4 3,1 1,1 14,0 12,1 1,1 42,0 6,0 1,1 14,1
3 22,39 22,39 0,04 -0,01 0,01 22,38 22,40 7,9 22,0 4,0 1,1 13,7 14,6 1,1 41,7 6,7 1,1 14,3
4 20,38 20,38 0,03 -0,03 0,03 20,35 20,42 8,4 19,9 4,9 1,1 13,4 17,2 1,1 41,2 7,4 1,1 14,4
5 19,13 19,13 0,03 -0,04 0,04 19,09 19,18 8,7 18,5 5,5 1,1 13,2 18,9 1,1 40,7 7,9 1,1 14,4
6 17,36 17,36 0,02 -0,05 0,05 17,31 17,41 9,0 16,6 6,4 1,1 12,7 21,4 1,1 39,8 8,6 1,1 14,3
7 15,68 15,68 0,02 -0,05 0,05 15,64 15,73 9,2 14,7 7,3 1,1 12,2 24,0 1,1 38,5 9,4 1,1 14,0
8 14,07 14,07 0,02 -0,05 0,05 14,01 14,12 9,3 12,9 8,2 1,1 11,6 26,6 1,1 36,9 10,2 1,1 13,7
9 12,48 12,48 0,02 -0,06 0,06 12,42 12,54 9,3 11,2 9,1 1,1 10,9 29,2 1,1 35,0 10,9 1,1 13,1
10 10,91 10,91 0,02 -0,08 0,08 10,83 10,98 9,2 9,5 10,0 1,1 10,1 31,7 1,1 32,6 11,7 1,1 12,4
11 9,29 9,29 0,02 -0,09 0,09 9,20 9,37 8,9 7,7 11,0 1,1 9,1 34,3 1,1 29,7 12,4 1,1 11,5
12 6,96 6,96 0,02 -0,10 0,10 6,85 7,06 8,3 5,3 12,2 1,1 7,3 37,8 1,1 24,5 13,4 1,1 9,9
13 4,36 4,36 0,02 -0,13 0,13 4,23 4,49 7,1 2,9 13,3 1,1 4,9 40,8 1,1 17,3 14,2 1,1 7,5
14 0,82 0,82 0,02 -0,16 0,16 0,66 0,99 4,5 0,4 14,1 1,1 0,9 42,7 1,1 5,4 14,4 1,1 3,5
15 0,82 0,82 0,02 -0,16 0,16 0,66 0,99 4,5 0,4 14,1 1,1 0,9 42,7 1,1 5,4 14,4 1,1 3,5
16 0,82 0,82 0,02 -0,16 0,16 0,66 0,99 4,5 0,4 14,1 1,1 0,9 42,7 1,1 5,4 14,4 1,1 3,5
17 0,82 0,82 0,02 -0,16 0,16 0,66 0,99 4,5 0,4 14,1 1,1 0,9 42,7 1,1 5,4 14,4 1,1 3,5
18 0,82 0,82 0,02 -0,16 0,16 0,66 0,99 4,5 0,4 14,1 1,1 0,9 42,7 1,1 5,4 14,4 1,1 3,5
19 0,82 0,82 0,02 -0,16 0,16 0,66 0,99 4,5 0,4 14,1 1,1 0,9 42,7 1,1 5,4 14,4 1,1 3,5
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 35/158
LOAD CASE I - Aux "On board " wave height [m] 0 [ft] 0,000
purchaser data (for vessel specific method only) design crane dynamic horz acceleration a9h [m/s2] 0,294
crane dyn. horiz. accel. a9hp [m/s2] 0 design crane static inclination angle (heel) q9s [deg] 0,500
crane base angle (0° only offlead ; 90° only sidelead) j1A = [deg] 0,00
vessel static inclination angle q9SP [deg] 0 crane dynamic vertical acceleration a9v [m/s2] 0,000 0,686
1 27,98 27,98 0,05 0,05 -0,05 28,03 27,93 6,2 27,9 1,9 1,1 14,2 8,9 1,1 41,8 5,1 1,1 13,4
2 24,60 24,60 0,04 0,01 -0,01 24,61 24,59 7,3 24,4 3,1 1,1 14,0 12,1 1,1 42,0 6,0 1,1 14,1
3 22,39 22,39 0,04 -0,01 0,01 22,38 22,40 7,9 22,0 4,0 1,1 13,7 14,6 1,1 41,7 6,7 1,1 14,3
4 20,38 20,38 0,03 -0,03 0,03 20,35 20,42 8,4 19,9 4,9 1,1 13,4 17,2 1,1 41,2 7,4 1,1 14,4
5 19,13 19,13 0,03 -0,04 0,04 19,09 19,18 8,7 18,5 5,5 1,1 13,2 18,9 1,1 40,7 7,9 1,1 14,4
6 17,36 17,36 0,02 -0,05 0,05 17,31 17,41 9,0 16,6 6,4 1,1 12,7 21,4 1,1 39,8 8,6 1,1 14,3
7 15,68 15,68 0,02 -0,05 0,05 15,64 15,73 9,2 14,7 7,3 1,1 12,2 24,0 1,1 38,5 9,4 1,1 14,0
8 14,07 14,07 0,02 -0,05 0,05 14,01 14,12 9,3 12,9 8,2 1,1 11,6 26,6 1,1 36,9 10,2 1,1 13,7
9 12,48 12,48 0,02 -0,06 0,06 12,42 12,54 9,3 11,2 9,1 1,1 10,9 29,2 1,1 35,0 10,9 1,1 13,1
10 10,91 10,91 0,02 -0,08 0,08 10,83 10,98 9,2 9,5 10,0 1,1 10,1 31,7 1,1 32,6 11,7 1,1 12,4
11 9,29 9,29 0,02 -0,09 0,09 9,20 9,37 8,9 7,7 11,0 1,1 9,1 34,3 1,1 29,7 12,4 1,1 11,5
12 6,96 6,96 0,02 -0,10 0,10 6,85 7,06 8,3 5,3 12,2 1,1 7,3 37,8 1,1 24,5 13,4 1,1 9,9
13 4,36 4,36 0,02 -0,13 0,13 4,23 4,49 7,1 2,9 13,3 1,1 4,9 40,8 1,1 17,3 14,2 1,1 7,5
14 0,82 0,82 0,02 -0,16 0,16 0,66 0,99 4,5 0,4 14,1 1,1 0,9 42,7 1,1 5,4 14,4 1,1 3,5
15 0,82 0,82 0,02 -0,16 0,16 0,66 0,99 4,5 0,4 14,1 1,1 0,9 42,7 1,1 5,4 14,4 1,1 3,5
16 0,82 0,82 0,02 -0,16 0,16 0,66 0,99 4,5 0,4 14,1 1,1 0,9 42,7 1,1 5,4 14,4 1,1 3,5
17 0,82 0,82 0,02 -0,16 0,16 0,66 0,99 4,5 0,4 14,1 1,1 0,9 42,7 1,1 5,4 14,4 1,1 3,5
18 0,82 0,82 0,02 -0,16 0,16 0,66 0,99 4,5 0,4 14,1 1,1 0,9 42,7 1,1 5,4 14,4 1,1 3,5
19 0,82 0,82 0,02 -0,16 0,16 0,66 0,99 4,5 0,4 14,1 1,1 0,9 42,7 1,1 5,4 14,4 1,1 3,5
Luffing cylinder Y < 0 : force due to static inclination, supply boat motion, vertical accel. [kN] Luffing cylinder Y > 0 : force due to static inclination, supply boat motion, vertical accel. [kN]
1 28,03 28,03 28,03 28,03 28,03 28,03 28,03 28,03 28,03 27,93 27,93 27,93 27,93 27,93 27,93 27,93 27,93 27,93
2 24,61 24,61 24,61 24,61 24,61 24,61 24,61 24,61 24,61 24,59 24,59 24,59 24,59 24,59 24,59 24,59 24,59 24,59
3 22,38 22,38 22,38 22,38 22,38 22,38 22,38 22,38 22,38 22,40 22,40 22,40 22,40 22,40 22,40 22,40 22,40 22,40
4 20,35 20,35 20,35 20,35 20,35 20,35 20,35 20,35 20,35 20,42 20,42 20,42 20,42 20,42 20,42 20,42 20,42 20,42
5 19,09 19,09 19,09 19,09 19,09 19,09 19,09 19,09 19,09 19,18 19,18 19,18 19,18 19,18 19,18 19,18 19,18 19,18
6 17,31 17,31 17,31 17,31 17,31 17,31 17,31 17,31 17,31 17,41 17,41 17,41 17,41 17,41 17,41 17,41 17,41 17,41
7 15,64 15,64 15,64 15,64 15,64 15,64 15,64 15,64 15,64 15,73 15,73 15,73 15,73 15,73 15,73 15,73 15,73 15,73
8 14,01 14,01 14,01 14,01 14,01 14,01 14,01 14,01 14,01 14,12 14,12 14,12 14,12 14,12 14,12 14,12 14,12 14,12
9 12,42 12,42 12,42 12,42 12,42 12,42 12,42 12,42 12,42 12,54 12,54 12,54 12,54 12,54 12,54 12,54 12,54 12,54
10 10,83 10,83 10,83 10,83 10,83 10,83 10,83 10,83 10,83 10,98 10,98 10,98 10,98 10,98 10,98 10,98 10,98 10,98
11 9,20 9,20 9,20 9,20 9,20 9,20 9,20 9,20 9,20 9,37 9,37 9,37 9,37 9,37 9,37 9,37 9,37 9,37
12 6,85 6,85 6,85 6,85 6,85 6,85 6,85 6,85 6,85 7,06 7,06 7,06 7,06 7,06 7,06 7,06 7,06 7,06
13 4,23 4,23 4,23 4,23 4,23 4,23 4,23 4,23 4,23 4,49 4,49 4,49 4,49 4,49 4,49 4,49 4,49 4,49
14 0,66 0,66 0,66 0,66 0,66 0,66 0,66 0,66 0,66 0,99 0,99 0,99 0,99 0,99 0,99 0,99 0,99 0,99
15 0,66 0,66 0,66 0,66 0,66 0,66 0,66 0,66 0,66 0,99 0,99 0,99 0,99 0,99 0,99 0,99 0,99 0,99
16 0,66 0,66 0,66 0,66 0,66 0,66 0,66 0,66 0,66 0,99 0,99 0,99 0,99 0,99 0,99 0,99 0,99 0,99
17 0,66 0,66 0,66 0,66 0,66 0,66 0,66 0,66 0,66 0,99 0,99 0,99 0,99 0,99 0,99 0,99 0,99 0,99
18 0,66 0,66 0,66 0,66 0,66 0,66 0,66 0,66 0,66 0,99 0,99 0,99 0,99 0,99 0,99 0,99 0,99 0,99
19 0,66 0,66 0,66 0,00 0,66 0,66 0,66 0,66 0,66 0,99 0,99 0,99 0,00 0,99 0,99 0,99 0,99 0,99
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 36/158
WIND FORCES ACTING ON STRUCTURES AND LIFTED LOADS - in accordance with API design rule
crane base angle (0° only offlead ; 90° only sidelead) j1A = 0 [deg]
wind direction (0° longitudinal ; 90° transversal) jW = 0,00 deg 0,0000 rad
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 37/158
LOAD CASE B Hsig2 [m] 2,5 wind speed Vwb 25 m/s
1 20,00 1,43886 1,62 135,08 135,08 0,05 0,00 0,00 135,08 135,08
2 20,00 1,35368 1,62 117,23 117,23 0,04 0,00 0,00 117,23 117,23
3 20,00 1,28858 1,62 105,15 105,15 0,04 0,00 0,00 105,15 105,15
4 20,00 1,22205 1,62 93,91 93,91 0,03 0,00 0,00 93,91 93,91
5 20,00 1,17671 1,62 86,79 86,79 0,03 0,00 0,00 86,79 86,79
6 17,50 1,10684 1,49 75,89 75,89 0,02 0,00 0,00 75,89 75,89
7 15,00 1,03418 1,35 65,53 65,53 0,02 0,00 0,00 65,53 65,53
8 13,00 0,95795 1,24 55,76 55,76 0,02 0,00 0,00 55,76 55,76
9 11,00 0,87703 1,12 46,37 46,37 0,02 0,00 0,00 46,37 46,37
10 10,00 0,78976 1,05 37,51 37,51 0,02 0,00 0,00 37,51 37,51
11 8,50 0,69348 0,96 28,81 28,81 0,02 0,00 0,00 28,81 28,81
12 7,50 0,54189 0,89 17,68 17,68 0,02 0,00 0,00 17,68 17,68
13 6,50 0,35486 0,82 7,76 7,76 0,02 0,00 0,00 7,76 7,76
14 6,00 0,07080 0,78 0,39 0,39 0,02 0,00 0,00 0,39 0,39
15 6,00 0,07080 0,78 0,39 0,39 0,02 0,00 0,00 0,39 0,39
16 6,00 0,07080 0,78 0,39 0,39 0,02 0,00 0,00 0,39 0,39
17 6,00 0,07080 0,78 0,39 0,39 0,02 0,00 0,00 0,39 0,39
18 6,00 0,07080 0,78 0,39 0,39 0,02 0,00 0,00 0,39 0,39
19 6,00 0,07080 0,78 0,39 0,39 0,02 0,00 0,00 0,39 0,39
1 0,00 1,43886 0,21 123,09 123,09 0,05 0,00 0,00 123,09 123,09
2 0,00 1,35368 0,21 106,71 106,71 0,04 0,00 0,00 106,71 106,71
3 0,00 1,28858 0,21 95,60 95,60 0,04 0,00 0,00 95,60 95,60
4 0,00 1,22205 0,21 85,25 85,25 0,03 0,00 0,00 85,25 85,25
5 0,00 1,17671 0,21 78,67 78,67 0,03 0,00 0,00 78,67 78,67
6 0,00 1,10684 0,21 69,22 69,22 0,02 0,00 0,00 69,22 69,22
7 0,00 1,03418 0,21 60,18 60,18 0,02 0,00 0,00 60,18 60,18
8 0,00 0,95795 0,21 51,46 51,46 0,02 0,00 0,00 51,46 51,46
9 0,00 0,87703 0,21 43,02 43,02 0,02 0,00 0,00 43,02 43,02
10 0,00 0,78976 0,21 34,81 34,81 0,02 0,00 0,00 34,81 34,81
11 0,00 0,69348 0,21 26,79 26,79 0,02 0,00 0,00 26,79 26,79
12 0,00 0,54189 0,21 16,33 16,33 0,02 0,00 0,00 16,33 16,33
13 0,00 0,35486 0,21 7,03 7,03 0,02 0,00 0,00 7,03 7,03
14 0,00 0,07080 0,21 0,31 0,31 0,02 0,00 0,00 0,31 0,31
15 0,00 0,07080 0,21 0,31 0,31 0,02 0,00 0,00 0,31 0,31
16 0,00 0,07080 0,21 0,31 0,31 0,02 0,00 0,00 0,31 0,31
17 0,00 0,07080 0,21 0,31 0,31 0,02 0,00 0,00 0,31 0,31
18 0,00 0,07080 0,21 0,31 0,31 0,02 0,00 0,00 0,31 0,31
19 0,00 0,07080 0,21 0,31 0,31 0,02 0,00 0,00 0,31 0,31
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 38/158
LOAD CASE D Hsig4 [m] 0 wind speed Vwd 25 m/s
1 0,00 1,43886 0,21 123,09 123,09 0,05 0,00 0,00 123,09 123,09
2 0,00 1,35368 0,21 106,71 106,71 0,04 0,00 0,00 106,71 106,71
3 0,00 1,28858 0,21 95,60 95,60 0,04 0,00 0,00 95,60 95,60
4 0,00 1,22205 0,21 85,25 85,25 0,03 0,00 0,00 85,25 85,25
5 0,00 1,17671 0,21 78,67 78,67 0,03 0,00 0,00 78,67 78,67
6 0,00 1,10684 0,21 69,22 69,22 0,02 0,00 0,00 69,22 69,22
7 0,00 1,03418 0,21 60,18 60,18 0,02 0,00 0,00 60,18 60,18
8 0,00 0,95795 0,21 51,46 51,46 0,02 0,00 0,00 51,46 51,46
9 0,00 0,87703 0,21 43,02 43,02 0,02 0,00 0,00 43,02 43,02
10 0,00 0,78976 0,21 34,81 34,81 0,02 0,00 0,00 34,81 34,81
11 0,00 0,69348 0,21 26,79 26,79 0,02 0,00 0,00 26,79 26,79
12 0,00 0,54189 0,21 16,33 16,33 0,02 0,00 0,00 16,33 16,33
13 0,00 0,35486 0,21 7,03 7,03 0,02 0,00 0,00 7,03 7,03
14 0,00 0,07080 0,21 0,31 0,31 0,02 0,00 0,00 0,31 0,31
15 0,00 0,07080 0,21 0,31 0,31 0,02 0,00 0,00 0,31 0,31
16 0,00 0,07080 0,21 0,31 0,31 0,02 0,00 0,00 0,31 0,31
17 0,00 0,07080 0,21 0,31 0,31 0,02 0,00 0,00 0,31 0,31
18 0,00 0,07080 0,21 0,31 0,31 0,02 0,00 0,00 0,31 0,31
19 0,00 0,07080 0,21 0,31 0,31 0,02 0,00 0,00 0,31 0,31
1 20,00 1,43886 1,62 135,08 135,08 0,05 0,00 0,00 135,08 135,08
2 20,00 1,35368 1,62 117,23 117,23 0,04 0,00 0,00 117,23 117,23
3 20,00 1,28858 1,62 105,15 105,15 0,04 0,00 0,00 105,15 105,15
4 20,00 1,22205 1,62 93,91 93,91 0,03 0,00 0,00 93,91 93,91
5 15,50 1,17671 1,38 85,41 85,41 0,03 0,00 0,00 85,41 85,41
6 13,70 1,10684 1,28 74,78 74,78 0,02 0,00 0,00 74,78 74,78
7 10,00 1,03418 1,05 64,13 64,13 0,02 0,00 0,00 64,13 64,13
8 8,00 0,95795 0,92 54,44 54,44 0,02 0,00 0,00 54,44 54,44
9 7,00 0,87703 0,85 45,39 45,39 0,02 0,00 0,00 45,39 45,39
10 7,00 0,78976 0,85 36,87 36,87 0,02 0,00 0,00 36,87 36,87
11 7,00 0,69348 0,85 28,53 28,53 0,02 0,00 0,00 28,53 28,53
12 7,00 0,54189 0,85 17,61 17,61 0,02 0,00 0,00 17,61 17,61
13 7,00 0,35486 0,85 7,80 7,80 0,02 0,00 0,00 7,80 7,80
14 7,00 0,07080 0,85 0,40 0,40 0,02 0,00 0,00 0,40 0,40
15 7,00 0,07080 0,85 0,40 0,40 0,02 0,00 0,00 0,40 0,40
16 7,00 0,07080 0,85 0,40 0,40 0,02 0,00 0,00 0,40 0,40
17 7,00 0,07080 0,85 0,40 0,40 0,02 0,00 0,00 0,40 0,40
18 7,00 0,07080 0,85 0,40 0,40 0,02 0,00 0,00 0,40 0,40
19 7,00 0,07080 0,85 0,40 0,40 0,02 0,00 0,00 0,40 0,40
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 39/158
LOAD CASE F Hsig6 [m] 0 wind speed Vwf 25 m/s
1 0,00 1,43886 0,21 123,09 123,09 0,05 0,00 0,00 123,09 123,09
2 0,00 1,35368 0,21 106,71 106,71 0,04 0,00 0,00 106,71 106,71
3 0,00 1,28858 0,21 95,60 95,60 0,04 0,00 0,00 95,60 95,60
4 0,00 1,22205 0,21 85,25 85,25 0,03 0,00 0,00 85,25 85,25
5 0,00 1,17671 0,21 78,67 78,67 0,03 0,00 0,00 78,67 78,67
6 0,00 1,10684 0,21 69,22 69,22 0,02 0,00 0,00 69,22 69,22
7 0,00 1,03418 0,21 60,18 60,18 0,02 0,00 0,00 60,18 60,18
8 0,00 0,95795 0,21 51,46 51,46 0,02 0,00 0,00 51,46 51,46
9 0,00 0,87703 0,21 43,02 43,02 0,02 0,00 0,00 43,02 43,02
10 0,00 0,78976 0,21 34,81 34,81 0,02 0,00 0,00 34,81 34,81
11 0,00 0,69348 0,21 26,79 26,79 0,02 0,00 0,00 26,79 26,79
12 0,00 0,54189 0,21 16,33 16,33 0,02 0,00 0,00 16,33 16,33
13 0,00 0,35486 0,21 7,03 7,03 0,02 0,00 0,00 7,03 7,03
14 0,00 0,07080 0,21 0,31 0,31 0,02 0,00 0,00 0,31 0,31
15 0,00 0,07080 0,21 0,31 0,31 0,02 0,00 0,00 0,31 0,31
16 0,00 0,07080 0,21 0,31 0,31 0,02 0,00 0,00 0,31 0,31
17 0,00 0,07080 0,21 0,31 0,31 0,02 0,00 0,00 0,31 0,31
18 0,00 0,07080 0,21 0,31 0,31 0,02 0,00 0,00 0,31 0,31
19 0,00 0,07080 0,21 0,31 0,31 0,02 0,00 0,00 0,31 0,31
1 5,00 1,43886 0,70 127,27 127,27 0,05 0,00 0,00 127,27 127,27
2 5,00 1,35368 0,70 110,37 110,37 0,04 0,00 0,00 110,37 110,37
3 5,00 1,28858 0,70 98,93 98,93 0,04 0,00 0,00 98,93 98,93
4 5,00 1,22205 0,70 88,26 88,26 0,03 0,00 0,00 88,26 88,26
5 5,00 1,17671 0,70 81,50 81,50 0,03 0,00 0,00 81,50 81,50
6 5,00 1,10684 0,70 71,78 71,78 0,02 0,00 0,00 71,78 71,78
7 5,00 1,03418 0,70 62,48 62,48 0,02 0,00 0,00 62,48 62,48
8 5,00 0,95795 0,70 53,52 53,52 0,02 0,00 0,00 53,52 53,52
9 5,00 0,87703 0,70 44,84 44,84 0,02 0,00 0,00 44,84 44,84
10 5,00 0,78976 0,70 36,39 36,39 0,02 0,00 0,00 36,39 36,39
11 5,00 0,69348 0,70 28,12 28,12 0,02 0,00 0,00 28,12 28,12
12 5,00 0,54189 0,70 17,31 17,31 0,02 0,00 0,00 17,31 17,31
13 5,00 0,35486 0,70 7,62 7,62 0,02 0,00 0,00 7,62 7,62
14 5,00 0,07080 0,70 0,38 0,38 0,02 0,00 0,00 0,38 0,38
15 5,00 0,07080 0,70 0,38 0,38 0,02 0,00 0,00 0,38 0,38
16 5,00 0,07080 0,70 0,38 0,38 0,02 0,00 0,00 0,38 0,38
17 5,00 0,07080 0,70 0,38 0,38 0,02 0,00 0,00 0,38 0,38
18 5,00 0,07080 0,70 0,38 0,38 0,02 0,00 0,00 0,38 0,38
19 5,00 0,07080 0,70 0,38 0,38 0,02 0,00 0,00 0,38 0,38
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 40/158
LOAD CASE H - Aux Hsig8 [m] 2,5 wind speed Vwh 25 m/s
1 5,00 1,43886 0,70 127,27 127,27 0,05 0,00 0,00 127,27 127,27
2 5,00 1,35368 0,70 110,37 110,37 0,04 0,00 0,00 110,37 110,37
3 5,00 1,28858 0,70 98,93 98,93 0,04 0,00 0,00 98,93 98,93
4 5,00 1,22205 0,70 88,26 88,26 0,03 0,00 0,00 88,26 88,26
5 5,00 1,17671 0,70 81,50 81,50 0,03 0,00 0,00 81,50 81,50
6 5,00 1,10684 0,70 71,78 71,78 0,02 0,00 0,00 71,78 71,78
7 5,00 1,03418 0,70 62,48 62,48 0,02 0,00 0,00 62,48 62,48
8 5,00 0,95795 0,70 53,52 53,52 0,02 0,00 0,00 53,52 53,52
9 5,00 0,87703 0,70 44,84 44,84 0,02 0,00 0,00 44,84 44,84
10 5,00 0,78976 0,70 36,39 36,39 0,02 0,00 0,00 36,39 36,39
11 5,00 0,69348 0,70 28,12 28,12 0,02 0,00 0,00 28,12 28,12
12 5,00 0,54189 0,70 17,31 17,31 0,02 0,00 0,00 17,31 17,31
13 5,00 0,35486 0,70 7,62 7,62 0,02 0,00 0,00 7,62 7,62
14 5,00 0,07080 0,70 0,38 0,38 0,02 0,00 0,00 0,38 0,38
15 5,00 0,07080 0,70 0,38 0,38 0,02 0,00 0,00 0,38 0,38
16 5,00 0,07080 0,70 0,38 0,38 0,02 0,00 0,00 0,38 0,38
17 5,00 0,07080 0,70 0,38 0,38 0,02 0,00 0,00 0,38 0,38
18 5,00 0,07080 0,70 0,38 0,38 0,02 0,00 0,00 0,38 0,38
19 5,00 0,07080 0,70 0,38 0,38 0,02 0,00 0,00 0,38 0,38
1 5,00 1,43886 0,70 127,27 127,27 0,05 0,00 0,00 127,27 127,27
2 5,00 1,35368 0,70 110,37 110,37 0,04 0,00 0,00 110,37 110,37
3 5,00 1,28858 0,70 98,93 98,93 0,04 0,00 0,00 98,93 98,93
4 5,00 1,22205 0,70 88,26 88,26 0,03 0,00 0,00 88,26 88,26
5 5,00 1,17671 0,70 81,50 81,50 0,03 0,00 0,00 81,50 81,50
6 5,00 1,10684 0,70 71,78 71,78 0,02 0,00 0,00 71,78 71,78
7 5,00 1,03418 0,70 62,48 62,48 0,02 0,00 0,00 62,48 62,48
8 5,00 0,95795 0,70 53,52 53,52 0,02 0,00 0,00 53,52 53,52
9 5,00 0,87703 0,70 44,84 44,84 0,02 0,00 0,00 44,84 44,84
10 5,00 0,78976 0,70 36,39 36,39 0,02 0,00 0,00 36,39 36,39
11 5,00 0,69348 0,70 28,12 28,12 0,02 0,00 0,00 28,12 28,12
12 5,00 0,54189 0,70 17,31 17,31 0,02 0,00 0,00 17,31 17,31
13 5,00 0,35486 0,70 7,62 7,62 0,02 0,00 0,00 7,62 7,62
14 5,00 0,07080 0,70 0,38 0,38 0,02 0,00 0,00 0,38 0,38
15 5,00 0,07080 0,70 0,38 0,38 0,02 0,00 0,00 0,38 0,38
16 5,00 0,07080 0,70 0,38 0,38 0,02 0,00 0,00 0,38 0,38
17 5,00 0,07080 0,70 0,38 0,38 0,02 0,00 0,00 0,38 0,38
18 5,00 0,07080 0,70 0,38 0,38 0,02 0,00 0,00 0,38 0,38
19 5,00 0,07080 0,70 0,38 0,38 0,02 0,00 0,00 0,38 0,38
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 41/158
Luffing cylinder in Y<0 forces due to wind [kN] Luffing cylinder in Y>0 forces due to wind [kN]
1 135,1 135,1 123,1 123,1 135,1 123,1 127,3 127,3 127,3 1 135,1 135,1 123,1 123,1 135,1 123,1 127,3 127,3 127,3
2 117,2 117,2 106,7 106,7 117,2 106,7 110,4 110,4 110,4 2 117,2 117,2 106,7 106,7 117,2 106,7 110,4 110,4 110,4
3 105,2 105,2 95,6 95,6 105,2 95,6 98,9 98,9 98,9 3 105,2 105,2 95,6 95,6 105,2 95,6 98,9 98,9 98,9
4 93,9 93,9 85,2 85,2 93,9 85,2 88,3 88,3 88,3 4 93,9 93,9 85,2 85,2 93,9 85,2 88,3 88,3 88,3
5 86,8 86,8 78,7 78,7 85,4 78,7 81,5 81,5 81,5 5 86,8 86,8 78,7 78,7 85,4 78,7 81,5 81,5 81,5
6 76,6 75,9 69,2 69,2 74,8 69,2 71,8 71,8 71,8 6 76,6 75,9 69,2 69,2 74,8 69,2 71,8 71,8 71,8
7 66,8 65,5 60,2 60,2 64,1 60,2 62,5 62,5 62,5 7 66,8 65,5 60,2 60,2 64,1 60,2 62,5 62,5 62,5
8 56,9 55,8 51,5 51,5 54,4 51,5 53,5 53,5 53,5 8 56,9 55,8 51,5 51,5 54,4 51,5 53,5 53,5 53,5
9 47,3 46,4 43,0 43,0 45,4 43,0 44,8 44,8 44,8 9 47,3 46,4 43,0 43,0 45,4 43,0 44,8 44,8 44,8
10 38,4 37,5 34,8 34,8 36,9 34,8 36,4 36,4 36,4 10 38,4 37,5 34,8 34,8 36,9 34,8 36,4 36,4 36,4
11 29,7 28,8 26,8 26,8 28,5 26,8 28,1 28,1 28,1 11 29,7 28,8 26,8 26,8 28,5 26,8 28,1 28,1 28,1
12 18,0 17,7 16,3 16,3 17,6 16,3 17,3 17,3 17,3 12 18,0 17,7 16,3 16,3 17,6 16,3 17,3 17,3 17,3
13 7,9 7,8 7,0 7,0 7,8 7,0 7,6 7,6 7,6 13 7,9 7,8 7,0 7,0 7,8 7,0 7,6 7,6 7,6
14 0,4 0,4 0,3 0,3 0,4 0,3 0,4 0,4 0,4 14 0,4 0,4 0,3 0,3 0,4 0,3 0,4 0,4 0,4
15 0,4 0,4 0,3 0,3 0,4 0,3 0,4 0,4 0,4 15 0,4 0,4 0,3 0,3 0,4 0,3 0,4 0,4 0,4
16 0,4 0,4 0,3 0,3 0,4 0,3 0,4 0,4 0,4 16 0,4 0,4 0,3 0,3 0,4 0,3 0,4 0,4 0,4
17 0,4 0,4 0,3 0,3 0,4 0,3 0,4 0,4 0,4 17 0,4 0,4 0,3 0,3 0,4 0,3 0,4 0,4 0,4
18 0,4 0,4 0,3 0,3 0,4 0,3 0,4 0,4 0,4 18 0,4 0,4 0,3 0,3 0,4 0,3 0,4 0,4 0,4
19 0,4 0,4 0,3 0,3 0,4 0,3 0,4 0,4 0,4 19 0,4 0,4 0,3 0,3 0,4 0,3 0,4 0,4 0,4
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 42/158
EQUIVALENT STATIC LOAD COMBINATION D + Cvc*L
Forces acting on Luffing cylinders
Main Aux
Radius Off Off Off Off On On Off Off On
Prog. L[m] A B C D E F G - Aux H - Aux I - Aux
1 4,00 420,3 420,3 138,4 138,4 420,3 138,4 200,4 200,4 200,4
2 6,00 577,7 577,7 200,2 200,2 577,7 200,2 283,2 283,2 283,2
3 7,50 675,3 675,3 238,7 238,7 675,3 238,7 334,7 334,7 334,7
4 9,00 759,3 759,3 271,8 271,8 759,3 271,8 379,1 379,1 379,1
5 10,00 809,0 809,0 291,5 291,5 692,6 291,5 405,3 405,3 405,3
6 11,50 875,5 805,8 317,8 317,8 699,8 317,8 440,5 440,5 440,5
7 13,00 933,4 785,3 340,9 340,9 637,2 340,9 471,3 471,3 471,3
8 14,50 921,7 766,0 361,2 361,2 610,3 361,2 498,2 498,2 498,2
9 16,00 881,9 735,9 378,9 378,9 606,1 378,9 521,7 521,7 521,7
10 17,50 881,0 729,9 394,3 394,3 629,2 394,3 542,0 542,0 542,0
11 19,00 879,9 700,5 407,4 407,4 648,8 407,4 559,1 559,1 559,1
12 21,00 775,0 686,5 421,0 421,0 668,8 421,0 576,8 576,8 576,8
13 22,80 714,6 660,9 428,5 428,5 678,8 428,5 585,8 585,8 585,8
14 24,00 671,6 636,5 425,4 425,4 671,6 425,4 580,2 580,2 580,2
15 24,00 671,6 636,5 425,4 425,4 671,6 425,4 580,2 580,2 580,2
16 24,00 671,6 636,5 425,4 425,4 671,6 425,4 580,2 580,2 580,2
17 24,00 671,6 636,5 425,4 425,4 671,6 425,4 580,2 580,2 580,2
18 24,00 671,6 636,5 425,4 425,4 671,6 425,4 580,2 580,2 580,2
19 24,00 671,6 636,5 425,4 425,4 671,6 425,4 580,2 580,2 580,2
max compression Fc1max 933,4 max tension Ft1max 138,4
Main Aux
Radius Off Off Off Off On On Off Off On
Prog. L[m] A B C D E G - Aux H - Aux 0 0
1 4,00 92,9 92,9 30,6 30,6 92,9 30,6 44,3 44,3 44,3
2 6,00 127,7 127,7 44,3 44,3 127,7 44,3 62,6 62,6 62,6
3 7,50 149,3 149,3 52,8 52,8 149,3 52,8 74,0 74,0 74,0
4 9,00 167,8 167,8 60,1 60,1 167,8 60,1 83,8 83,8 83,8
5 10,00 178,8 178,8 64,4 64,4 153,1 64,4 89,6 89,6 89,6
6 11,50 193,5 178,1 70,3 70,3 154,7 70,3 97,4 97,4 97,4
7 13,00 206,3 173,6 75,4 75,4 140,9 75,4 104,2 104,2 104,2
8 14,50 203,7 169,3 79,8 79,8 134,9 79,8 110,1 110,1 110,1
9 16,00 194,9 162,7 83,8 83,8 134,0 83,8 115,3 115,3 115,3
10 17,50 194,7 161,4 87,2 87,2 139,1 87,2 119,8 119,8 119,8
11 19,00 194,5 154,8 90,0 90,0 143,4 90,0 123,6 123,6 123,6
12 21,00 171,3 151,7 93,1 93,1 147,8 93,1 127,5 127,5 127,5
13 22,80 158,0 146,1 94,7 94,7 150,0 94,7 129,5 129,5 129,5
14 24,00 148,5 140,7 94,0 94,0 148,5 94,0 128,2 128,2 128,2
15 24,00 148,5 140,7 94,0 94,0 148,5 94,0 128,2 128,2 128,2
16 24,00 148,5 140,7 94,0 94,0 148,5 94,0 128,2 128,2 128,2
17 24,00 148,5 140,7 94,0 94,0 148,5 94,0 128,2 128,2 128,2
18 24,00 148,5 140,7 94,0 94,0 148,5 94,0 128,2 128,2 128,2
19 24,00 148,5 140,7 94,0 94,0 148,5 94,0 128,2 128,2 128,2
max jacket press. bar 206,3
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 43/158
DYNAMIC LOAD COMBINATION w/o wind and inertial forces D + Cv*L
Forces on Luffing cylinders
Main Aux
Radius Off Off Off Off On On Off Off On
Prog. L[m] A B C D E F G - Aux H - Aux I - Aux
1 4,00 517,9 517,9 167,1 167,6 517,9 143,0 266,6 266,6 225,5
2 6,00 708,4 708,4 233,5 234,0 708,4 206,4 368,1 368,1 316,9
3 7,50 826,6 826,6 274,2 274,6 826,6 245,9 430,4 430,4 373,6
4 9,00 928,2 928,2 309,1 309,5 928,2 279,9 483,8 483,8 422,5
5 10,00 988,3 988,3 329,7 330,0 833,5 300,0 515,3 515,3 451,5
6 11,50 1068,7 976,0 357,2 357,5 835,1 327,0 557,5 557,5 490,2
7 13,00 1138,7 941,7 381,2 381,5 744,7 350,7 594,5 594,5 524,1
8 14,50 1117,0 909,9 402,2 402,5 702,8 371,5 627,1 627,1 553,7
9 16,00 1058,6 864,4 420,6 420,9 691,7 389,6 655,9 655,9 579,5
10 17,50 1052,7 858,9 436,6 436,8 717,8 405,4 681,1 681,1 601,8
11 19,00 1047,2 836,2 450,2 450,4 739,8 418,7 703,1 703,1 620,6
12 21,00 919,5 829,4 464,5 464,7 762,2 432,7 727,0 727,0 639,8
13 22,80 868,1 809,3 472,3 472,5 773,2 440,3 741,7 741,7 649,5
14 24,00 832,6 791,6 469,2 469,4 764,5 437,1 740,2 740,2 642,9
15 24,00 832,6 791,6 469,2 469,4 764,5 437,1 740,2 740,2 642,9
16 24,00 832,6 791,6 469,2 469,4 764,5 437,1 740,2 740,2 642,9
17 24,00 832,6 791,6 469,2 469,4 764,5 437,1 740,2 740,2 642,9
18 24,00 832,6 791,6 469,2 469,4 764,5 437,1 740,2 740,2 642,9
19 24,00 832,6 791,6 469,2 469,4 764,5 437,1 740,2 740,2 642,9
max compression Fc1max 1138,7 max tension Ft1max 143,0
Main Aux
Radius Off Off Off Off On On Off Off On
Prog. L[m] A B C D E F G - Aux H - Aux I - Aux
1 23,68 114,5 114,5 36,9 37,1 114,5 31,6 58,9 58,9 49,8
2 23,25 156,6 156,6 51,6 51,7 156,6 45,6 81,4 81,4 70,0
3 22,81 182,7 182,7 60,6 60,7 182,7 54,3 95,1 95,1 82,6
4 22,26 205,2 205,2 68,3 68,4 205,2 61,9 106,9 106,9 93,4
5 21,83 218,5 218,5 72,9 72,9 184,2 66,3 113,9 113,9 99,8
6 21,08 236,2 215,7 79,0 79,0 184,6 72,3 123,2 123,2 108,4
7 20,19 251,7 208,2 84,3 84,3 164,6 77,5 131,4 131,4 115,8
8 19,14 246,9 201,1 88,9 89,0 155,4 82,1 138,6 138,6 122,4
9 17,91 234,0 191,1 93,0 93,0 152,9 86,1 145,0 145,0 128,1
10 16,45 232,7 189,9 96,5 96,6 158,7 89,6 150,6 150,6 133,0
11 14,69 231,5 184,8 99,5 99,6 163,5 92,6 155,4 155,4 137,2
12 11,65 203,3 183,3 102,7 102,7 168,5 95,7 160,7 160,7 141,4
13 7,54 191,9 178,9 104,4 104,5 170,9 97,3 164,0 164,0 143,6
14 0,85 184,0 175,0 103,7 103,8 169,0 96,6 163,6 163,6 142,1
15 0,85 184,0 175,0 103,7 103,8 169,0 96,6 163,6 163,6 142,1
16 0,85 184,0 175,0 103,7 103,8 169,0 96,6 163,6 163,6 142,1
17 0,85 184,0 175,0 103,7 103,8 169,0 96,6 163,6 163,6 142,1
18 0,85 184,0 175,0 103,7 103,8 169,0 96,6 163,6 163,6 142,1
19 0,85 184,0 175,0 103,7 103,8 169,0 96,6 163,6 163,6 142,1
max jacket press. bar 251,7
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 44/158
DYNAMIC LOAD COMBINATION with inertial forces and w/o wind D + Cv*L + I : Forces acting on Luffing cylinders
Luffing cylinder forces Y<0 [kN] Luffing cylinder forces Y>0 [kN]
Luffing cylinders pressure (bothY<0 and Y>0) [bar] Luffing cylinder pressure Y>0 [bar]
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 45/158
DYNAMIC LOAD COMBINATION with inertial forces and wind D + Cv*L + I + W : Forces acting on Luffing cylinders
Luffing cylinder forces Y<0 [kN] Luffing cylinder forces Y>0 [kN]
Luffing cylinders pressure (bothY<0 and Y>0) [bar] Luffing cylinder pressure Y>0 [bar]
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 46/158
EQUIVALENT STATIC LOAD COMBINATION D + Cvc*L : Forces acting on the boom hinges
radius Load case A Load case B Load case C Load case D Load case E Load case F Load case G - Aux Load case H - Aux Load case I - Aux
Prog. L [m] Fx Fz Fcomb Fx Fz Fcomb Fx Fz Fcomb Fx Fz Fcomb Fx Fz Fcomb Fx Fz Fcomb Fx Fz Fcomb Fx Fz Fcomb Fx Fz Fcomb
1 4,00 36 188 192 36 188 192 12 6 13 12 6 13 36 188 192 12 6 13 17 46 49 17 46 49 17 46 49
2 6,00 81 342 351 81 342 351 28 66 72 28 66 72 81 342 351 28 66 72 40 127 133 40 127 133 40 127 133
3 7,50 123 434 451 123 434 451 43 103 111 43 103 111 123 434 451 43 103 111 61 175 186 61 175 186 61 175 186
4 9,00 171 510 537 171 510 537 61 133 146 61 133 146 171 510 537 61 133 146 85 216 232 85 216 232 85 216 232
5 10,00 205 552 589 205 552 589 74 150 167 74 150 167 176 462 494 74 150 167 103 238 260 103 238 260 103 238 260
6 11,50 261 606 659 240 551 601 95 171 196 95 171 196 208 469 513 95 171 196 131 267 297 131 267 297 131 267 297
7 13,00 321 646 722 270 532 596 117 188 222 117 188 222 219 417 471 117 188 222 162 289 331 162 289 331 162 289 331
8 14,50 361 628 724 300 509 591 141 200 245 141 200 245 239 390 458 141 200 245 195 305 362 195 305 362 195 305 362
9 16,00 389 583 701 325 474 575 167 208 267 167 208 267 268 377 463 167 208 267 230 314 390 230 314 390 230 314 390
10 17,50 436 562 711 361 453 579 195 210 287 195 210 287 311 380 492 195 210 287 268 317 415 268 317 415 268 317 415
11 19,00 486 534 722 387 410 564 225 207 306 225 207 306 358 374 518 225 207 306 309 312 439 309 312 439 309 312 439
12 21,00 496 414 646 440 358 567 270 191 331 270 191 331 428 347 551 270 191 331 369 289 469 369 289 469 369 289 469
13 22,80 531 307 613 491 278 564 318 155 354 318 155 354 504 288 581 318 155 354 435 238 496 435 238 496 435 238 496
14 24,00 591 153 610 560 141 577 374 70 381 374 70 381 591 153 610 374 70 381 510 122 525 510 122 525 510 122 525
15 24,00 591 153 610 560 141 577 374 70 381 374 70 381 591 153 610 374 70 381 510 122 525 510 122 525 510 122 525
16 24,00 591 153 610 560 141 577 374 70 381 374 70 381 591 153 610 374 70 381 510 122 525 510 122 525 510 122 525
17 24,00 591 153 610 560 141 577 374 70 381 374 70 381 591 153 610 374 70 381 510 122 525 510 122 525 510 122 525
18 24,00 591 153 610 560 141 577 374 70 381 374 70 381 591 153 610 374 70 381 510 122 525 510 122 525 510 122 525
19 24,00 591 153 610 560 141 577 374 70 381 374 70 381 591 153 610 374 70 381 510 122 525 510 122 525 510 122 525
724 601 381 381 610 381 525 525 525
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 47/158
DYNAMIC LOAD COMBINATION w/o wind and inertial forces D + Cv*L : Forces acting on the boom hinges
radius Load case A Load case B Load case C Load case D Load case E Load case F Load case G - Aux Load case H - Aux Load case I - Aux
Prog. L [m] Fx Fz Fcomb Fx Fz Fcomb Fx Fz Fcomb Fx Fz Fcomb Fx Fz Fcomb Fx Fz Fcomb Fx Fz Fcomb Fx Fz Fcomb Fx Fz Fcomb
1 4,00 44 252 256 44 252 256 14 24 28 14 25 29 44 252 256 12 9 15 23 89 92 23 89 92 19 62 65
2 6,00 99 437 448 99 437 448 33 90 96 33 91 96 99 437 448 29 71 76 52 189 196 52 189 196 44 151 158
3 7,50 151 549 569 151 549 569 50 130 139 50 130 139 151 549 569 45 108 117 78 248 260 78 248 260 68 205 216
4 9,00 208 640 673 208 640 673 69 162 176 69 162 176 208 640 673 63 139 153 109 297 316 109 297 316 95 249 267
5 10,00 251 692 736 251 692 736 84 180 198 84 180 198 211 571 609 76 156 174 131 324 349 131 324 349 114 274 297
6 11,50 318 756 820 291 684 743 106 202 228 106 202 228 249 574 626 97 178 203 166 358 395 166 358 395 146 305 339
7 13,00 391 805 895 324 653 729 131 219 255 131 219 256 256 500 562 121 196 230 204 384 435 204 384 435 180 330 376
8 14,50 437 777 891 356 619 714 157 232 280 158 232 280 275 461 537 145 208 254 245 403 472 245 403 472 217 347 409
9 16,00 467 715 854 382 570 686 186 239 303 186 239 303 305 441 537 172 216 276 290 414 506 290 414 506 256 358 440
10 17,50 521 686 862 425 546 692 216 241 324 216 241 324 355 444 569 201 218 297 337 418 537 337 418 537 298 360 468
11 19,00 579 650 870 462 504 684 249 237 344 249 237 344 409 437 599 231 215 316 388 412 566 388 412 566 343 355 493
12 21,00 589 505 776 531 448 695 298 218 369 298 219 369 488 406 635 277 198 341 466 384 603 466 384 603 410 329 525
13 22,80 645 389 753 601 357 699 351 178 393 351 178 394 575 338 667 327 161 365 551 321 638 551 321 638 483 272 554
14 24,00 732 207 761 696 193 723 413 85 421 413 85 422 672 184 697 384 74 392 651 176 675 651 176 675 566 143 583
15 24,00 732 207 761 696 193 723 413 85 421 413 85 422 672 184 697 384 74 392 651 176 675 651 176 675 566 143 583
16 24,00 732 207 761 696 193 723 413 85 421 413 85 422 672 184 697 384 74 392 651 176 675 651 176 675 566 143 583
17 24,00 732 207 761 696 193 723 413 85 421 413 85 422 672 184 697 384 74 392 651 176 675 651 176 675 566 143 583
18 24,00 732 207 761 696 193 723 413 85 421 413 85 422 672 184 697 384 74 392 651 176 675 651 176 675 566 143 583
19 24,00 732 207 761 696 193 723 413 85 421 413 85 422 672 184 697 384 74 392 651 176 675 651 176 675 566 143 583
895 743 421 422 697 392 675 675 583
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 48/158
DYNAMIC LOAD COMBINATION with inertial forces and w/o wind D + Cv*L + I : Forces acting on the boom hinges
radius Load case A Y<0 Load case B Y<0 Load case C Y<0 Load case D Y<0 Load case E Y<0 Load case F Y<0 Load case G - Aux Y<0 Load case H - Aux Y<0 Load case I - Aux Y<0
Prog. L [m] Fx Fy Fz Fcomb Fx Fy Fz Fcomb Fx Fy Fz Fcomb Fx Fy Fz Fcomb Fx Fy Fz Fcomb Fx Fy Fz Fcomb Fx Fy Fz Fcomb Fx Fy Fz Fcomb Fx Fy Fz Fcomb
1 4,00 133 10 799 810 173 14 1054 1068 29 2 103 107 29 2 104 108 69 2 397 403 22 1 55 60 66 4 335 341 84 6 438 446 33 1 134 138
2 6,00 222 10 949 974 278 14 1183 1215 52 2 163 172 52 2 164 172 133 2 573 589 42 1 117 124 110 4 417 432 133 6 509 526 63 1 220 229
3 7,50 298 10 1036 1077 364 14 1255 1307 73 2 199 212 73 2 200 213 190 2 678 704 61 1 154 165 148 4 464 487 174 6 549 576 90 1 272 286
4 9,00 379 10 1102 1166 455 14 1307 1384 96 2 228 247 96 2 228 248 254 2 763 804 81 1 184 201 188 4 500 534 218 6 579 619 120 1 314 336
5 10,00 435 10 1138 1218 518 14 1332 1430 112 2 244 269 112 2 244 269 254 2 673 720 96 1 201 223 216 4 519 562 249 6 594 644 142 1 337 366
6 11,50 525 10 1177 1289 556 12 1219 1339 139 2 263 298 139 2 264 298 294 2 664 726 120 1 222 252 261 4 541 601 297 6 611 679 177 1 366 406
7 13,00 619 10 1201 1351 579 11 1090 1234 167 2 277 324 167 2 278 324 299 2 573 647 146 1 237 279 309 4 556 636 347 5 620 711 215 1 387 442
8 14,50 663 9 1113 1295 602 10 976 1147 196 2 286 347 196 2 287 348 318 2 523 613 174 1 248 303 359 4 562 666 400 5 621 738 255 1 401 475
9 16,00 682 8 988 1200 612 8 854 1051 228 2 290 369 228 2 290 369 350 2 497 608 203 1 253 325 411 4 560 694 455 5 613 763 297 1 408 504
10 17,50 737 7 920 1179 655 8 785 1023 261 2 288 389 262 2 288 389 403 2 495 639 234 1 253 345 467 4 548 720 513 5 595 786 342 1 406 531
11 19,00 797 7 846 1163 685 7 695 976 297 2 279 408 298 2 279 408 460 2 482 666 268 1 247 364 526 4 526 744 575 5 566 807 390 1 396 555
12 21,00 777 6 629 999 755 7 586 956 350 2 252 432 350 2 252 432 543 2 442 700 317 1 224 388 613 4 471 773 664 6 501 832 461 1 361 585
13 22,80 822 5 461 942 819 6 439 929 407 2 201 454 407 2 201 454 633 2 362 729 370 1 179 411 705 4 376 799 757 6 394 854 536 1 294 612
14 24,00 898 5 218 924 904 6 204 927 470 2 91 479 471 2 91 479 731 2 190 755 429 1 80 436 803 4 182 823 853 6 182 872 619 1 149 637
15 24,00 898 5 218 924 904 6 204 927 470 2 91 479 471 2 91 479 731 2 190 755 429 1 80 436 803 4 182 823 853 6 182 872 619 1 149 637
16 24,00 898 5 218 924 904 6 204 927 470 2 91 479 471 2 91 479 731 2 190 755 429 1 80 436 803 4 182 823 853 6 182 872 619 1 149 637
17 24,00 898 5 218 924 904 6 204 927 470 2 91 479 471 2 91 479 731 2 190 755 429 1 80 436 803 4 182 823 853 6 182 872 619 1 149 637
18 24,00 898 5 218 924 904 6 204 927 470 2 91 479 471 2 91 479 731 2 190 755 429 1 80 436 803 4 182 823 853 6 182 872 619 1 149 637
19 24,00 898 5 218 924 904 6 204 927 470 2 91 479 428 0 85 436 731 2 190 755 429 1 80 436 803 4 182 823 853 6 182 872 619 1 149 637
1351 1430 479 479 804 436 823 872 637
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 49/158
Dynamic FORCES acting on the BOOM HINGE (in Y > 0) [kN]
radius Load case A Y>0 Load case B Y>0 Load case C Y>0 Load case D Y>0 Load case E Y>0 Load case F Y>0 Load case G - Aux Y>0 Load case H - Aux Y>0 Load case I - Aux Y>0
Prog. L [m] Fx Fy Fz Fcomb Fx Fy Fz Fcomb Fx Fy Fz Fcomb Fx Fy Fz Fcomb Fx Fy Fz Fcomb Fx Fy Fz Fcomb Fx Fy Fz Fcomb Fx Fy Fz Fcomb Fx Fy Fz Fcomb
1 4,00 45 10 281 285 45 14 302 306 19 2 38 43 19 2 39 43 54 2 301 306 18 1 24 30 23 4 109 111 21 6 118 119 25 1 86 89
2 6,00 90 10 439 448 85 14 442 450 38 2 103 110 38 2 103 110 109 2 478 491 35 1 86 93 47 4 196 202 44 6 199 204 51 1 173 180
3 7,50 131 10 533 548 122 14 524 538 55 2 141 152 55 2 142 152 160 2 584 606 52 1 123 134 71 4 248 258 66 6 248 256 75 1 225 238
4 9,00 179 10 611 636 164 14 593 615 74 2 173 188 74 2 173 188 218 2 672 706 70 1 154 169 97 4 291 307 91 6 287 301 102 1 268 287
5 10,00 213 10 654 688 194 14 630 660 89 2 190 210 89 2 190 210 220 2 597 636 84 1 172 191 117 4 315 336 108 6 309 328 122 1 293 317
6 11,50 268 10 708 757 225 12 615 655 111 2 212 239 112 2 212 240 257 2 595 649 106 1 193 220 148 4 345 375 137 6 337 364 154 1 323 358
7 13,00 327 10 749 818 253 11 584 637 136 2 229 266 136 2 229 266 264 2 518 581 130 1 210 247 181 4 368 410 168 5 357 395 189 1 346 394
8 14,50 367 9 723 811 281 10 554 621 163 2 240 290 163 2 240 290 284 2 476 554 155 1 222 271 217 4 384 441 202 5 373 424 225 1 362 426
9 16,00 396 8 668 777 306 8 512 597 191 2 247 312 191 2 247 312 314 2 455 553 183 1 229 293 256 4 394 470 238 5 381 449 265 1 371 456
10 17,50 443 7 643 781 343 8 492 600 221 2 249 333 221 2 249 333 364 2 456 583 212 1 231 313 298 4 397 496 276 5 384 473 307 1 373 482
11 19,00 493 7 611 785 376 7 456 591 253 2 244 352 254 2 244 352 417 2 448 612 243 1 227 332 343 4 391 520 318 5 378 494 352 1 365 507
12 21,00 511 6 482 703 434 7 409 597 302 2 224 376 302 2 224 376 495 2 414 646 290 1 208 357 410 4 365 549 379 6 354 519 418 1 338 537
13 22,80 564 5 376 678 494 6 332 595 354 2 182 399 354 2 183 399 580 2 344 674 340 1 168 380 483 4 309 574 447 6 301 539 490 1 279 564
14 24,00 641 5 209 674 569 6 193 601 414 2 88 424 414 2 88 424 675 2 187 701 397 1 78 405 568 4 180 596 524 6 180 554 571 1 147 589
15 24,00 641 5 209 674 569 6 193 601 414 2 88 424 414 2 88 424 675 2 187 701 397 1 78 405 568 4 180 596 524 6 180 554 571 1 147 589
16 24,00 641 5 209 674 569 6 193 601 414 2 88 424 414 2 88 424 675 2 187 701 397 1 78 405 568 4 180 596 524 6 180 554 571 1 147 589
17 24,00 641 5 209 674 569 6 193 601 414 2 88 424 414 2 88 424 675 2 187 701 397 1 78 405 568 4 180 596 524 6 180 554 571 1 147 589
18 24,00 641 5 209 674 569 6 193 601 414 2 88 424 414 2 88 424 675 2 187 701 397 1 78 405 568 4 180 596 524 6 180 554 571 1 147 589
19 24,00 641 5 209 674 569 6 193 601 414 2 88 424 400 0 85 409 675 2 187 701 397 1 78 405 568 4 180 596 524 6 180 554 571 1 147 589
818 660 424 424 706 405 596 554 589
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 50/158
SLEWING BEARING FORCES - Load Condtitions : STATIC EQUIVALENT and DYNAMIC w/o WIND
LOAD CASE A "Off board Lifts" wave height Hsig1 [m] 1 [ft] 3,281
LOAD CASE B "Off board Lifts" wave height Hsig2 [m] 2,5 [ft] 8,202
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 51/158
LOAD CASE C "Off board Lifts" wave height Hsig3 [m] 0 [ft] 0,000
LOAD CASE D "Off board Lifts" wave height Hsig4 [m] 0 [ft] 0,000
LOAD CASE E "On board " wave height Hsig5 [m] 0 [ft] 0,000
LOAD CASE G - Aux "Off board Lifts" wave height Hsig7 [m] 1 [ft] 3,281
LOAD CASE H - Aux "Off board Lifts" wave height Hsig8 [m] 2,5 [ft] 8,202
Slewing bearing combined bending moments Mc - Load condition : D + Cv*L + I (dynamic w/o wind)
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 54/158
SLEWING BEARING FORCES - Load Condtition : DYNAMIC with max WIND D+Cv*L + I + W
LOAD CASE B "Off board Lifts" wave height Hsig2 [m] 2,5
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 55/158
LOAD CASE C "Off board Lifts" wave height Hsig3 [m] 0
LOAD CASE G - Aux "Off board Lifts" wave height Hsig7 [m] 1
LOAD CASE H - Aux "Off board Lifts" wave height Hsig8 [m] 2,5
Slewing bearing combined bending moments Mc - Load condition : D + Cv*L + I + W (dynamic with max in-service wind)
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 58/158
SLEWING BEARING - ULTIMATE LIMIT STRENGTH CONDITION (with WIND) ref. par. 9.2.1.4 API 2C
LOAD CASE B "Off board Lifts" wave height Hsig2 [m] 2,5
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 59/158
LOAD CASE C "Off board Lifts" wave height Hsig3 [m] 0
LOAD CASE G - Aux "Off board Lifts" wave height Hsig7 [m] 1
LOAD CASE H - Aux "Off board Lifts" wave height Hsig8 [m] 2,5
Slewing bearing comb. bending moments Mc - Load condition : D + 3.75*Cv*L + I + W (ultimate strength criteria API 9.2.1.4)
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 62/158
SLEWING BEARING FORCES - DESIGN PLATFORM CONNECTION LOAD CONDITION (with or w/o WIND depending on Cv) ref. par. 5.2 API 2C rule
radius Capacity D forces paragraf 5.2 API rule (general or low dyn. condition) Dynamic with o w/o Wind depending on Cv
L P Fz Fx Fy Mx My Mz Fz Fx Fy FCOMB Mx My MCOMB Mz
Prog. [m] [tons] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kN] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kNm]
1 4,0 20,0 -137 15 9 -235 968 34 -992 109 30 113 -738 3756 3828 105
2 6,0 20,0 -137 15 9 -231 1236 51 -992 108 30 113 -727 4780 4835 158
3 7,5 20,0 -137 15 9 -227 1434 64 -992 108 30 112 -715 5539 5585 198
4 9,0 20,0 -137 15 9 -223 1631 77 -992 107 30 112 -701 6289 6328 238
5 10,0 20,0 -137 15 9 -219 1762 86 -992 107 30 111 -689 6784 6819 265
6 11,5 20,0 -137 15 9 -213 1956 99 -992 106 30 110 -669 7520 7549 305
7 13,0 20,0 -137 15 9 -205 2147 112 -992 105 30 110 -646 8245 8270 345
8 14,5 18,0 -124 14 8 -177 2114 113 -953 100 28 103 -562 8289 8308 350
9 16,0 15,5 -108 12 7 -146 1983 108 -904 93 25 96 -466 8034 8047 337
10 17,5 14,5 -101 11 6 -127 1997 111 -884 89 24 92 -410 8216 8226 347
11 19,0 13,7 -96 11 6 -110 2019 114 -869 85 23 88 -357 8415 8422 359
12 21,0 10,0 -74 8 5 -71 1681 97 -803 41 19 45 -236 7380 7384 310
13 22,8 8,0 -65 7 4 -46 1569 93 -777 38 17 42 -157 7257 7259 300
14 24,0 7,0 -62 7 4 -18 1511 93 -766 37 16 40 -66 7231 7231 300
15 24,0 7,0 -62 7 4 -18 1511 93 -766 37 16 40 -66 7231 7231 300
16 24,0 7,0 -62 7 4 -18 1511 93 -766 37 16 40 -66 7231 7231 300
17 24,0 7,0 -62 7 4 -18 1511 93 -766 37 16 40 -66 7231 7231 300
18 24,0 7,0 -62 7 4 -18 1511 93 -766 37 16 40 -66 7231 7231 300
19 24,0 7,0 -62 7 4 -18 1511 93 -766 37 16 40 -66 7231 7231 300
LOAD CASE B "Off board Lifts" wave height Hsig2 [m] 2,5
radius Capacity D forces paragraf 5.2 API rule (general or low dyn. condition) Dynamic with o w/o Wind depending on Cv
L P Fz Fx Fy Mx My Mz Fz Fx Fy FCOMB Mx My MCOMB Mz
Prog. [m] [tons] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kN] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kNm]
1 4,0 20,0 -137 24 13 -347 1191 51 -992 133 43 140 -1075 4424 4553 154
2 6,0 20,0 -137 24 13 -342 1455 76 -992 133 43 139 -1059 5438 5540 232
3 7,5 20,0 -137 24 13 -336 1650 95 -992 132 43 139 -1042 6185 6273 291
4 9,0 20,0 -137 24 13 -329 1843 114 -992 132 43 139 -1020 6922 6997 349
5 10,0 20,0 -137 24 13 -324 1969 127 -992 131 43 138 -1004 7407 7475 388
6 11,5 17,5 -121 21 11 -277 1900 129 -943 122 38 128 -862 7350 7401 395
7 13,0 15,0 -104 18 10 -231 1784 126 -894 113 34 118 -723 7149 7185 387
8 14,5 13,0 -91 16 8 -193 1682 123 -855 105 30 109 -609 6985 7012 380
9 16,0 11,0 -78 13 7 -157 1542 116 -816 96 26 100 -499 6707 6726 361
10 17,5 10,0 -73 12 7 -136 1525 118 -799 54 25 59 -435 6501 6515 369
11 19,0 8,5 -66 11 6 -112 1459 116 -779 50 23 55 -362 6480 6490 364
12 21,0 7,5 -61 11 6 -87 1453 120 -765 48 22 53 -285 6697 6703 377
13 22,8 6,5 -57 10 5 -59 1413 121 -752 46 21 50 -198 6789 6792 382
14 24,0 6,0 -56 10 5 -23 1386 124 -749 45 20 49 -83 6856 6856 395
15 24,0 6,0 -56 10 5 -23 1386 124 -749 45 20 49 -83 6856 6856 395
16 24,0 6,0 -56 10 5 -23 1386 124 -749 45 20 49 -83 6856 6856 395
17 24,0 6,0 -56 10 5 -23 1386 124 -749 45 20 49 -83 6856 6856 395
18 24,0 6,0 -56 10 5 -23 1386 124 -749 45 20 49 -83 6856 6856 395
19 24,0 6,0 -56 10 5 -23 1386 124 -749 45 20 49 -83 6856 6856 395
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 63/158
LOAD CASE C "Off board Lifts" wave height Hsig3 [m] 0
radius Capacity D forces paragraf 5.2 API rule (general or low dyn. condition) Dynamic with o w/o Wind depending on Cv
L P Fz Fx Fy Mx My Mz Fz Fx Fy FCOMB Mx My MCOMB Mz
Prog. [m] [tons] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kN] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kNm]
1 4,0 0,0 -15 1 1 -17 90 3 -626 20 7 21 -86 614 620 9
2 6,0 0,0 -14 1 1 -16 108 3 -622 19 6 20 -80 903 907 14
3 7,5 0,0 -13 1 1 -15 122 4 -620 19 6 20 -77 1119 1122 18
4 9,0 0,0 -12 1 1 -14 135 5 -618 19 6 20 -74 1335 1337 21
5 10,0 0,0 -12 1 1 -13 144 5 -617 19 6 20 -72 1479 1481 23
6 11,5 0,0 -12 1 1 -12 158 6 -616 19 6 20 -69 1694 1696 26
7 13,0 0,0 -12 1 0 -12 171 6 -616 19 6 20 -66 1910 1911 30
8 14,5 0,0 -11 1 0 -11 184 7 -615 19 6 20 -63 2125 2126 33
9 16,0 0,0 -11 1 0 -10 197 8 -615 19 6 20 -60 2341 2342 36
10 17,5 0,0 -11 1 0 -9 210 8 -614 19 6 20 -56 2557 2558 40
11 19,0 0,0 -11 1 0 -9 224 9 -614 19 6 20 -52 2773 2774 43
12 21,0 0,0 -11 1 0 -7 242 10 -614 19 6 20 -45 3063 3063 48
13 22,8 0,0 -11 1 0 -5 258 11 -614 19 6 20 -35 3325 3325 52
14 24,0 0,0 -11 1 0 -2 268 11 -614 19 6 20 -19 3500 3500 55
15 24,0 0,0 -11 1 0 -2 268 11 -614 19 6 20 -19 3500 3500 55
16 24,0 0,0 -11 1 0 -2 268 11 -614 19 6 20 -19 3500 3500 55
17 24,0 0,0 -11 1 0 -2 268 11 -614 19 6 20 -19 3500 3500 55
18 24,0 0,0 -11 1 0 -2 268 11 -614 19 6 20 -19 3500 3500 55
19 24,0 0,0 -11 1 0 -2 268 11 -614 19 6 20 -19 3500 3500 55
LOAD CASE D "Off board Lifts" wave height Hsig4 [m] 0 [ft] 0,000
radius Capacity D forces paragraf 5.2 API rule (general or low dyn. condition) Dynamic with o w/o Wind depending on Cv
L P Fz Fx Fy Mx My Mz Fz Fx Fy FCOMB Mx My MCOMB Mz
Prog. [m] [tons] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kN] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kNm]
1 4,0 0,0 -15 1 1 -18 91 3 -626 20 7 21 -87 617 623 10
2 6,0 0,0 -14 1 1 -16 109 3 -622 19 6 20 -81 906 909 14
3 7,5 0,0 -13 1 1 -15 123 4 -620 19 6 20 -77 1122 1124 18
4 9,0 0,0 -12 1 1 -14 136 5 -618 19 6 20 -74 1337 1340 21
5 10,0 0,0 -12 1 1 -13 145 5 -618 19 6 20 -72 1481 1483 23
6 11,5 0,0 -12 1 1 -12 158 6 -617 19 6 20 -69 1696 1698 26
7 13,0 0,0 -12 1 0 -12 172 6 -616 19 6 20 -66 1912 1913 30
8 14,5 0,0 -11 1 0 -11 185 7 -615 19 6 20 -63 2127 2128 33
9 16,0 0,0 -11 1 0 -10 198 8 -615 19 6 20 -60 2343 2344 36
10 17,5 0,0 -11 1 0 -10 211 8 -614 19 6 20 -56 2559 2560 40
11 19,0 0,0 -11 1 0 -9 225 9 -614 19 6 20 -52 2776 2776 43
12 21,0 0,0 -11 1 0 -7 242 10 -614 19 6 20 -45 3065 3065 48
13 22,8 0,0 -11 1 0 -5 259 11 -614 19 6 20 -35 3327 3327 52
14 24,0 0,0 -11 1 0 -2 269 11 -614 19 6 20 -19 3502 3503 55
15 24,0 0,0 -11 1 0 -2 269 11 -614 19 6 20 -19 3502 3503 55
16 24,0 0,0 -11 1 0 -2 269 11 -614 19 6 20 -19 3502 3503 55
17 24,0 0,0 -11 1 0 -2 269 11 -614 19 6 20 -19 3502 3503 55
18 24,0 0,0 -11 1 0 -2 269 11 -614 19 6 20 -19 3502 3503 55
19 24,0 0,0 -11 1 0 -2 269 11 -614 19 6 20 -19 3502 3503 55
LOAD CASE E "On board " wave height Hsig5 [m] 0 [ft] 0,000
radius Capacity D forces paragraf 5.2 API rule (general or low dyn. condition) Dynamic with o w/o Wind depending on Cv
L P Fz Fx Fy Mx My Mz Fz Fx Fy FCOMB Mx My MCOMB Mz
Prog. [m] [tons] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kN] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kNm]
1 4,0 20,0 -137 4 1 -33 660 5 -992 75 8 75 -132 2832 2835 16
2 6,0 20,0 -137 4 1 -32 932 7 -992 75 8 75 -130 3870 3872 25
3 7,5 20,0 -137 4 1 -32 1136 9 -992 74 8 75 -128 4644 4645 32
4 9,0 20,0 -137 4 1 -31 1339 11 -992 74 8 74 -126 5412 5414 39
5 10,0 15,5 -108 3 1 -24 1158 9 -904 70 8 71 -104 4968 4969 36
6 11,5 13,7 -96 3 1 -21 1174 10 -869 68 7 69 -94 5165 5166 38
7 13,0 10,0 -72 2 1 -15 984 8 -796 65 7 65 -76 4741 4742 35
8 14,5 8,0 -59 2 1 -12 891 7 -757 63 6 63 -65 4607 4607 34
9 16,0 7,0 -52 2 0 -10 869 7 -738 61 6 61 -58 4681 4681 35
10 17,5 7,0 -52 2 0 -9 945 8 -738 59 6 59 -55 5048 5048 39
11 19,0 7,0 -52 2 0 -8 1020 9 -738 57 6 57 -51 5410 5410 42
12 21,0 7,0 -52 2 0 -7 1120 10 -738 54 6 54 -44 5880 5881 47
13 22,8 7,0 -52 2 0 -5 1207 10 -738 49 6 50 -35 6286 6286 51
14 24,0 7,0 -52 2 0 -2 1259 11 -738 42 6 42 -19 6514 6514 54
15 24,0 7,0 -52 2 0 -2 1259 11 -738 42 6 42 -19 6514 6514 54
16 24,0 7,0 -52 2 0 -2 1259 11 -738 42 6 42 -19 6514 6514 54
17 24,0 7,0 -52 2 0 -2 1259 11 -738 42 6 42 -19 6514 6514 54
18 24,0 7,0 -52 2 0 -2 1259 11 -738 42 6 42 -19 6514 6514 54
19 24,0 7,0 -52 2 0 -2 1259 11 -738 42 6 42 -19 6514 6514 54
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 64/158
LOAD CASE F "On board " wave height Hsig6 [m] 0 [ft] 0,000
radius Capacity D forces paragraf 5.2 API rule (general or low dyn. condition) Dynamic with o w/o Wind depending on Cv
L P Fz Fx Fy Mx My Mz Fz Fx Fy FCOMB Mx My MCOMB Mz
Prog. [m] [tons] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kN] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kNm]
1 4,0 0,0 -7 0 0 -2 31 0 -601 62 5 62 -39 907 908 3
2 6,0 0,0 -7 0 0 -2 44 0 -601 61 5 62 -38 1168 1169 5
3 7,5 0,0 -7 0 0 -2 54 0 -601 61 5 61 -38 1360 1361 6
4 9,0 0,0 -7 0 0 -1 64 1 -601 60 5 61 -37 1549 1550 8
5 10,0 0,0 -7 0 0 -1 70 1 -601 60 5 60 -37 1674 1674 9
6 11,5 0,0 -7 0 0 -1 80 1 -601 59 5 59 -36 1857 1858 11
7 13,0 0,0 -7 0 0 -1 89 1 -601 58 5 58 -35 2037 2038 13
8 14,5 0,0 -7 0 0 -1 99 1 -601 57 5 57 -34 2214 2214 14
9 16,0 0,0 -7 0 0 -1 109 1 -601 56 5 56 -33 2387 2387 16
10 17,5 0,0 -7 0 0 -1 118 1 -601 54 5 55 -31 2556 2556 18
11 19,0 0,0 -7 0 0 -1 128 1 -601 52 5 53 -29 2720 2720 20
12 21,0 0,0 -7 0 0 -1 140 1 -601 49 5 49 -26 2932 2932 22
13 22,8 0,0 -7 0 0 -1 151 1 -601 45 5 45 -21 3110 3110 24
14 24,0 0,0 -7 0 0 0 157 1 -601 37 5 38 -14 3206 3206 26
15 24,0 0,0 -7 0 0 0 157 1 -601 37 5 38 -14 3206 3206 26
16 24,0 0,0 -7 0 0 0 157 1 -601 37 5 38 -14 3206 3206 26
17 24,0 0,0 -7 0 0 0 157 1 -601 37 5 38 -14 3206 3206 26
18 24,0 0,0 -7 0 0 0 157 1 -601 37 5 38 -14 3206 3206 26
19 24,0 0,0 -7 0 0 0 157 1 -601 37 5 38 -14 3206 3206 26
LOAD CASE G - Aux "Off board Lifts" wave height Hsig7 [m] 1 [ft] 3,281
radius Capacity D forces paragraf 5.2 API rule (general or low dyn. condition) Dynamic with o w/o Wind depending on Cv
La P Fz Fx Fy Mx My Mz Fz Fx Fy FCOMB Mx My MCOMB Mz
Prog. [m] [tons] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kN] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kNm]
1 5,5 5,0 -55 6 3 -94 468 16 -746 33 14 36 -315 1747 1776 51
2 7,7 5,0 -54 5 3 -92 575 23 -743 33 14 36 -308 2304 2324 73
3 9,3 5,0 -53 5 3 -89 654 28 -741 33 14 35 -300 2716 2732 89
4 11,0 5,0 -53 5 3 -86 732 33 -739 32 14 35 -291 3126 3139 105
5 12,1 5,0 -53 5 3 -84 784 36 -739 32 14 35 -285 3398 3410 115
6 13,7 5,0 -52 5 3 -81 861 41 -738 32 14 35 -275 3805 3815 131
7 15,4 5,0 -52 5 3 -78 938 45 -737 32 14 35 -264 4212 4220 147
8 17,0 5,0 -52 5 3 -74 1015 50 -737 32 14 35 -251 4618 4625 163
9 18,7 5,0 -52 5 3 -69 1092 55 -737 32 14 35 -237 5025 5031 179
10 20,3 5,0 -52 5 3 -64 1169 60 -737 32 14 35 -221 5433 5437 195
11 21,9 5,0 -52 5 3 -59 1246 65 -737 32 14 35 -202 5841 5844 212
12 24,0 5,0 -53 5 3 -49 1349 72 -739 32 14 35 -169 6386 6388 235
13 25,9 5,0 -53 5 3 -35 1440 79 -741 33 14 35 -124 6872 6873 257
14 27,1 5,0 -54 6 3 -12 1488 84 -744 33 14 36 -49 7161 7161 273
15 27,1 5,0 -54 6 3 -12 1488 84 -744 33 14 36 -49 7161 7161 273
16 27,1 5,0 -54 6 3 -12 1488 84 -744 33 14 36 -49 7161 7161 273
17 27,1 5,0 -54 6 3 -12 1488 84 -744 33 14 36 -49 7161 7161 273
18 27,1 5,0 -54 6 3 -12 1488 84 -744 33 14 36 -49 7161 7161 273
19 27,1 5,0 -54 6 3 -12 1488 84 -744 33 14 36 -49 7161 7161 273
LOAD CASE H - Aux "Off board Lifts" wave height Hsig8 [m] 2,5 [ft] 8,202
radius Capacity D forces paragraf 5.2 API rule (general or low dyn. condition) Dynamic with o w/o Wind depending on Cv
La P Fz Fx Fy Mx My Mz Fz Fx Fy FCOMB Mx My MCOMB Mz
Prog. [m] [tons] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kN] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kNm]
1 5,5 5,0 -55 9 5 -139 557 24 -746 42 19 46 -450 2014 2064 74
2 7,7 5,0 -54 8 5 -133 661 34 -743 41 18 45 -434 2560 2597 105
3 9,3 5,0 -53 8 4 -129 737 41 -741 41 18 45 -422 2965 2995 127
4 11,0 5,0 -53 8 4 -125 813 48 -739 41 18 45 -409 3367 3392 150
5 12,1 5,0 -53 8 4 -122 863 52 -739 41 18 45 -400 3634 3655 165
6 13,7 5,0 -52 8 4 -118 937 59 -738 41 18 44 -385 4032 4050 187
7 15,4 5,0 -52 8 4 -113 1011 66 -737 41 18 44 -370 4429 4444 209
8 17,0 5,0 -52 8 4 -107 1084 73 -737 41 18 44 -352 4825 4838 232
9 18,7 5,0 -52 8 4 -101 1157 80 -737 41 18 44 -332 5220 5230 255
10 20,3 5,0 -52 8 4 -94 1229 88 -737 41 18 44 -309 5613 5622 278
11 21,9 5,0 -52 8 4 -85 1301 95 -737 41 18 44 -282 6005 6012 301
12 24,0 5,0 -53 8 4 -71 1395 105 -739 41 18 45 -235 6522 6526 334
13 25,9 5,0 -53 8 4 -51 1473 115 -741 41 18 45 -172 6970 6972 364
14 27,1 5,0 -54 8 5 -18 1499 122 -744 42 18 45 -66 7195 7195 388
15 27,1 5,0 -54 8 5 -18 1499 122 -744 42 18 45 -66 7195 7195 388
16 27,1 5,0 -54 8 5 -18 1499 122 -744 42 18 45 -66 7195 7195 388
17 27,1 5,0 -54 8 5 -18 1499 122 -744 42 18 45 -66 7195 7195 388
18 27,1 5,0 -54 8 5 -18 1499 122 -744 42 18 45 -66 7195 7195 388
19 27,1 5,0 -54 8 5 -18 1499 122 -744 42 18 45 -66 7195 7195 388
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 65/158
LOAD CASE I - Aux "On board " wave height Hsig9 [m] 0 [ft] 0,000
radius Capacity D forces paragraf 5.2 API rule (general or low dyn. condition) Dynamic with o w/o Wind depending on Cv
La P Fz Fx Fy Mx My Mz Fz Fx Fy FCOMB Mx My MCOMB Mz
Prog. [m] [tons] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kN] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kNm]
1 5,5 5,0 -39 1 0 -9 245 2 -698 65 6 65 -62 1563 1564 7
2 7,7 5,0 -39 1 0 -9 331 2 -698 64 6 65 -61 2044 2044 11
3 9,3 5,0 -39 1 0 -9 396 3 -698 64 6 64 -60 2400 2400 14
4 11,0 5,0 -39 1 0 -9 460 3 -698 64 6 64 -59 2752 2752 17
5 12,1 5,0 -39 1 0 -9 502 4 -698 63 6 63 -58 2984 2985 19
6 13,7 5,0 -39 1 0 -8 566 4 -698 62 6 63 -57 3329 3330 22
7 15,4 5,0 -39 1 0 -8 629 5 -698 61 6 62 -55 3670 3671 24
8 17,0 5,0 -39 1 0 -8 692 5 -698 60 6 61 -53 4006 4007 27
9 18,7 5,0 -39 1 0 -7 755 6 -698 59 6 59 -50 4337 4337 30
10 20,3 5,0 -39 1 0 -7 817 6 -698 57 6 58 -47 4662 4663 33
11 21,9 5,0 -39 1 0 -6 878 7 -698 55 6 56 -44 4981 4981 36
12 24,0 5,0 -39 1 0 -5 958 7 -698 52 6 52 -38 5393 5393 40
13 25,9 5,0 -39 1 0 -3 1027 8 -698 48 6 48 -30 5743 5743 44
14 27,1 5,0 -39 1 0 -1 1063 8 -698 40 6 41 -17 5924 5924 46
15 27,1 5,0 -39 1 0 -1 1063 8 -698 40 6 41 -17 5924 5924 46
16 27,1 5,0 -39 1 0 -1 1063 8 -698 40 6 41 -17 5924 5924 46
17 27,1 5,0 -39 1 0 -1 1063 8 -698 40 6 41 -17 5924 5924 46
18 27,1 5,0 -39 1 0 -1 1063 8 -698 40 6 41 -17 5924 5924 46
19 27,1 5,0 -39 1 0 -1 1063 8 -698 40 6 41 -17 5924 5924 46
Slewing bearing combined bending moments Mc - Load condition : D + 1.5*Cv*L + 1.5*I + (W) (design platform connection load condition in accordance with par. 5.2 API rule)
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 66/158
SLEWING BEARING FORCES - TEST CONDITIONS
Test conditions:
1) Static 100% condition : nominal load + dead weights
2) Dyn. 100% condition: nominal load amplified by hoist dyn coeff. + dead weightd + inertial forces calculated on the dead and
amplified nominal load to neglect the hoist dynamic coefficients : to override the values with 1.0
only the dynamic forces in XZ plane have been considered, neglected that ones in YZ plane
3) Dyn. 110% condition: nominal load amplified by hoist and dyntc (1.1) coeff. + dead weights + inertial forces calculated on the
dead and not amplified nominal load to neglect the hoist dynamic coefficients : to override the values with 1.0
only the dynamic forces in XZ plane have been considered, neglected that ones in YZ plane
4) Static 133% condition : nominal load amplified by statc (1.33) + dead weights
max velocità sollevamento VHmax 30 m/1' dynamic test coefficient dyntc 1,10
max velocità di rotazione v Rmax 1,00 rpm static test coefficient statc 1,33
LOAD CASE B Hsig2 [m] 2,5 TEST LOAD CONDITIONS WITHOUT WIND
1) Static 2) Dynamic 100% 3) Dynamic 110% 4) Test Static 133%
Nominal capacities Nom. capacity amplif. Nom. capacity amplif. Nominal capacities
radius Capacity dyn tangential by hoist coeff. by hoist and dyntc amplif by statc
L P hoisting speed Fz My Fz My Fz My Fz My
Prog. [m] [tons] coeff. m/1' [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm]
1 4,0 20,0 1,15 25,1 -749 1036 -780 1190 -804 1285 -817 1308
2 6,0 20,0 1,15 37,7 -749 1667 -780 1898 -804 2040 -817 2075
3 7,5 20,0 1,15 47,1 -749 2142 -780 2430 -804 2607 -817 2651
4 9,0 20,0 1,15 56,5 -749 2616 -780 2961 -804 3174 -817 3228
5 10,0 20,0 1,15 62,8 -749 2933 -780 3315 -804 3552 -817 3612
6 11,5 17,5 1,15 72,3 -724 3126 -752 3513 -773 3753 -784 3814
7 13,0 15,0 1,15 81,7 -700 3246 -723 3625 -741 3860 -752 3919
8 14,5 13,0 1,15 91,1 -680 3364 -701 3734 -717 3963 -726 4021
9 16,0 11,0 1,15 100,5 -661 3425 -678 3774 -692 3991 -700 4046
10 17,5 10,0 1,15 110,0 -651 3599 -667 3947 -679 4164 -686 4222
11 19,0 8,5 1,15 119,4 -636 3651 -650 3976 -661 4179 -667 4235
12 21,0 7,5 1,15 131,9 -626 3861 -639 4176 -648 4377 -654 4439
13 22,8 6,5 1,15 143,3 -617 3999 -628 4292 -636 4484 -641 4553
14 24,0 6,0 1,15 150,8 -612 4126 -622 4394 -630 4584 -634 4670
15 24,0 6,0 1,15 150,8 -612 4126 -622 4394 -630 4584 -634 4670
16 24,0 6,0 1,15 150,8 -612 4126 -622 4394 -630 4584 -634 4670
17 24,0 6,0 1,15 150,8 -612 4126 -622 4394 -630 4584 -634 4670
18 24,0 6,0 1,15 150,8 -612 4126 -622 4394 -630 4584 -634 4670
19 24,0 6,0 1,15 150,8 -612 4126 -622 4394 -630 4584 -634 4670
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 67/158
LOAD CASE C Hsig3 [m] 0 TEST LOAD CONDITIONS WITHOUT WIND
1) Static 2) Dynamic 100% 3) Dynamic 110% 4) Test Static 133%
Nominal capacities Nom. capacity amplif. Nom. capacity amplif. Nominal capacities
radius Capacity dyn tangential by hoist coeff. by hoist and dyntc amplif by statc
L P hoisting speed Fz My Fz My Fz My Fz My
Prog. [m] [tons] coeff. m/1' [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm]
1 4,0 0,0 1,15 25,1 -553 251 -554 264 -555 268 -556 264
2 6,0 0,0 1,15 37,7 -553 491 -554 510 -555 516 -556 510
3 7,5 0,0 1,15 47,1 -553 670 -554 694 -555 703 -556 695
4 9,0 0,0 1,15 56,5 -553 851 -554 880 -555 890 -556 880
5 10,0 0,0 1,15 62,8 -553 971 -554 1003 -555 1014 -556 1004
6 11,5 0,0 1,15 72,3 -553 1152 -554 1189 -555 1202 -556 1189
7 13,0 0,0 1,15 81,7 -553 1334 -554 1375 -555 1389 -556 1376
8 14,5 0,0 1,15 91,1 -553 1516 -554 1561 -555 1577 -556 1563
9 16,0 0,0 1,15 100,5 -553 1699 -554 1747 -555 1766 -556 1750
10 17,5 0,0 1,15 110,0 -553 1882 -554 1934 -555 1954 -556 1939
11 19,0 0,0 1,15 119,4 -553 2067 -554 2122 -555 2143 -556 2129
12 21,0 0,0 1,15 131,9 -553 2316 -554 2373 -555 2397 -556 2384
13 22,8 0,0 1,15 143,3 -553 2546 -554 2602 -555 2628 -556 2620
14 24,0 0,0 1,15 150,8 -553 2714 -554 2763 -555 2790 -556 2791
15 24,0 0,0 1,15 150,8 -553 2714 -554 2763 -555 2790 -556 2791
16 24,0 0,0 1,15 150,8 -553 2714 -554 2763 -555 2790 -556 2791
17 24,0 0,0 1,15 150,8 -553 2714 -554 2763 -555 2790 -556 2791
18 24,0 0,0 1,15 150,8 -553 2714 -554 2763 -555 2790 -556 2791
19 24,0 0,0 1,15 150,8 -553 2714 -554 2763 -555 2790 -556 2791
LOAD CASE G - Aux Hsig7 [m] 1 TEST LOAD CONDITIONS WITHOUT WIND
1) Static 2) Dynamic 100% 3) Dynamic 110% 4) Test Static 133%
Nominal capacities Nom. capacity amplif. Nom. capacity amplif. Nominal capacities
radius Capacity dyn tangential by hoist coeff. by hoist and dyntc amplif by statc
La P hoisting speed Fz My Fz My Fz My Fz My
Prog. [m] [tons] coeff. m/1' [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm]
1 5,5 5,0 1,15 34,2 -602 533 -611 597 -617 634 -621 639
2 7,7 5,0 1,15 48,2 -602 883 -611 974 -617 1026 -621 1032
3 9,3 5,0 1,15 58,6 -602 1146 -611 1257 -617 1320 -621 1327
4 11,0 5,0 1,15 69,0 -602 1409 -611 1539 -617 1614 -621 1622
5 12,1 5,0 1,15 76,0 -602 1584 -611 1728 -617 1810 -621 1819
6 13,7 5,0 1,15 86,3 -602 1848 -611 2010 -617 2103 -621 2115
7 15,4 5,0 1,15 96,7 -602 2112 -611 2292 -617 2396 -621 2410
8 17,0 5,0 1,15 107,0 -602 2376 -611 2574 -617 2689 -621 2706
9 18,7 5,0 1,15 117,3 -602 2640 -611 2855 -617 2981 -621 3002
10 20,3 5,0 1,15 127,5 -602 2905 -611 3135 -617 3272 -621 3299
11 21,9 5,0 1,15 137,7 -602 3170 -611 3415 -617 3563 -621 3596
12 24,0 5,0 1,15 151,1 -602 3525 -611 3785 -617 3948 -621 3992
13 25,9 5,0 1,15 162,9 -602 3848 -611 4116 -617 4291 -621 4351
14 27,1 5,0 1,15 170,0 -602 4070 -611 4329 -617 4512 -621 4596
15 27,1 5,0 1,15 170,0 -602 4070 -611 4329 -617 4512 -621 4596
16 27,1 5,0 1,15 170,0 -602 4070 -611 4329 -617 4512 -621 4596
17 27,1 5,0 1,15 170,0 -602 4070 -611 4329 -617 4512 -621 4596
18 27,1 5,0 1,15 170,0 -602 4070 -611 4329 -617 4512 -621 4596
19 27,1 5,0 1,15 170,0 -602 4070 -611 4329 -617 4512 -621 4596
LOAD CASE H - Aux Hsig8 [m] 2,5 TEST LOAD CONDITIONS WITHOUT WIND
1) Static 2) Dynamic 100% 3) Dynamic 110% 4) Test Static 133%
Nominal capacities Nom. capacity amplif. Nom. capacity amplif. Nominal capacities
radius Capacity dyn tangential by hoist coeff. by hoist and dyntc amplif by statc
La P hoisting speed Fz My Fz My Fz My Fz My
Prog. [m] [tons] coeff. m/1' [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm]
1 5,5 5,0 1,15 34,2 -602 533 -611 597 -617 634 -621 639
2 7,7 5,0 1,15 48,2 -602 883 -611 974 -617 1026 -621 1032
3 9,3 5,0 1,15 58,6 -602 1146 -611 1257 -617 1320 -621 1327
4 11,0 5,0 1,15 69,0 -602 1409 -611 1539 -617 1614 -621 1622
5 12,1 5,0 1,15 76,0 -602 1584 -611 1728 -617 1810 -621 1819
6 13,7 5,0 1,15 86,3 -602 1848 -611 2010 -617 2103 -621 2115
7 15,4 5,0 1,15 96,7 -602 2112 -611 2292 -617 2396 -621 2410
8 17,0 5,0 1,15 107,0 -602 2376 -611 2574 -617 2689 -621 2706
9 18,7 5,0 1,15 117,3 -602 2640 -611 2855 -617 2981 -621 3002
10 20,3 5,0 1,15 127,5 -602 2905 -611 3135 -617 3272 -621 3299
11 21,9 5,0 1,15 137,7 -602 3170 -611 3415 -617 3563 -621 3596
12 24,0 5,0 1,15 151,1 -602 3525 -611 3785 -617 3948 -621 3992
13 25,9 5,0 1,15 162,9 -602 3848 -611 4116 -617 4291 -621 4351
14 27,1 5,0 1,15 170,0 -602 4070 -611 4329 -617 4512 -621 4596
15 27,1 5,0 1,15 170,0 -602 4070 -611 4329 -617 4512 -621 4596
16 27,1 5,0 1,15 170,0 -602 4070 -611 4329 -617 4512 -621 4596
17 27,1 5,0 1,15 170,0 -602 4070 -611 4329 -617 4512 -621 4596
18 27,1 5,0 1,15 170,0 -602 4070 -611 4329 -617 4512 -621 4596
19 27,1
Doc. N. CN-C1515-C1516_Rev.03 5,0 1,15 170,0 -602 4070 -611 4329 -617 4512 -621 4596
Date 23/10/12 69/158
LOAD CASE I - Aux Hsig9 [m] 0 TEST LOAD CONDITIONS WITHOUT WIND
1) Static 2) Dynamic 100% 3) Dynamic 110% 4) Test Static 133%
Nominal capacities Nom. capacity amplif. Nom. capacity amplif. Nominal capacities
radius Capacity dyn tangential by hoist coeff. by hoist and dyntc amplif by statc
La P hoisting speed Fz My Fz My Fz My Fz My
Prog. [m] [tons] coeff. m/1' [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm]
1 5,5 5,0 1,15 34,2 -602 533 -611 597 -617 634 -621 639
2 7,7 5,0 1,15 48,2 -602 883 -611 974 -617 1026 -621 1032
3 9,3 5,0 1,15 58,6 -602 1146 -611 1257 -617 1320 -621 1327
4 11,0 5,0 1,15 69,0 -602 1409 -611 1539 -617 1614 -621 1622
5 12,1 5,0 1,15 76,0 -602 1584 -611 1728 -617 1810 -621 1819
6 13,7 5,0 1,15 86,3 -602 1848 -611 2010 -617 2103 -621 2115
7 15,4 5,0 1,15 96,7 -602 2112 -611 2292 -617 2396 -621 2410
8 17,0 5,0 1,15 107,0 -602 2376 -611 2574 -617 2689 -621 2706
9 18,7 5,0 1,15 117,3 -602 2640 -611 2855 -617 2981 -621 3002
10 20,3 5,0 1,15 127,5 -602 2905 -611 3135 -617 3272 -621 3299
11 21,9 5,0 1,15 137,7 -602 3170 -611 3415 -617 3563 -621 3596
12 24,0 5,0 1,15 151,1 -602 3525 -611 3785 -617 3948 -621 3992
13 25,9 5,0 1,15 162,9 -602 3848 -611 4116 -617 4291 -621 4351
14 27,1 5,0 1,15 170,0 -602 4070 -611 4329 -617 4512 -621 4596
15 27,1 5,0 1,15 170,0 -602 4070 -611 4329 -617 4512 -621 4596
16 27,1 5,0 1,15 170,0 -602 4070 -611 4329 -617 4512 -621 4596
17 27,1 5,0 1,15 170,0 -602 4070 -611 4329 -617 4512 -621 4596
18 27,1 5,0 1,15 170,0 -602 4070 -611 4329 -617 4512 -621 4596
19 27,1 5,0 1,15 170,0 -602 4070 -611 4329 -617 4512 -621 4596
Test condition : Slewing bearing bending moments My - Dynamic 100 % load condition : D + j L + CN (2) CN is for centrifugal corces
Test condition : Slewing bearing bending moments My - Dynamic 110 % load condition : D + j*1.1* L + CN (3) CN is for centrifugal corces
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 70/158
Test condition : Slewing bearing bending moments My - Static 133 % load condition : D + 1.33*L (4)
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 71/158
FORCES AND COUPLES ACTING ON SWING MECHANISM IN ACCORDANCE WITH API 9.1.2 PROVISIONS
Data
design crane static inclination angle (Heel) q1s [deg] 0,5 crane base angle j1A 0 deg
design crane dynamic horz acceleration a1h [m/s2] 0,294
wind direction jW 0 deg
wind speed Vw m/s 25
reduced wind speerd for swing mechanical design Vwr [m/s] 25
Dynamic horizintal forces on lifted load Dynamic horizintal forces on structures Forces due to reduced wind (Vwr m/sec) Total side forces and moments - (W/O Cv and dynamic from SB)
moment CM forces CI forces CM forces CI forces Lifted load Structures 1 2 3
radius Capacity of inertia W sidedyn Csidedyn W sideCI CsideCI W sideCM CsideCM W sideCI CsideCI W sideWL CsideWL W sideStru CsideStru W / O load and wind W / O wind With wind
L P Mi force couple force couple force couple force couple force couple force couple force couple force couple force couple
Prog. [m] [tons] [tm2] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm]
1 4,0 20,0 397 0,0 0,0 1,80 7,2 0,0 0,0 4,7 1,9 0,0 0,0 0,0 0,0 4,7 1,9 6,5 9,0 6,5 9,0
2 6,0 20,0 895 0,0 0,0 1,80 10,8 0,0 0,0 4,7 3,8 0,0 0,0 0,0 0,0 4,7 3,8 6,5 14,6 6,5 14,6
3 7,5 20,0 1405 0,0 0,0 1,80 13,5 0,0 0,0 4,7 5,2 0,0 0,0 0,0 0,0 4,7 5,2 6,5 18,7 6,5 18,7
4 9,0 20,0 2032 0,0 0,0 1,80 16,2 0,0 0,0 4,7 6,7 0,0 0,0 0,0 0,0 4,7 6,7 6,5 22,8 6,5 22,8
5 10,0 20,0 2515 0,0 0,0 1,80 18,0 0,0 0,0 4,7 7,6 0,0 0,0 0,0 0,0 4,7 7,6 6,5 25,6 6,5 25,6
6 11,5 20,0 3338 0,0 0,0 1,80 20,7 0,0 0,0 4,7 9,1 0,0 0,0 0,0 0,0 4,7 9,1 6,5 29,7 6,5 29,7
7 13,0 20,0 4278 0,0 0,0 1,80 23,4 0,0 0,0 4,7 10,5 0,0 0,0 0,0 0,0 4,7 10,5 6,5 33,9 6,5 33,9
8 14,5 18,0 4915 0,0 0,0 1,63 23,6 0,0 0,0 4,7 12,0 0,0 0,0 0,0 0,0 4,7 12,0 6,4 35,6 6,4 35,6
9 16,0 15,5 5360 0,0 0,0 1,41 22,6 0,0 0,0 4,7 13,5 0,0 0,0 0,0 0,0 4,7 13,5 6,2 36,0 6,2 36,0
10 17,5 14,5 6124 0,0 0,0 1,33 23,2 0,0 0,0 4,7 14,9 0,0 0,0 0,0 0,0 4,7 14,9 6,1 38,1 6,1 38,1
11 19,0 13,7 6950 0,0 0,0 1,26 23,9 0,0 0,0 4,7 16,4 0,0 0,0 0,0 0,0 4,7 16,4 6,0 40,3 6,0 40,3
12 21,0 10,0 6891 0,0 0,0 0,94 19,8 0,0 0,0 4,7 18,4 0,0 0,0 0,0 0,0 4,7 18,4 5,7 38,2 5,7 38,2
13 22,8 8,0 7126 0,0 0,0 0,77 17,6 0,0 0,0 4,7 20,3 0,0 0,0 0,0 0,0 4,7 20,3 5,5 37,8 5,5 37,8
14 24,0 7,0 7387 0,0 0,0 0,68 16,4 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,4 38,1 5,4 38,1
15 24,0 7,0 7387 0,0 0,0 0,68 16,4 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,4 38,1 5,4 38,1
16 24,0 7,0 7387 0,0 0,0 0,68 16,4 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,4 38,1 5,4 38,1
17 24,0 7,0 7387 0,0 0,0 0,68 16,4 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,4 38,1 5,4 38,1
18 24,0 7,0 7387 0,0 0,0 0,68 16,4 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,4 38,1 5,4 38,1
19 24,0 7,0 7387 0,0 0,0 0,68 16,4 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,4 38,1 5,4 38,1
LOAD CASE B "Off board Lifts" wave height Hsig2 [m] 2,5
Dynamic horizintal forces on lifted load Dynamic horizintal forces on structures Forces due to reduced wind (Vwr m/sec) Total side forces and moments - (W/O Cv and dynamic from SB)
moment CM forces CI forces CM forces CI forces Lifted load Structures 1 2 3
radius Capacity of inertia W sidedyn Csidedyn W sideCI CsideCI W sideCM CsideCM W sideCI CsideCI W sideWL CsideWL W sideStru CsideStru W / O load and wind W / O wind With wind
L P Mi force couple force couple force couple force couple force couple force couple force couple force couple force couple
Prog. [m] [tons] [tm2] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm]
1 4,0 20,0 397 0,0 0,0 1,80 7,2 0,0 0,0 4,7 1,9 0,0 0,0 0,0 0,0 4,7 1,9 6,5 9,0 6,5 9,0
2 6,0 20,0 895 0,0 0,0 1,80 10,8 0,0 0,0 4,7 3,8 0,0 0,0 0,0 0,0 4,7 3,8 6,5 14,6 6,5 14,6
3 7,5 20,0 1405 0,0 0,0 1,80 13,5 0,0 0,0 4,7 5,2 0,0 0,0 0,0 0,0 4,7 5,2 6,5 18,7 6,5 18,7
4 9,0 20,0 2032 0,0 0,0 1,80 16,2 0,0 0,0 4,7 6,7 0,0 0,0 0,0 0,0 4,7 6,7 6,5 22,8 6,5 22,8
5 10,0 20,0 2515 0,0 0,0 1,80 18,0 0,0 0,0 4,7 7,6 0,0 0,0 0,0 0,0 4,7 7,6 6,5 25,6 6,5 25,6
6 11,5 17,5 3007 0,0 0,0 1,58 18,2 0,0 0,0 4,7 9,1 0,0 0,0 0,0 0,0 4,7 9,1 6,3 27,3 6,3 27,3
7 13,0 15,0 3433 0,0 0,0 1,37 17,8 0,0 0,0 4,7 10,5 0,0 0,0 0,0 0,0 4,7 10,5 6,1 28,3 6,1 28,3
8 14,5 13,0 3864 0,0 0,0 1,20 17,4 0,0 0,0 4,7 12,0 0,0 0,0 0,0 0,0 4,7 12,0 5,9 29,4 5,9 29,4
9 16,0 11,0 4208 0,0 0,0 1,03 16,4 0,0 0,0 4,7 13,5 0,0 0,0 0,0 0,0 4,7 13,5 5,8 29,9 5,8 29,9
10 17,5 10,0 4746 0,0 0,0 0,94 16,5 0,0 0,0 4,7 14,9 0,0 0,0 0,0 0,0 4,7 14,9 5,7 31,4 5,7 31,4
11 19,0 8,5 5072 0,0 0,0 0,81 15,4 0,0 0,0 4,7 16,4 0,0 0,0 0,0 0,0 4,7 16,4 5,6 31,9 5,6 31,9
12 21,0 7,5 5789 0,0 0,0 0,73 15,3 0,0 0,0 4,7 18,4 0,0 0,0 0,0 0,0 4,7 18,4 5,5 33,7 5,5 33,7
13 22,8 6,5 6347 0,0 0,0 0,64 14,6 0,0 0,0 4,7 20,3 0,0 0,0 0,0 0,0 4,7 20,3 5,4 34,9 5,4 34,9
14 24,0 6,0 6811 0,0 0,0 0,60 14,4 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,3 36,0 5,3 36,0
15 24,0 6,0 6811 0,0 0,0 0,60 14,4 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,3 36,0 5,3 36,0
16 24,0 6,0 6811 0,0 0,0 0,60 14,4 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,3 36,0 5,3 36,0
17 24,0 6,0 6811 0,0 0,0 0,60 14,4 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,3 36,0 5,3 36,0
18 24,0 6,0 6811 0,0 0,0 0,60 14,4 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,3 36,0 5,3 36,0
19 24,0 6,0 6811 0,0 0,0 0,60 14,4 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,3 36,0 5,3 36,0
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 72/158
LOAD CASE C "Off board Lifts" wave height Hsig3 [m] 0
Dynamic horizintal forces on lifted load Dynamic horizintal forces on structures Forces due to reduced wind (Vwr m/sec) Total side forces and moments - (W/O Cv and dynamic from SB)
moment CM forces CI forces CM forces CI forces Lifted load Structures 1 2 3
radius Capacity of inertia W sidedyn Csidedyn W sideCI CsideCI W sideCM CsideCM W sideCI CsideCI W sideWL CsideWL W sideStru CsideStru W / O load and wind W / O wind With wind
L P Mi force couple force couple force couple force couple force couple force couple force couple force couple force couple
Prog. [m] [tons] [tm2] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm]
1 4,0 0,0 77 0,0 0,0 0,09 0,3 0,0 0,0 4,7 1,9 0,0 0,0 0,0 0,0 4,7 1,9 4,8 2,2 4,8 2,2
2 6,0 0,0 175 0,0 0,0 0,09 0,5 0,0 0,0 4,7 3,8 0,0 0,0 0,0 0,0 4,7 3,8 4,8 4,3 4,8 4,3
3 7,5 0,0 280 0,0 0,0 0,09 0,6 0,0 0,0 4,7 5,2 0,0 0,0 0,0 0,0 4,7 5,2 4,8 5,9 4,8 5,9
4 9,0 0,0 412 0,0 0,0 0,09 0,8 0,0 0,0 4,7 6,7 0,0 0,0 0,0 0,0 4,7 6,7 4,8 7,4 4,8 7,4
5 10,0 0,0 515 0,0 0,0 0,09 0,9 0,0 0,0 4,7 7,6 0,0 0,0 0,0 0,0 4,7 7,6 4,8 8,5 4,8 8,5
6 11,5 0,0 693 0,0 0,0 0,09 1,0 0,0 0,0 4,7 9,1 0,0 0,0 0,0 0,0 4,7 9,1 4,8 10,1 4,8 10,1
7 13,0 0,0 898 0,0 0,0 0,09 1,1 0,0 0,0 4,7 10,5 0,0 0,0 0,0 0,0 4,7 10,5 4,8 11,6 4,8 11,6
8 14,5 0,0 1131 0,0 0,0 0,09 1,2 0,0 0,0 4,7 12,0 0,0 0,0 0,0 0,0 4,7 12,0 4,8 13,2 4,8 13,2
9 16,0 0,0 1392 0,0 0,0 0,09 1,4 0,0 0,0 4,7 13,5 0,0 0,0 0,0 0,0 4,7 13,5 4,8 14,8 4,8 14,8
10 17,5 0,0 1683 0,0 0,0 0,09 1,5 0,0 0,0 4,7 14,9 0,0 0,0 0,0 0,0 4,7 14,9 4,8 16,4 4,8 16,4
11 19,0 0,0 2004 0,0 0,0 0,09 1,6 0,0 0,0 4,7 16,4 0,0 0,0 0,0 0,0 4,7 16,4 4,8 18,0 4,8 18,0
12 21,0 0,0 2481 0,0 0,0 0,09 1,8 0,0 0,0 4,7 18,4 0,0 0,0 0,0 0,0 4,7 18,4 4,8 20,2 4,8 20,2
13 22,8 0,0 2968 0,0 0,0 0,09 2,0 0,0 0,0 4,7 20,3 0,0 0,0 0,0 0,0 4,7 20,3 4,8 22,2 4,8 22,2
14 24,0 0,0 3355 0,0 0,0 0,09 2,1 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 4,8 23,7 4,8 23,7
15 24,0 0,0 3355 0,0 0,0 0,09 2,1 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 4,8 23,7 4,8 23,7
16 24,0 0,0 3355 0,0 0,0 0,09 2,1 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 4,8 23,7 4,8 23,7
17 24,0 0,0 3355 0,0 0,0 0,09 2,1 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 4,8 23,7 4,8 23,7
18 24,0 0,0 3355 0,0 0,0 0,09 2,1 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 4,8 23,7 4,8 23,7
19 24,0 0,0 3355 0,0 0,0 0,09 2,1 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 4,8 23,7 4,8 23,7
LOAD CASE D "Off board Lifts" wave height Hsig4 [m] 0 [ft] 0,000
Dynamic horizintal forces on lifted load Dynamic horizintal forces on structures Forces due to reduced wind (Vwr m/sec) Total side forces and moments - (W/O Cv and dynamic from SB)
moment CM forces CI forces CM forces CI forces Lifted load Structures 1 2 3
radius Capacity of inertia W sidedyn Csidedyn W sideCI CsideCI W sideCM CsideCM W sideCI CsideCI W sideWL CsideWL W sideStru CsideStru W / O load and wind W / O wind With wind
L P Mi force couple force couple force couple force couple force couple force couple force couple force couple force couple
Prog. [m] [tons] [tm2] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm]
1 4,0 0,0 77 0,0 0,0 0,09 0,3 0,0 0,0 4,7 1,9 0,0 0,0 0,0 0,0 4,7 1,9 4,8 2,2 4,8 2,2
2 6,0 0,0 175 0,0 0,0 0,09 0,5 0,0 0,0 4,7 3,8 0,0 0,0 0,0 0,0 4,7 3,8 4,8 4,3 4,8 4,3
3 7,5 0,0 280 0,0 0,0 0,09 0,6 0,0 0,0 4,7 5,2 0,0 0,0 0,0 0,0 4,7 5,2 4,8 5,9 4,8 5,9
4 9,0 0,0 412 0,0 0,0 0,09 0,8 0,0 0,0 4,7 6,7 0,0 0,0 0,0 0,0 4,7 6,7 4,8 7,4 4,8 7,4
5 10,0 0,0 515 0,0 0,0 0,09 0,9 0,0 0,0 4,7 7,6 0,0 0,0 0,0 0,0 4,7 7,6 4,8 8,5 4,8 8,5
6 11,5 0,0 693 0,0 0,0 0,09 1,0 0,0 0,0 4,7 9,1 0,0 0,0 0,0 0,0 4,7 9,1 4,8 10,1 4,8 10,1
7 13,0 0,0 898 0,0 0,0 0,09 1,1 0,0 0,0 4,7 10,5 0,0 0,0 0,0 0,0 4,7 10,5 4,8 11,6 4,8 11,6
8 14,5 0,0 1131 0,0 0,0 0,09 1,2 0,0 0,0 4,7 12,0 0,0 0,0 0,0 0,0 4,7 12,0 4,8 13,2 4,8 13,2
9 16,0 0,0 1392 0,0 0,0 0,09 1,4 0,0 0,0 4,7 13,5 0,0 0,0 0,0 0,0 4,7 13,5 4,8 14,8 4,8 14,8
10 17,5 0,0 1683 0,0 0,0 0,09 1,5 0,0 0,0 4,7 14,9 0,0 0,0 0,0 0,0 4,7 14,9 4,8 16,4 4,8 16,4
11 19,0 0,0 2004 0,0 0,0 0,09 1,6 0,0 0,0 4,7 16,4 0,0 0,0 0,0 0,0 4,7 16,4 4,8 18,0 4,8 18,0
12 21,0 0,0 2481 0,0 0,0 0,09 1,8 0,0 0,0 4,7 18,4 0,0 0,0 0,0 0,0 4,7 18,4 4,8 20,2 4,8 20,2
13 22,8 0,0 2968 0,0 0,0 0,09 2,0 0,0 0,0 4,7 20,3 0,0 0,0 0,0 0,0 4,7 20,3 4,8 22,2 4,8 22,2
14 24,0 0,0 3355 0,0 0,0 0,09 2,1 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 4,8 23,7 4,8 23,7
15 24,0 0,0 3355 0,0 0,0 0,09 2,1 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 4,8 23,7 4,8 23,7
16 24,0 0,0 3355 0,0 0,0 0,09 2,1 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 4,8 23,7 4,8 23,7
17 24,0 0,0 3355 0,0 0,0 0,09 2,1 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 4,8 23,7 4,8 23,7
18 24,0 0,0 3355 0,0 0,0 0,09 2,1 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 4,8 23,7 4,8 23,7
19 24,0 0,0 3355 0,0 0,0 0,09 2,1 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 4,8 23,7 4,8 23,7
LOAD CASE E "On board " wave height Hsig5 [m] 0 [ft] 0,000
Dynamic horizintal forces on lifted load Dynamic horizintal forces on structures Forces due to reduced wind (Vwr m/sec) Total side forces and moments - (W/O Cv and dynamic from SB)
moment CM forces CI forces CM forces CI forces Lifted load Structures 1 2 3
radius Capacity of inertia W sidedyn Csidedyn W sideCI CsideCI W sideCM CsideCM W sideCI CsideCI W sideWL CsideWL W sideStru CsideStru W / O load and wind W / O wind With wind
L P Mi force couple force couple force couple force couple force couple force couple force couple force couple force couple
Prog. [m] [tons] [tm2] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm]
1 4,0 20,0 397 0,0 0,0 1,80 7,2 0,0 0,0 4,7 1,9 0,0 0,0 0,0 0,0 4,7 1,9 6,5 9,0 6,5 9,0
2 6,0 20,0 895 0,0 0,0 1,80 10,8 0,0 0,0 4,7 3,8 0,0 0,0 0,0 0,0 4,7 3,8 6,5 14,6 6,5 14,6
3 7,5 20,0 1405 0,0 0,0 1,80 13,5 0,0 0,0 4,7 5,2 0,0 0,0 0,0 0,0 4,7 5,2 6,5 18,7 6,5 18,7
4 9,0 20,0 2032 0,0 0,0 1,80 16,2 0,0 0,0 4,7 6,7 0,0 0,0 0,0 0,0 4,7 6,7 6,5 22,8 6,5 22,8
5 10,0 15,5 2065 0,0 0,0 1,41 14,1 0,0 0,0 4,7 7,6 0,0 0,0 0,0 0,0 4,7 7,6 6,2 21,7 6,2 21,7
6 11,5 13,7 2504 0,0 0,0 1,26 14,5 0,0 0,0 4,7 9,1 0,0 0,0 0,0 0,0 4,7 9,1 6,0 23,5 6,0 23,5
7 13,0 10,0 2588 0,0 0,0 0,94 12,2 0,0 0,0 4,7 10,5 0,0 0,0 0,0 0,0 4,7 10,5 5,7 22,8 5,7 22,8
8 14,5 8,0 2813 0,0 0,0 0,77 11,2 0,0 0,0 4,7 12,0 0,0 0,0 0,0 0,0 4,7 12,0 5,5 23,2 5,5 23,2
9 16,0 7,0 3184 0,0 0,0 0,68 11,0 0,0 0,0 4,7 13,5 0,0 0,0 0,0 0,0 4,7 13,5 5,4 24,4 5,4 24,4
10 17,5 7,0 3827 0,0 0,0 0,68 12,0 0,0 0,0 4,7 14,9 0,0 0,0 0,0 0,0 4,7 14,9 5,4 26,9 5,4 26,9
11 19,0 7,0 4531 0,0 0,0 0,68 13,0 0,0 0,0 4,7 16,4 0,0 0,0 0,0 0,0 4,7 16,4 5,4 29,4 5,4 29,4
12 21,0 7,0 5568 0,0 0,0 0,68 14,4 0,0 0,0 4,7 18,4 0,0 0,0 0,0 0,0 4,7 18,4 5,4 32,8 5,4 32,8
13 22,8 7,0 6607 0,0 0,0 0,68 15,6 0,0 0,0 4,7 20,3 0,0 0,0 0,0 0,0 4,7 20,3 5,4 35,9 5,4 35,9
14 24,0 7,0 7387 0,0 0,0 0,68 16,4 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,4 38,1 5,4 38,1
15 24,0 7,0 7387 0,0 0,0 0,68 16,4 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,4 38,1 5,4 38,1
16 24,0 7,0 7387 0,0 0,0 0,68 16,4 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,4 38,1 5,4 38,1
17 24,0 7,0 7387 0,0 0,0 0,68 16,4 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,4 38,1 5,4 38,1
18 24,0 7,0 7387 0,0 0,0 0,68 16,4 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,4 38,1 5,4 38,1
19 24,0 7,0 7387 0,0 0,0 0,68 16,4 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,4 38,1 5,4 38,1
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 73/158
LOAD CASE F "On board " wave height Hsig6 [m] 0 [ft] 0,000
Dynamic horizintal forces on lifted load Dynamic horizintal forces on structures Forces due to reduced wind (Vwr m/sec) Total side forces and moments - (W/O Cv and dynamic from SB)
moment CM forces CI forces CM forces CI forces Lifted load Structures 1 2 3
radius Capacity of inertia W sidedyn Csidedyn W sideCI CsideCI W sideCM CsideCM W sideCI CsideCI W sideWL CsideWL W sideStru CsideStru W / O load and wind W / O wind With wind
L P Mi force couple force couple force couple force couple force couple force couple force couple force couple force couple
Prog. [m] [tons] [tm2] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm]
1 4,0 0,0 77 0,0 0,0 0,09 0,3 0,0 0,0 4,7 1,9 0,0 0,0 0,0 0,0 4,7 1,9 4,8 2,2 4,8 2,2
2 6,0 0,0 175 0,0 0,0 0,09 0,5 0,0 0,0 4,7 3,8 0,0 0,0 0,0 0,0 4,7 3,8 4,8 4,3 4,8 4,3
3 7,5 0,0 280 0,0 0,0 0,09 0,6 0,0 0,0 4,7 5,2 0,0 0,0 0,0 0,0 4,7 5,2 4,8 5,9 4,8 5,9
4 9,0 0,0 412 0,0 0,0 0,09 0,8 0,0 0,0 4,7 6,7 0,0 0,0 0,0 0,0 4,7 6,7 4,8 7,4 4,8 7,4
5 10,0 0,0 515 0,0 0,0 0,09 0,9 0,0 0,0 4,7 7,6 0,0 0,0 0,0 0,0 4,7 7,6 4,8 8,5 4,8 8,5
6 11,5 0,0 693 0,0 0,0 0,09 1,0 0,0 0,0 4,7 9,1 0,0 0,0 0,0 0,0 4,7 9,1 4,8 10,1 4,8 10,1
7 13,0 0,0 898 0,0 0,0 0,09 1,1 0,0 0,0 4,7 10,5 0,0 0,0 0,0 0,0 4,7 10,5 4,8 11,6 4,8 11,6
8 14,5 0,0 1131 0,0 0,0 0,09 1,2 0,0 0,0 4,7 12,0 0,0 0,0 0,0 0,0 4,7 12,0 4,8 13,2 4,8 13,2
9 16,0 0,0 1392 0,0 0,0 0,09 1,4 0,0 0,0 4,7 13,5 0,0 0,0 0,0 0,0 4,7 13,5 4,8 14,8 4,8 14,8
10 17,5 0,0 1683 0,0 0,0 0,09 1,5 0,0 0,0 4,7 14,9 0,0 0,0 0,0 0,0 4,7 14,9 4,8 16,4 4,8 16,4
11 19,0 0,0 2004 0,0 0,0 0,09 1,6 0,0 0,0 4,7 16,4 0,0 0,0 0,0 0,0 4,7 16,4 4,8 18,0 4,8 18,0
12 21,0 0,0 2481 0,0 0,0 0,09 1,8 0,0 0,0 4,7 18,4 0,0 0,0 0,0 0,0 4,7 18,4 4,8 20,2 4,8 20,2
13 22,8 0,0 2968 0,0 0,0 0,09 2,0 0,0 0,0 4,7 20,3 0,0 0,0 0,0 0,0 4,7 20,3 4,8 22,2 4,8 22,2
14 24,0 0,0 3355 0,0 0,0 0,09 2,1 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 4,8 23,7 4,8 23,7
15 24,0 0,0 3355 0,0 0,0 0,09 2,1 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 4,8 23,7 4,8 23,7
16 24,0 0,0 3355 0,0 0,0 0,09 2,1 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 4,8 23,7 4,8 23,7
17 24,0 0,0 3355 0,0 0,0 0,09 2,1 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 4,8 23,7 4,8 23,7
18 24,0 0,0 3355 0,0 0,0 0,09 2,1 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 4,8 23,7 4,8 23,7
19 24,0 0,0 3355 0,0 0,0 0,09 2,1 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 4,8 23,7 4,8 23,7
LOAD CASE G - Aux "Off board Lifts" wave height Hsig7 [m] 1 [ft] 3,281
Dynamic horizintal forces on lifted load Dynamic horizintal forces on structures Forces due to reduced wind (Vwr m/sec) Total side forces and moments - (W/O Cv and dynamic from SB)
moment CM forces CI forces CM forces CI forces Lifted load Structures 1 2 3
radius Capacity of inertia W sidedyn Csidedyn W sideCI CsideCI W sideCM CsideCM W sideCI CsideCI W sideWL CsideWL W sideStru CsideStru W / O load and wind W / O wind With wind
La P Mi force couple force couple force couple force couple force couple force couple force couple force couple force couple
Prog. [m] [tons] [tm2] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm]
1 5,5 5,0 239 0,0 0,0 0,46 2,5 0,0 0,0 4,7 1,9 0,0 0,0 0,0 0,0 4,7 1,9 5,2 4,4 5,2 4,4
2 7,7 5,0 492 0,0 0,0 0,51 3,9 0,0 0,0 4,7 3,8 0,0 0,0 0,0 0,0 4,7 3,8 5,3 7,7 5,3 7,7
3 9,3 5,0 746 0,0 0,0 0,51 4,8 0,0 0,0 4,7 5,2 0,0 0,0 0,0 0,0 4,7 5,2 5,3 10,0 5,3 10,0
4 11,0 5,0 1056 0,0 0,0 0,51 5,6 0,0 0,0 4,7 6,7 0,0 0,0 0,0 0,0 4,7 6,7 5,3 12,3 5,3 12,3
5 12,1 5,0 1292 0,0 0,0 0,51 6,2 0,0 0,0 4,7 7,6 0,0 0,0 0,0 0,0 4,7 7,6 5,3 13,8 5,3 13,8
6 13,7 5,0 1693 0,0 0,0 0,51 7,1 0,0 0,0 4,7 9,1 0,0 0,0 0,0 0,0 4,7 9,1 5,3 16,1 5,3 16,1
7 15,4 5,0 2149 0,0 0,0 0,51 7,9 0,0 0,0 4,7 10,5 0,0 0,0 0,0 0,0 4,7 10,5 5,3 18,4 5,3 18,4
8 17,0 5,0 2660 0,0 0,0 0,51 8,7 0,0 0,0 4,7 12,0 0,0 0,0 0,0 0,0 4,7 12,0 5,3 20,7 5,3 20,7
9 18,7 5,0 3226 0,0 0,0 0,51 9,6 0,0 0,0 4,7 13,5 0,0 0,0 0,0 0,0 4,7 13,5 5,3 23,0 5,3 23,0
10 20,3 5,0 3847 0,0 0,0 0,51 10,4 0,0 0,0 4,7 14,9 0,0 0,0 0,0 0,0 4,7 14,9 5,3 25,3 5,3 25,3
11 21,9 5,0 4523 0,0 0,0 0,51 11,3 0,0 0,0 4,7 16,4 0,0 0,0 0,0 0,0 4,7 16,4 5,3 27,7 5,3 27,7
12 24,0 5,0 5510 0,0 0,0 0,51 12,3 0,0 0,0 4,7 18,4 0,0 0,0 0,0 0,0 4,7 18,4 5,3 30,8 5,3 30,8
13 25,9 5,0 6481 0,0 0,0 0,51 13,3 0,0 0,0 4,7 20,3 0,0 0,0 0,0 0,0 4,7 20,3 5,3 33,6 5,3 33,6
14 27,1 5,0 7170 0,0 0,0 0,51 13,9 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,3 35,5 5,3 35,5
15 27,1 5,0 7170 0,0 0,0 0,51 13,9 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,3 35,5 5,3 35,5
16 27,1 5,0 7170 0,0 0,0 0,51 13,9 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,3 35,5 5,3 35,5
17 27,1 5,0 7170 0,0 0,0 0,51 13,9 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,3 35,5 5,3 35,5
18 27,1 5,0 7170 0,0 0,0 0,51 13,9 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,3 35,5 5,3 35,5
19 27,1 5,0 7170 0,0 0,0 0,51 13,9 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,3 35,5 5,3 35,5
35,5
LOAD CASE H - Aux "Off board Lifts" wave height Hsig8 [m] 2,5 [ft] 8,202
Dynamic horizintal forces on lifted load Dynamic horizintal forces on structures Forces due to reduced wind (Vwr m/sec) Total side forces and moments - (W/O Cv and dynamic from SB)
moment CM forces CI forces CM forces CI forces Lifted load Structures 1 2 3
radius Capacity of inertia W sidedyn Csidedyn W sideCI CsideCI W sideCM CsideCM W sideCI CsideCI W sideWL CsideWL W sideStru CsideStru W / O load and wind W / O wind With wind
La P Mi force couple force couple force couple force couple force couple force couple force couple force couple force couple
Prog. [m] [tons] [tm2] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm]
1 5,5 5,0 239 0,0 0,0 0,46 2,5 0,0 0,0 4,7 1,9 0,0 0,0 0,0 0,0 4,7 1,9 5,2 4,4 5,2 4,4
2 7,7 5,0 492 0,0 0,0 0,46 3,5 0,0 0,0 4,7 3,8 0,0 0,0 0,0 0,0 4,7 3,8 5,2 7,3 5,2 7,3
3 9,3 5,0 746 0,0 0,0 0,46 4,3 0,0 0,0 4,7 5,2 0,0 0,0 0,0 0,0 4,7 5,2 5,2 9,5 5,2 9,5
4 11,0 5,0 1056 0,0 0,0 0,46 5,1 0,0 0,0 4,7 6,7 0,0 0,0 0,0 0,0 4,7 6,7 5,2 11,7 5,2 11,7
5 12,1 5,0 1292 0,0 0,0 0,46 5,6 0,0 0,0 4,7 7,6 0,0 0,0 0,0 0,0 4,7 7,6 5,2 13,2 5,2 13,2
6 13,7 5,0 1693 0,0 0,0 0,46 6,4 0,0 0,0 4,7 9,1 0,0 0,0 0,0 0,0 4,7 9,1 5,2 15,4 5,2 15,4
7 15,4 5,0 2149 0,0 0,0 0,46 7,1 0,0 0,0 4,7 10,5 0,0 0,0 0,0 0,0 4,7 10,5 5,2 17,6 5,2 17,6
8 17,0 5,0 2660 0,0 0,0 0,46 7,9 0,0 0,0 4,7 12,0 0,0 0,0 0,0 0,0 4,7 12,0 5,2 19,9 5,2 19,9
9 18,7 5,0 3226 0,0 0,0 0,46 8,6 0,0 0,0 4,7 13,5 0,0 0,0 0,0 0,0 4,7 13,5 5,2 22,1 5,2 22,1
10 20,3 5,0 3847 0,0 0,0 0,46 9,4 0,0 0,0 4,7 14,9 0,0 0,0 0,0 0,0 4,7 14,9 5,2 24,3 5,2 24,3
11 21,9 5,0 4523 0,0 0,0 0,46 10,1 0,0 0,0 4,7 16,4 0,0 0,0 0,0 0,0 4,7 16,4 5,2 26,5 5,2 26,5
12 24,0 5,0 5510 0,0 0,0 0,46 11,1 0,0 0,0 4,7 18,4 0,0 0,0 0,0 0,0 4,7 18,4 5,2 29,5 5,2 29,5
13 25,9 5,0 6481 0,0 0,0 0,46 12,0 0,0 0,0 4,7 20,3 0,0 0,0 0,0 0,0 4,7 20,3 5,2 32,2 5,2 32,2
14 27,1 5,0 7170 0,0 0,0 0,46 12,5 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,2 34,1 5,2 34,1
15 27,1 5,0 7170 0,0 0,0 0,46 12,5 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,2 34,1 5,2 34,1
16 27,1 5,0 7170 0,0 0,0 0,46 12,5 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,2 34,1 5,2 34,1
17 27,1 5,0 7170 0,0 0,0 0,46 12,5 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,2 34,1 5,2 34,1
18 27,1 5,0 7170 0,0 0,0 0,46 12,5 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,2 34,1 5,2 34,1
19 27,1 5,0 7170 0,0 0,0 0,46 12,5 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,2 34,1 5,2 34,1
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 74/158
LOAD CASE I - Aux "On board " wave height Hsig9 [m] 0 [ft] 0,000
Dynamic horizintal forces on lifted load Dynamic horizintal forces on structures Forces due to reduced wind (Vwr m/sec) Total side forces and moments - (W/O Cv and dynamic from SB)
moment CM forces CI forces CM forces CI forces Lifted load Structures 1 2 3
radius Capacity of inertia W sidedyn Csidedyn W sideCI CsideCI W sideCM CsideCM W sideCI CsideCI W sideWL CsideWL W sideStru CsideStru W / O load and wind W / O wind With wind
La P Mi force couple force couple force couple force couple force couple force couple force couple force couple force couple
Prog. [m] [tons] [tm2] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm]
1 5,5 5,0 239 0,0 0,0 0,46 2,5 0,0 0,0 4,7 1,9 0,0 0,0 0,0 0,0 4,7 1,9 5,2 4,4 5,2 4,4
2 7,7 5,0 492 0,0 0,0 0,46 3,5 0,0 0,0 4,7 3,8 0,0 0,0 0,0 0,0 4,7 3,8 5,2 7,3 5,2 7,3
3 9,3 5,0 746 0,0 0,0 0,46 4,3 0,0 0,0 4,7 5,2 0,0 0,0 0,0 0,0 4,7 5,2 5,2 9,5 5,2 9,5
4 11,0 5,0 1056 0,0 0,0 0,46 5,1 0,0 0,0 4,7 6,7 0,0 0,0 0,0 0,0 4,7 6,7 5,2 11,7 5,2 11,7
5 12,1 5,0 1292 0,0 0,0 0,46 5,6 0,0 0,0 4,7 7,6 0,0 0,0 0,0 0,0 4,7 7,6 5,2 13,2 5,2 13,2
6 13,7 5,0 1693 0,0 0,0 0,46 6,4 0,0 0,0 4,7 9,1 0,0 0,0 0,0 0,0 4,7 9,1 5,2 15,4 5,2 15,4
7 15,4 5,0 2149 0,0 0,0 0,46 7,1 0,0 0,0 4,7 10,5 0,0 0,0 0,0 0,0 4,7 10,5 5,2 17,6 5,2 17,6
8 17,0 5,0 2660 0,0 0,0 0,46 7,9 0,0 0,0 4,7 12,0 0,0 0,0 0,0 0,0 4,7 12,0 5,2 19,9 5,2 19,9
9 18,7 5,0 3226 0,0 0,0 0,46 8,6 0,0 0,0 4,7 13,5 0,0 0,0 0,0 0,0 4,7 13,5 5,2 22,1 5,2 22,1
10 20,3 5,0 3847 0,0 0,0 0,46 9,4 0,0 0,0 4,7 14,9 0,0 0,0 0,0 0,0 4,7 14,9 5,2 24,3 5,2 24,3
11 21,9 5,0 4523 0,0 0,0 0,46 10,1 0,0 0,0 4,7 16,4 0,0 0,0 0,0 0,0 4,7 16,4 5,2 26,5 5,2 26,5
12 24,0 5,0 5510 0,0 0,0 0,46 11,1 0,0 0,0 4,7 18,4 0,0 0,0 0,0 0,0 4,7 18,4 5,2 29,5 5,2 29,5
13 25,9 5,0 6481 0,0 0,0 0,46 12,0 0,0 0,0 4,7 20,3 0,0 0,0 0,0 0,0 4,7 20,3 5,2 32,2 5,2 32,2
14 27,1 5,0 7170 0,0 0,0 0,46 12,5 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,2 34,1 5,2 34,1
15 27,1 5,0 7170 0,0 0,0 0,46 12,5 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,2 34,1 5,2 34,1
16 27,1 5,0 7170 0,0 0,0 0,46 12,5 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,2 34,1 5,2 34,1
17 27,1 5,0 7170 0,0 0,0 0,46 12,5 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,2 34,1 5,2 34,1
18 27,1 5,0 7170 0,0 0,0 0,46 12,5 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,2 34,1 5,2 34,1
19 27,1 5,0 7170 0,0 0,0 0,46 12,5 0,0 0,0 4,7 21,6 0,0 0,0 0,0 0,0 4,7 21,6 5,2 34,1 5,2 34,1
Couples acting on the swing mechanism - Load condition : w/o Load and w/o Wind - Load case (1)
Couples acting on the swing mechanism - Load condition : with Load and w/o Wind - Load case (2)
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 75/158
Couples acting on the swing mechanism - Load condition : with Load and with Wind - Load case (3)
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 76/158
INTERFACE WITH BATTERY LIMIT SUPPORT' STRUCTURE
Load Condtitions : STATIC EQUIVALENT and DYNAMIC w/o WIND
Mechanical parameters
ref. system SRT
[kN] X2[m] Z2[m]
lower pedestal adapter P11p 35,00 0,00 2,17 crane base angle j1A 0 deg
P12p 0,0 0,00 0,00
P13p 0,0 0,00 0,00 wind direction jW 0 deg
tot. values (lower structure) Ps 35,0 0,000 2,171
LOAD CASE A "Off board Lifts" wave height Hsig1 [m] 1 [ft] 3,281
LOAD CASE B "Off board Lifts" wave height Hsig2 [m] 2,5 [ft] 8,202
LOAD CASE C "Off board Lifts" wave height Hsig3 [m] 0 [ft] 0,000
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 77/158
LOAD CASE D "Off board Lifts" wave height Hsig4 [m] 0 [ft] 0,000
LOAD CASE E "On board " wave height Hsig5 [m] 0 [ft] 0,000
LOAD CASE F "On board " wave height Hsig6 [m] 0 [ft] 0,000
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 78/158
LOAD CASE G - Aux "Off board Lifts" wave height Hsig7 [m] 1 [ft] 3,281
LOAD CASE H - Aux "Off board Lifts" wave height Hsig8 [m] 2,5 [ft] 8,202
LOAD CASE I - Aux "On board " wave height Hsig9 [m] 0 [ft] 0,000
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 79/158
Interface plane : bending moments My - Load condition : D + Cvc*L (static equivalent)
Interface plane : combined bending moments Mc - Load condition : D + Cv*L + I (dynamic w/o wind)
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 80/158
INTERFACE WITH BATTERY LIMIT SUPPORT' STRUCTURE - Load Cond.: D + Cv*L +I +W
LOAD CASE A "Off board Lifts" wave height Hsig1 [m] 1 [ft] 3,281
radius Capacity Static eq. D + Cvc*L Dynamic with max in-service Wind D +Cv*L +I + W
L P Fz My Fz Fx Fy FCOMB Mx My MCOMB Mz
Prog. [m] [tons] [kN] [kNm] [kN] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kNm]
1 4,0 20,0 -784 1036 -892 96 22 99 -548 2978 3028 70
2 6,0 20,0 -784 1667 -892 96 22 98 -540 3734 3772 107
3 7,5 20,0 -784 2142 -892 95 22 98 -532 4293 4325 134
4 9,0 20,0 -784 2616 -892 95 22 97 -522 4845 4873 161
5 10,0 20,0 -784 2933 -892 94 22 97 -515 5209 5234 179
6 11,5 20,0 -784 3408 -892 94 22 96 -501 5749 5770 206
7 13,0 20,0 -784 3884 -892 93 22 95 -485 6280 6299 234
8 14,5 18,0 -764 4075 -866 89 21 91 -425 6350 6364 237
9 16,0 15,5 -740 4131 -834 83 19 85 -357 6216 6226 229
10 17,5 14,5 -730 4371 -821 80 18 82 -318 6377 6385 237
11 19,0 13,7 -722 4620 -810 77 17 79 -281 6548 6554 245
12 21,0 10,0 -686 4376 -766 69 14 70 -194 6021 6024 213
13 22,8 8,0 -666 4335 -749 62 13 64 -137 5925 5926 207
14 24,0 7,0 -656 4361 -742 54 13 55 -73 5865 5866 207
15 24,0 7,0 -656 4361 -742 54 13 55 -73 5865 5866 207
16 24,0 7,0 -656 4361 -742 54 13 55 -73 5865 5866 207
17 24,0 7,0 -656 4361 -742 54 13 55 -73 5865 5866 207
18 24,0 7,0 -656 4361 -742 54 13 55 -73 5865 5866 207
19 24,0 7,0 -656 4361 -742 54 13 55 -73 5865 5866 207
LOAD CASE B "Off board Lifts" wave height Hsig2 [m] 2,5 [ft] 8,202
radius Capacity Static eq. D + Cvc*L Dynamic with max in-service Wind D +Cv*L +I + W
L P Fz My Fz Fx Fy FCOMB Mx My MCOMB Mz
Prog. [m] [tons] [kN] [kNm] [kN] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kNm]
1 4,0 20,0 -784 1036 -892 112 30 116 -789 3455 3544 103
2 6,0 20,0 -784 1667 -892 112 30 116 -778 4204 4275 156
3 7,5 20,0 -784 2142 -892 112 30 116 -766 4756 4817 195
4 9,0 20,0 -784 2616 -892 111 30 115 -752 5299 5352 235
5 10,0 20,0 -784 2933 -892 111 30 115 -740 5656 5705 261
6 11,5 17,5 -759 3126 -860 104 27 108 -640 5656 5692 266
7 13,0 15,0 -735 3246 -827 97 24 100 -541 5557 5583 262
8 14,5 13,0 -715 3364 -801 92 22 94 -460 5484 5504 257
9 16,0 11,0 -696 3425 -775 86 20 88 -381 5334 5348 245
10 17,5 10,0 -686 3599 -764 82 19 84 -336 5431 5441 251
11 19,0 8,5 -671 3651 -750 78 17 80 -285 5424 5431 248
12 21,0 7,5 -661 3861 -741 73 16 75 -231 5572 5577 258
13 22,8 6,5 -652 3999 -733 67 16 69 -169 5621 5624 262
14 24,0 6,0 -647 4126 -730 59 15 61 -91 5625 5626 270
15 24,0 6,0 -647 4126 -730 59 15 61 -91 5625 5626 270
16 24,0 6,0 -647 4126 -730 59 15 61 -91 5625 5626 270
17 24,0 6,0 -647 4126 -730 59 15 61 -91 5625 5626 270
18 24,0 6,0 -647 4126 -730 59 15 61 -91 5625 5626 270
19 24,0 6,0 -647 4126 -730 59 15 61 -91 5625 5626 270
LOAD CASE C "Off board Lifts" wave height Hsig3 [m] 0 [ft] 0,000
radius Capacity Static eq. D + Cvc*L Dynamic with max in-service Wind D +Cv*L +I + W
L P Fz My Fz Fx Fy FCOMB Mx My MCOMB Mz
Prog. [m] [tons] [kN] [kNm] [kN] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kNm]
1 4,0 0,0 -588 251 -648 66 6 67 -81 1122 1125 7
2 6,0 0,0 -588 491 -646 66 6 66 -77 1381 1383 11
3 7,5 0,0 -588 670 -644 65 6 65 -75 1570 1572 13
4 9,0 0,0 -588 851 -643 64 6 65 -72 1756 1757 16
5 10,0 0,0 -588 971 -643 64 6 64 -71 1878 1879 18
6 11,5 0,0 -588 1152 -642 63 6 63 -69 2057 2058 21
7 13,0 0,0 -588 1334 -642 62 6 62 -67 2233 2234 23
8 14,5 0,0 -588 1516 -641 61 6 61 -64 2405 2406 26
9 16,0 0,0 -588 1699 -641 60 6 60 -61 2573 2574 29
10 17,5 0,0 -588 1882 -641 58 6 58 -59 2737 2737 31
11 19,0 0,0 -588 2067 -640 56 6 57 -55 2896 2896 34
12 21,0 0,0 -588 2316 -640 53 6 53 -49 3099 3099 38
13 22,8 0,0 -588 2546 -640 48 6 49 -42 3268 3268 41
14 24,0 0,0 -588 2714 -640 41 6 41 -29 3350 3350 44
15 24,0 0,0 -588 2714 -640 41 6 41 -29 3350 3350 44
16 24,0 0,0 -588 2714 -640 41 6 41 -29 3350 3350 44
17 24,0 0,0 -588 2714 -640 41 6 41 -29 3350 3350 44
18 24,0 0,0 -588 2714 -640 41 6 41 -29 3350 3350 44
19 24,0 0,0 -588 2714 -640 41 6 41 -29 3350 3350 44
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 81/158
LOAD CASE D "Off board Lifts" wave height Hsig4 [m] 0 [ft] 0,000
radius Capacity Static eq. D + Cvc*L Dynamic with max in-service Wind D +Cv*L +I + W
L P Fz My Fz Fx Fy FCOMB Mx My MCOMB Mz
Prog. [m] [tons] [kN] [kNm] [kN] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kNm]
1 4,0 0,0 -588 251 -649 66 6 67 -82 1125 1128 7
2 6,0 0,0 -588 491 -646 66 6 66 -77 1383 1385 11
3 7,5 0,0 -588 670 -644 65 6 65 -75 1572 1574 13
4 9,0 0,0 -588 851 -643 64 6 65 -73 1757 1759 16
5 10,0 0,0 -588 971 -643 64 6 64 -71 1879 1880 18
6 11,5 0,0 -588 1152 -642 63 6 63 -69 2059 2060 21
7 13,0 0,0 -588 1334 -642 62 6 63 -67 2234 2235 23
8 14,5 0,0 -588 1516 -641 61 6 61 -64 2406 2407 26
9 16,0 0,0 -588 1699 -641 60 6 60 -62 2574 2575 29
10 17,5 0,0 -588 1882 -641 58 6 58 -59 2738 2739 31
11 19,0 0,0 -588 2067 -641 56 6 57 -55 2897 2898 34
12 21,0 0,0 -588 2316 -640 53 6 53 -49 3100 3101 38
13 22,8 0,0 -588 2546 -640 48 6 49 -42 3270 3270 41
14 24,0 0,0 -588 2714 -641 41 6 41 -29 3351 3351 44
15 24,0 0,0 -588 2714 -641 41 6 41 -29 3351 3351 44
16 24,0 0,0 -588 2714 -641 41 6 41 -29 3351 3351 44
17 24,0 0,0 -588 2714 -641 41 6 41 -29 3351 3351 44
18 24,0 0,0 -588 2714 -641 41 6 41 -29 3351 3351 44
19 24,0 0,0 -588 2714 -641 41 6 41 -29 3351 3351 44
LOAD CASE E "On board " wave height Hsig5 [m] 0 [ft] 0,000
radius Capacity Static eq. D + Cvc*L Dynamic with max in-service Wind D +Cv*L +I + W
L P Fz My Fz Fx Fy FCOMB Mx My MCOMB Mz
Prog. [m] [tons] [kN] [kNm] [kN] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kNm]
1 4,0 20,0 -784 1036 -892 74 7 74 -114 2317 2319 11
2 6,0 20,0 -784 1667 -892 73 7 74 -113 3082 3084 18
3 7,5 20,0 -784 2142 -892 73 7 73 -111 3651 3653 23
4 9,0 20,0 -784 2616 -892 72 7 73 -110 4215 4217 28
5 10,0 15,5 -740 2491 -834 70 7 70 -94 3947 3948 26
6 11,5 13,7 -722 2697 -810 68 7 69 -87 4126 4127 28
7 13,0 10,0 -686 2609 -762 66 6 66 -73 3886 3887 27
8 14,5 8,0 -666 2653 -736 64 6 64 -66 3841 3841 27
9 16,0 7,0 -656 2797 -723 62 6 62 -60 3934 3934 28
10 17,5 7,0 -656 3084 -723 60 6 61 -58 4222 4222 31
11 19,0 7,0 -656 3372 -723 58 6 59 -55 4504 4505 34
12 21,0 7,0 -656 3758 -723 55 6 55 -49 4869 4869 38
13 22,8 7,0 -656 4111 -723 51 6 51 -41 5178 5178 41
14 24,0 7,0 -656 4361 -723 43 6 44 -29 5340 5340 43
15 24,0 7,0 -656 4361 -723 43 6 44 -29 5340 5340 43
16 24,0 7,0 -656 4361 -723 43 6 44 -29 5340 5340 43
17 24,0 7,0 -656 4361 -723 43 6 44 -29 5340 5340 43
18 24,0 7,0 -656 4361 -723 43 6 44 -29 5340 5340 43
19 24,0 7,0 -656 4361 -723 43 6 44 -29 5340 5340 43
LOAD CASE F "On board " wave height Hsig6 [m] 0 [ft] 0,000
radius Capacity Static eq. D + Cvc*L Dynamic with max in-service Wind D +Cv*L +I + W
L P Fz My Fz Fx Fy FCOMB Mx My MCOMB Mz
Prog. [m] [tons] [kN] [kNm] [kN] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kNm]
1 4,0 0,0 -588 251 -632 64 5 65 -47 1002 1003 2
2 6,0 0,0 -588 491 -632 64 5 64 -47 1250 1251 4
3 7,5 0,0 -588 670 -632 64 5 64 -47 1431 1432 6
4 9,0 0,0 -588 851 -632 63 5 63 -46 1610 1610 8
5 10,0 0,0 -588 971 -632 63 5 63 -46 1727 1727 9
6 11,5 0,0 -588 1152 -632 62 5 62 -45 1899 1900 10
7 13,0 0,0 -588 1334 -632 61 5 61 -44 2068 2068 12
8 14,5 0,0 -588 1516 -632 60 5 60 -43 2232 2233 14
9 16,0 0,0 -588 1699 -632 58 5 59 -42 2393 2394 15
10 17,5 0,0 -588 1882 -632 57 5 57 -40 2549 2550 17
11 19,0 0,0 -588 2067 -632 55 5 55 -38 2701 2701 19
12 21,0 0,0 -588 2316 -632 52 5 52 -35 2893 2893 21
13 22,8 0,0 -588 2546 -632 47 5 47 -31 3052 3052 23
14 24,0 0,0 -588 2714 -632 40 5 40 -24 3126 3126 24
15 24,0 0,0 -588 2714 -632 40 5 40 -24 3126 3126 24
16 24,0 0,0 -588 2714 -632 40 5 40 -24 3126 3126 24
17 24,0 0,0 -588 2714 -632 40 5 40 -24 3126 3126 24
18 24,0 0,0 -588 2714 -632 40 5 40 -24 3126 3126 24
19 24,0 0,0 -588 2714 -632 40 5 40 -24 3126 3126 24
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 82/158
LOAD CASE G - Aux "Off board Lifts" wave height Hsig7 [m] 1 [ft] 3,281
radius Capacity Static eq. D + Cvc*L Dynamic with max in-service Wind D +Cv*L +I + W
La P Fz My Fz Fx Fy FCOMB Mx My MCOMB Mz
Prog. [m] [tons] [kN] [kNm] [kN] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kNm]
1 5,5 5,0 -637 533 -728 76 11 77 -244 1912 1928 34
2 7,7 5,0 -637 883 -726 75 11 76 -239 2348 2360 50
3 9,3 5,0 -637 1146 -725 75 11 75 -233 2668 2678 61
4 11,0 5,0 -637 1409 -724 74 11 75 -227 2983 2991 72
5 12,1 5,0 -637 1584 -724 73 11 74 -223 3190 3197 79
6 13,7 5,0 -637 1848 -723 73 11 73 -216 3497 3503 90
7 15,4 5,0 -637 2112 -723 72 11 72 -208 3799 3805 102
8 17,0 5,0 -637 2376 -722 70 11 71 -199 4098 4103 113
9 18,7 5,0 -637 2640 -722 69 11 70 -190 4393 4397 124
10 20,3 5,0 -637 2905 -722 68 11 68 -178 4683 4687 135
11 21,9 5,0 -637 3170 -723 66 11 67 -165 4969 4972 147
12 24,0 5,0 -637 3525 -724 62 11 63 -142 5341 5343 163
13 25,9 5,0 -637 3848 -725 58 11 59 -111 5658 5659 178
14 27,1 5,0 -637 4070 -727 51 11 52 -60 5812 5812 189
15 27,1 5,0 -637 4070 -727 51 11 52 -60 5812 5812 189
16 27,1 5,0 -637 4070 -727 51 11 52 -60 5812 5812 189
17 27,1 5,0 -637 4070 -727 51 11 52 -60 5812 5812 189
18 27,1 5,0 -637 4070 -727 51 11 52 -60 5812 5812 189
19 27,1 5,0 -637 4070 -727 51 11 52 -60 5812 5812 189
LOAD CASE H - Aux "Off board Lifts" wave height Hsig8 [m] 2,5 [ft] 8,202
radius Capacity Static eq. D + Cvc*L Dynamic with max in-service Wind D +Cv*L +I + W
La P Fz My Fz Fx Fy FCOMB Mx My MCOMB Mz
Prog. [m] [tons] [kN] [kNm] [kN] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kNm]
1 5,5 5,0 -637 533 -728 82 14 83 -340 2102 2129 50
2 7,7 5,0 -637 883 -726 81 14 82 -328 2531 2552 71
3 9,3 5,0 -637 1146 -725 80 14 81 -320 2846 2864 87
4 11,0 5,0 -637 1409 -724 80 14 81 -311 3155 3170 102
5 12,1 5,0 -637 1584 -724 79 14 80 -305 3358 3372 112
6 13,7 5,0 -637 1848 -723 78 14 79 -295 3659 3671 128
7 15,4 5,0 -637 2112 -723 77 14 78 -284 3955 3966 143
8 17,0 5,0 -637 2376 -722 76 14 77 -272 4247 4256 159
9 18,7 5,0 -637 2640 -722 75 14 76 -258 4534 4541 174
10 20,3 5,0 -637 2905 -722 73 14 74 -243 4815 4821 190
11 21,9 5,0 -637 3170 -723 71 14 73 -224 5090 5095 206
12 24,0 5,0 -637 3525 -724 68 14 70 -192 5443 5447 229
13 25,9 5,0 -637 3848 -725 64 14 65 -149 5734 5736 250
14 27,1 5,0 -637 4070 -727 57 14 58 -76 5846 5846 266
15 27,1 5,0 -637 4070 -727 57 14 58 -76 5846 5846 266
16 27,1 5,0 -637 4070 -727 57 14 58 -76 5846 5846 266
17 27,1 5,0 -637 4070 -727 57 14 58 -76 5846 5846 266
18 27,1 5,0 -637 4070 -727 57 14 58 -76 5846 5846 266
19 27,1 5,0 -637 4070 -727 57 14 58 -76 5846 5846 266
LOAD CASE I - Aux "On board " wave height Hsig9 [m] 0 [ft] 0,000
radius Capacity Static eq. D + Cvc*L Dynamic with max in-service Wind D +Cv*L +I + W
La P Fz My Fz Fx Fy FCOMB Mx My MCOMB Mz
Prog. [m] [tons] [kN] [kNm] [kN] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kNm]
1 5,5 5,0 -637 533 -697 67 6 67 -64 1449 1450 5
2 7,7 5,0 -637 883 -697 66 6 66 -63 1843 1844 8
3 9,3 5,0 -637 1146 -697 66 6 66 -62 2134 2134 11
4 11,0 5,0 -637 1409 -697 65 6 65 -62 2420 2421 13
5 12,1 5,0 -637 1584 -697 65 6 65 -61 2609 2610 15
6 13,7 5,0 -637 1848 -697 64 6 64 -60 2889 2890 17
7 15,4 5,0 -637 2112 -697 63 6 63 -58 3165 3165 20
8 17,0 5,0 -637 2376 -697 62 6 62 -56 3436 3436 22
9 18,7 5,0 -637 2640 -697 61 6 61 -54 3702 3702 25
10 20,3 5,0 -637 2905 -697 59 6 59 -52 3962 3962 27
11 21,9 5,0 -637 3170 -697 57 6 57 -49 4216 4216 30
12 24,0 5,0 -637 3525 -697 54 6 54 -44 4541 4542 33
13 25,9 5,0 -637 3848 -697 49 6 50 -38 4813 4813 36
14 27,1 5,0 -637 4070 -697 42 6 42 -27 4943 4943 38
15 27,1 5,0 -637 4070 -697 42 6 42 -27 4943 4943 38
16 27,1 5,0 -637 4070 -697 42 6 42 -27 4943 4943 38
17 27,1 5,0 -637 4070 -697 42 6 42 -27 4943 4943 38
18 27,1 5,0 -637 4070 -697 42 6 42 -27 4943 4943 38
19 27,1 5,0 -637 4070 -697 42 6 42 -27 4943 4943 38
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 83/158
Interface plane : combined bending moments Mc - Load condition : D + Cv*L + I (dynamic w/o wind)
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 84/158
INTERFACE WITH BATTERY LIMIT SUPPORT' STRUCTURE - Design Platform Connection Load Condtition
(w or w/o Wind depending on Cv) in accordance with paragraph 5.2 API 2C rule
LOAD CASE A "Off board Lifts" wave height Hsig1 [m] 1 [ft] 3,281
radius Capacity Static eq. D + Cvc*L Dynamic with or without wind depending on Cv
L P Fz My Fz Fx Fy FCOMB Mx My MCOMB Mz
Prog. [m] [tons] [kN] [kNm] [kN] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kNm]
1 4,0 20,0 -784 1036 -1029 110 31 114 -800 3975 4054 105
2 6,0 20,0 -784 1667 -1029 109 31 114 -788 4998 5060 158
3 7,5 20,0 -784 2142 -1029 109 31 113 -777 5756 5808 198
4 9,0 20,0 -784 2616 -1029 108 31 113 -762 6505 6549 238
5 10,0 20,0 -784 2933 -1029 108 31 112 -751 6999 7039 265
6 11,5 20,0 -784 3408 -1029 107 31 112 -731 7733 7767 305
7 13,0 20,0 -784 3884 -1029 106 31 111 -707 8456 8486 345
8 14,5 18,0 -764 4075 -990 101 28 105 -618 8489 8512 350
9 16,0 15,5 -740 4131 -941 94 25 97 -516 8220 8236 337
10 17,5 14,5 -730 4371 -922 90 24 93 -458 8395 8407 347
11 19,0 13,7 -722 4620 -906 86 23 89 -403 8586 8596 359
12 21,0 10,0 -686 4376 -840 42 19 46 -274 7464 7469 310
13 22,8 8,0 -666 4335 -814 39 17 43 -191 7335 7338 300
14 24,0 7,0 -656 4361 -803 38 17 42 -99 7307 7307 300
15 24,0 7,0 -656 4361 -803 38 17 42 -99 7307 7307 300
16 24,0 7,0 -656 4361 -803 38 17 42 -99 7307 7307 300
17 24,0 7,0 -656 4361 -803 38 17 42 -99 7307 7307 300
18 24,0 7,0 -656 4361 -803 38 17 42 -99 7307 7307 300
19 24,0 7,0 -656 4361 -803 38 17 42 -99 7307 7307 300
LOAD CASE B "Off board Lifts" wave height Hsig2 [m] 2,5 [ft] 8,202
radius Capacity Static eq. D + Cvc*L Dynamic with or without wind depending on Cv
L P Fz My Fz Fx Fy FCOMB Mx My MCOMB Mz
Prog. [m] [tons] [kN] [kNm] [kN] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kNm]
1 4,0 20,0 -784 1036 -1029 134 43 141 -1161 4691 4832 154
2 6,0 20,0 -784 1667 -1029 134 43 141 -1144 5703 5817 232
3 7,5 20,0 -784 2142 -1029 133 43 140 -1127 6451 6548 291
4 9,0 20,0 -784 2616 -1029 133 43 140 -1106 7186 7271 349
5 10,0 20,0 -784 2933 -1029 132 43 139 -1089 7670 7747 388
6 11,5 17,5 -759 3126 -980 123 39 129 -939 7595 7653 395
7 13,0 15,0 -735 3246 -931 114 34 119 -791 7374 7417 387
8 14,5 13,0 -715 3364 -892 106 30 110 -670 7195 7226 380
9 16,0 11,0 -696 3425 -853 98 27 101 -552 6901 6923 361
10 17,5 10,0 -686 3599 -837 55 25 60 -485 6610 6628 369
11 19,0 8,5 -671 3651 -816 51 23 56 -409 6582 6595 364
12 21,0 7,5 -661 3861 -803 49 22 54 -329 6794 6802 377
13 22,8 6,5 -652 3999 -790 47 21 51 -239 6882 6886 382
14 24,0 6,0 -647 4126 -786 46 21 51 -124 6947 6949 395
15 24,0 6,0 -647 4126 -786 46 21 51 -124 6947 6949 395
16 24,0 6,0 -647 4126 -786 46 21 51 -124 6947 6949 395
17 24,0 6,0 -647 4126 -786 46 21 51 -124 6947 6949 395
18 24,0 6,0 -647 4126 -786 46 21 51 -124 6947 6949 395
19 24,0 6,0 -647 4126 -786 46 21 51 -124 6947 6949 395
LOAD CASE C "Off board Lifts" wave height Hsig3 [m] 0 [ft] 0,000
radius Capacity Static eq. D + Cvc*L Dynamic with or without wind depending on Cv
L P Fz My Fz Fx Fy FCOMB Mx My MCOMB Mz
Prog. [m] [tons] [kN] [kNm] [kN] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kNm]
1 4,0 0,0 -588 251 -663 21 7 22 -100 655 662 9
2 6,0 0,0 -588 491 -659 20 7 21 -94 944 948 14
3 7,5 0,0 -588 670 -657 20 7 21 -90 1160 1163 18
4 9,0 0,0 -588 851 -656 20 7 21 -87 1375 1378 21
5 10,0 0,0 -588 971 -655 20 7 21 -85 1519 1521 23
6 11,5 0,0 -588 1152 -654 20 7 21 -82 1734 1736 26
7 13,0 0,0 -588 1334 -653 20 7 21 -79 1949 1951 30
8 14,5 0,0 -588 1516 -653 20 6 21 -76 2165 2166 33
9 16,0 0,0 -588 1699 -652 20 6 21 -73 2380 2382 36
10 17,5 0,0 -588 1882 -652 20 6 21 -69 2596 2597 40
11 19,0 0,0 -588 2067 -651 20 6 21 -65 2813 2814 43
12 21,0 0,0 -588 2316 -651 20 6 21 -57 3102 3103 48
13 22,8 0,0 -588 2546 -651 20 6 21 -48 3364 3365 52
14 24,0 0,0 -588 2714 -651 20 6 21 -32 3540 3540 55
15 24,0 0,0 -588 2714 -651 20 6 21 -32 3540 3540 55
16 24,0 0,0 -588 2714 -651 20 6 21 -32 3540 3540 55
17 24,0 0,0 -588 2714 -651 20 6 21 -32 3540 3540 55
18 24,0 0,0 -588 2714 -651 20 6 21 -32 3540 3540 55
19 24,0 0,0 -588 2714 -651 20 6 21 -32 3540 3540 55
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 85/158
LOAD CASE D "Off board Lifts" wave height Hsig4 [m] 0 [ft] 0,000
radius Capacity Static eq. D + Cvc*L Dynamic with or without wind depending on Cv
L P Fz My Fz Fx Fy FCOMB Mx My MCOMB Mz
Prog. [m] [tons] [kN] [kNm] [kN] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kNm]
1 4,0 0,0 -588 251 -664 21 7 22 -101 658 666 10
2 6,0 0,0 -588 491 -659 20 7 21 -94 946 951 14
3 7,5 0,0 -588 670 -657 20 7 21 -91 1162 1166 18
4 9,0 0,0 -588 851 -656 20 7 21 -87 1378 1380 21
5 10,0 0,0 -588 971 -655 20 7 21 -85 1521 1523 23
6 11,5 0,0 -588 1152 -654 20 7 21 -82 1736 1738 26
7 13,0 0,0 -588 1334 -653 20 7 21 -79 1952 1953 30
8 14,5 0,0 -588 1516 -653 20 6 21 -76 2167 2168 33
9 16,0 0,0 -588 1699 -652 20 6 21 -73 2383 2384 36
10 17,5 0,0 -588 1882 -652 20 6 21 -69 2599 2600 40
11 19,0 0,0 -588 2067 -652 20 6 21 -65 2815 2816 43
12 21,0 0,0 -588 2316 -651 20 6 21 -57 3105 3105 48
13 22,8 0,0 -588 2546 -651 20 6 21 -48 3367 3367 52
14 24,0 0,0 -588 2714 -652 20 6 21 -32 3542 3542 55
15 24,0 0,0 -588 2714 -652 20 6 21 -32 3542 3542 55
16 24,0 0,0 -588 2714 -652 20 6 21 -32 3542 3542 55
17 24,0 0,0 -588 2714 -652 20 6 21 -32 3542 3542 55
18 24,0 0,0 -588 2714 -652 20 6 21 -32 3542 3542 55
19 24,0 0,0 -588 2714 -652 20 6 21 -32 3542 3542 55
LOAD CASE E "On board " wave height Hsig5 [m] 0 [ft] 0,000
radius Capacity Static eq. D + Cvc*L Dynamic with or without wind depending on Cv
L P Fz My Fz Fx Fy FCOMB Mx My MCOMB Mz
Prog. [m] [tons] [kN] [kNm] [kN] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kNm]
1 4,0 20,0 -784 1036 -1029 76 9 77 -149 2983 2987 16
2 6,0 20,0 -784 1667 -1029 76 9 76 -147 4020 4023 25
3 7,5 20,0 -784 2142 -1029 75 9 76 -146 4793 4795 32
4 9,0 20,0 -784 2616 -1029 75 9 75 -143 5561 5563 39
5 10,0 15,5 -740 2491 -941 71 8 72 -120 5110 5111 36
6 11,5 13,7 -722 2697 -906 69 8 70 -109 5303 5304 38
7 13,0 10,0 -686 2609 -834 66 7 66 -90 4872 4873 35
8 14,5 8,0 -666 2653 -795 64 7 64 -78 4733 4734 34
9 16,0 7,0 -656 2797 -775 62 6 62 -71 4803 4804 35
10 17,5 7,0 -656 3084 -775 60 6 60 -68 5168 5168 39
11 19,0 7,0 -656 3372 -775 58 6 59 -64 5525 5526 42
12 21,0 7,0 -656 3758 -775 55 6 55 -57 5990 5990 47
13 22,8 7,0 -656 4111 -775 50 6 51 -47 6386 6386 51
14 24,0 7,0 -656 4361 -775 43 6 43 -32 6600 6600 54
15 24,0 7,0 -656 4361 -775 43 6 43 -32 6600 6600 54
16 24,0 7,0 -656 4361 -775 43 6 43 -32 6600 6600 54
17 24,0 7,0 -656 4361 -775 43 6 43 -32 6600 6600 54
18 24,0 7,0 -656 4361 -775 43 6 43 -32 6600 6600 54
19 24,0 7,0 -656 4361 -775 43 6 43 -32 6600 6600 54
LOAD CASE F "On board " wave height Hsig6 [m] 0 [ft] 0,000
radius Capacity Static eq. D + Cvc*L Dynamic with or without wind depending on Cv
L P Fz My Fz Fx Fy FCOMB Mx My MCOMB Mz
Prog. [m] [tons] [kN] [kNm] [kN] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kNm]
1 4,0 0,0 -588 251 -638 63 5 63 -49 1032 1033 3
2 6,0 0,0 -588 491 -638 62 5 63 -49 1292 1293 5
3 7,5 0,0 -588 670 -638 62 5 62 -48 1484 1485 6
4 9,0 0,0 -588 851 -638 61 5 62 -48 1672 1672 8
5 10,0 0,0 -588 971 -638 61 5 61 -47 1795 1796 9
6 11,5 0,0 -588 1152 -638 60 5 60 -46 1977 1978 11
7 13,0 0,0 -588 1334 -638 59 5 60 -46 2155 2156 13
8 14,5 0,0 -588 1516 -638 58 5 58 -44 2330 2330 14
9 16,0 0,0 -588 1699 -638 57 5 57 -43 2500 2500 16
10 17,5 0,0 -588 1882 -638 55 5 56 -41 2666 2666 18
11 19,0 0,0 -588 2067 -638 53 5 54 -40 2827 2827 20
12 21,0 0,0 -588 2316 -638 50 5 50 -36 3031 3032 22
13 22,8 0,0 -588 2546 -638 46 5 46 -32 3201 3201 24
14 24,0 0,0 -588 2714 -638 38 5 39 -24 3282 3282 26
15 24,0 0,0 -588 2714 -638 38 5 39 -24 3282 3282 26
16 24,0 0,0 -588 2714 -638 38 5 39 -24 3282 3282 26
17 24,0 0,0 -588 2714 -638 38 5 39 -24 3282 3282 26
18 24,0 0,0 -588 2714 -638 38 5 39 -24 3282 3282 26
19 24,0 0,0 -588 2714 -638 38 5 39 -24 3282 3282 26
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 86/158
LOAD CASE G - Aux "Off board Lifts" wave height Hsig7 [m] 1 [ft] 3,281
radius Capacity Static eq. D + Cvc*L Dynamic with or without wind depending on Cv
La P Fz My Fz Fx Fy FCOMB Mx My MCOMB Mz
Prog. [m] [tons] [kN] [kNm] [kN] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kNm]
1 5,5 5,0 -637 533 -783 34 14 37 -344 1815 1848 51
2 7,7 5,0 -637 883 -780 34 14 37 -337 2371 2395 73
3 9,3 5,0 -637 1146 -778 34 14 37 -328 2783 2802 89
4 11,0 5,0 -637 1409 -777 33 14 36 -319 3192 3208 105
5 12,1 5,0 -637 1584 -776 33 14 36 -313 3464 3478 115
6 13,7 5,0 -637 1848 -775 33 14 36 -303 3871 3883 131
7 15,4 5,0 -637 2112 -775 33 14 36 -291 4278 4288 147
8 17,0 5,0 -637 2376 -774 33 14 36 -279 4684 4693 163
9 18,7 5,0 -637 2640 -774 33 14 36 -265 5091 5098 179
10 20,3 5,0 -637 2905 -774 33 14 36 -249 5499 5504 195
11 21,9 5,0 -637 3170 -775 33 14 36 -230 5907 5912 212
12 24,0 5,0 -637 3525 -776 33 14 36 -197 6452 6455 235
13 25,9 5,0 -637 3848 -778 34 14 36 -152 6939 6941 257
14 27,1 5,0 -637 4070 -781 34 14 37 -78 7229 7229 273
15 27,1 5,0 -637 4070 -781 34 14 37 -78 7229 7229 273
16 27,1 5,0 -637 4070 -781 34 14 37 -78 7229 7229 273
17 27,1 5,0 -637 4070 -781 34 14 37 -78 7229 7229 273
18 27,1 5,0 -637 4070 -781 34 14 37 -78 7229 7229 273
19 27,1 5,0 -637 4070 -781 34 14 37 -78 7229 7229 273
LOAD CASE H - Aux "Off board Lifts" wave height Hsig8 [m] 2,5 [ft] 8,202
radius Capacity Static eq. D + Cvc*L Dynamic with or without wind depending on Cv
La P Fz My Fz Fx Fy FCOMB Mx My MCOMB Mz
Prog. [m] [tons] [kN] [kNm] [kN] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kNm]
1 5,5 5,0 -637 533 -783 43 19 47 -487 2100 2156 74
2 7,7 5,0 -637 883 -780 43 19 46 -471 2645 2687 105
3 9,3 5,0 -637 1146 -778 42 18 46 -458 3049 3083 127
4 11,0 5,0 -637 1409 -777 42 18 46 -445 3451 3479 150
5 12,1 5,0 -637 1584 -776 42 18 46 -436 3717 3742 165
6 13,7 5,0 -637 1848 -775 42 18 46 -422 4115 4137 187
7 15,4 5,0 -637 2112 -775 42 18 45 -406 4512 4530 209
8 17,0 5,0 -637 2376 -774 42 18 45 -388 4908 4923 232
9 18,7 5,0 -637 2640 -774 42 18 45 -368 5303 5315 255
10 20,3 5,0 -637 2905 -774 42 18 45 -345 5696 5707 278
11 21,9 5,0 -637 3170 -775 42 18 45 -318 6088 6096 301
12 24,0 5,0 -637 3525 -776 42 18 46 -272 6605 6611 334
13 25,9 5,0 -637 3848 -778 42 18 46 -208 7054 7057 364
14 27,1 5,0 -637 4070 -781 43 19 47 -103 7280 7281 388
15 27,1 5,0 -637 4070 -781 43 19 47 -103 7280 7281 388
16 27,1 5,0 -637 4070 -781 43 19 47 -103 7280 7281 388
17 27,1 5,0 -637 4070 -781 43 19 47 -103 7280 7281 388
18 27,1 5,0 -637 4070 -781 43 19 47 -103 7280 7281 388
19 27,1 5,0 -637 4070 -781 43 19 47 -103 7280 7281 388
LOAD CASE I - Aux "On board " wave height Hsig9 [m] 0 [ft] 0,000
radius Capacity Static eq. D + Cvc*L Dynamic with or without wind depending on Cv
La P Fz My Fz Fx Fy FCOMB Mx My MCOMB Mz
Prog. [m] [tons] [kN] [kNm] [kN] [kN] [kN] [kN] [kNm] [kNm] [kNm] [kNm]
1 5,5 5,0 -637 533 -736 66 6 66 -74 1694 1695 7
2 7,7 5,0 -637 883 -736 66 6 66 -73 2174 2175 11
3 9,3 5,0 -637 1146 -736 65 6 65 -72 2529 2530 14
4 11,0 5,0 -637 1409 -736 65 6 65 -71 2880 2881 17
5 12,1 5,0 -637 1584 -736 64 6 64 -70 3112 3113 19
6 13,7 5,0 -637 1848 -736 63 6 64 -68 3455 3456 22
7 15,4 5,0 -637 2112 -736 62 6 63 -67 3794 3795 24
8 17,0 5,0 -637 2376 -736 61 6 62 -65 4128 4129 27
9 18,7 5,0 -637 2640 -736 60 6 60 -62 4456 4457 30
10 20,3 5,0 -637 2905 -736 58 6 59 -59 4779 4779 33
11 21,9 5,0 -637 3170 -736 57 6 57 -56 5094 5094 36
12 24,0 5,0 -637 3525 -736 53 6 54 -50 5499 5499 40
13 25,9 5,0 -637 3848 -736 49 6 49 -42 5839 5840 44
14 27,1 5,0 -637 4070 -736 41 6 42 -28 6006 6006 46
15 27,1 5,0 -637 4070 -736 41 6 42 -28 6006 6006 46
16 27,1 5,0 -637 4070 -736 41 6 42 -28 6006 6006 46
17 27,1 5,0 -637 4070 -736 41 6 42 -28 6006 6006 46
18 27,1 5,0 -637 4070 -736 41 6 42 -28 6006 6006 46
19 27,1 5,0 -637 4070 -736 41 6 42 -28 6006 6006 46
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 87/158
Interface plane : combined bending moments Mc - Load condition : D + 1.5*Cv*L + 1.5*I + (W) (load comb. ref. par. 5.2 API rule)
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 88/158
INTERFACE WITH SUPPORT' STRUCTURE - Test Load Conditions (the same of slewing bearing)
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 89/158
TEST LOAD CONDITIONS WITHOUT WIND
LOAD CASE D 1) Static 2) Dynamic 100% 3) Dynamic 110% 4) Test Static 133%
Nominal capacities Nom. capacity amplif. Nom. capacity amplif. Nominal capacities
radius Capacity amplif by hoist coeff. by hoist coeff. by hoist and dyntc amplif by statc
L P Fz My Fz My Fz My Fz My
Prog. [m] [tons] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm]
1 4,0 0,0 -588 251 -589 264 -590 269 -591 264
2 6,0 0,0 -588 491 -589 511 -590 517 -591 510
3 7,5 0,0 -588 670 -589 696 -590 704 -591 695
4 9,0 0,0 -588 851 -589 881 -590 892 -591 880
5 10,0 0,0 -588 971 -589 1005 -590 1017 -591 1004
6 11,5 0,0 -588 1152 -589 1191 -590 1204 -591 1189
7 13,0 0,0 -588 1334 -589 1378 -590 1392 -591 1376
8 14,5 0,0 -588 1516 -589 1564 -590 1581 -591 1563
9 16,0 0,0 -588 1699 -589 1751 -590 1769 -591 1750
10 17,5 0,0 -588 1882 -589 1939 -590 1958 -591 1939
11 19,0 0,0 -588 2067 -589 2127 -590 2148 -591 2129
12 21,0 0,0 -588 2316 -589 2378 -590 2402 -591 2384
13 22,8 0,0 -588 2546 -589 2608 -590 2633 -591 2620
14 24,0 0,0 -588 2714 -589 2769 -590 2796 -591 2791
15 24,0 0,0 -588 2714 -589 2769 -590 2796 -591 2791
16 24,0 0,0 -588 2714 -589 2769 -590 2796 -591 2791
17 24,0 0,0 -588 2714 -589 2769 -590 2796 -591 2791
18 24,0 0,0 -588 2714 -589 2769 -590 2796 -591 2791
19 24,0 0,0 -588 2714 -589 2769 -590 2796 -591 2791
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 90/158
TEST LOAD CONDITIONS WITHOUT WIND
LOAD CASE G - Aux 1) Static 2) Dynamic 100% 3) Dynamic 110% 4) Test Static 133%
Nominal capacities Nom. capacity amplif. Nom. capacity amplif. Nominal capacities
radius Capacity amplif by hoist coeff. by hoist coeff. by hoist and dyntc amplif by statc
L P Fz My Fz My Fz My Fz My
Prog. [m] [tons] [kN] [kNm] [kN] [kNm] [kN] [kNm] [kN] [kNm]
1 5,5 5,0 -637 533 -646 598 -652 635 -656 639
2 7,7 5,0 -637 883 -646 976 -652 1028 -656 1032
3 9,3 5,0 -637 1146 -646 1259 -652 1322 -656 1327
4 11,0 5,0 -637 1409 -646 1543 -652 1617 -656 1622
5 12,1 5,0 -637 1584 -646 1731 -652 1813 -656 1819
6 13,7 5,0 -637 1848 -646 2014 -652 2107 -656 2115
7 15,4 5,0 -637 2112 -646 2297 -652 2401 -656 2410
8 17,0 5,0 -637 2376 -646 2579 -652 2694 -656 2706
9 18,7 5,0 -637 2640 -646 2860 -652 2987 -656 3002
10 20,3 5,0 -637 2905 -646 3141 -652 3279 -656 3299
11 21,9 5,0 -637 3170 -646 3422 -652 3570 -656 3596
12 24,0 5,0 -637 3525 -646 3793 -652 3956 -656 3992
13 25,9 5,0 -637 3848 -646 4124 -652 4300 -656 4351
14 27,1 5,0 -637 4070 -646 4338 -652 4521 -656 4596
15 27,1 5,0 -637 4070 -646 4338 -652 4521 -656 4596
16 27,1 5,0 -637 4070 -646 4338 -652 4521 -656 4596
17 27,1 5,0 -637 4070 -646 4338 -652 4521 -656 4596
18 27,1 5,0 -637 4070 -646 4338 -652 4521 -656 4596
19 27,1 5,0 -637 4070 -646 4338 -652 4521 -656 4596
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 91/158
Test condition : Interface plane bending moments My - Dynamic 100 % load condition : D + j L + CN - Load case (2)
CN is for centrifugal corces
radius A B C D E F G - Aux H - Aux I - Aux
Prog. L [m] [kNm] [kNm] [kNm] [kNm] [kNm] [kNm] [kNm] [kNm] [kNm]
1 4,0 1192 1192 264 264 1192 264 598 598 598
2 6,0 1902 1902 511 511 1902 511 976 976 976
3 7,5 2434 2434 696 696 2434 696 1259 1259 1259
4 9,0 2967 2967 881 881 2967 881 1543 1543 1543
5 10,0 3321 3321 1005 1005 2800 1005 1731 1731 1731
6 11,5 3853 3520 1191 1191 3014 1191 2014 2014 2014
7 13,0 4384 3632 1378 1378 2881 1378 2297 2297 2297
8 14,5 4579 3741 1564 1564 2904 1564 2579 2579 2579
9 16,0 4612 3782 1751 1751 3043 1751 2860 2860 2860
10 17,5 4862 3955 1939 1939 3350 1939 3141 3141 3141
11 19,0 5120 3984 2127 2127 3656 2127 3422 3422 3422
12 21,0 4787 4185 2378 2378 4064 2378 3793 3793 3793
13 22,8 4691 4300 2608 2608 4431 2608 4124 4124 4124
14 24,0 4676 4403 2769 2769 4676 2769 4338 4338 4338
15 24,0 4676 4403 2769 2769 4676 2769 4338 4338 4338
16 24,0 4676 4403 2769 2769 4676 2769 4338 4338 4338
17 24,0 4676 4403 2769 2769 4676 2769 4338 4338 4338
18 24,0 4676 4403 2769 2769 4676 2769 4338 4338 4338
19 24,0 4676 4403 2769 2769 4676 2769 4338 4338 4338
Test condition : Interface plane bending moments My - Dynamic 110 % load condition : D + j*1.1* L + CN - Load case (3)
CN is for centrifugal corces
radius A B C D E F G - Aux H - Aux I - Aux
Prog. L [m] [kNm] [kNm] [kNm] [kNm] [kNm] [kNm] [kNm] [kNm] [kNm]
1 4,0 1287 1287 269 269 1287 269 635 635 635
2 6,0 2044 2044 517 517 2044 517 1028 1028 1028
3 7,5 2612 2612 704 704 2612 704 1322 1322 1322
4 9,0 3180 3180 892 892 3180 892 1617 1617 1617
5 10,0 3558 3558 1017 1017 2986 1017 1813 1813 1813
6 11,5 4125 3760 1204 1204 3205 1204 2107 2107 2107
7 13,0 4692 3867 1392 1392 3042 1392 2401 2401 2401
8 14,5 4890 3970 1581 1581 3051 1581 2694 2694 2694
9 16,0 4910 3998 1769 1769 3188 1769 2987 2987 2987
10 17,5 5168 4172 1958 1958 3508 1958 3279 3279 3279
11 19,0 5435 4188 2148 2148 3828 2148 3570 3570 3570
12 21,0 5047 4386 2402 2402 4254 2402 3956 3956 3956
13 22,8 4923 4493 2633 2633 4636 2633 4300 4300 4300
14 24,0 4892 4593 2796 2796 4892 2796 4521 4521 4521
15 24,0 4892 4593 2796 2796 4892 2796 4521 4521 4521
16 24,0 4892 4593 2796 2796 4892 2796 4521 4521 4521
Test condition : Interface plane bending moments My - Static 133 % load condition : D + 1.33*L - Load case (4)
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 92/158
FORCES AND MOMENTS AT THE CRANE INTERFACE
vertical bending
torque
Load condition force moment shear force
N [kN] M [kNm] T [kN] Mt [kNm]
Dyn. w/o wind 810 6224 42 245 page 77/158 LC A L=19 P=13,7
Dyn. w max wind 810 6554 79 245 page 81/158 LC A L=19 P=13,7
According to par. 5.2 API 2c 906 8596 89 359 page 85/158 LC A L=19 P=13,7
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 93/158
RESISTANCE STRESS CHECK and BUCKLING STRESS CHECK
2
Outside diameter De [mm] 1336,0 Mcomb
1
Cross section area A [m2] 1,2309E-01
Moment of inertia I [m4] 2,6257E-02
4 3
Torsional inertia Jp [m ] 5,2513E-02
Section modulus W [m3] 3,9306E-02 2
4
Effective length le [m] 1,635
Slenderness l 3,5
Buckling coefficient w 1,00
Tensile strength R [MPa] 510
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 94/158
C ONICAL SHELL BUC KLING - C1515/16
GEOMETRY
MATERIAL PROPERTIES
ν := 0.3
.............input end.............
N
stress due to axial force σa := = 6.41 MPa
2 π te R e
Mc
stress due to bending moment σb := = 160.94 MPa see DNV reference 5.2.4
2
π te R e
0.36
k b := = 0.346 coefficient see DNV reference 4.3.11
Re
t
1+
300
l 2
e
2
Z := 1 - ν Batdorf parameter see DNV reference 4.1.7
= 109.63
R e t
C b := (
1 + kb Z )2 = 37.92 reduced buckling coefficient see DNV reference 4.3.11
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 95/158
2 2
π E t 3
σE := C b σE = 2.4 10 MPa elastic buckling resistance
( 2 l
12 1 - ν e ) see DNV reference 4.3.4
σk
λ := = 0.376
σE slenderness
σk
σcr := = 341.6 MPa critical buckling
4
1+λ
σx
safety coefficient η := 1.5 unity check uc1 := = 0.735
σcr
Re
nominal knock-down factor ρxR := 0.35 - 0.0002 = 0.345
t
Pr := 0.6
coefficient
σF
critical buckling stress σCxR := σF 1 - Pr 1 - P r
( ) = 328.3 MPa
σExR
adjustament factor
ψ1 := 0.833
(
ψ := if σCxR < 0.55 σk , ψ 1 , ψ 2 ) ψ = 0.98
1 σx
safety coefficient ηη := = 1.667 unity check uc2 := = 0.865
0.6 σCxR ψ
ηη
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 96/158
RESISTANCE STRESS CHECK and BUCKLING STRESS CHECK
2
Outside diameter De [mm] 1336,0 Mcomb
1
Cross section area A [m2] 1,2309E-01
Moment of inertia I [m4] 2,6257E-02
4 3
Torsional inertia Jp [m ] 5,2513E-02
Section modulus W [m3] 3,9306E-02 2
4
Effective length le [m] 1,635
Slenderness l 3,5
Buckling coefficient w 1,00
Tensile strength R [MPa] 510
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 97/158
Fixed boom crane
Job C1515-16
Tensile stress
Max stress -164,90 / 1 s max -164,90
Minimum stress 151,80 / 1 s min 151,80
Ratio of extreme stress values Ks -0,92
Construction case K1 Reference 1,1
Permessible stress in alternating tension/compression s w 173
Permissible tensile stress (formula 2) s c 179,9
Shear stress
Max stress 3,10 / 1 t max 3,10
Minimum stress 3,10 / 1 t min 3,10
Ratio of extreme stress values Kt 1,00
Permessible stress in alternating tension/compression tw 116,5
Permissible shear stress t a 220,8
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 98/158
BOLTS VERIFICATION
M1 := 8596kN
m
number of bolts Nb := 60
2
net area of bolts Ar := 694 mm
-2 4
mom ent of inertia of tensioned bolts Ib := 4.0636410
m
-3 4
mom ent of inertia of compressed ring Ic := 4.4760210
m
-2 4
It := Ib + Ic It = 4.51124 10 m
total m oment of inertia
Di
M1 + dN
max bolt stress σ3 :=
2 c1 σ3 = 381.7 MPa
It
σ3
unity check uc3 := uc3 = 0.794 OK
0.66Ft 0.7
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 99/158
BOLTS VERIFICATION
M1 := 16416kN
m
number of bolts Nb := 60
2
net area of bolts Ar := 694 mm
-2 4
mom ent of inertia of tensioned bolts Ib := 4.0636410
m
-3 4
mom ent of inertia of compressed ring Ic := 4.4760210
m
-2 4
It := Ib + Ic It = 4.51124 10 m
total m oment of inertia
Di
M1 + dN
max bolt stress σ3 :=
2 c1 σ3 = 729 MPa
It
σ3
unity check uc3 := uc3 = 0.701 OK
Ft
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 100/158
CONICAL PEDESTAL ADAPTOR ANALYSIS
PURPOSE
The focus of this analysis is to verify both the strength and the fatigue strength of the conical pedestal
adaptor taking into account the manhole. It was performed a finite element analysis in order to calculate
the stresses diffused and localized.
MODEL
The model of the conical pedestal adaptor is constituted by:
• Conical adaptor: th = 30 mm, material S355J2
• Stiffener: th = 20 mm, material S355J2
The load condition considered is “Dynamic without wind”:
• M = 6224 kNm
• N = 810 kNm
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 101/158
STRESS VERIFICATION
Diffused stress
σdiff = 164 MPa < 240 MPa
Localized stress
σloc = 327 MPa < 355 MPa
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 102/158
FATIGUE STRESS VERIFICATION
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 103/158
Offshore crane
Job C1515-16
FATIGUE CALCULATION
Ref. API2C par. 5.4
equivalent design by using FEM Sect.I° rules
Units: Newton, millimiter
Tensile stress
Max stress 124,00 / 1 s max 124,00
Minimum stress -120,00 / 1 s min -120,00
Ratio of extreme stress values Ks -0,97
Construction case K2 Reference 2,5
Permessible stress in alternating tension/compression s w 118
Permissible tensile stress (formula 1) s a 119,3
Shear stress
Max stress 0,00 / 1 t max 0,00
Minimum stress 0,00 / 1 t min 0,00
Ratio of extreme stress values Kt 1
Permessible stress in alternating tension/compression tw 102,3
Permissible shear stress t a 220,8
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 104/158
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 105/158
Parametri
RESISTANCE STRESS CHECK
SEC A
Length Bs Bs [mm] 20
Length Bd Bd [mm] 20
Webs spacing Ba [mm] 1724
H Ha 16 G 14
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 106/158
Parametri
RESISTANCE STRESS CHECK
SEC B1
Length Bs Bs [mm] 20
Length Bd Bd [mm] 20
Webs spacing Ba [mm] 1724
H Ha 16 G 14
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 107/158
Parametri
RESISTANCE STRESS CHECK
SEC B2
el.
Length Bs Bs [mm] 20
Length Bd Bd [mm] 20
Webs spacing Ba [mm] 1724
H Ha 16 G 14
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 108/158
Parametri
RESISTANCE STRESS CHECK
SEC C
el.
Length Bs Bs [mm] 20
Length Bd Bd [mm] 20
Webs spacing Ba [mm] 1648
H Ha 16 G 14
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 109/158
Parametri
RESISTANCE STRESS CHECK
SEC D
el.
Length Bs Bs [mm] 20
Length Bd Bd [mm] 20
Webs spacing Ba [mm] 1567
H Ha 16 G 14
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 110/158
Parametri
RESISTANCE STRESS CHECK
SEC E
el.
Length Bs Bs [mm] 20
Length Bd Bd [mm] 20
Webs spacing Ba [mm] 1486
H Ha 16 G 14
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 111/158
Parametri
RESISTANCE STRESS CHECK
SEC F
el.
Length Bs Bs [mm] 20
Length Bd Bd [mm] 20
Webs spacing Ba [mm] 1405
H Ha 16 G 14
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 112/158
Parametri
RESISTANCE STRESS CHECK
SEC G
el.
Length Bs Bs [mm] 20
Length Bd Bd [mm] 20
Webs spacing Ba [mm] 1325
H Ha 16 G 14
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 113/158
Parametri
RESISTANCE STRESS CHECK
SEC H
el.
Length Bs Bs [mm] 20
Length Bd Bd [mm] 20
Webs spacing Ba [mm] 1244
H Ha 16 G 14
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 114/158
Parametri
RESISTANCE STRESS CHECK
SEC I
el.
Length Bs Bs [mm] 20
Length Bd Bd [mm] 20
Webs spacing Ba [mm] 1108
H Ha 16 G 14
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 115/158
Parametri
RESISTANCE STRESS CHECK
SEC L
el.
Length Bs Bs [mm] 20
Length Bd Bd [mm] 20
Webs spacing Ba [mm] 1724
H Ha 16 G 14
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 116/158
Parametri
RESISTANCE STRESS CHECK
SEC M
el.
Length Bs Bs [mm] 20
Length Bd Bd [mm] 20
Webs spacing Ba [mm] 1724
H Ha 16 G 14
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 117/158
Parametri
RESISTANCE STRESS CHECK
SEC N
el.
Length Bs Bs [mm] 20
Length Bd Bd [mm] 20
Webs spacing Ba [mm] 1724
H Ha 16 G 14
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 118/158
Parametri
RESISTANCE STRESS CHECK
SEC O
el.
Length Bs Bs [mm] 20
Length Bd Bd [mm] 20
Webs spacing Ba [mm] 1724
H Ha 16 G 14
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 119/158
Parametri
RESISTANCE STRESS CHECK
Length Bs Bs [mm] 20
Length Bd Bd [mm] 20
Webs spacing Ba [mm] 1724
H Ha 16 G 14
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 120/158
BUCKLING VERIFICATION ACCORDING TO ABS GUIDE FOR BUCKLING AND
UTLIMATE STRENGTH ASSESSMENT FOR OFFSHORE STRUCTURE
MEMBER SUBJECTED TO COMBINED LOADS:AXIAL COMPRESSION AND
BENDING MOMENT
SECTION
Web depth d := 847mm
Outstand b2 := 20mm
Lengths Ly := 18.39m
Lz := 24m
MATERIAL PROPERTIES
COEFFICIENTS
8.4
k sf := k sf = 7.636
kf 1.1
Web
2
k sw := 7.6 - 6.4 k w + 10 k w k sw = 24
C mz := 0.85
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 121/158
INTERNAL FORC ES
N := -587.5kN
Axial force
.....INPUT END....
PROPERTIES
2
Cross sectional area (
A := 2 b tf + d t w ) A = 0.045 m
2
2 d 4
St. Venant torsion constant K := 2 a K = 0.012 m
a d
t + t
f w
4
Polar mom ent of inertia I0 := Iy + Iz I0 = 0.019 m
2
b3 d2 t - a2 d3 t
f w -4 6
Warping constant Γ := Γ = 2.631 10 m
3 2 2 3
24 b d t f + a d tw
Iy
Radius of gyration ry := ry = 0.379 m
A
Iz
rz := rz = 0.528 m
A
k z := 2
d
ξ cz := ξ cz = 0.423 m
2
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 122/158
Section Modulus of Iy
com pressive flange SMy := 3
ξ cz SMy = 0.015 m
Iz
3
SMz := SMz = 0.017 m
ξcy
2
C y :=
Γ
+ K
( k y Ly)
C y = 96.661 m
2
Iy 2
Iy 2.6 π
2
C z :=
Γ
+ K
( k z Lz )
C z = 84.845 m
2
Iz 2
Iz 2.6 π
COMPACT LIMITS
a E
cl1 := 1.5 cl1 = 0 0 = false 1 = true
tf σ0
d E
cl2 := 1.5 cl2 = 0
tw σ0
b2 E
cl3 := 0.4 cl3 = 1
tf σ0
STRESSES
2 E
Euler buckling y-dir σEy := π σEy = 215.898 MPa
2
L
k y
y ry
2 E
Euler buckling y-dir σEz := π σEz = 245.921 MPa
2
Lz
k
z rz
2
π E Iy
3
Elastic-torsional bending σELTy := C y σELTy = 6.258 10 MPa
2
stress (
SMy ky Ly )
2
π E Iz
3
σELTz := Cz σELTz = 5.881 10 MPa
2
(
SMz k z Lz )
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 123/158
Critical latera-torsion buckling
stress
σ0
σCLTy := if σELTy Pr σ0 , σELTy , σ0 1 - Pr 1 - Pr
( ) σCLTy = 350.167 MPa
σELTy
σ0
σCLTz := if σELTz P r σ0 , σELTz , σ0 1 - P r 1 - Pr
( ) σ = 349.857 MPa
σELTz CLTz
2
Ideal elastic torsional E K π2 E Γ 4
σET := + σET = 4.96 10 MPa
buckling stress 2.6 I0 k y Ly
I0
2
I0 σEη I0 σET I0 σEη I0 σET I0 I0 σEη σET
+ + + - 4
A A A A A A
σEA1 :=
I0
2
A
4
σEA1 = 4.96 10 MPa
2
I0 σEη I0 σET I0 σEη I0 σET I0 I0 σEη σET
+ - + - 4
A A A A A A
σEA2 :=
I0
2
A
σEA2 = 215.898 MPa
(
σEA := min σEA1 , σEA2 ) σEA = 215.898 MPa
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 124/158
Local buckling stress
Flange
2 2
π E tf
σExf := k sf σExf = 88.912 MPa
( 2
12 1 - ν )
a
σ0
σCxf := if σExf Pr σ0 , σExf , σ0 1 - Pr 1 - Pr
(
) σCxf = 88.912 MPa
σExf
Web
2 2
π E t w
σExw := k sw σExw = 420.173 MPa
12 1 - ν (
2 d - 2 t )
( ) f
σ0
σCxw := if σExw Pr σ0 , σExw , σ0 1 - Pr 1 - Pr σ
( )
= 283.015 MPa
σExw Cxw
(
σCx := min σCxf , σCxw ) σCx = 88.912 MPa
(
σF := if cl1 = 1 cl2 = 1 cl3 = 1 , σ0 , σCx ) σF = 88.912 MPa
σF
σCA := if σEA Pr σF , σEA , σF 1 - P r 1 - Pr
(
) σCA = 80.124 MPa
σEA
ψ11 := 0.87
σ0
ψ12 := 1 - 0.13 Pr
σEA
(
ψ1 := if σEA Pr σ0 , ψ11 , ψ12 ) ψ1 = 0.871
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 125/158
For bending
ψ2 := 1
For bending
η2 := 0.6 ψ2
η2 = 0.6
N
Axial com pressive stress σa := σa = 12.945 MPa
A
My
Bending stress about y axis σby := σby = 60.41 MPa
SMy
Mz
Bending stress about z axis σbz := σbz = 11.52 MPa
SMz
BUCKLING VERIFICATION
Unity check
σa 1 C my σby 1 C mz σbz
uc1 := + + uc1 = 0.637
η1 σCA η2 σCBy σa η2 σCBz σa
1- 1-
η1 σEy η1 σEz
σa σby σbz
uc2 := + +
η1 σCA η2 σCBy η2 σCBz uc2 = 0.652
σa
uc := if > 0.15 , uc1 , uc2 uc = 0.637
σCA
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 126/158
Parametri
RESISTANCE STRESS CHECK
Length Bs Bs [mm] 20
Length Bd Bd [mm] 20
Webs spacing Ba [mm] 1724
H Ha 16 G 14
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 127/158
Fixed boom crane
Job C1515-16
Welding verification
Admissible tensile stress s a 240
Admissible shear stress t a 170
Tensile stress
Max stress 179,00 / 1 s max 179,00
Minimum stress 92,80 / 1 s min 92,80
Ratio of extreme stress values Ks 0,52
Construction case K3 Reference 3,2
Permessible stress in alternating tension/compression s w 84
Permissible tensile stress (formula 3) s a 208,9
Shear stress
Max stress -11,90 / 1 t max -11,90
Minimum stress -5,80 / 1 t min -5,80
Ratio of extreme stress values Kt 0,49
Permessible stress in alternating tension/compression tw 111,1
Permissible shear stress t a 267,8
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 128/158
BOOM HINGES ASSESSMENT
MAIN HINGE
BOOM CONFIGURATION:
θ =67.421°; L = 10 m ; P = 20 t
θ := 67.421°
FORCES
Fx := 518kN
Fy := 14kN
Fz := 1332kN
3
R := Fz sin( θ) + Fx cos( θ) = 1.429 10 kN
GEOMETRY
b 1 := 165mm
b 2 := 165mm
t1 := 165mm
MATERIAL
R
( d2 - d1 ) 2
th2 = 5.8 103 mm2 ≥ = 2.977 10 mm
3 2
t1 th1 +
2 σadm
BEARING STRESS
R
2 σrif
σrif :=
σrif = 119.1MPa
uc := uc = 0.367
(
th1 + th2 d1 ) 1.35 σadm
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 129/158
PIVOT Ø150 SUPER DUPLEX A 240
σadmp := 366MPa
σe := 144.1MPa
σe
uc := uc = 0.394
σadmp
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 130/158
CYLINDER HINGES ASSESSMEN T
LUFFING CYLINDER
BOOM CONFIGURATION:
θ = 59.254° L= 13m ; P = 20 t P := 1303.2kN
GEOMETRY
b 1 := 90mm
b 2 := 177mm
MATERIAL
BEARING STRESS
P
2 σrif
σrif :=
σrif = 116.357 MPa uc := uc = 0.359
( )
th1 + 2 th2 d1 1.35 σadm
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 131/158
PIVOT Ø140 39 NiCrMo3
σadmp := 360MPa
σe := 244.2MPa
σe
uc := uc = 0.678
σadmp
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 132/158
MAIN PULLEY
a := 105mm
b := 135mm
T := 137.0kN
σadm := 360MPa
d := 110mm
c := 2 a + b c = 345 mm
V A := T V A = 137 kN
V B:= V A V B = 137 kN
(a + b )
HA := T HA = 95.304kN
c
a
HB := T HB = 41.696kN
c
SEC. C
2 2
Tcomb := HA + V A Tcomb = 166.889kN
My := V A a My = 14.385kN
m
Mz := HA a Mz = 10.007kN
m
2 2
Mcomb := My + Mz Mcomb = 17.523kN
m
τ := 4 Tcomb τ = 23.415MPa
3 d
2
π
4
M comb
σ := σ = 134.103 MPa
3
d
π
32
2 2
σeq := σ + 3 τ σeq = 140.101 MPa
σeq
uc := uc = 0.389
σadm
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 133/158
SPHERICAL PLAIN BEARINGS _1515
LUFFING CYLINDER
DYNAMIC Cl := 3000kN
DYNAMIC kl := 300MPa
VERIFICATION
LUFFING CYLINDER
Pl
SPECIFIC BEARING LOAD: p l := kl = 92.68 MPa
Cl
Δθ 1
ANGULAR VELOCITY: ω := = 0.0215
Tl s
SLIDING VELOCITY: (
vl := 8.73 10
-3 )dnl Δθ 180 = 1.743 10- 3 m
Tl 3.14 s
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 134/158
EXPONENT FOR THE SPECIFIC BEARING LOAD: nl := 1.2
p hl := 92.68
vhl := 0.001743
OPERATING HOURS:
Kpl
Ghl := b 1 b 2 b 4 = 44038 ore di vita
nl
p hl vhl
CYCLES:
t := 3600s
Ghl t
cl := = 3446488 oltre 1.5 milioni di cicli
Tl
Cl
safety factor rispetto carico m ax sf := = 2.302
P2
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 135/158
LUFFING CYLINDER - Job.1515-16
Cylinder characteristics
Cylinder => outer diam eter: dec := 295 mm inner diameter: dic := 240 mm
π
dec - dic
2 2 2
Cylinder area: Ac := Ac = 0.023 m
4
π -4 4
dec - dic
4 4
Cylinder inertia: Ic := Ic = 2.089 10 m
64
Rod => outer diam eter: des := 200.0 mm inner diameter: dis := 150 mm
π
des - dis
2 2 2
Rod section: As := As = 0.014 m
4
π -5 4
des - dis
4 4
Rod inertia: Is := Is = 5.369 10 m
64
des + dis dec + dic
Mean diam eters: dms := dms = 175 mm dmc := dmc = 267.5 mm
2 2
des - dis dec - dic
thicknesses: ss := ss = 25 mm sc := s.c = 27.5 mm
2 2
Ratios:
2
dms des
=7 < 10 about => large thickness pipe theory is applied X s := d
ss X s = 1.778
is
dmc 2
= 9.73 < 10 about => large thickness pipe theory is applied dec
sc X c := X c = 1.511
dic
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 136/158
5 N
Young's modulus: E := 2.06 10
2
mm
N
Steel: Fe 510 => σamm1 := 240
Acceptable stress dyn. case: 2
mm
Yielding stress Fy := 355 MPa
l c1 := 7.922 m
Corresponding length of the cylinder + rod out:
Chamber cylinder length: l 11 := 4.690 m
l 11
2
l x - x2
Cylinder A1 :=
c1 dx A1 = 3.329 10 mm
9
Ic
0
c1l
2
l x - x2
Rod B1 :=
c1 dx B1 = 6.418 10 mm
9
Is
l
11
3
E lc1
Carico critico: Pcr1 := Pcr1 = 3502 kN
3 (A1 + B1)
Pcr1
Stability verification : ν1 := ν1 = 3.08 >2.0 OK
N 5c
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 137/158
l 11
2
l x - x2
Cylinder A1 :=
c1 dx A1 = 3.329 10 mm
9
Ic
0
l
c1
2
lc1 x - x2
Rod B1 :=
dx B1 = 6.418 10 mm
9
Is
l
11
3
E lc1
Carico critico: Pcr1 := Pcr1 = 3502 kN
3 (A1 + B1)
Pcr1
Stability verification : ν1 := ν1 = 2.54 >1.5 OK
N 4c
>2.0
----------------------------------------------------------------
N min p lav1
Max working pressure: p lav1 := = 304 bar
π 2 g
dic
4
N min
σaci := N
Axial stress: π σaci = -59.6
dec - dic
2 2
2
4 mm
2 2 2 N
σeqci := σtci + σrci + σaci - σtci σrci - σrci σaci - σtci σaci σeqci = 196
2
mm
σeqci
= 0.818 <1 OK
Shall be: 1) σamm1
σtci - σaci
2) = 0.872 <1 OK
σamm1
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 138/158
CYLINDER - external surface
dic dec
Defined: ac := ac = 120 mm b c := b c = 147.5 mm
2 2
2
2 ac N
Tangential stress: σtce := p lav1 σtce = 119.2
2 2 2
b c - ac mm
N
Radial stress: σrce := 0
2
mm
N
Axial stress: σace := σaci σace = -59.6
2
mm
2 2 2 N
σeqce := σtce + σrce + σace - σtce σrce - σtce σace - σrce σace σeqce = 158
2
mm
σeqce
Shall be: 1) = 0.657 <1 OK
σamm1
σtce - σace
2) = 0.745 <1 OK
σamm1
___________________________________________________________________________________________
plav1 N
Tangential stress: σtsi := ( 1 + X s) σtsi = 108.7
Xs - 1 2
mm
N min N
Axial stress: σasi := σasi = -100.2
π 2
des - dis
2 2
mm
4
1 - Xs N
Radial stress: σrsi := p lav1 σrsi = -30.4
Xs - 1 2
mm
2 2 2 N
σeqsi := σtsi + σrsi + σasi - σtsi σrsi - σasi σrsi - σtsi σasi σeqsi = 184
2
mm
σtsi - σasi
2) = 0.87 <1 OK
σamm1
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 139/158
ROD - external surface
dis des
Defined: as := as = 75 mm b s := b s = 100 mm
2 2
2
2 as N
Tangential stress: σtse := p lav1 σtse = 78.3
2 2 2
bs - as mm
N
Axial stress: σase := σasi σase = -100.2
2
mm
N
Radial stress: σrse := 0
2
mm
2 2 2 N
σeqse := σtse + σrse + σase - σtse σrse - σtse σase - σrse σase σeqse = 155
2
mm
σeqse
Shall be: 1) = 0.646 <1 OK
σamm1
σtse - σase
= 0.744 <1 OK
2) σamm1
---------------------------------------------------------------
CYLINDER ASSESSMENT IN ACCORDANCE WITH API Par. 8.2. 2.4 static load N 3c = -933.4 kN
N 3c p lav2
p lav2 := = 206 bar
π 2 g
dic
4
CYLINDER
Tangential stress p lav2 N
σtcis := (1 + X c) σtcis = 101.4
internal surface: Xc - 1 2
mm
2
Tangential stress 2 ac N
σtces := p lav2 σtces = 80.8
external surface: 2 2 2
b c - ac mm
Mean tangential stress: σtcs := 0.5 ( σtcis + σtces) σtcs = 91.09 MPa
N 3c N
Axial stress: σacs := σacs = -40.4
π 2
dec - dic
2 2
mm
4
1 - Xc N
Radial stress σrcis := p lav2 σrcis = -20.6
internal surface: Xc - 1 2
mm
N
Radial stress σrces := 0
external surface: 2
mm
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 140/158
Mean radial stress: σrcs := 0.5 ( σrcis + σrces) σrcs = -10.32 MPa
2 2 2 N
σeqcs := σtcs + σrcs + σacs - σtcs σrcs - σrcs σacs - σtcs σacs σeqcs = 119
2
mm
Fy
yielding safety factor sf1 API := sf1 API = 2.975
σeqcs
Ft
ultimate safety factor sf2 API := sf2 API = 4.274
(burst pressure) σeqcs
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 141/158
FORCES AND MOMENTS AT THE SLEW BEARING FOR ALL SIGNIFICATIVE LOAD CASES - 1515 - Ref. Rev2 program
vertical bending
torque
Load condition force moment shear force Configuration
N [kN] M [kNm] T [kN] Mt [kNm]
Dyn. w/o wind 773 6145 41 245 L = 19.0 m ; P = 13.7 tons ; Cv=1.33 ; wh = 1 m ; L.case A
Dyn. w max wind 773 6400 76 245 L = 19.0 m ; P = 13.7 tons ; Cv=1.33 ; wh = 1 m ; L.case A
33% overload condition 735 5524 - - L = 19.0 m ; P = 13.7 tons ; Cv=1..33 ; wh = 1 m ; L.case A
According to par. 9.2.1.4 API 2c 1300 16416 76 245 L = 19.0 m ; P = 13.7 tons ; Cv=1.33 ; wh = 1 m ; L.case A
According to par. 5.2 API 2c 869 8422 88 359 L = 19.0 m ; P = 13.7 tons ; Cv=2 ; wh = 1 m ; L.case A
NOTES:
1) The above load cases are the ones that maximize the bending moment on the slewing bearing (worst condition for the section)
2) The dynamic coefficients, have been carried out considering both lifting and luffing movements at the same time and at the max speed
3) The load case in accordance with API 5.2 paragraph foresees and additional 1.5 factor applied to the lifted load
and to the corrispondent horizontal loads
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 142/158
page 1
TECHNICAL PROPOSAL
Our ref. : 120080 Bearing Code: V92-2187-001-21-32-1990
Customer: ITALGRU Project No. Customer: C1515/16
Application: OFFSHORE CRANE Date/Name: 22/10/2012 D.R.
Ref.: TP-V92-2187-001-120080-STATIC-R02
MATERIAL
Gear Ring 42 CrMo 4 Q+T (LTV) Seal : NBR
Outer Ring(s) 42 CrMo 4 Q+T (LTV) Spacers : Nylon
GEAR
Internal Gear Data Pinion Data
Bearing Gear
Module mm 16
No. of Teeth -109 12
Addendum Modification mm -8 8
Addendum Reduction mm 1.6
Tooth Face Width mm 108 115
Gear Quality DIN 12 10
Heat Treatment quenched a. tempered hardened a. ground
Material 42 CrMo 4 Q+T (LTV) 16 MnCr 5 E
Centre Distance mm 776.00 + - 0,220
If You use different pinion data, please inform us.
FASTENING BOLTS
Bolt DIA min.clamping Preload Tightening
Bolt PCD (mm) No. of bolts M length (mm) (%) factor A
inner 1875 60 33 165 80 1.4
outer 2115 60 33 165 80 1.4
The bolts have to be preloaded to 80% of the yield point by a hydraulical wrench.
The nut height has to be determined with the bolt supplier.
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 143/158
page 2
1 2 3 4 5
Max working loads Test load
Loadcase w/o wind with wind 33% overload
We have provided all rings to be made of material 42 CrMo 4 Q&T(LTV) with one
tensile test and three Impact notch tests for each ring.
The statistical mean value for notch bar impact test results for the before menti-
oned material - with three ISO-V longitudinal samples and at a test temperature of
253K (-20° C ) - in AV = 42 Joule ( specimen location as per UNI EN 183/1/3).
The minimum single value is AV = 27 Joule.
GEAR LOADS
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 144/158
page 1
TECHNICAL PROPOSAL
Our ref. : 120080 Bearing Code: V92-2187-001-21-32-1990
Customer: ITALGRU Project No. Customer: C1515/16
Application: OFFSHORE CRANE Date/Name: 22/10/2012 D.R.
Ref.: TP-V92-2187-001-120080-FATIGUE-R01
MATERIAL
Gear Ring 42 CrMo 4 Q+T (LTV) Seal : NBR
Outer Ring(s) 42 CrMo 4 Q+T (LTV) Sapcers : Nylon
GEAR
Internal Gear Data Pinion Data
Bearing Gear
Module mm 16
No. of Teeth -109 12
Addendum Modification mm -8 8
Addendum Reduction mm 1.6
Tooth Face Width mm 108 115
Gear Quality DIN 12 10
Heat Treatment quenched a. tempered hardened a. ground
Material 42 CrMo 4 Q+T (LTV) 16 MnCr 5 E
Centre Distance mm 776.00 + - 0,220
If You use different pinion data, please inform us.
FASTENING BOLTS
Bolt DIA min.clamping Preload Tightening
Bolt PCD (mm) No. of bolts M length (mm) (%) factor A
inner 1875 60 33 165 80 1.4
outer 2115 60 33 165 80 1.4
The bolts have to be preloaded to 80% of the yield point by a hydraulical wrench.
The nut height has to be determined with the bolt supplier.
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 145/158
page 2
1 2 3 4 5 6
Andata full Andata full Ritorno Andata full Andata full Ritorno
Loadcase static load dynamic load empty static load static load empty
onda 1 onda 1 onda 1 onda 2.5 onda 2.5 onda 2.5
Axial Load kN 749 855 604 724 855 604
Radial Load kN 52 20 70 21
Tilt. Moment kNm 3408 5153 1962 3056 4665 1993
No. of Revolutions rpm 1.2 1.2 1.2 1.2 1.2 1.2
% of time 12 12 26 12 12 26
Our life calculation carried out on the basis of DIN / ISO 281 ( L10 life ) for the load
cases 1/2/3/4/5/6 shows a service bearing life of 278500 revolutions.
We have provided all rings to be made of material 42 CrMo 4 Q&T (LTV) with one tensile test and three Impact
notch tests for each ring. The statistical mean value for notch bar impact test results for the before mentioned
material - with three ISO-V longitudinal samples and at a test temperature of 253K (-20° C ) - in AV = 42 Joule
(specimen location as per UNI EN 183/1/3 ). The minimum single value is AV = 27 Joule.
GEAR LOADS
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 146/158
BOLTS VERIFICATION
M1 := 16416kN
m
number of bolts Nb := 60
2
net area of bolts Ar := 694 mm
M1 H1
Load acting on the most stressed bolt Fb := 4 - Nb Fb = 562 kN
Nb Di
Fb
max stress σb := σb = 809.8MPa
Ar
σb
unity check ucb := ucb = 0.78
Ft
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 147/158
THIS DRAWING MUST BE SENT TO GALPERTI TECH N.12 CAP SCREW M16 N.60 HOLES O36
STAMPED AND SIGNED FOR APPROVAL IN CASE OF ORDER EQUALLY SPACED G2 EQUALLY SPACED
C/W THRUST WASHER G1
OTHERWISE ORDER CANNOT BE PROCESSED G lO1 Y
SCHNORR S-TYPE
O 2187
N.
O 2115 60
x
6°
O 1949 G G2
°
30
x
G1
12
N.6 GREASE HOLES
N.
^ 0.604 Y M10 x 1
EQUALLY SPACED
42
xm 8
G1
6 x45°
°
°
60
60
D
6x
x
.6
N.
N
178 ±0.5
21 °
C
196 ±1
108
D
55
B C
15°
154 ±0.5
Y B
9°
6 x45°
N.6+6 GREASE HOLES S
M10 x 1 A
EQUALLY SPACED
27°
G G2 A G
G2
R
68
1.
6
N.3 LIFTING HOLES G1
46
M16 `35
EQUALLY SPACED
E
18
lO1 Y
6°
0x
M33
.6
O 36 N.3x
N
+0.6 120°
O 35 O 1731.2 0
E
SECT. A - A O 1744 N.3+3 LIFTING HOLES
M24 `45
O 1805 EQUALLY SPACED
O 1875 lO1 Y
G1
O 1944 G N.60 HOLES M33`123
c/w Plastic Plug
c O35 `68
G2 EQUALLY SPACED
lO1 Y
10
M10 x 1
G
10
SECT. B - B 15 SECT. C - C SECT. D - D M24 SECT. E - E G1
O 18
15 G2
45
70 ±1
25 ±1
G G1
131 ±1
Gear data
module mn 16
c/w Plastic Plug
z 109
O 18
number of teeth
G2 pitch diameter d2 1744
tooth profile II DIN 3972
M10 x 1
35
addendum modification
O 18
coefficient x -0.5
45
truncation coefficient k -0.1
15 quality class DIN 3962/3967 12 cd27
M10 x 1
Drawing 1 6
2) Point of minimum eccentricity of the gear ("high point") to be G1 Grease fitting: N.6 M10x1 c/w Plastic Plug V92-2187-001-COMM 1 of 1 2 7
identified with three painted teeth (blue paint). GALPERTI TECH
1 D.R. C.C. Description
34 0 PF A
Date 23/10/12
REVISIONI www.galperti.com 1471kg 5
148/158 10
SLEWING REDUCTION GEAR
INPUT DATA
CLASSIFICATION OF MECHANISM (FEM): M5 (L2‐T5)
MEAN TORQUE: 161 kNm
TORQUE WITH MAX WIND: 371 kNm
MEAN ANGULAR VELOCITY: 1 rpm
MAX ANGULAR VELOCITY: 2 rpm
REDUCTION RATIO: 62.8
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 149/158
Via Togliatti 15 – (41030) Bomporto (Mo) ( Italy ) Tel.: +39 059 81 26 11 Fax: +39 059 81 26 03 E-mail: dinamicoil@dinamicoil.it
Title:
Customer:
Date:12/03/2012
Subject: RE 1523 DBS F504
CLASSE FEM L2-T5-M5 coppia di calcolo :8865*0.63=5585 Nm
Input data
Product Gearbox
Reduction ratio 62,7847
Gearbox lifetime (Standard) h
Equivalent pitting torque 5585 Nm
Equivalent bending torque 5585 Nm
Equivalent bearing torque 5585 Nm
Equivalent output speed 18 rpm
Output cycle
N° Cycle Torque (Nm) Output speed (RPM) Cycle duration (%)
1 ° 5585 18 100
Gearbox configuration
Stage PIT. (h) Sh BEN. (h) Sf Lh10 (h)
RE 1520 (4,09) Unlimited 3 Unlimited 5,7 342713
RE 510 (3,6) Unlimited 3,7 Unlimited 5,5 293524
RE 210 (4,26) Unlimited 4,1 Unlimited 7,7 153029
Output data
Critical stage 3 - RE 210 (4,26) 153029 h
Note:
“All the above calculation are theoretical and computed assuming that all the parameters are correct, i.e.:
• the given duty cycle correspond to the real need of the customer
• correct lubrication proper gear oil (60 cts @ working temperature)
• room temperature 20°C
• on duty oil temperature 60°C
• no shocks or vibrations
• no chemical or physical aggressive environment
• altitude between 0 - 500 mt.
• correct maintenance.
The above figures can not be considered as lifetime guarantee in any case.
Dinamic Oil reserves the right to modify the performances of the gearboxes without previous notice to anybody.”
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 150/158
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 151/158
MAIN WINCH REDUCTION GEAR
INPUT DATA
CLASSIFICATION OF MECHANISM (FEM): M5 (L2‐T5)
REDUCTION GEAR EFFICIENCY: 0.857
PULLEY EFFICIENCY: 0.956
AMPLIFIED TORQUE: 52.558 kNm
ANGULAR VELOCITY: 19.9 rpm
REDUCTION RATIO: 70.4
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 152/158
Via Togliatti 15 – (41030) Bomporto (Mo) ( Italy ) Tel.: +39 059 81 26 11 Fax: +39 059 81 26 03 E-mail: dinamicoil@dinamicoil.it
Title:
Customer:
Date:09/03/2012
Subject: RW 4803 F915
CLASSE FEM L2-T5-M5 COPPIA DI CALCOLO : 52558x0.63 = 33111 Nm
Input data
Product Wheel
Reduction ratio 70,405
Gearbox lifetime (Standard) h
Equivalent pitting torque 33111 Nm
Equivalent bending torque 33111 Nm
Equivalent bearing torque 33111 Nm
Equivalent output speed 20 rpm
Output cycle
N° Cycle Torque (Nm) Output speed (RPM) Cycle duration (%)
1 ° 33111 20 100
Gearbox configuration
Stage PIT. (h) Sh BEN. (h) Sf Lh10 (h)
RE 4800 (3,84) Unlimited 1,6 Unlimited 2,7 30023
RE 1520 (4,09) Unlimited 1,9 Unlimited 3,7 18018
* RE 610 (4,55) Unlimited 2,8 Unlimited 5,1 36903
Output data
Critical stage 2 - RE 1520 (4,09) 18018 h
Note:
“All the above calculation are theoretical and computed assuming that all the parameters are correct, i.e.:
• the given duty cycle correspond to the real need of the customer
• correct lubrication proper gear oil (60 cts @ working temperature)
• room temperature 20°C
• on duty oil temperature 60°C
• no shocks or vibrations
• no chemical or physical aggressive environment
• altitude between 0 - 500 mt.
• correct maintenance.
The above figures can not be considered as lifetime guarantee in any case.
Dinamic Oil reserves the right to modify the performances of the gearboxes without previous notice to anybody.”
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 153/158
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 154/158
AUXILIARY WINCH REDUCTION GEAR
INPUT DATA
CLASSIFICATION OF MECHANISM (FEM): M5 (L2‐T5)
REDUCTION GEAR EFFICIENCY: 0.857
PULLEY EFFICIENCY: 0.97
AMPLIFIED TORQUE: 21.42 kNm
ANGULAR VELOCITY: 45.92 rpm
REDUCTION RATIO: 51.69
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 155/158
Via Togliatti 15 – (41030) Bomporto (Mo) ( Italy ) Tel.: +39 059 81 26 11 Fax: +39 059 81 26 03 E-mail: dinamicoil@dinamicoil.it
Title:
Customer:
Date:12/03/2012
Subject: RW 2003 F908
CLASSE FEM L2-T5-M5 : coppia di calcolo =21420*0.63=13495 Nm
Input data
Product Wheel
Reduction ratio 51,6909
Gearbox lifetime (Standard) h
Equivalent pitting torque 13495 Nm
Equivalent bending torque 13495 Nm
Equivalent bearing torque 13495 Nm
Equivalent output speed 47 rpm
Output cycle
N° Cycle Torque (Nm) Output speed (RPM) Cycle duration (%)
1 ° 13495 47,24 100
Gearbox configuration
Stage PIT. (h) Sh BEN. (h) Sf Lh10 (h)
RE 2000 (3,83) Unlimited 1,7 Unlimited 3,2 17376
RE 510 (3,6) Unlimited 1,4 Unlimited 2,1 4762
RE 240 (3,82) Unlimited 2,3 Unlimited 4,4 6560
Output data
Critical stage 2 - RE 510 (3,6) 4762 h
Note:
“All the above calculation are theoretical and computed assuming that all the parameters are correct, i.e.:
• the given duty cycle correspond to the real need of the customer
• correct lubrication proper gear oil (60 cts @ working temperature)
• room temperature 20°C
• on duty oil temperature 60°C
• no shocks or vibrations
• no chemical or physical aggressive environment
• altitude between 0 - 500 mt.
• correct maintenance.
The above figures can not be considered as lifetime guarantee in any case.
Dinamic Oil reserves the right to modify the performances of the gearboxes without previous notice to anybody.”
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 156/158
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 157/158
C1515-16 - DESIGN FAIL SAFE
1 CYLINDER LUFFING
2 BOOM
3 CONICAL ADAPTOR
4 OPERATOR DEAD
Doc. N. CN-C1515-C1516_Rev.03
Date 23/10/12 158/158