There was a slight decrease in photoconductive output voltage then a rapid
decrease and then a steady decrease as the lamp filament voltage continued to increase. A photoconductive cell is a light sensitive semiconducting device whose electrical conductivity varies with the amount of light falling on it. If voltage is applied across the cell it is found to vary with the light intensity. With no illumination, the conductivity decreases and increases with illumination. In absence of light, the resistance of the photoconductive cell is very high and hence current is measured is also very low. This current is called dark current and resistance corresponding to this is called dark resistance. This reduction in current leads toa voltage drop across the load resistor. THE photoconductive cells are used in various places like: The photoconductive cells are used in light sensitive alarms, fast recording situations, automatic street lights, lightning control, etc. Photoconductive cells can be used for detecting the location of aircraft and ships with help of radiations coming out from the exhaust. They are used to wither switch on or off the transistors in electronic circuits. Photoconductive cells are used at LED current level. CONCLUSION 2 In conclusion, we got to observe the photoelectric cell utilizing photoconductivity so that an increase in illumination causes a decrease in electrical resistance and permits the flow of a greater electrical current. The results were as per anticipated.