Professional Documents
Culture Documents
CODE: 00ZMXRB20/S1E
MODEL MX-RB20
CONTENTS
Parts marked with " " are important for maintaining the safety of the set. Be sure to replace these parts with
specified ones for maintaining the safety and performance of the set.
MX-RB20 SPECIFICATIONS 1 – 1
MX-RB20
[2] Service Manual
EXTERNAL VIEW AND INTERNAL STRUCTURE
1. Sensor
PDPPD1
PDOS
PDPPD2
2. Motor, Solenoid
0$04-
0$0'3
1. Maintenance list
✕: Check (Clean, replace, or adjust according to necessity.) : Clean : Replace : Adjust ✩: Lubricate
MEMO:
Cleaning of the paper feed and paper transport system sensors and detectors
Cleaning of the paper feed and paper transport system sensors and detectors is not always necessary for every maintenance. In the following
case, check and clean.
? A trouble or jam is generated because of the sensors or detectors. (Check the jam history.)
MEMO:
Note for alcohol used for cleaning
Use ethanol alcohol for cleaning.
MX-RB20 MAINTENANCE 3 – 1
2. Each unit disassembly 3. Disassembly and assembly of each
unit
No. Name
1 Paper pass unit
No. Name
1 Inlet port roller (Drive)
2 Inlet port rear roller (Drive)
3 Paper exit front roller (Drive)
4 Paper exit roller (Drive)
MX-RB20 MAINTENANCE 3 – 2
NOTE: If the interface reverse path solenoid is removed, the
adjustment is required at the installation.
Slide the flapper toward the left side with the solenoid plunger
pushed in, until the position in which width becomes maximum.
Install the interface reverse path solenoid.
24 - 26mm
MX-RB20 MAINTENANCE 3 – 3
MX-RB20
[4] OPERATIONAL DESCRIPTIONS Service Manual
PDPTM
PDPPD2
5
PDPGS
1
7
2 PDPPD1
8
PDOS 3
4
1. Block diagram
PDPTM
Control
section
Driver
circuit
PDPGS
PDPPD1
Sensor/Alarm
input circuit
PDPPD2
PBA-CONT-JPT
Finisher
Paper pass
&%%$ -/4/2
&1 & 1 &= + %%3+.6
9 B23 1 5 /<0 B% %
*1 'B2 31 1&
2 3 16( 1 5/< 0B% %
2. Actual wiring diagram
0!0%2 0!33 3%.3/2
3$ 66( 1 3$66(1
*1' *1'
9 B3$ 6 9B3$6
;5 + 3 9+36*$
0!0%2 %.42!.#% 3%.3/2
(1 76( 1 (176(1
*1' *1'
9 B( 1 7 9B(17
; 5 + 3 9+36*$
*1'
)$ 1$/ 0
9 B)$ 1
62/ 6 2/ 62 /
9 9
% % &=+ .% & = + ; 5 +3
'!4% 3/,%./)$
LEAD-FREE SOLDER
The PWB’s of this model employs lead-free solder. The “LF” marks indicated on the PWB’s and the Service Manual mean “Lead-Free” solder.
The alphabet following the LF mark shows the kind of lead-free solder.
Example:
4RADEMARK ACKNOWLEDGEMENTS
v -ICROSOFT¤ 7INDOWS¤ 7INDOWS¤ 7INDOWS¤ -E 7INDOWS .4¤