You are on page 1of 6

QUICK START GUIDE

User's Manual
1. Hold the Green Button to dispense water
2. Put your preferred storage of water in the faucet to fill it up

Operator's Manual
1. Open the Solar Charge Controller's switch to start the device
2. If there is a message that states "Refill Main Tank" refill the external tank
3. If the main tank is low and there is a message that states "Storage Tank Low" Refill the
main tank as to the above level from the floater switch to refill the storage tank, if not refilled
the device will stop dispensing water until the message storage tank low disappeared.
4. If the message is check filters, replace the filters one by one to check what filter is needed
to be replaced. The device will not dispense until the message has disappeared.

USER INTERFACE

Button
Button Faucet 2
Faucet 1
Faucet 1 Faucet 2

Main tank
Storage tank

Reverse Osmosis
Solenoid 1

Solenoid 2
Solenoid 1

Solenoid 2

Solar Charge
Controller
(Switch On/Off)
Pic
Microcontroller

Relay Driver

(Message)

Refill main tank


(Message)

Storage Tank LOW

You might also like