Professional Documents
Culture Documents
© 2012 IVY Biomedical Systems Inc. All Rights Reserved. Part No. 2811-00-20
2718-55-16
User Responsibility
This product will perform in conformity with the description thereof contained in this Operation Manual and
accompanying labels and/or inserts, when assembled, operated, maintained and repaired in accordance with the
instructions provided. This product must be checked periodically. A defective Product should not be used. Parts that
are broken, missing, plainly worn, distorted or contaminated should be replaced immediately. Should such repair or
replacement become necessary, IVY Biomedical Systems, Inc. recommends that a telephone call or written request
for service advice be made to IVY Biomedical Systems, Inc. Service Department. This product or any of its parts
should not be repaired other than in accordance with instructions provided by IVY Biomedical Systems, Inc. trained
personnel. The product must not be altered without the prior written approval of IVY Biomedical Systems, Inc.
Quality Assurance Department. The user of this Product shall have the sole responsibility for any malfunction, which
results from improper use, faulty maintenance, improper repair, damage or alteration by anyone other than IVY
Biomedical Systems, Inc.
CAUTION: US Federal law restricts this device to sale by or on the order of a licensed medical practitioner.
Ivy Biomedical Systems, Inc. has declared that this product conforms with the Eurpean Council Directive 93/42/EEC
Medical Device Directive when its used in accordance with the instructions provided in the Operation and
Maintenace Manual.
SM3000series
19-January-2012
2811-00-20 Rev.05
This page is intentionally left blank.
Declaration of Conformity
Manufacturer: Ivy Biomedical Systems, Inc.
11 Business Park Drive
Branford, CT 06405
We, Ivy Biomedical Systems, Inc., hereby declare that the devices mentioned above
comply with the Swedish National Board of Health and Welfare Regulation and
guidelines on medical devices LVFS 2003:11 (M) 28 October 1994 – transposing
European Medical Devices Directive 93/42/EEC.
Conformity Assessment
Procedure: Annex II
Signature
This page is intentionally left blank.
Table of Contents
Table of Contents
INTRODUCTION ................................................................................................................................................ 1
SAFETY ................................................................................................................................................................ 2
Electrical ................................................................................................................................................................ 2
Explosion ............................................................................................................................................................... 2
Patient Connections .............................................................................................................................................. 3
MRI ........................................................................................................................................................................ 3
Pacemakers............................................................................................................................................................ 3
Electrosurgery Protection .................................................................................................................................... 3
Defibrillation Protection ...................................................................................................................................... 3
EMC ....................................................................................................................................................................... 3
Electromagnetic Compatibility IEC 60601-1-2:2007 ............................................................................... 3
Description of Warning Labels ............................................................................................................................ 8
ACCESSORIES .................................................................................................................................................. 27
ECG ..................................................................................................................................................................... 27
Disposal ................................................................................................................................................................ 27
SPECIFICATIONS ............................................................................................................................................ 28
WARRANTY
All products manufactured by Ivy Biomedical Systems, Inc. under normal use, are warranted to be free from defects
in material and workmanship and to operate within published specifications, for a period of one year from date of
original shipment.
All accessories such as patient cables and lead wires, supplied by Ivy Biomedical Systems, Inc. under normal use,
are warranted to be free from defects in material and workmanship and to operate within published specifications, for
a period of 90 days from date of original shipment.
If an examination by Ivy Biomedical Systems, Inc. discloses such product(s) or component part(s) to have been
defective, then Ivy’s obligation is limited at Ivy’s option, to repair or replacement.
When a product or products need to be returned to the manufacturer for repair or examination, contact customer
service personnel at Ivy Biomedical Systems, to obtain a Return Material Authorization number (RMA #) and the
correct packing instructions:
Customer Service
Telephone: (203) 481-4183 or (800) 247-4614.
Fax: (203) 481-8734.
E-mail: ivybio@ivybiomedical.com
All products being returned for warranty repair shall be shipped prepaid to:
Ivy will prepay the shipment of the repaired or replacement product to customer at Ivy’s expense.
INTRODUCTION
This manual is to provide information on the correct use of the Model 3000 Series ECG and Heart Rate
synchronizer/patient monitor. It is up to the user to ensure that any applicable regulations regarding the installation
and operation of the monitor are observed.
The model 3000 Series is Medical Electrical Equipment intended to be used under medical supervision. The model
3000 Series must be operated by trained and qualified medical personnel only.
We recommend that you read this manual before operating the equipment. This manual is written to include all
options. If your monitor does not include all options, menu selections and display data for those options will not
appear on your monitor.
Use the Monitor Description section for general descriptions of controls and displays. For details on the use of each
option, refer to the section of the manual dealing with the appropriate option.
Boldface type is used in text to refer to the labeling on user controls. Special brackets [ ] surround menu
selections used with the programmable keys.
Manufacturer’s Responsibility
The manufacturer of this equipment is responsible for the effects on safety, reliability, and performance of the
equipment only if:
• Assembly operations, extensions, re-adjustments, or repairs are carried out by persons authorized by the
manufacturer
Incorrect operation or failure of the user to maintain the monitor in accordance with proper maintenance procedures
relieves the manufacturer or his agent from all responsibility for consequent non-compliance, damage, or injury.
This manual explains how to set up and use the Model 3000 Series. Important safety information is located
throughout the manual where appropriate. READ THE ENTIRE SAFETY INFORMATION SECTION BEFORE
YOU OPERATE THE MONITOR.
SAFETY
Electrical
This product is intended to be operated from a mains power source of nominally 100 to 230V~, 47 to 63 Hz and
Maximum AC Power consumption: 35VA. 45VA (Model 3150-B Only)
WARNING: To prevent electrical hazards to all personnel, this monitor must be properly grounded. Connect the
monitor only to a three-wire, grounded, hospital grade receptacle. The three-conductor plug must be inserted into a
properly wired three-wire receptacle; if a three-wire receptacle is not available, a qualified electrician must install
one in accordance with the governing electric code.
WARNING: Do not under any circumstances remove grounding conductor from the power plug.
WARNING: The power cable supplied with this equipment provides for this protection. Do not attempt to defeat
this protection by modifying the cable or by using ungrounded adapters or extension cables. The power cord and
plug must be intact and undamaged. To disconnect the equipment from the mains power unplug the power cord.
WARNING: If there is any doubt about the integrity of the protective ground conductor arrangement, do not
operate the monitor until the AC power source protective conductor is fully functional.
WARNING: Do not place the monitor in any position that may cause it to fall on the patient. Do not lift the monitor
by the power supply cord or patient cable.
WARNING: Electric shock hazard! Do not remove covers or panels. Refer service to qualified service
personnel.
WARNING: To avoid electrical shock, disconnect the monitor from its power source before changing fuses.
Replace fuses only with same type and rating T.5A, 250V (Metric 5x20mm).
WARNING: Do not clean monitor while it is on and/or plugged into a power source.
WARNING: If unit is accidentally wet, discontinue use until dry and then test unit for proper operation before reuse
on a patient.
WARNING: This unit uses a common isolation path for the ECG leads. Do not connect any non-isolated
accessories to the ECG input when connected to a patient, as this may compromise the safety of the unit. When
attached to other devices, insure that the total chassis leakage currents of all units do not exceed 300 μA.
Explosion
DANGER: Explosion hazard! Do not use this equipment in the presence of flammable anesthetics or other
flammable substance in combination with air, oxygen-enriched environment or nitrous oxide.
Patient Connections
Patient connections are electrically isolated. For all connections use isolated probes. Don’t let patient connections
contact other conductive parts, including ground. See instructions for patient connections in this manual.
Carefully route patient cables to reduce the possibility of patient entanglement or strangulation.
Leakage current is limited internally by this monitor to less than 10 μA. However, always consider cumulative
leakage current that can be caused by other equipment used on the patient at the same time as this monitor.
To ensure that the leakage current protection remains within the specifications, use only the patient cables specified
in this manual. This monitor is supplied with protected lead wires. Do not use cables and leads with unprotected
lead wires having exposed conductors at the cable end. Unprotected lead wires and cables may pose an
unreasonable risk of adverse health consequences or death.
Line isolation monitor transients may resemble actual cardiac waveforms and thus inhibit heart rate alarms. To
minimize this problem, ensure proper electrode placement and cable arrangement.
If an alarm condition occurs while the alarms are set to off, neither visual or audio alarms will be present.
MRI
The model 3000 Series should not be used within the magnetic field during Magnetic Resonance Imaging.
Pacemakers
Rate meters might continue to count the pacemaker rate during occurrences of cardiac arrest or some arrhythmias.
Do not rely on rate meter alarms. Keep pacemaker patients under close surveillance.
Electrosurgery Protection
This equipment is protected against electrosurgery potentials. To avoid the potential of electrosurgery burns at
monitoring sites, ensure proper connection of the electrosurgery return circuit as described by the manufacturer’s
instructions. If improperly connected, some electrosurgery units might allow energy to return through the ECG
electrodes.
Defibrillation Protection
This equipment is protected against 360 J defibrillator discharge.. The monitor is internally protected to limit current
through the electrodes to prevent injury to the patient and damage to the equipment as long as the defibrillator is
used in conformance with the manufacturer’s instructions.
EMC
This equipment has been certified to be protected to emissions and immunity according to IEC-60601-1-2.
CAUTION: Portable and mobile RF communications equipment can affect medical electrical equipment.
WARNING: The model 3000 should not be used adjacent to or stacked with other equipment and that if adjacent or
stacked use is necessary, the Model 3000 should be observed to verify normal operation in the configuration in
which it will used.
Accessories
WARNING: The use of accessories other than those specified below may result in increased emissions or decreased
immunity of the equipment.
The minimum amplitude or value patient physiological signal is 0.5 mV (AAMI EC-13 3.2.6.1).
WARNING: The use of the Model 3000 below the following amplitude values may cause inaccurate results:
<5 % UT <5 % UT
(>95 % dip in UT) (>95 % dip in UT)
for 5 sec cycle for 5 sec cycle
Power frequency 3 A/m Not applicable Not applicable
(50/60 Hz)
magnetic field
IEC 61000-4-8
NOTE 1 – At 80 MHz and 800 MHz, the higher frequency range applies.
NOTE 2 – These guidelines may not apply in all situations. Electromagnetic propagation is affected by absorption and
reflection from structures, objects, and people.
a
Field strengths from fixed transmitters, such as base stations for radio (cellular/cordless) telephones and land mobile
radios, amateur radios, AM and FM radio broadcast, and TV broadcast cannot be predicted theoretically with accuracy.
To assess the electromagnetic environment due to fixed RF transmitters, and electromagnetic site survey should be
considered. If the measured field strength in the location in which the Model 3000 is used exceeds the applicable RF
compliance level above, the Model 3000 should be observed to verify normal operation. If abnormal performance is
observed, additional measures may be necessary, such as re-orienting or relocating the Model 3000.
b
Over the frequency range 150 KHz to 80 MHz, field strengths should be less than 3 V/m.
ON Input signal.
WEEE Compliance
Manufacturer
Caution - Electric shock hazard. Do not remove covers or panels. Refer service to
qualified service personnel.
MONITOR DESCRIPTION
The Model 3000 Series Cardiac Trigger Monitor is an easy to use color monitor that displays a patient’s ECG
waveform and heart rate. The ECG lead displayed can be selected from Leads I, II or III. In addition high and low
heart rate alarm limits can be adjusted to bracket the patient’s heart rate so that a violation of these limits produces
an audible and visual indication of the violation. The color display has a single trace, large Heart Rate numbers and
alphanumeric characters for other data, alarm messages, menus and user information.
The Model 3000 monitor is intended primarily for use on patients in applications requiring precision R-wave
synchronization such as timed imaging studies.
The Model 3050 is the same as the Model 3000 except that it has software that detects when the monitor is
connected or not connected to another device requiring precision R-wave synchronization.
The Model 3100 is the same as the Model 3050 except that it has an internal Floppy Drive System that allows the
operator to store and retrieve ECG events on standard IBM formatted 1.44 MB 3.5” floppy disks. This function will
only operate when the model 3100 is electrically connected to a CT-Scanner and only if the DISK STORAGE mode
is selected in the data transfer mode switch.
The Model 3150 is the same as the Model 3100 except that it has a RJ54 “Ethernet” connector that allows the
monitor to transfer ECG data and trigger controls to the CT console and vice-versa. This function will only operate
when the model 3150 is electrically connected to a CT-scanner and CT console and only if the ETHERNET mode is
selected in the data transfer mode switch.
The Model 3200 is the same as the Model 3050 except that it has a RJ54 “Ethernet” connector that allows the
monitor to transfer ECG data and trigger controls to the CT console and vice-versa. This function will only operate
when the model 3200 is electrically connected to a CT-scanner and CT console.
An optional integral recorder is available, set up of recorder functions are made through the monitor menus
The Model 3000 Series is available with different options; not all options are included in all monitors.
The Model 3000 Series is suitable for use in presence of Electro-surgery.
The Model 3000 Series is not intended for use with any other physiological monitoring unit.
The Model 3000 Series is restricted to use on one patient at a time.
The Model 3000 Series is not intended for home-care patient monitoring
Degree of protection against electric shock: Type CF applied part. Defibrillator proof: ECG
Degree of protection against harmful ingress of water: Ordinary equipment IPX0 per IEC-60529
Degree of safety of application in the presence of a Equipment not suitable for use in the presence of a
flammable anesthetic mixture with air or with oxygen flammable anesthetic mixture
or nitrous oxide:
Basic Keys
When the monitor is plugged into an AC power source the ON switch, when pressed, provides power to
the monitor’s electronic circuits.
The STBY switch, when pressed, disconnects power from the monitor’s electronic circuits.
NOTE: To disconnect the monitor from the main power unplug the AC power cord.
Disables the audible and visual alarms for a two-minute period to allow the operator to perform procedures
that would otherwise set off the alarms. This avoids the problem of turning off the alarms and forgetting to
turn them back on. Press this key again to return the alarms to normal before the two minutes have expired.
Pressing ALARM PAUSE key for 3 seconds will turn alarms off. Press ALARMS PAUSE key again to
reactivate the alarms. Pressing ALARM PAUSE key will pause the alarms for 120 seconds (2 minutes).
This key enables or disables (arm or disarm) the ECG storage function of the monitor allowing the user to
save up to 60 seconds of ECG signal in a 3.5 inches floppy disc.
When the ECG data has been successfully stored this key opens a special menu to re-write data, clear
memory or patient ID.
ON switch
(Basic Key)
Keypad
(Only available in Models
3100 and 3150)
Stand By switch
(Basic Key)
Recorder
ECG Patient
Cable Connector
Alarm Pause
Key
Programmable
Keys
Programmable Keys
Displayed above each programmable key is either a menu item or a function. Pressing a programmable key will
display other menu levels or activate an appropriate function. Menu functions are described in the Menu Structure
section of this manual.
MEASURE TEST
SETUP PRINT IMPEDANCE FREEZE MODE
VOL/CLOCK
ECG LIMITS USB DRIVE
REC MODE EXIT
Display
HEART RATE: Displayed in beats per minute (bpm) on the upper part of the screen.
SETUP: Selections made in the menu setup modes (alarm limits, lead selection, and filter on/off) are displayed in
small characters at the upper left corner.
ECG: Trace is displayed across the screen moving from left to right.
SETUP: Selections made in the menu setup modes (alarm limits, lead selection, and filter on/off) are displayed in
small characters at the upper left corner.
ECG: Trace is displayed across the screen moving from left to right.
System Interlock: Large symbols in the upper right hand corner of the display provide the operator with a visual
indication of the status of the connection between the Model 3150-B and the CT Scanner.
XRAY On/Off: Indicates that the CT-Scanner X-Ray is “ON” or the CT Scanner X-Ray is “OFF”. The XRAY
On/Off indicator is located in the upper right hand corner of the display.
Impedance Measurement: Displays the measured value of the impedance between the patient’s skin and each
individual ECG electrode (RA, LA, and LL). Impedance measurements are located in the upper right hand corner of
the display.
80
11:40 PATIENT ID 858745
HR
ON
150
I-FILT
I-FILT
XRAY OFF
60 - 160 RA LA LL
ON 2 0 MM/MV 9K 10k 12k
REC: DIRECT
20 MM/MV
STBY
ECG
REC: DIRECT
18-JUL-2002
11:40 PACER DETECT
DISABLED
Alarm Messages
The following alarm indications are displayed in reverse video. Alarm indications appear on the center of the screen
and flash once per second. ALARMS PAUSE message (PAUSE) is also displayed on the center of the screen and is
displayed in regular video.
ALARMS OFF: The audible and visual alarms have been turned off.
LEAD OFF: A lead has become disconnected. This alarm cannot be reset with the
ALARM PAUSE key.
HR HIGH: The high heart rate limit has been exceeded for four seconds.
HR LOW: The low heart rate limit has been exceeded for four seconds.
WARNING: The monitor always powers on with the ALARMS paused for 30 seconds and then they are set to ON.
Rear Panel
The following are located on the rear panel.
When the monitor is connected to another piece of equipment, always make sure that each piece of connected
equipment has its own separate ground connection.
Do not attempt to connect cables to these connectors without contacting your Biomedical Engineering Department.
This is to ensure the connection complies with leakage current requirements of one of the following applicable
standards: UL2601-1, CAN/CSA C22.2 No 601.1-M90, IEC 60601-2-25, and CE-MDD 93/42/EEC. The maximum
non-destructive voltage that may be applied to these connectors is 5V.
SYNCHRONIZED OUTPUT: A BNC type connector for the output of the synch pulse indicating the timing of the
peak of the R-wave. Limit to 100Hz bandwidth.
PEQ GROUND: Potential Equalization - A ground connection that can be used to ensure that no potential
differences can develop between this equipment and other electrical equipment.
FUSE: Replace only with the same type and rating of fuse as indicated on the fuse rating label T.5A 250V (Metric
5x20mm).
ECG X1000 (ECG X500 for GEHC Nuclear Medicine applications only) and SYNCHRONIZED OUTPUT:
This is a ¼ stereo phone jack with an ECG analog waveform output on the tip, synch output on the ring, and
common on the sleeve. Limit to 100Hz bandwidth.
AUXILIARY: A digital interface for device communication. This auxiliary output provides 5V and -8Vwith a
maximum current of 20mA.
ETHERNET: This output provides an Ethernet protocol (10Base-T, IEEE 802.3) to allow the model 3000 Series
and the CT scanner console to share data and control options.
DATA TRANSFER MODE SWITCH: This switch allows the user to select the mode in which the model 3000
Series stores or transfer ECG data. There are two modes: Disk transfer or Ethernet.
LINE VOLTAGE SELECTOR: Switch to select the input voltage range of the device (100 to 230V~, 47 to 63
Hz.).
The use of ACCESSORY equipment not complying with the equivalent safety requirements of this equipment may
lead to a reduce level of safety of the resulting system. Consideration relating to the choice shall include:
• Use of the accessory in the PATIENT VICINITY
• Evidence that the safety certification of the ACCESSORY has been performed in accordance to the
appropriate IEC 60601-1 and / or IEC 60601-1-1 harmonized national standard.
PEQ
Ground
Data Transfer
Mode Switch
Fuses
(Behind the
panel)
SERIAL NUMBER LABEL: The serial number label indicates the model number and a unique serial number for
the monitor. The date of manufacture is encoded in the first 4 digits of the serial number using the YYMM format.
PEQ
Ground
Fuses
(Behind the
panel)
Power entry
BNC connector module
Synchronized AUXILIARY Line Voltage
Output (Optional) Selector
Fuse Ratings
The fuses are located behind the cover of the power entry module. To replace the fuses, remove the cover and
replace them only with same type and rating T.5A, 250V (Metric 5x20mm).
MONITOR TESTING
Press the [TEST] key to test the internal functions of the monitor. You should do this each time you begin
monitoring a patient.
The [TEST] function generates a 1 mV pulse at 70 bpm, causing a waveform and a 70 bpm indication on the display
and a signal at the rear panel connector. If these indications are not present, contact qualified service personnel.
To test the visual and audio alarms turn on the monitor. Make sure the ALARMS OFF message is not present in the
center portion of the display. If the alarms are off press thekey. Unplug the patient cable. Check that the
LEAD OFF message is displayed on the ECG channel and the audio alarm is on. While pressing the TEST key check
for the following to happen: 1) LEAD OFF message disappears, and 2) Monitor starts counting QRS. Release the
TEST key and press for three seconds, the message PAUSE and the timer should be displayed on the display,
all audio and visual alarms should be off
Under normal operation, no internal adjustment or recalibration is required. Safety tests and internal adjustments
should be done by qualified personnel only. Safety checks should be performed at regular intervals or in accordance
with local or governmental regulations. In the event that internal adjustment or recalibration is necessary, refer to the
Service Addendum for this equipment.
Note:
If no display is visible on the monitor, the monitor is inoperable. Contact qualified personal. When ECG input is
>0.5 V, a inoperable condition is indicated by flashing LEAD OFF indicator on the display.
To turn the simulator on and set the heart rate, follow the procedure below:
1. Press the [TEST MODE] key located in the main menu to access the simulator mode menu.
2. Press the key [SIM RATE] to turn the simulator on and toggle through the heart rate options.
3. Press the keys [ ↑ FINE TUNE ↓ ] to change the heart rate in increments of one.
NOTE: When the simulator is on, a message “SIMULATOR ON” is displayed in the center of the screen below the
ECG trace.
TROUBLESHOOTING
WARNING: The following procedures include voltage checks. These procedures should be done by qualified
personnel only with appropriate equipment such as oscilloscope and digital voltmeter.
FUNCTIONAL TESTS
Equipment Required
Oscilloscope (2 channel 100Mhz)
Digital Voltmeter
ECG Simulator
Unregulated Voltages
Set the line voltage to the voltage selected on the rear panel. Apply power. Measure the voltage at VI (TP10)
located in the 5148-00-01 Mother Board. The voltage should be +24.0V to +34.0V.
Regulated Voltages
Measure the following regulated voltages. Their test points are located in the 5148-00-01 Mother Board:
LI Black (LA) +
White (RA) -
Red (LL) com
ECG trace is clamped to 0.
L II Black (LA) com LEAD OFF alarm tag is displayed.
Red (LL) +
Press the TEST key with the LEAD OFF alarm present and verify that the LEAD OFF tag disappears.
Audio
Press the TEST key. Confirm the operation of the QRS audio. Check the HIGH, LOW and OFF menu selections.
Cause an alarm condition. Verify the operation of the audio alarm. Check the HIGH and LOW menu selections.
Set the monitor to FILTER OFF. Measure the amplitude at the ECG X1000 rear panel output.
Lead I 1 V peak (0.90Vp to 1.10Vp)
Lead II 1.5 V peak (1.35Vp to 1.65Vp)
Lead III 0.5 V peak (0.45Vp to 0.55Vp)
Measure the TRIGGER pulse at the rear panel ECG X1000 output (ring). Set the TRIGGER ON.
Refer to the following matrix for customer requirements and the timing of the trigger pulse compared to the ECG
waveform.
Verify that the trigger pulse is also present at the rear panel Synchronized Output (BNC connector) and at Auxiliary
output (pin 11) for the models 3050, 3100, 3150, and 3200.
Verify that the trace is displayed in RED beginning at the peak of the test signal and corresponds with the trigger
output pulse. Press the TRIGGER key in the ECG menu to disable the Trigger Mark and the trigger pulse.
Verify that the correct date and time is printed in the lower margin.
Press the paper eject button to open the door at the front of the recorder. Check for the DOOR OPEN message to be
displayed in the lower left corner of the display.
Remove the paper and close the door. Verify that the PAPER OUT message is displayed. Load the recorder with
paper.
Leakage Tests
Use a leakage tester or the AC voltage range on a digital voltmeter.
Using the DMM, select AC VOLTS and the 200 mV range. Connect the leakage filter as shown below.
DMM
A.C. VOLTS
TO CIRCUIT
0.015µf 1kΩ BEING
MEASURED
Connect the meter from the rear panel PEQ ground of the monitor to line cord ground.
Measure the leakage with the following conditions.
Unit Grounded - the current must be < 20 µA
Ground Broken - the current must be < 30 µA
Ground Broken, reversed polarity - the current must be < 30 µA
Connect the patient cable to the ECG input. With the monitor on, measure the leakage from the shorted patient leads
to the HOT side of the line. The leakage must be <10 µA for 120V units.
Simulator/Functional Check
If a simulator is installed, connect the lead wires to the side terminals and verify operation in all lead configurations.
Connect the ECG simulator and check for the correct heart rate and ECG display. If a recorder is present, verify
operation.
The Monitor
When necessary, clean the exterior surfaces of the monitor with a cloth or swab dampened with a warm water and
mild detergent solution. Do not allow liquids to enter the interior of the instrument.
CAUTION:
• Use cleaning solution sparingly. Excessive solution can flow into the monitor and cause damage to internal
components.
• Do not touch, press or rub the display and covers with abrasive cleaning compounds, instruments, brushes,
rough surface materials, or bring them into contact with anything that could scratch the display or the
covers.
• Do not use petroleum based or acetones solutions, or other harsh solvents, to clean the monitor.
Patient Cables
Do not autoclave the patient cables.
Wipe the cables using a mild detergent solution. Never submerge the cables in any liquid or allow liquids to enter
the electrical connections.
Preventive Maintenance
ECG
Check before connecting the monitor to a new patient that:
• Cables and Leads are clean and intact.
• The LEAD OFF message is displayed when the patient cable is connected, but the patient leads are not
connected. Connecting the patient leads together should make the message disappear.
• The BNC Interconnect cable is clean and intact.
NOTE: There are no user serviceable items contained in the model 3000 Series.
ACCESSORIES
ECG
ECG 3 lead Patient Cable (Model 3000 only) 590406
Low noise 3 Lead ECG Patient Cable with 1kohm resistors 590323
Set of three radiotranslucent lead wires (use with 590317 or 590323)) 590318
Box of 10 IBM preformatted 3.5” floppy disks (Unavailable for Model 3000,
3050, and 3200) 590292
Disposal
Disposal of devices or consumables must be done in accordance with local, state, and federal laws and regulations.
WEEE Directive 2002/96/EC.- Do not dispose of WEEE products in general waste. At the end of life of product
contact IVY Biomedical Systems, Inc. customer service for return instructions.
SPECIFICATIONS
ECG
Lead Selection: LI, LII, LIII menu selectable.
Isolation: Isolated from ground related circuits by >4 kV rms, 5.5 kV peak
Frequency Response
LCD: Filtered: 0.5 to 25 Hz
Unfiltered: 0.5 to 45 Hz
Frequency Response
X1000 output: Filtered: 0.5 to 25 Hz
Unfiltered: 0.2 to 100 Hz
Noise: <20 µV peak-to-peak, referred to the input with all leads connected
through 51 kΩ/47 nF to ground
Electrosurgical Interference
Protection: Standard. Recovery time: <6 seconds.
Cardiotach
Range: 15 to 300 bpm
Accuracy: ±1%
Resolution: 1 bpm
Sensitivity: 300 µV peak
Heart Rate Averaging: Exponential averaging calculated once a second with a maximum
response time of 8 seconds.
Response Time: ≤ 8 seconds
Tall T Wave Rejection: Rejects T waves ≤R wave
Alarms
High Rate: 15 to 250 bpm in 5 bpm increments
Low Rate: 10 to 245 bpm in 5 bpm increments
Asystole: R to R interval >6 seconds
Lead Off: Detached lead or offset potential >0.5 V
Simulator Option
ECG waveform amplitude: 1mV
Simulator rate: Variable rate in steps of 40, 60, 90, 120 and 150 BPM
Also manually adjustable in increments of 1 BPM.
Test Mode
ECG: 1 mV/100 ms @ 70 bpm
Display
Type: Active Matrix TFT Color LCD (640x480)
Trace: Single ECG trace with “freeze” function.
Screen Size: 13.25cm x 9.94cm, 16.5cm (6.5in) diagonal
Sweep Speed: 25, 50 mm/s
Aspect ratio: 0.4 (standard). User selectable.
Ethernet Module
Network Interface: RJ45 (10BASE-T)
Ethernet compatibility: Version 2.0/IEEE 802.3
Protocol: TCP/IP
Packet Rate: 250ms
ECG Data Rate: 240 samples/s
Default IP address: 10.44.22.21
Data Rates: 300bps to 115.2Kbps
Standard Temperature: 32 to 158°F (0 to 70°C)
Size: 1.574 x 1.929 in (40mm x 49mm)
Mechanical
Size: Height: 6.70in. (17.2cm)
Width: 9.25in. (33.5cm)
Depth: 9.21in. (23.4cm)
Recorder (optional)
Writing Method: Direct Thermal
Number of Traces: 1
Modes: Direct - Manual Recording
Timed - Print button initiates a 30 second recording
Delay - Recorder is activated by an alarm
Paper Speeds: 25 and 50 mm/s
Resolution: Vertical - 200 dots/in.
Horizontal - 600 dots/in. at ≤25 mm/s
400 dots/in. at >25 mm/s
Frequency Response: >100 Hz at 50 mm/s
Data Rate: 400 samples/s/trace
Environmental
Operating Temperature
Range: 5°C to 40°C
Storage Temperature
Range: -5°C to 55°C
Relative Humidity: 0-90% non-condensing
Atmospheric Pressure: 500-1060 mbar
Power Requirements
Voltage Input: 100 to 230V~
Line Frequency: 47 to 63 Hz
Fuses Type and Rating: T.5A, 250V (Metric 5x20mm)
Maximum ac Power
Consumption: 35VA, 45VA (Model 3150-B Only)
Regulatory
Unit meets or exceeds the specifications for the AAMI Cardiac Monitor Standard EC-13, UL2601-1,
CAN/CSA C22.2 No 601.1-M90, CDN MDR (CMDCAS), IEC 60601-2-25, IEC 60601-2-27,
MDD.93/42/EEC, CE 0143, ISO 13485:1996, and FDA/CGMP.
1. Adult 3 lead and ECG peak detector board (Mother board) 5148-00-01
5. Adult / Neonate 3 lead and ECG peak detector board (Mother board) 5197-00-01
5197-01-01
D1
15 REVISED PER ECN 1628. GP 2-14-08 08 REVISED PER ECN 1309. GP 11-10-03 REVISIONS
ISO.GND. +6.5V MMBD4148CC U1B GP 11-26-03 REV DESCRIPTION BY DATE
09 REVISED PER ECN 1312.
TP20
TL062ACD 10 REVISED PER ECN 1319. GP 1-9-04 01 REVISED FOR REV-01 ARTWORK PER ECN 1138. GP 2-12-02
2 1 -6.5V 1 R1
J101 3 5 11 REVISED FOR REV-05A ARTWORK PER ECN 1422. GP 3-29-05 02 REVISED PER ECN 1166. GP 3-5-02
ECG INPUT SHIELD 100K 7
I DRIVE +6.5V 2 6 12 REVISED PER ECN 1508. GP 4-7-06 03 REVISED FOR REV-02 ARTWORK PER ECN 1244. GP 1-23-03
LA D2 D3
3
1 RA TP25 MMBD1503A +5VI
2 LL C1 +5VI MMBD4148 13 REVISED PER ECN 1564. GP 1-8-07 04 REVISED PER ECN 1261. GP 3-17-03
3 R2
4 .1UF D4 +5VI 14 REVISED PER ECN 1623. GP 7-9-07 05 REVISED FOR REV-03 ARTWORK PER ECN 1262. GP 3-17-03
SHIELD DRIVE R7 CER 20K Q1 R4 U2B
+5VI 80.6K R6 SAMPLE 06 REVISED FOR REV-04 ARTWORK PER ECN 1294. GP 7-29-03
C96 10K U1A R3 CMPT3906 LM393M 100K
MMBD4148 R5 50HZ 07 REVISED FOR REV-05 ARTWORK PER ECN 1308. GP 11-10-03
8
.01UF TL062ACD I 30.1K 3 2 5 +
100K +5VI +5V
1% NPO + 3 7 60HZ
1 _ 2 I 6 _
I I R12
10K R9 R8
1
R13 +5VI 1K 1K C4 MAX364CSE X1000_OUT
30.1K R10 NOTCH U4D
4
RA C5 + R14 PACE 3 2 TP1 TL064ACD
D +5VI .1UF C6 C2 14 NO1 COM1
15 D
12.7K
5
.1UF 100K 11 NO2 COM2
10 13 R16
R15 CER 6.8UF TANT I U5 .01UF NO3 COM3 C8 - X1000_OUT
-6.5V R21 CER 1% NPO 6 NO4 COM4 7 R19 14
5K MELF 1W 35V 7343 CNY17F-3X007 12 100
121K R193 R18 1 +
8
R20 I D5 I 16 IN1
.01UF NPO 100K OHM
4
22M I 3 + 9 IN2
R27 8.06K 787K .1% IN3 R225
5% 1 8 U3
MMBD4148
4.75M 2 _ A 50PPM 1206
IN4
R24 C10 100K
R22 R23 U2A +5V 12 1000PF
LM393M C9 VL INSTALL FOR
5K MELF 1W R25 80.6K 100K NPO
GND
6 +12V 13 X500 GAIN
4
22M - V+
7 -12V 4 A OPTION ONLY
5% C7 .01UF 5 V-
9
DS1 -5VI .1UF + - 8
BA-CMS-90 -5VI R26 1% NPO U4B 10
CER
5
D6 392K .1% A TL064ACD +
R28 MMBD1503A U4C
22M +6.5V I 50PPM 1206 A A
2
5% +5VI I TL064ACD
2 1 C12 3 C13 NOTCH-
.1UF R33 Q3
I R31 C14 MMBF4393 .01UF 63V R194 R29
R34 CER R32 60.4K R30
-5VI 100K .1% 50PPM .1UF MP 2824 6.04K 187K .1%
1
22M U6B 100K 113K .1%
CER
3
16
200K X500 100K
7
5 + I I LT1058SW J109
R37 C15 TP2 A 1
7 12 13 3 R38 TEST
VD
6 - 14 X0 X + 6 14 + R39 +5VI +5V 170508 2
15 X1
3 10K .1% 2 16 ECG X1000 3
C16 11 X2 Y 50PPM - 402K 15 - D
1UF 63V
1
220PF X3
LT1055S8 C18 49.9K
LA C17 MP 2824 U10 NOTCHX1000
NPO 1 U8 470PF
4
1
5
5 Y0 .01UF 63V C19 CNY17F-3X007 J109-3
R41 Y1 C20 NPO TP3 PDT2 D7
+5VI 2 MP 2824 R43
5K MELF 1W Q4 4 Y2
R42 R40
-5VI 22MS MMBD1503A
2
MMBF4393 -6.5V 6 Y3 402K 680PF NPO
1
R44 INH U7
R45 10 10K .1% .1UF
A 2K
VS
VE
22M 3 9 CD4052BCM R46 2 1
5% B 50PPM I CER LOD +5V -8V
1M R48 R52
R50 C22 165K A
SHFT J115
2
8
7
60.4K .1% I 100K U11C
R51 R49
3
5K MELF 1W R53 I -6.5V 50PPM 1206 TL034ACD
22M I 1K -6.5V 1 2 C23 100K
3 4 KEYING PLUG
5% .1UF CER R56 5 6 9 R54
VCC 7 8
- 8
16.2K R57 +12V 9 10 -12V .0047UF MP R55 10 10K
DS2 D10 100K +
C
BA-CMS-90 R58 10K 50V 1206 C
22M MMBD1503A +6.5V D9 R59 +5VI 170513 D8 Q5
5% MMBD4148 A MMBD4148 MMBF4393
2 1 C25 10 OHM +6.5V DOUT +12V A
U12 SIG240 R223
2
.1UF C26
U6A .1UF IL300-X007 C27 3
R61 CER I Q6 R62 PDO 100K
I LT1058SW CER 1 8 .1UF A
R63 22M -5VI D11 CMPT3906 249 (SLAVE) C28
3
8
5% MMBD4148CA OHM CER 680PF
1
4
2
200K I 2 I 2 7
R64 NPO
8
3 + 1 1 3 6 5 + R65 A
1 1 R66 3 499 7 2
2 - 3 +5VI U13A
A 6 _ 1 R67
TL062ACD OHM 4 5 100K 3
C30
3
C29 2 1M I U14A 909K
4
13
4
R68 .1UF .1UF 220PF
CER NPO C34
5K MELF 1W +5VI CER .1UF A
-6.5V
Q7 I R70 -12V CER R71 R72
R69
22M MMBF4393 I
5% R47 49.9K RV1 A R81 100K 100K
C35
1
5% -8V +8V
DS3
BA-CMS-90 I RV2 649K
PDI
D12 20K 5 TURN C21 TP4 C36
R79 MMBD1503A ECG BAL
22M
5%
2 1
ISOLATED R80
20K
.1UF
CER
R82
20K .047UF MP
R86
60.4K
I 50V 1812
4
A
R83 U6C D13 R85 2
22M -5VI +6.5V +5V 6 1 - C37
R84 MMBD4148CC
3
200K
5% LT1058SW
NON-ISOLATED 7 -
5 20K
U11A +
3
14 -
13
5
11
10 U15 D14 -12V 3 TL034ACD +
11 - CNY17F-3X007 +12V U11B A MP 1812
+5V MMBD1503A 10K 2 R88 U11D A
C38 TL034ACD C24 1K
R90 TL034ACD
4
8
A
3
-6.5V R91 A 3
-6.5V
5
1 + 5 Q8
1
3
3 D17 1K U16A - 6 TL072ACD
Q9 CNY17F-3X007 MMBD4148
R92 MMBD4148CC R93 TL072ACD -
MMBF4393 L1 L1
4
4
499K
R95 R96
2
R94 1K C40 A
10K .1UF +8V
I 10K
3
A R97 THRESHOLD
MMBD4148 C41 -12V
Q10 49.9K -8V +8V -12V
2
+8V -12V
CMPT3906
R98
499K 680PF CER C42 R99
I .15UF 5% R100 +12V
49.9K 200K R189 +12V +12V
X7R 1206 2M
SHIELD C43 -5VI
A MODEL 3150 ONLY
.0015UF REPLACE C44 WITH -12V +5V
R102 50V MP 1812 R103 .47UF 63V MP 2824 C44 +5V
R101
(138216)
2
4
6 R105 D19 6
-
R106 A
-
7 I 10K 7 2
5 +12V 5
+
1
20K A 100K 3
+
DGND
MMBD4148 DGND
U13B R107 A U19B U19A
+5VI U9 +6.5V C47 -8V A TL032ACD
TL062ACD TL032ACD
8
TP21 LM2931M-5.0 TP6 .1UF 3.24M D
+6.5V R108 CER R109 +12V
7.5K C48
1 8 100 OHM .1UF AGND
+5VI VOUT VIN D20 D AGND
MURS160T3 Q11 CER
GND
GND
GND
GND
NC
NC
A
R110 A A A
+ C51 MURS160T3 100UF TANT R111
1 R112
20K 180UF TANT 16V 7343
5
4
7
6
3
2
TP7 6 T1 G
16V 7343 I 1029-00-10 2.21K .5W NOTES: FRONT END
DIS
Q
THR
1
2010 8
I
+ C56
180UF TANT * 2
D
3
S
4
V+
R V- 1
C53
1000PF
NPO 2
1. ALL RESISTORS ARE 1/10W, 1%, SIZE 0805 U.O.S. IVY BIOMEDICAL SYSTEMS INC.
7
I + U22 + C54 16V SIZE-R 16US ALL .1UF CER CAPACITORS ARE SIZE 0805 U.O.S. 11 BUSINESS PARK DRIVE
C57 D23 + C55 Q12
CV
TR
100UF TANT LM2990S-5.0 6.8UF TANT ICL8069CBA + BRANFORD, CT., 06405 USA
2
3
R116 07 REVISED FOR REV-05 ARTWORK PER ECN 1308. GP 11-10-03
1 1
4.99K 08 REVISED PER ECN 1309. GP 11-10-03
R117
2
09 REVISED PER ECN 1312. GP 11-26-03
R119 4.99K
261K D 10 REVISED PER ECN 1319. GP 1-9-04
+12V -12V R118
C59 C60 261K 11 REVISED FOR REV-05A ARTWORK PER ECN 1422. GP 3-29-05
+
12 REVISED PER ECN 1508. GP 4-7-06
+5V 68UF TANT 68UF TANT 13 REVISED PER ECN 1564. GP 1-8-07
D 16V 7343 16V 7343 D -12V 14 REVISED PER ECN 1623. GP 7-9-07
14
1
Vcc
+V
-V
2 A Y 4 2 1A 1Y 3
GND
U23 4 2A 2Y 6
SN74AHC1G04DCK 5 2B +12V
PGND 9 8 +5V
3A 3Y
10
3
+5V 3B
R121 R120
GND
TP10 12 11 22.1 OHM
13 4A 4Y 402
VI 4B SW1
OHM
3
J106 D R122 1 1 20 BIPOLAR
U24
POWER IN D25 1 Q17
7
MC1488D 2 19 HIGH CURR
VI MMBD4148 U25 10 OHM MMBT3904LT1
4
8
* 4 ICM7555ISA D 3 2 18
2
3 D26
R123
R
V+
2 POS TRIG
1 2 TR Q 3 4 17
MURS160T3 100K 7 R124 SW1 SHOWN 5 3 16 NEG TRIG
DIS 475 OHM
5 6 IN ON POSTION 6 15
CHASSIS_GND R125 CV THR
V-
D MP 2824
TRIG LEVEL SW1-1 SW1-2 SW1-3 9 5 12 WIDTH 2
WITH2
D 10 11
+/- 11V ON ON OFF
R183 R184
LNFREQ 5V POS OFF OFF OFF D 10K 10K
R126
R127 10K C62 VI D27 5V NEG OFF OFF ON
ON VI 100K SF1
+
2
.033UF 63V
LM2678S-ADJ +5V
6
3
MP 2824
FB
CB
L1 D
VI 2 VIN VOUT 1 +5V
GND
TP11
ONF
2
+ D28 C66 U29
47UF 50V
MBRS340T3 + TP13
7
A
ALUM 680UF 10V LM2931CM 3 1 -8V
+8V -12V
4
ADJ
GND3ADJ
B
R134 C64 D
C
+12V 8 1
GND7
GND6
GND2
4
+ C67 R135 + C68
+5V 33UF TANT 1.21K 180UF TANT A A
7
6
3
2
L2 RF1,RV3,T1,TP25,SF8,SW3,U49,Y2.
VI 2 VIN VOUT 1 +12V +12V
GND
ONF
ALUM
180UF TANT
16V SIZE-R + C71
R212
TP14
+5V 1
2 J112
POWER SUPPLY
-12V +12V
8.2UF
16V
100K U30
LT1054CS8
3
4
174011
AND TRIGGER OUT
8
A
ALUM 1 VOUT 5 -12V D A
*
VCC+
+ C70 7 FB/SD
RECGND + C72 OSC IVY BIOMEDICAL SYSTEMS INC.
8.2UF 6
180UF TANT VREF
GND
REVISIONS
BREQ RDOSW REV DESCRIPTION BY DATE
BREQ RDOSW
STRB1 WITH1 01 REVISED FOR REV-01 ARTWORK PER ECN 1138. GP 2-12-02
STRB1 WITH1
STRB2 WITH2 02 REVISED PER ECN 1166. GP 3-5-02
OPTIONS SETTINGS STRB2 WITH2
STRB3 CSATD 03 REVISED FOR REV-02 ARTWORK PER ECN 1244. GP 1-23-03
STRB3 CSATD
R/W HONK 04 REVISED PER ECN 1261. GP 3-17-03
OPTIONS REFERENCE INSTALLED NOT INSTALLED R/W HONK
DS BEEP 05 REVISED FOR REV-03 ARTWORK PER ECN 1262. GP 3-17-03
DS BEEP
OPTION A R201 3000, 3050, 3100 3200 AS T150 06 REVISED FOR REV-04 ARTWORK PER ECN 1294. GP 7-29-03
AS T150
OPTION B R210 FOR FUTURE USE FOR FUTURE USE 1.8MHZ HONKD 07 REVISED FOR REV-05 ARTWORK PER ECN 1308. GP 11-10-03
1.8MHZ HONKD
OPTION C R211 FOR FUTURE USE FOR FUTURE USE EVENT /WRT 08 REVISED PER ECN 1309. GP 11-10-03
EVENT /WRT
VCC IRQ5 /RD 09 REVISED PER ECN 1312. GP 11-26-03
IRQ5 /RD
IACK5 CS2 10 REVISED PER ECN 1319. GP 1-9-04
SW3 IACK5 CS2
11 REVISED FOR REV-05A ARTWORK PER ECN 1422. GP 3-29-05
20
D 492008 A[0..21] 2US
2US
HONK HONK D
VCC
15 2 4 1A1 1Y1
16 D9 D[0..15] RESET
1A2 1Y2 D10 13 REVISED PER ECN 1564. GP 1-8-07
14 3 6 14 RES
RES
13 4 8 1A3 1Y3
12 D11
1A4 1Y4 D12 14 REVISED PER ECN 1623. GP 7-9-07
SWITCH ON OFF 12 5 11 9 DSACK1
DSACK1
11 6 13 2A1 2Y1
7 D13
2A2 2Y2 D14 -12V 15 REVISED PER ECN 1628. GP 2-14-08
10 7 15 5 RECRDY
RECRDY -12V -12V
SW3-1 3050, 3100, 3200 3000, 3240 (SLAVE) 9 8 17 2A3 2Y3
3 D15
2A4 2Y4 PPR
PPR +12V
GND
SW3-2 MONITOR DEFAULTS TRIGGER DEFAULTS D 1 +12V +12V
19 1G CAL TP16
2G CAL
SW3-3 ECG FILTER ON ECG FILTER OFF R213 R215 R217 R219 U49 AZ DGND
AZ +5V +5V
10
SW3-4 PACER DETECT ON PACER DETECT OFF 10K 10K 10K 10K CD74HCT244M DGND
RDOSW U33 GND DGND
SW3-5 ECG SIMULATOR ON ECG SIMULATOR OFF CY7C1009-20VC VCC
R214 R216 R218 R220 D A0 D8 VCC VCC D
SW3-6 TRIG POLARITY ON TRIG POLARITY OFF 12 A0 D0 13
10K 10K 10K 10K A1 11 A1 D9
A2 D1 14 D10 C76
SW3-7 TOSHIBA FILTER ON TOSHIBA FILTER OFF 10 A2 D2 15 -8V -8V TP17
A3 9 A3 D11
A4 D3 17 D12 AGND
SW3-8 FOR FUTURE USE FOR FUTURE USE VCC 8 A4 D4 18 SPK-B
A5 7 A5 D13 AGND
A6 D5 19 D14 680PF NPO AGND
6 A6 D6 20
A7 5 A7 D15
A8 D7 21 LOVLA
27 A8 A
A9 26 A9 CS3 3
A10 CS1 22 R141 2 J110
23 A10 CS2 30
VCC A11 25 A11 1 SPEAKER
A12 4 /WRT +5V 60.4K
A13 WE 29 /RD R195
28 A12 OE 24
A14 A13
3 A14 3.32K
A15 31 A15 R142 SPK-A
R221 A16 NC 1 1 SDWN VO2 8
2 A16 10K C79 2 BYPS GND 7 VCC
10K R143 R144 R145 3 6
HONK +IN VDD
16 GND VCC 32 VCC 4 -IN VO1 5
C80
10K 2K 20K .1UF CER
D .01UF 63V C82 U35 C83
1
VCC D C84 MP 2824 .1UF LM4861M
VCC HONKD G3 CER D
R148 R147 .1UF
.22UF 63V Q18 32.4K A A
4.99K +5V CER
R140 VCC VCC R151 MMBF5460LT1
2
KEALRO
R150 MP 2824
KESFT1
KESFT3
KESFT4
KESFT2
DSACK1 VCC 1.47M D30 S C85 +5V
5
KESFT5
4.99K 10K
IACK5
A0 C78 MMBD4148 .01UF 63V
C77
D15
D12
D11
Vcc
D14
D13
D10
DSACK0 VCC MP 2824
D9
D7
D6
D5
.1UF CER .1UF CER
D8
D4
D3
D2
D1
D0
C BR R154 C
1
D C86
GND
VCC DSACK0
U34 1 DU DQ0 21 D0 3G T150
SN74AHC1G04DCK R149 10K A1 24 20 D1 R196 R156
C81 D A2 A0 DQ1 BEEP
144
143
142
141
140
139
138
137
136
135
134
133
132
131
130
129
128
127
126
125
124
123
122
121
120
119
118
117
116
115
114
113
112
111
110
109
RESET 25 A1 DQ2 19 D2 .033UF 63V
.1UF CER A3 26 18 D3
3
2
TP24 R191 10K A4 27 A2 DQ3
17 D4 4.02K 4.02K MP 2824
IRQ5 A5 28 A3 DQ4
16 D5 R159 S D31
R157
DSACK1
DSACK0
A0
A31/IACK7
A30/IACK6
A29/IACK5
A28/IACK4
A27/IACK3
A26/IACK2
A25/IACK1
A24
D15
D14
D13
D12
D11
D10
D9
D8
D7
D6
D5
D4
D3
D2
D1
D0
GND
VCC
GND
VCC
GND
GND
VCC
GND
VCC
LN FREQ D D A6 29 A4 DQ5
15 D6 10K R197 R160 MMBD4148
R192 10K A7 30 A5 DQ6
14 D7 2K 4.02K 1.47M
IRQ7 A8 31 A6 DQ7
11 D8
50HZ CS0 A9 A7 DQ8 D9
50HZ CS0/AVEC 108 32 A8 DQ9 10 +5V
1 107 CS1 R152 10K A10 35 9 D10 LOVL
R/W 2 RMC CS1/IRQ2
106 CS2 A11 36 A9 DQ10
8 D11
R/W CS2/IRQ2 A12 A10 DQ11 D12
3 SIZ1 IRQ3 105 37 A11 DQ12 7 D
4 104 CS3 R153 10K A13 38 6 D13
DS SIZ0 CS3/IRQ4 A14 A12 DQ13 D14
5 DS GND 103 39 A13 DQ14 5
AS 6 102 A15 40 4 D15
BGACK 7 AS VCC
101 IRQ5 R155 10K A16 41 A14 DQ15
VCC 8 BGACK IRQ5
100 DONE2 A15
22 /RD
RESET BR 9 BG IRQ6
99 IRQ7 12 /OE
3 CS0 VCC
DS BERR BR IRQ7 DONE2 GND /CE
R190 10 98 R158 10K 34 R164
BERR HALT 11 BERR DONE2
97 DONE1 GND
44 VCC
RESET 12 HALT DACK2
96 BREQ D 23 VCC
33 VCC
10K RESET /DREQ2 DONE1 DU NC 47.5 OHM C88 D32
13 95 R161 10K VCC 2 43
14 GND DONE1
94 HALT VPP /PGM 1UF 63V MBR0520LT1
CLKOUT DACK1
15 93 SOCKET MP 2824
16 VCC U37 DREQ1
92 44 PIN
XFC X1
17 VCC MC68340FE16 GND 91 A
18 90 R165 CONNECTIONS
9
7
5
3
1
EXTAL VCC D0
19 VCCSYN X2 89 VCC 15 DB0 VIN 1 NOTCHX1000
20 88 D1 16
WITH SW2 IN
IF /RE
GD2
BK GD1
/IP VCC
BER DS
21 XTAL SCLK
87 COMCTS R163 D2 17 DB1 0 OHM
J111 22 GND CTSB
86 COMRTS VCC D3 18 DB2
FRZ
4
10
27 BKPT RXRDYA
81 -SINEN M48T58SOH28 D8 23 DB7
4 CER J108
Vcc
28 FREEZE CTSA
80 -SOUTEN D9 24 DB8 AVCC U4A AUX
4
TIN1 RTSA D DB9 A
28
29 TOUT1 GND 79 D10 25 DB10 TL064ACD R167
30 78 3 D11 26 R168 2 1
31 TGATE1 VCC
77 SIN OUT
1 19 D15 D12 27 DB11
5 1 - VCC 1
6 TRIGGER_OUT
VCC
TCK TXDA SOUT A12 FT DQ7 DB12 V- 15.8K GND 6
GND
32 76 2 18 D14 3 2
33 TMS RXDA
75 A11 23 A12 DQ6
17 D13 /WRT 7 47.5 + 2
7 XOFF
34 TDI TIN2
74 A10 21 A11 DQ5
16 D12 /RD 11 WR C91 OHM -8V 3 7
A
11
WITH1 35 TDO TOUT2
73 WITH2 R166 A9 24 A10 DQ4
15 D11 CSATD 10 RD
28 1UF 63V 3
8 +5V
36 VCC TGATE2 A8 25 A9 DQ3
13 D10 2US 8 CS DVCC
MP 2824 DCNCT- 4 8
2
B GND 100 OHM A7 3 A8 DQ2
12 D9 12 CLKIN
6 AZ 4
9 B
A6 A7 DQ1 EOC AZ C11 9
GND
GND
GND
GND
GND
4 11 D8 13 9 CAL 5
VCC
VCC
VCC
VCC
TEST
FC3
FC2
FC1
FC0
A23
A22
A21
A20
A19
A18
A17
A16
A15
A14
A13
A12
A11
A10
A3
A2
A1
1.8MHZ D A4 A5 -12V
6 20
DGND
AGND
A4 /E1 CER
VCC A3 7 26 U39
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
A2 A3 E2
16US 8 A2 /G 22 A
VCC A1 9 27 5216-00-01 R169
A0 A1 /WRT
10
16MHZ
*
VSS
14
A0
3
C89 15.8K
C90
/WRT
D .1UF CER D A
14
*
CS1
VCC VCC
/RD
VCC J108
A9
A8
A7
A6
A5
A4
A2
A1
A3
D
A18
A17
A16
A15
A14
A13
A12
A11
A10
18
MEA8020T10R0 1
7
1
BATTERY 6
COMTX 2 5 9 8 TXD 2 6
VCC
COMRTS 1 T1IN T1OUT
18 2
7 CTS
T2IN T2OUT RXD 7
J109-3 10 7 X1000_OUT 3
+5V OPTION A
3
8 RTS
CRDSW 3 4 11 6 4 8
R1OUT R1IN 4
+5V +5V OFF 20 R2OUT R2IN 19 9 9
R201 12 5 5 5
1 21 R170 ON 0 OHM
KEALRO
KEALRO
1 21 COMCTS
KESFT1
KESFT2
KESFT3
KESFT4
KESFT1
KESFT2
KESFT3
KESFT4
2 22 12 13 4
KESFT5
KESFT5
R171 3 2 22
23 470K KESFT1 C2+
15
4 3 23
24 SIN ON/OFF STRB1 KESFT2 13 C2+
11 14 3
470K 5 4 24
25 SOUT KESFT3 14 C1+ C2-
16
6 5 25
26 STRB2 KESFT4 10 C1- C2-
15 2
D 7 6 26
27 -SOUTEN KESFT5 17 V-
9
PPR 8 7 27
28 -SINEN KEALRO R173 8 V- GND
6 16 1
8 28 10K V+ GND
9 9 29 29 R174
10 30 RECRDY 10K
11 10 30
31 RES SF5 R176 U40
R175
17
11 31
12 12 32 32 MEA8020T10R0 R177 R178 MAX233ACWP
13 33 10K 10K
14 13 33
34 10K 10K
+12VREC
8
7
5
3
2
1
6
4
15 14 34
35 D NOTES:
+
C93* 16
17
18
15
16
17
35
36
37
36
37
38
R181
470K
R182
470K
VCC
1
J113
2 +12V 1. ALL RESISTORS ARE 1/10W, 1%, SIZE 0805 U.O.S.
+12V
1
2
3
4
5
6
7
8
6800UF 16V 19 18 38
39 17 18 D 3 4
19 39 ALL .1UF CER CAPACITORS ARE SIZE 0805 U.O.S.
20 40 +5V 5 6
IN
IN
IN
IN
IN
IN
IN
-V
RECGND 20 40
7 8 D
U48
10
12
14
15
16
11
13
9 10 2.
* INDICATES A THROUGH HOLE COMPONENT.
9
RECORDER
IN
IN
IN
IN
IN
IN
IN
1
2
3
4
5
6
7
8
RF1,RV3,T1,TP25,SF8,SW3,U49,Y2.
16
15
14
13
12
11
10
A
MODEL 3150 ONLY 3 A
9
R210 4
VCC ADD A 2nd SP720AB 5
VCC 0 OHM SF7 4. NOT USED: C95,Q2,R11,R17,R60,R162,R172,R202,
6
V+
TP23
IN
IN
IN
IN
IN
IN
IN
U41 Q20 9
9
8 7 ACH3218-472 17
VB RS R222 D (203) 481-4183
1K -8V 16
DWN: GP 2/12/02 CHK: GC 2/12/02 APR: RAM 2/12/02
R180
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
806 OHM
3
1K D TRIGGER_OUT Title
SW2 SHOWN ADULT 3 LEAD ECG & PEAK DETECTOR BOARD
J102 D
D D IN "COM" Size Document Number Rev
FRONT PANEL D 5148-00-01 (-03 SCHEMATIC) 15
POSTION
Date: Friday, February 15, 2008 Sheet 3 of 4
5 4 3 2 1
5 4 3 2 1
REVISIONS
REV DESCRIPTION BY DATE
01 REVISED FOR REV-01 ARTWORK PER ECN 1138. GP 2-12-02
02 REVISED PER ECN 1166. GP 3-5-02
03 REVISED FOR REV-02 ARTWORK PER ECN 1244. GP 1-23-03
J103 04 REVISED PER ECN 1261. GP 3-17-03
+5V
INVPWR
05 REVISED FOR REV-03 ARTWORK PER ECN 1262. GP 3-17-03
1
2 06 REVISED FOR REV-04 ARTWORK PER ECN 1294. GP 7-29-03
3
PGND 4 07 REVISED FOR REV-05 ARTWORK PER ECN 1308. GP 11-10-03
08 REVISED PER ECN 1309. GP 11-10-03
va[0..16] 09 REVISED PER ECN 1312. GP 11-26-03
10 REVISED PER ECN 1319. GP 1-9-04
D 11 REVISED FOR REV-05A ARTWORK PER ECN 1422. GP 3-29-05 D
4
A0
wa1 9 A1 D1 12
wd1
wa2 8 D2 13
wd2
+5VDC
A2
HONK
wa3 7 A3 D3 15
wd3
wa4 6 D4 16
wd4 R185
PPR
LNFREQ
de
5 A4 CLOCK
D5 17 3
wa5 wd5
A5 OUT
wa6 4 D6 18
wd6
wd11
wd14
A6 100 OHM
161 hsynch
GND
3 D7 19
vd12
vd11
vd15
wa7 wd7
Data0
wd3
wd2
wd6
wa9
A15
A14
A10
A11
wa14
wa11
wa10
wa12
A7
vd2
vd1
vd6
vd5
vd9
wa8 25 Y2
A1
166 VCCIO
A6
A4
A5
GND
D11
D10
D15
D14
wa6
wa7
wa8
VCCIO
184 dclk
A8
199 GND
205 va9
160 va5
24 20
VCCIO
wa9
D1
D5
D4
D7
A9 CE EMC60S5B-048
165 GND
wa10 21 A10 OE 22
wa11 23 27
2
A11 WE
wa12 2 A12
208
207
206
204
203
202
201
200
198
197
196
195
194
193
192
191
190
189
188
187
186
185
183
182
181
180
179
178
177
176
175
174
173
172
171
170
169
168
167
164
163
162
159
158
157
wa13 26 A13
wa14 1 wram_we
A14
14 28
dclk
wram_cs
wave_add14
wave_add11
wave_add10
vram_add9
hd1
hd5
hd4
hd7
hd11
hd10
hd15
hd14
VCCIO
GND
video_data2
video_data1
video_data6
video_data5
video_data9
wave_data12
wave_data11
wave_data15
wave_data3
wave_data2
data0
host_add15
host_add6
host_add14
host_add10
host_add11
host_add4
host_add5
hsynch
VCCIO
GND
wave_data6
wave_add9
4KHZ
PPR
DE
WD11
VCCIO
GND
WD14
wave_add6
host_add1
vram_add5
wave_add12
wave_add7
wave_add8
wram_we 1 156 wa13 DGND VCC VCC
green1 wram_we wave_add13 va3
2 green1 vram_add3 155
green2 3 green2 vram_add4 154 va4
DTRG 4 153 VRAM_CS
A18 5 DTRG vram_cs
152 DCNCT- U45
6 host_add18 DCNCT-
151 vsynch CY7C199-12VI
VCC 7 ^nCE vsync
150 conf_done 10 D0 11
GND wa0 wd8
8 GND CONF_DONE
149 VCCIO R203 9 A0
D1 12
VCCINT wa1 wd9 VCC
VCCIO VCCINT VCCIO VCCINT 1K A1
9 VCCIO VCCINT 148 wa2 8 A2 D2 13
wd10
A16 10 147 GND 7 D3 15
wa3 wd11
R205 A17 11 host_add16 GND
146 6 A3
D4 16
wa4 wd12
10K STRB1 host_add17 XOFF va2 A4
LOVLA 12 STRB1 vram_add2 145 CMPD6263
wa5 5 A5 D5 17
wd13
13 144 /WRT 4 D6 18
wa6 wd14
GATF 14 LOVLA /WRT
143 va16 D34 3 A6
D7 19
wa7 wd15
IRQ5 GATF vram_add16 va15 A7
15 eow_int vram_add15 142 R204 wa8 25 A8 R186 R187
16 141 va1 wa9 24 20 U44 VCC
WD13 SHFT vram_add1 wa0 1K A9 CE WRAM_OE 10K 10K
17 WD13 wave_add0 140 wa10 21 A10 OE 22 2683-01-04
1.8MHZ 18 139 wa2 wa11 23 27
SHFT L1 19 1.8MHZ wave_add2
138 wa5 VCC XOFF wa12 2 A11 WE
CAL L1 wave_add5 wa4 A12 Data0
20 CAL wave_add4 137 wa13 26 A13 1 Data VCC 8
SAMPLE 21 136 wa3 wa14 1 wram_we dclk 2 7 C97
2US SAMPLE wave_add3 wa1 A14 nstatus DCLK VCC
22 2US wave_add1 135 R208 3 OE nCASC 6 .1UF CER
LOVL 23 U43 134 RES 14 28 conf_done 4 5
RESET 24 LOVL RES
133 DOUT 10K DGND VCC VCC nCS GND
clear DOUT
C GND 25 GND EPF6016QC208-2 MRKIN 132 C
VCCINT 26 VCCINT VCCIO 131 VCCIO
VCC
VCCIO 27 VCCIO VCCINT 130 VCCINT
VCC
clock 28 129 GND U46 SOCKET
LOD
CSATD
T150
29
30
31
clock
CSATD
LOD
T150
GND
intack5
host_cs3
ds
128
127
126
IACK5
cs2
ds R224
R199 va0
CY7C1009-20VC
12 A0 D0 13
vd0
8 PIN
*
AZ 32 125 RDOSW 10K 11 A1 D1 14
va1 vd1
NOTCH- AZ RDOSW as 10K
33 NOTCH- as 124 va2 10 A2 D2 15
vd2
dsack1 34 dsack1 CTSET 123 CTSET va3 9 A3 D3 17
vd3
RECRDY 35 122 8 A4 D4 18
va4 vd4
HONKD RECRDY RSPWRT r/w
36 HONKD r/w 121 va5 7 A5 D5 19
vd5
green5 37 green5 VRAM_WE 120 vram_we R211 va6 6 A6 D6 20
vd6
green3 38 119 red5 OPTION va7 5 A7 D7 21
vd7
blue3 39 green3 red5
118 blue1 0 OHM va8 27 A8
blue2 40 blue3 blue1
117 STRB3 C 26 A9 CS1 22
va9
blue4 blue2 STRB3 STRB2
41 blue4 STRB2 116 va10 23 A10 CS2 30
green4 42 green4 red1 115 red1 va11 25 A11
GND 43 GND red2 114 red2 va12 4 WE 29
vram_we
VCCINT 44 VCCINT red3 113 red3 va13 28 A12
A13 OE 24
VRAM_CS
VCCIO 45 VCCIO VCCIO 112 VCCIO va14 3 A14
46 MSEL VCCINT 111 VCCINT va15 31 A15 NC 1 VCC
blue5 47 blue5 GND 110 GND va16 2 A16
va14 48 109 red4
video_data10
video_data13
video_data14
wave_data0
wave_data1
wave_data4
wave_data5
wave_data7
host_add13
host_add12
WRAM_CS
vramadd10 L0 GND VCC
vramadd13
vram_add8
25_MHz 50 host_add3 107 va0 R/W
host_add9
host_add8
host_add2
host_add7
va11 25MHz vram_add0 va6
51 vramadd11 vram_add6 106 R/W
16MHZ
nconfig
nstatus
VCCIO
VCCIO
VCCIO
va12 52 105 va7 DS
BREQ
WD12
WD10
WD15
PACE
22MS
2KHZ
16US
vramadd12 vram_add7
WD8
WD9
GND
GND
GND
hd12
hd13
PDO
DS
/RD
hd0
hd2
hd3
hd6
hd8
hd9
AS
U47 AS
100
101
102
103
104
CY7C1009-20VC 1.8MHZ
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
1.8MHZ
va0 12 A0 D0 13
vd8 EVENT
va1 11 A1 D1 14
vd9 EVENT
nstatus
16US
va13 va8 10 A2 IRQ5
D2 15
va2 vd10
WRAM_OE
VCCIO
wd8
wd9
vd10
vd13
vd14
VCCIO
GND
GND
GND
D12
D13
wd0
wd1
wd4
wd5
wd7
A13
A12
9 A3 D3 17
VCCIO
va3 vd11
vd0
vd3
vd4
vd7
vd8
IRQ5
A7
D0
D2
D3
D6
D8
D9
A3
A9
A8
A2
PDO
va4 8 A4 D4 18
vd12 IACK5
va5 7 A5 D5 19
vd13 IACK5
R188 va6 6 A6 D6 20
vd14 2US
BREQ
22MS
/RD
16MHZ
PACE
BEEP
va7 5 A7 D7 21
vd15 2US
wd12
wd15
va9 26 A9 CS1 22 RESET
vd[0..15]
va10 23 A10 CS2 30
RES
va11 25 A11 RES
va12 4 WE 29
vram_we 16MHZ
va13 28 A12
A13 OE 24
VRAM_CS 16MHZ
va14 3 A14 DSACK1
va15 31 A15 NC 1 VCC DSACK1
va16 2 A16 RECRDY
B B
RECRDY
16 GND VCC 32 PPR
CAL PPR
AZ
CAL
red[0..5] AZ
green[0..5] CSATD
blue[0..5] CSATD
1 HONK
hsynch 2
vsynch 3 BEEP
HONK
SF4 4
A[0..21] ACH3218-101 5 T150
BEEP
25_MHz
SF3 red1 6
red2 7 HONKD
T150
D[0..15] 0 OHM 1206 red3 8
red4 9 /WRT
HONKD
D red5 10
11 /RD
/WRT
12 J104 /RD
green1 13 DISPLAY CS2
green2 14
green3 15 191501 RDOSW
CS2
16US green4 16
16US green5 17 RDOSW
PACE 18
PACE 19
L1 blue1 20
L1 blue2 21
LO blue3 22
L0 blue4 23
PDO blue5 24
PDO 25
22MS DE 26 NOTES:
22MS 27
D 28
29 1. ALL RESISTORS ARE 1/10W, 1%, SIZE 0805 U.O.S.
SAMPLE 30 VCCINT ALL .1UF CER CAPACITORS ARE SIZE 0805 U.O.S.
SAMPLE 31
8
7
6
5
LNFREQ
NOTCH-
LNFREQ
NOTCH- +5V
VCCIO 2.
* INDICATES A THROUGH HOLE COMPONENT.
1
2
3
4
A STRB3 A
STRB3 J114
CTSET C94 TP18
CTSET +
10V 3528
210067
DISPLAY DGND VIDEO AND
10UF TANT GND LUG DGND DGND
DOUT
DOUT GATF
1
GND
MEMORY
LOD
LOD D 2 D
SHFT
SHFT IVY BIOMEDICAL SYSTEMS INC.
RDOSW D 11 BUSINESS PARK DRIVE
RDOSW TP19
AGND BRANFORD, CT., 06405 USA
DTRG AGND
(203) 481-4183
DTRG AGND
DWN: GP 2/12/02 CHK: GC 2/12/02 APR: RAM 2/12/02
DCNCT-
DCNCT- Title
XOFF A ADULT 3 LEAD ECG & PEAK DETECTOR BOARD
XOFF
Size Document Number Rev
D 5148-00-01 (-03 SCHEMATIC) 15
Date: Friday, February 15, 2008 Sheet 4 of 4
5 4 3 2 1
8 7 6 5 4 3 2 1
REVISIONS
REV DESCRIPTION BY DATE
01 REVISED FOR REV-01 ARTWORK PER ECN 1244. GP 1-23-03
02 REVISED FOR REV-02 ARTWORK PER ECN 1260. GP 3-11-03
03 REVISED PER ECN 1282. GP 6-24-03
04 REVISED PER ECN 1307. GP 11-7-03
05 REVISED FOR REV-03 ARTWORK PER ECN 1950. GP 4-14-11
D D
ECG
J1
C
D
A
B
E
F
FB5 FB7
150013 150013
C FB6 FB8 C
150013 150013
FB1 FB2
150014 150014 FB4 FB3
150014 150014
RA
LA
LL
SHIELD_DR
B B
1
2
3
4
J2
174014
A A
Title
ECG ISOLATED INPUT BOARD
Size Document Number Rev
A 5150-00-01 (-03 SCHEMATIC) 05
Date: Thursday, April 14, 2011 Sheet 1 of 1
8 7 6 5 4 3 2 1
5 4 3 2 1
REVISIONS
F3 REV DESCRIPTION BY DATE
+12V 01 REVISED FOR REV-01 ARTWORK PER ECN 1140. G PEERS 2-13-02
02 REVISED FOR REV-02 ARTWORK PER ECN 1141. G PEERS 2-13-02
500mASB 03 REVISED FOR REV-03 ARTWORK PER ECN 1244. G PEERS 1-23-03
R1 R2 04 REVISED PER ECN 1270. G PEERS 5-29-03
R3 05 REVISED PER ECN 1368. G PEERS 7-12-04
10K 806 OHM 06 REVISED FOR REV-05 ARTWORK PER ECN 1369. G PEERS 7-12-04
2 OHM 1W
2512 5%
2
GROUNDED 1 Q1
CMPT3906
Q2
CMPT3906
1 ISOLATED
R4
3
10K
D R5 D D
D 1K D
2
1
Q3
F1 MMBT3904LT1
3
TP1
J101 D1 +5VI_E
174012 2ASB 2AG VI J102
2
GBU4G
173001 D2 D3
~
1 4 1 BZT52-C16
2 - + 1 C3
3 2 + R6 16V
~
180UF TANT MBRS340T3 C4
4 + C1 + C2 3 16V SIZE-R 4.02K 180UF TANT + TP2
F2 4700UF 4700UF E_GND
16V SIZE-R
3
LOW ESR
50V AXIAL 50V AXIAL 5 D4 1 5 LOW ESR
2ASB 2AG MBRS340T3 7
PGND Vin
Switch 4 4 8
T1 I
D D 1 Comp 2532-00-10 U2
Feedback 2 LM3411M5-5.0
50/60HZ
Gnd
R7
U1 5 Out IN 1
3
LM2587S-ADJ 1K C5
.1UF CER 2
0805 GND
D U3
CNY17-3SM 4 Comp
C
NC 3 C
2
C7
C6 .1UF CER
0805
1
I
D
+5V R8
2
10K
TX J103 R9
U4 1
182002 HCNW2601-300 1K
Q4
J104 +12V 2 1 +12V COMTX R10 8
3
4 3 7 VCC 2 CMPT3906
180006 COMRTS 2K
6 5
1 2 8 7 CRDSW 6
3 4 CTS 10 9 CTSET
5 6 RTS +5V 12 11 +5V 3
7 8 14 13 C8 5
9 10 GND
.1UF CER R11
0805 499 OHM
D
D I J105
RX
+5V 170505
+5VI_ETHER 1 2 IGND_ETHER
R12 RXD_ETHER 3 4 TXD_ETHER
RTS_ETHER 5 6
10K CTS_ETHER 7 8
2
R13 U5 9 10
B
1 HCNW2601-300 11 12 B
1K VCC 8
Q5 R14 ETHERNET
2 7
3
CMPT3906 1K
6
3 C9
GND 5
R15 .1UF CER
499 OHM 0805
D I
+5V
R16
U6
2
10K
HCNW2601-300 R17
1
R18 8 VCC 1K
7 2 Q6
2K
3
CMPT3906
6
3
C10 5 GND
.1UF CER R19 NOTES:
0805 499 OHM 1. LAST USED: C11,D4,F3,J105,Q7,R23,T1,TP2,U7.
D I
+5V 2. NOT USED:
R20
3. ALL RESISTORS ARE 1/10W, SIZE 0805 UNLESS
A A
10K OTHERWISE SPECIFIED.
2
R21 U7
1 HCNW2601-300
1K
Q7 VCC 8 IVY BIOMEDICAL SYSTEMS INC.
2 7 R22 11 BUSINESS PARK DRIVE
3
REVISIONS
F3 REV DESCRIPTION BY DATE
+12V 01 REVISED FOR REV-01 ARTWORK PER ECN 1140. G PEERS 2-13-02
02 REVISED FOR REV-02 ARTWORK PER ECN 1141. G PEERS 2-13-02
500mASB 03 REVISED FOR REV-03 ARTWORK PER ECN 1244. G PEERS 1-23-03
R1 R2 04 REVISED PER ECN 1270. G PEERS 5-29-03
R3 05 REVISED PER ECN 1368. G PEERS 7-12-04
10K 806 OHM 06 REVISED FOR REV-05 ARTWORK PER ECN 1369. G PEERS 7-12-04
2 OHM 1W
2512 5% 07 REVISED FOR REV-06 ARTWORK PER ECN 1787. RM 6-16-09
08 REVISED FOR REV-07 ARTWORK PER ECN 1950. G PEERS 4-14-11
09 REVISED FOR REV-08 ARTWORK PER ECN 2023. G PEERS 9-16-11
2
GROUNDED 1 Q1
CMPT3906
Q2
CMPT3906
1 ISOLATED 10 REVISED FOR 5151-01-02 REV-00 ARTWORK PER ECN 2042.GPEERS 12-27-11
R4
3
10K
D R5 D D
D 1K D
2
1
Q3
F1 MMBT3904LT1
3
TP1
J101 D1 +5VI_E
174012 2ASB 2AG VI J102
2
GBU4G
173001 D2 D3
~
1 4 1 BZT52-C16
2 - + 1 C3
3 2 + R6 16V
~
LOW ESR
50V AXIAL 50V AXIAL 5 D4 1 5 LOW ESR
2ASB 2AG MBRS340T3 7
PGND Vin
Switch 4 4 8
T1 I
D D 1 Comp 2532-00-10 U2
Feedback 2 LM3411M5-5.0
50/60HZ
Gnd
R7
U1 5 Out IN 1
3
LM2587S-ADJ 1K C5
.1UF CER 2
0805 GND
D U3
CNY17-3SM 4 Comp
C
NC 3 C
2
C7
C6 .1UF CER
0805
1
I
D
+5V R8
2
10K
TX J103 R9
U4 1
182002 HCNW2601-300 1K
Q4
J104 +12V 2 1 R10 8
3
+12V COMTX VCC CMPT3906
180006 4 3 7 2
6 5 COMRTS 2K
1 2 8 7 CRDSW 6
3 4 CTS 10 9 CTSET
5 6 RTS +5V 12 11 +5V 3
7 8 14 13 C8 5
9 10 GND
.1UF CER R11
0805 499 OHM
D
D I J105
RX
+5V 170505
+5VI_ETHER 1 2 IGND_ETHER
R12 RXD_ETHER 3 4 TXD_ETHER
RTS_ETHER 5 6
10K CTS_ETHER 7 8
2
R13 U5 9 10
B
1 HCNW2601-300 11 12 B
1K VCC 8
Q5 R14 ETHERNET
2 7
3
CMPT3906 1K
6
3 C9
GND 5
R15 .1UF CER
499 OHM 0805
D I
+5V
R16
U6
2
10K
HCNW2601-300 R17
1
R18 8 VCC 1K
2K
7 2 Q6
3
CMPT3906
6
3
C10 5 GND
.1UF CER R19 NOTES:
0805 499 OHM 1. LAST USED: C11,D4,F3,J105,Q7,R23,T1,TP2,U7.
D I
+5V 2. NOT USED:
R20
3. ALL RESISTORS ARE 1/10W, SIZE 0805 UNLESS
A A
10K OTHERWISE SPECIFIED.
2
R21 U7
1 HCNW2601-300
1K
Q7 VCC 8 IVY BIOMEDICAL SYSTEMS INC.
2 7 R22 11 BUSINESS PARK DRIVE
3
REVISIONS
F3 REV DESCRIPTION BY DATE
+12V 00 INITIAL RELEASE PER ECN 2042. G PEERS 12-27-11
01 REVISED PER ECN 2045. G PEERS 12-30-11
500mASB ASSY SMT
R1 R2
R3 10K 0805 806 OHM 0805
2 OHM 1W 2512 5%
2
GROUNDED 1 Q1
CMPT3906
Q2
CMPT3906
1 ISOLATED
3
R4
10K 0805
D R5 D D
1K 0805
D D
2
1
Q3
F1 MMBT3904LT1
3
TP1
J101 D1 +5VI_E
174012 2ASB 2AG VI J102
2
GBU4G
173001 D2 D3
~
1 4 1 BZT52-C16
2 - + 1
3 2 C3 + R6 16V
~
2
C7
C6
.1UF CER 0805
1
I
TX J103 +5V
182002
J104 +12V 2 1 +12V COMTX
180006 4 3 C9
6 5 COMRTS C8 .1UF CER 0805
1 2 8 7 CRDSW
3 4 CTS 10 9 CTSET U4 C10 C11
5 6 RTS +5V 12 11 +5V 1 16 22UF X5R 10% 1206
.1UF CER 0805
7 8 14 13 2 VDD1 VDD2 15
9 10 3 GND1 GND2 14
4 VIA VOA 13
COMTX_B 5 VIB VOB 12
D VOC VIC
6 VOD VID 11
7 10 J105
RX COMREC_B +5V VE1 VE2
8 GND1 GND2 9 170505
+5VI_ETHER 1 2 IGND_ETHER
ADuM2402ARWZ
3 4 TXD_ETHER
5 6
U5 CTS_ETHER 7 8
1 16 9 10
+5V 2 GND1 GND2 15 11 12
B NC NC B
3 VDD1 VDD2 14
4 VOA VIA 13 C12 C13 ETHERNET
C15 5 VIB VOB 12 22UF X5R 10% 1206
C14 .1UF CER 0805 6 11 .1UF CER 0805
7 NC NC 10
GND1 NC ETHER_B_REC
8 NC GND2 9 ETHER_B_XMT
ADuM2201ARWZ
D I
NOTES:
1. LAST USED: C15,D4,F3,J105,Q3,R7,T1,TP2,U5.
2. NOT USED:
REVISIONS
REV DESCRIPTION BY DATE
01 REVISED PER ECN 1306. GP 11-7-03
02 REVISED PER ECN 1330. GP 3-8-04
03 REVISED PER ECN 1650. GP 3-21-08
VCC
D D
R1
C1
C2
10 OHM +
6.8UF TANT .1UF
20V 3528 CER
VCC R2
3.01K
R3 R4 R5
2K 332K 332K
VCC
+ C6 C7 +12V
6.8UF TANT .1UF
20V 3528 CER
R6 R7 R8
VCC U1 SF1
8
10K 10K 10K ACH3218-472
C J1 8 REF VDD 7 2 R9 E1 C
R10 LL
SHFT LOD
4 /CLR 1 LL
1 6 3
1 2 /LD VOUT
U2A 200K
DOUT 3 4 KEYING PLUG
5 10K C3 R11
VCC 5 6 GND
.1UF TL062ACD 49.9 OHM
4
7 8 2 CLK
+12V -12V
9 10 CER SF2
3 SDI ACH3218-472 E2
170513 -12V R12 LA
+12V LA
AD7391AR 100 OHM
C5 -12V
.1UF C4
CER .1UF SF3
CER ACH3218-472 E3
RA
6 _ RA
7
5 +
VCC
U2B
U3 TL062ACD
B 16 V+ IN 1 B
15 IN IN 2
14 IN IN 3
13 IN IN 4
12 IN IN 5
11 IN IN 6
10 IN IN 7
9 IN -V 8
SP720AB
REVISIONS
REV DESCRIPTION BY DATE
01 REVISED FOR REV-01 ARTWORK FAB. GP 1-8-07
02 REVISED PER ECN 1623. GP 7-9-07
R263 R261 03 REVISED FOR REV-02 ARTWORK FAB PER ECN 1629. GP 2-15-08
04 REVISED PER ECN 1678. GP 6-27-08
51.1K 137K
05 REVISED PER ECN 1679. GP 6-27-08
C119
-12V 06 REVISED PER ECN 1797. GP 9-17-09
RBW ECG 07 REVISED PER ECN 1821. GP 1-18-10
.033UF 50V
TP27 REVISED FOR REV-04 ARTWORK FAB PER ECN 1844. RM
4
C121 R264 MP 2220 08 6-24-10
2 R262 R260 09 REVISED PER ECN 1870. RM 7-1-10
_ 1 6
1UF 63V 49.9K 3 + 7
137K 68.1K 5 10 REVISED PER ECN 1986. RM 7-6-11
MP 2824 U54A
TL062ACD 11 REVISED PER ECN 2023. GP 9-16-11
R19
8
A C120 U54B
.15UF 5% TL062ACD
X7R 1206 100K U53
+12V A
R291 MAX364CSE
14
D D
C10
1000PF 100K 0805
D2 A DNI 3 4
NO2
NPO NO1 V- -12V U4D
J116 MMBD1503A X500
RESP V+ 13 +12V TL064ACD
1 +6.5V 2 1 -6.5V A COM1 2 13 R16
RA - 14 X1000_OUT
2 16 15 12 X1000_OUT
3 LA FILTER 1 IN2 COM2 + 100
4 D1 IN1 OHM
R259
3
MMBD4148CC U1B 6 9
174014 +5V 7 NO4 IN3
TL062ACD 200K R258 COM4
1 R1 8
3
IN4 +5V
GND
3 5 200K 10 COM3
100K 7 1 11 NO3 VL 12
J101 +6.5V 2 6
ECG INPUT SHIELD D3 Q24
DRIVE +5VI
5
LA C1 +5VI MMBD4148 MMBT3904LT1
1 RA TP25 R2
2 LL
.1UF D4 +5VI A
3 SHIELD_DRIVE R7 CER 20K Q1 R4 U2B SAMPLE A
4 +5VI 80.6K R6
C96 10K R3 CMPT3906 LM393M 100K 50HZ
MMBD4148 R5
8
174019 I 30.1K 3 2 5 +
.01UF 100K +5VI +5V 60HZ
1% NPO + 3 7
1 _ 2 I 6 _
I I R12 C4
U1A 10K R9 R8 R10
1
TL062ACD R13 1K 3 2
+5VI 1K 14 NO1 COM1 15 NOTCH
4
5
.1UF 1% NPO NO4 COM4
R15 TP20 CER 6.8UF TANT I U5 1 C8
-6.5V R21 CER R193 R18 IN1
5.1K MELF 35V 7343 CNY17F-3X007 16 IN2
1W 2% 121K 9
8
R20 I D5 I 8.06K 787K .1% 8 IN3
.01UF NPO
4
22M I 3 + 50PPM 1206
IN4
5% I R27 1 12
4.75M 2 _ C9 +5V VL
MMBD4148 R24
U2A
GND
R22 R23 A 6 +12V 13 V+
80.6K LM393M - 7 -12V 4
5.1K MELF R25 5 V- 100K
.01UF
4
22M +
1W 2% 5% C7 1% NPO U4B 9
5
-5VI .1UF A TL064ACD U3 - 8
-5VI R26 10
CER MAX364CSE A +
SMCJ10CA D6 392K .1%
RA1 R28 MMBD1503A U4C
22M +6.5V I 50PPM 1206 A
2
5% +5VI I TL064ACD
2 1 C12 3 C13 NOTCH-
D36 .1UF R33 Q3
R31 C14 MMBF4393 .01UF 63V +5V R194 R29
R34 CER R32 60.4K R30
-5VI 100K .1UF MP 2824 6.04K 187K .1%
1
22M U6B 100K .1% 50PPM TRIGGER_OUT
CER 113K .1%
3
7
5 + I I LT1058SW 10K 170508 2
7 12 13 R37 3 C15 TP2 A 3
R38 TSTE ECG X1000
VD
1
NPO X3
LT1055S8 C18 49.9K J109-3
LA 1 C17 MP 2824 U10 NOTCHX1000
470PF
4
1
5
5 Y0 .01UF 63V U8 C19 CNY17F-3X007
R41 2 Y1 C20 NPO TP3 PDT2
+5VI Y2 MP 2824 R43
5.1K MELF Q4 4 R42 R40
2
6 Y3 -5VI 402K 22MS D7
1W 2% MMBF4393 -6.5V 680PF NPO
1
R44 10 INH U7
22M R45 A 10K .1% .1UF 2K MMBD1503A
VS
VE
8
7
3
1W 2% 5% 3 4 KEYING PLUG
9
.1UF CER R56 5 6 RADIO_CH0 R54
VCC 7 8
- 8
SMCJ10CA 16.2K R57 +12V -12V .0047UF MP R55 10
D10 9 10 + 10K
LA1 R58 10K 50V 1206 100K
22M MMBD1503A +6.5V D9 R59 +5VI 170513 D8 Q5
5% MMBD4148 A MMBD4148 MMBF4393
D37 2 1 C33 10 OHM +6.5V DOUT +12V A
U12 R223
2
.1UF C26
U6A .1UF IL300-X007 C27 3
R61 CER I Q6 R62 1 8 49.9K
22M
-5VI LT1058SW CER .1UF C28 A
D11 CMPT3906 249
3
+5V
8
R63 5% CER 680PF
MMBD4148CA OHM
1
NEO
4
2
49.9K I 2 I 2 7
R64 +12V NPO
8
3 + 1 1 3 6 5 + R65 +5V
1 1 3 7 2 A R267 RV3
2 - 3 R66 U13A 499 6 _ 1
+5VI A 100K 20K 5 TURN R67
13
12
C29 TL062ACD OHM 4 5 100K 3 R268
3
C30
3
220PF 2 1M I U14A ADULT THRESHOLD 909K
100K
4
U55
13
VL
-5VI
V+
LL C25 C32 C31 I TL062ACD A IN1 MAX364CSE
-6.5V 50V 1206
4
.1UF .1UF 220PF Q25 16
R68 NPO C34 IN2 2
CER
2
5.1K MELF +5VI CER .1UF MMBT3904LT1 9 COM1 A
-6.5V R70 IN3 R189
1W 2% Q7 I -12V CER A COM2 15 2M
R69 8
22M MMBF4393 I R47 49.9K RV1 IN4
5% R73 100K 5 TURN A 10
100K
1
COM3
R75 R76 499K ECG GAIN 3 NO1
R74 3 +5VI 14 NO2 COM4 7 R71 R72
11 RV4
5.1K MELF R77 1M 60.4K NO3
GND
-8V -8V +8V 20K 5 TURN 100K
22M
ISOLATED R82 6 4 100K
2
5
ECG BAL 10% 1206
SMCJ10CA D12 R81 -12V A
LL1 R79 MMBD1503A R78
22M A
20K R266
B
D38
5%
2 1 NON-ISOLATED +12V
1M 649K
C36
B
3
C38 MMBF4393 13
220PF 20K 14 -
R90 D13
4
4
NPO L0 2 1 A 12
R89 L0 MMBD4148CC 2 + .1UF X7R
10K 1K R85 10% 1206
D35 6 1 - R88
+6.5V +5V D14 1 7 - 3 U11D A
MMBD4148 +12V R87 20K 1K
-6.5V +5V MMBD1503A -12V 3
+
5 U11A + TL034ACD
5
-6.5V 10K A
11
D41 R230 2 TL034ACD
1
L1
1
8
499K Q8
-12V CER
3
I 3 R94 1K A 3 MMBF4393
Q9 R91 D16
3
10K .1UF 1 + 5 MMBD4148
3
A
MMBD4148
4
I
Q10 R95 R96
2
A CER A R97
-
2
-
6 105K C41 -12V
C43 -5VI 49.9K -12V -12V
1 + 7 +
3 5
U50A A 680PF CER C42 +12V
.0015UF TL032ACD A U50B A +12V +12V
R102 50V MP 1812 R103 .15UF 5%
8
C45 60.4K
NC
NC
7
6
3
2
4
ISO.GND. U21 6
-
R106 A A
2
+ ICM7555ISA 7 2
-
C49 16V SIZE-R R113 R107
3
7
6
THR
Q
1
8
+ 180UF TANT R V-
2
D S NPO 1. ALL RESISTORS ARE 1/10W, 1%, SIZE 0805 U.O.S.
7
3
R116 07 REVISED PER ECN 1821. GP 1-18-10
1 1
4.99K 08 REVISED FOR REV-04 ARTWORK FAB PER ECN 1844. RM 6-24-10
R117
2
09 REVISED PER ECN 1870. RM 7-1-10
R119 4.99K
261K D 10 REVISED PER ECN 1986. RM 7-6-11
+12V -12V R118
C59 C60 261K 11 REVISED PER ECN 2023. GP 9-16-11
+
+
+5V 68UF TANT 68UF TANT
D 16V 7343 16V 7343 D -12V
U23
SN74AHC1G04DCK
14
1
Vcc
+V
-V
2 A Y 4 2 1A 1Y 3
GND
4 2A 2Y 6
5 2B +12V
PGND 9 8 +5V
3A 3Y
10
3
+5V 3B
R121 R120
GND
TP10 12 4A 4Y 11 22.1 OHM
13 402
VI 4B SW1
OHM
3
J106 D R122 1 1 20 BIPOLAR
U24
POWER IN D25 1 Q17
7
MC1488D 2 19 HIGH CURR
VI MMBD4148 U25 10 OHM MMBT3904LT1
4
8 D
* 4 ICM7555ISA 3 2 18
2
3 D26
R123
R
V+
2 POS TRIG
1 2 TR Q 3 4 17
MURS160T3 100K 7 R124 SW1 SHOWN 5 3 16 NEG TRIG
DIS 475 OHM
5 6 IN ON POSTION 6 15
CHASSIS_GND R125 CV THR
V-
D MP 2824
TRIG LEVEL SW1-1 SW1-2 SW1-3 9 5 12 WIDTH 2
WITH2
D 10 11
+/- 11V ON ON OFF
R183 R184
LNFREQ 5V POS OFF OFF OFF D 10K 10K
R126 5V NEG OFF OFF ON
R127 10K VI HIGH CURR OFF ON OFF
C62 100K D27 +5V
ON VI SF1
+
ACH3218-221
TRIG WIDTH 1
6.8UF TANT MMBD4148 SW3-1 ON SW1-4 SW1-5 2 J118
OFF D 20V 3528 SW3-1 OFF AND 3 170508
R128 1K OR SW3-7 OFF D R198
D
8
2
D 2 D
VIN
C63 D
U28 .033UF 63V TP12 6 6
VOUT _ 7 D
LM2678S-ADJ +5V
6
3
MP 2824 4 GND 5 +
-12V TP11
C144 U27
CB
FB
2
2 1 +5V LM393M 10UF CER
VI VIN VOUT D C142
GND
A
77UH SMT D44 R294 3 1
1UF X7R 499K -12V VIN VOUT -8V
+ C65 MMBD4148 TP34 DGND DGND
D28 10% 1206 D 6
+ C66
ADJ
47UF 50V B AGND
MBRS340T3 R134 C64
7
C
ALUM 680UF 10V D
ALUM TP13 249 OHM + 180UF TANT
D42 D 16V SIZE-R AGND
4
MMBD4148 R296 4 +8V AGND
562K GND3ADJ
D A A
8 1
GND7
GND6
GND2
+5V +12V VIN VOUT +8V R136
D43 1.33K NOTES:
R135
+ C67 1.21K + C68
33UF TANT U29 180UF TANT 1. ALL RESISTORS ARE 1/10W, 1%, SIZE 0805 U.O.S.
7
6
3
2
MMBD4148 16V SIZE-R A ALL .1UF CER CAPACITORS ARE SIZE 0805 U.O.S.
R138 R139 35V SIZE-R LM2931CM
+12VREC
1.21K 10.7K A A
R137
6.81K
A 2.
* INDICATES A THROUGH HOLE COMPONENT.
U31 MP 2824 A
+12V 4. NOT USED: R243,R244,SF3
CB
FB
L2 R242
2 1 +12V A TP14
VI VIN VOUT 4.99K
GND
ONF
-12V
53UH SMT
R212 +5V 1
POWER SUPPLY
C74 D29
+ MBRS340T3 + C75 + C71 -12V
+12V
2 J112
AND TRIGGER OUT
7
47UF 50V
3
ALUM 1 VOUT 5
D
* IVY BIOMEDICAL SYSTEMS INC.
VCC+
+ C70 7 FB/SD
11 BUSINESS PARK DRIVE
C72
2
A 8.2UF + 6 OSC
180UF TANT VREF BRANFORD, CT., 06405 USA
GND
REVISIONS
TEST CSATD BREQ RESET REV DESCRIPTION BY DATE
OPTIONS SETTINGS TEST CSATD BREQ RESET
DIAD HONK STRB1 DSACK1 01 REVISED FOR REV-01 ARTWORK FAB. GP 1-8-07
DIAD HONK STRB1 DSACK1
CLKAD BEEP STRB2 DCNCT- 02 REVISED PER ECN 1623. GP 7-9-07
OPTIONS REFERENCE INSTALLED NOT INSTALLED FILTER VCC CLKAD BEEP STRB2 DCNCT-
DOAD T150 STRB3 XOFFI 03 REVISED FOR REV-02 ARTWORK FAB PER ECN 1629. GP 2-15-08
DOAD T150 STRB3 XOFFI
RSPOUT R241 RESP OUTPUT NO RESP OUTPUT SW3 CSAD HONKD R/W CSUAR 04 REVISED PER ECN 1678. GP 6-27-08
CSAD HONKD R/W CSUAR
20
492008 05 REVISED PER ECN 1679. GP 6-27-08
LDRSP LDRSP /WRT /WRT DS RDOSW
16 1 2 18 D8 DS RDOSW
VCC
15 2 4 1A1 1Y1
16 D9 DOUT /RD AS WITH1 06 REVISED PER ECN 1797. GP 9-17-09
1A2 1Y2 D10 DOUT /RD AS WITH1
14 3 6 14 07 REVISED PER ECN 1821. GP
13 4 8 1A3 1Y3
12 D11 SHFT SHFT CS2 CS2 1.8MHZ WITH2 1-18-10
SW3 SWITCH SETTINGS 12 5 11 1A4
2A1
1Y4
2Y1 9 D12 1.8MHZ WITH2
08 REVISED FOR REV-04 ARTWORK FAB PER ECN 1844. RM 6-24-10
11 6 13 7 D13 50KHZ 50KHZ HONK HONK EVENT PRES
10 7 15 2A2 2Y2
5 D14 EVENT PRES
9 8 17 2A3 2Y3
3 D15 IRQ5 09 REVISED PER ECN 1870. RM 7-1-10
SW3 (SWITCH No.) ON OFF 3200 / 3303 2A4 2Y4 D[0..15] IRQ5
D[0..15] -12V 10 REVISED PER ECN 1986. RM 7-6-11
GND
D 1 1G
IACK5
IACK5 -12V -12V
1 3050, 3100, 3150, 3000T-B 3000 OFF 19 2G 11 REVISED PER ECN 2023. GP 9-16-11
D D
R213 R215 R217 R219 U49 A[1..18]
2 MONITORING DEFAULTS TRIGGER DEFAULTS OFF TP16
10
10K 10K 10K 10K CD74HCT244M +12V +12V
DGND +12V
3 - ECG FILTER ON OFF OFF
DGND DGND
4 - PACER DETECTION DISABLE ON POWER UP ENABLE ON POWER UP OFF R214 R216 R218 R220 GND
D
RDOSW +5V
5 ECG SIMULATOR NO ECG SIMULATOR OFF 10K 10K 10K 10K D +5V
IF SW3-1 & SW3-7 = OFF 6 - TRIG POLARITY +/- MENU CONTROL NO MENU OFF C76
* VCC TP17 VCC VCC VCC
IF SW3-1 & SW3-7 = ON 6 - P-LOCK P-LOCK ENABLED P-LOCK DISABLED OFF AGND SPK-B
680PF NPO
7 - TOSHIBA FILTER ON OFF OFF AGND AGND
-8V -8V
U33 3
A R141 J110
* SW1-1, SW1-2 AND SW1-3 MUST BE OFF WITH THIS SELECTION. CY7C1009-20VC LOVLA
2
1 SPEAKER
A0 12 A0 D8 +5V 60.4K
A1 D0 13 D9
11 A1 D1 14 R195
A2 10 A2 D10
R250 R252 R254 KESFT1 A3 D2 15 D11 R142 3.32K SPK-A
9 A3 D3 17 1 SDWN VO2 8
KESFT2 A4 8 A4 D12
100 100 100
KESFT3 A5 D4 18 D13 10K C79 2 BYPS GND 7 VCC
OHM OHM OHM 7 A5 D5 19 R143 R144 R145 3 +IN VDD 6
KESFT4 A6 6 A6 D14 HONK
KESFT5 R173 A7 D6 20 D15
4 -IN VO1 5
C80
5 A7 D7 21
KEALRO 10K A8 27 A8 10K 2K 20K .1UF CER
A9 26 A9 CS3 D .01UF 63V C82 U35 C83
R174 CS1 22
KEALRO
1
A10 C84
KESFT1
KESFT3
KESFT5
KESFT4
KESFT2
10K 23 A10 CS2 30
MP 2824 .1UF LM4861M
R249 R251 R253 R175 A11 25 A11 HONKD G3 CER D
R176 A12 /WRT R147
100 100 100 R178 4 A12 WE 29 R148 .1UF
10K A13 28 A13 /RD A A
OHM OHM OHM R177 10K A14 OE 24 .22UF 63V Q18 4.99K 32.4K +5V CER
10K 3 A14 R151
2
10K A15 31 A15 R150 MP 2824 MMBF5460LT1
A16 NC 1 10K 1.47M D30 S C85 +5V
VCC 2 A16 MMBD4148 .01UF 63V
16 GND VCC 32 VCC MP 2824
Q19 R154
D +5V A D MMBF5460LT1 10K
1
VCC R196 R156 C86
VCC R221 BEEP 3G T150
VCC 4.02K 4.02K
10K VCC VCC R159 .033UF 63V
R140 R157
2
DSACK1 C77 C78 10K R197 R160 D31 MP 2824
VCC S MMBD4148
5
IACK5
PRES
A0 U36
D15
D12
D11
Vcc
D14
D13
D10
DSACK0
D9
D7
D6
D5
VCC 2853-00-04 +5V LOVL
D8
D4
D3
D2
D1
D0
C BR D D C
A7 A5 DQ6 D7 3.32K
TP24 R191 10K 30 A6 DQ7 14
IRQ5 A8 31 11 D8
GND
GND
GND
GND
GND
VCC
VCC
VCC
VCC
DSACK1
DSACK0
A0
D9
D8
D7
D6
D5
D4
D3
D2
D1
D0
A24
D15
D14
D13
D12
D11
D10
A31/IACK7
A30/IACK6
A29/IACK5
A28/IACK4
A27/IACK3
A26/IACK2
A25/IACK1
LN FREQ D D A9 32 A7 DQ8
10 D9
A10 A8 DQ9
R192 10K 35 A9 DQ10 9 D10
IRQ7 A11 36 8 D11
50HZ 50HZ 108 CS0 A12 37 A10 DQ11
7 D12 VCC A R235
CS0/AVEC CS1 A13 A11 DQ12 R273
1 RMC CS1/IRQ2 107 R152 10K 38 A12 DQ13 6 D13
3.32K IMP
R/W 2 106 CS2 IRQ3 A14 39 5 D14
3 R/W CS2/IRQ2
105 A15 40 A13 DQ14
4 D15 C104 4.75K
4 SIZ1 IRQ3
104 CS3 A16 41 A14 DQ15 .1UF + C105 J117
DS SIZ0 CS3/IRQ4 A15 /RD 6.8UF TANT
5 DS GND 103 42 A16 /OE 22 CER R237 170520
AS 6 102 12 3 CS0 20V 3528
BGACK 7 AS VCC
101 IRQ5 R155 10K 34 GND /CE A
VCC 8 BGACK IRQ5
100 DONE2 GND
44 A C106 4.75K MATES WITH 182008
RESET BR 9 BG IRQ6
99 IRQ7 D 23 VCC
33 VCC .047UF X7R SHFT RESP
DS BR IRQ7 DONE2 DU NC 1 2
R190 BERR 10 BERR DONE2 98 R158 10K VCC 2 VPP /PGM 43 20 VDD CH0 1 10% 1206
TSTR
3 4
LDRSP
BERR HALT 11 97 DONE1 CLKAD 19 2 DOUT RSPOFF
RESET HALT DACK2 BREQ CSAD SCLK CH1 C122 5 6
12 RESET /DREQ2 96 SOCKET 18 /CS CH2 3 R274 A 7 8
10K 13 95 DONE1 R161 10K R290 0 OHM 44 PIN DIAD 17 4 .047UF X7R
14 GND DONE1
94 HALT A17 16 DIN CH3
5 3.32K 50KHZ +12V 9 10 -12V
15 CLKOUT DACK1
93 DOAD 15 SSTRB CH4
6 10% 1206 A 11 12 A
16 VCC
XFC
U37 DREQ1
X1 92 EXP. MEM. OPTION 14 DO CH5
DGND CH6 7 13 14 CONNECTIONS
17 91 13 8 R232
18 VCC MC68340FE16 GND
90 12 AGND CH7
9 A RESP KEYING PLUG
WITH SW2 IN
9
7
5
3
1
170513 MODCK RTSB COMTX 100 OHM VCC 10% 1206 .1UF DNI
23 85 MAX186DCAP
24
25
VCC
IPIPE
TXDB
RXDB 84
83
CRDSW Y1
1.8432MHZ SMT VCC C87
D A
U4A CER 0 OHM 0805 J108
AUX *
4
A
10
27 BKPT RXRDYA
81 -SINEN M48T58SOH28 C110 A 2 RESP_OUT 1
R238
Vcc
28 FREEZE CTSA
80 -SOUTEN .1UF 1 - VCC 1
6 TRIGGER_OUT
TIN1 RTSA D C112 6
28
29 79 CER 3 15.8K GND 2
30 TOUT1 GND
78 3 BATTERY .1UF 10 OHM + 2
7 XOFF
TGATE1 VCC SIN OUT D15 -8V 7
31 77 1 19 CER 3
VCC
A
11
TCK TXDA SOUT A12 FT DQ7 C111 3 +5V
GND
32 TMS RXDA 76 2 A12 DQ6 18 D14 C108 8 8
TSTR 33 75 A11 23 17 D13 6.8UF TANT+ C109 DCNCT- 4
TDI TIN2 A10 A11 DQ5 D12 .1UF 4
34 TDO TOUT2 74 21 A10 DQ4 16 20V 3528 1UF X7R C11 9 9
WITH1 35 73 WITH2 R166 A9 24 15 D11 CER 5
36 VCC TGATE2 A8 25 A9 DQ3
13 D10 10% 1206 -12V .1UF 5
R269
2
B GND 100 OHM A7 3 A8 DQ2
12 D9 B
VCC A6 A7 DQ1 A CER
GND
GND
GND
GND
GND
4 11 D8
VCC
VCC
VCC
VCC
FC3
FC2
FC1
FC0
R270
A23
A22
A21
A20
A19
A18
A17
A16
A15
A14
A13
A12
A11
A10
10K A5 A6 DQ0
5
A9
A8
A7
A6
A5
A4
A3
A2
A1
D A4 6 A5
20 A R169 A
10K A4 /E1
D VCC A3 7 26
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
1.8MHZ A2 A3 E2
16US 8 A2 /G 22
VCC A1 9 27 15.8K
A0 A1 /WRT
10
VSS
16MHZ A0
R247 1.8MHZ-1 VCC
C89
*
/WRT
D .1UF CER
14
100 OHM J108
CS1
/RD
VCC AUX
A9
A8
A7
A6
A5
A4
A2
A1
A3
7
A18
A17
A16
A15
A14
A13
A12
A11
A10
D
C90 D TXD4C SF15 MEM2012P10R0 RESP_OUT 1
2 5
VCC
RTS4C 1 T1IN T1OUT
18 J109-3 1 3 X1000_OUT 1
6
VCC T2IN T2OUT 2 4 TXD 2 6
2 CTS
D .1UF CER SF14 MEM2012P10R0 7 7
RXD4C 3 4 RXD 3
CTS4C 20 R1OUT R1IN
19 1 3 3
8 RTS
R2OUT R2IN 2 4 4 8
R292
+5V 4
SF13 MEM2012P10R0 9 9
+5V +5V OFF 12 5
KEALRO
KESFT4 C2+ 1 3 5
KESFT1
KESFT2
KESFT3
DNI
KEALRO
STRB1 15
KESFT4
KESFT3
KESFT1
KESFT2
1 21 KESFT5 13 C2+
11 2 4
KESFT5
38
39
-SOUTEN MEM2012P10R0
7 7 27 27 1 3
PPR 8 28 -SINEN U40
9 8 28
29 23 22 D0 MAX233ACWP 2 4
VCC
VCC
9 29 RECRDY NC D0
10 10 30 30 11 NC D1 12 D1
SF10
11 31 RES 21 D2 MEM2012P10R0
11 31 D2 1 3
12 12 32 32 A1 40 A0 D3 13 D3
13 33 A2 42 20 D4 2 4
13 33 A1 D4
14 34 A3 44 14 D5
NOTES:
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
+12VREC 15 14 34
35 A4 1 A2 D5
19 D6 SF9 MEM2012P10R0
J113
* D D 1 3
3
4
3
4
15 35 A3 D6
3
4
3
4
3
4
3
4
3
4
3
4
16 36 15 D7
1. ALL RESISTORS ARE 1/10W, 1%, SIZE 0805 U.O.S.
MEM2012P10R0
MEM2012P10R0
R182 R295
IN
IN
IN
IN
IN
IN
IN
-V
IN
IN
IN
IN
IN
IN
IN
-V
SF22 MEM2012P10R0
SF20 MEM2012P10R0
MEM2012P10R0
SF16 MEM2012P10R0
SF21 MEM2012P10R0
SF19 MEM2012P10R0
+ C93 17 16 36
37 R181 D RXD4C 29 D7
1 2 +12V 2 4
17 37 470K 470K 0 OHM U52 U48 RXDA COMTX +12V ALL .1UF CER CAPACITORS ARE SIZE 0805 U.O.S.
18 38 TXD4C 28 30 1.8MHZ-1 3 4
6800UF 16V TL 19 18 38
39 SP720AB VCC SP720AB RTS4C 27 TXDA X1/CLK
31 COMRTS 5 6
19 39 OP0/RSTA X2 CRDSW D
20 40 2 7 8
*
V+
V+
CTS4C
+5V 2. INDICATES A THROUGH HOLE COMPONENT.
IN
IN
IN
IN
IN
IN
IN
IN
IN
IN
IN
IN
IN
IN
RECGND 20 40 IP0/CSTA
18 IRQ3 9 10
D VCC COMREC_B 5 INTRN COMCTS 11 12
+5V +5V
16
15
14
13
12
11
10
16
15
14
13
12
11
10
9
SF23
SF17
SF18
TXDB CE COMTX_B
RECORDER C117
RSTTL 7 OP1/RSTB WE 3 /WRT 1 RV6,SF8,SW3,T1,TP34,U63,Y2.
CTSTL 43 4 /RD 2 D
1
2
1
2
IP1/CSTB OE
1
2
1
2
1
2
1
2
1
2
1
2
Q20 26 9 12
MAX690A-CSA CMPT3906
Z0 8 OP2 OP5
25 SMD010 XOFF 11 A/D AND COM
2
PFI
14
D
POWER D SF6
ACH3218-472 R222
ACH3218-472 13 IVY BIOMEDICAL SYSTEMS INC.
CSAD 6 5 18 11 BUSINESS PARK DRIVE
WDI PFO POWERLED STRB3 -8V
GND
R179 17
1
1K D TRIGGER_OUT Title
J102
IN "COM" ADULT / NEONATE 3 LEAD ECG & PEAK DETECTOR BOARD
D Size Document Number Rev
D FRONT PANEL POSTION D 5197-00-01 (-03 SCHEMATIC) 11
Date: Friday, September 16, 2011 Sheet 3 of 5
5 4 3 2 1
5 4 3 2 1
REVISIONS
REV DESCRIPTION BY DATE
01 REVISED FOR REV-01 ARTWORK FAB. GP 1-8-07
VCC VCC
02 REVISED PER ECN 1623. GP 7-9-07
C115 C116 03 REVISED FOR REV-02 ARTWORK FAB PER ECN 1629. GP 2-15-08
.1UF CER .1UF CER 04 REVISED PER ECN 1678. GP 6-27-08
D 05 REVISED PER ECN 1679. GP 6-27-08
D
06 REVISED PER ECN 1797. GP 9-17-09
07 REVISED PER ECN 1821. GP 1-18-10
08 REVISED FOR REV-04 ARTWORK FAB PER ECN 1844. RM 6-24-10
va[0..16] 09 REVISED PER ECN 1870. RM 7-1-10
10 REVISED PER ECN 1986. RM 7-6-11
D 11 REVISED PER ECN 2023. GP 9-16-11 D
WA[0..15]
wd[0..15]
VCC VCC
CSUAR
LNFREQ
CSUAR
hsynch
U42
HONK
Data0
wa14
wa11
wa10
wd11
wd14
wa12
vd12
vd11
vd15
C100 C101 CY7C1021-12ZC 16US
GND
GND
GND
D11
D10
D15
D14
wd3
wd2
wd6
wa9
wa6
wa7
wa8
A15
A14
A10
A11
VCC
VCC
VCC
16US
dclk
vd2
vd1
vd6
vd5
vd9
tste
wa15
va9
va5
D1
D5
D4
D7
A6
A4
A5
A1
de
.1UF CER .1UF CER 40 /BHE D0 7
wd0 PACE
39 /BLE PACE
D1 8
wd1
22 NC D2 9
wd2 L1
L1
208
207
206
205
204
203
202
201
200
199
198
197
196
195
194
193
192
191
190
189
188
187
186
185
184
183
182
181
180
179
178
177
176
175
174
173
172
171
170
169
168
167
166
165
164
163
162
161
160
159
158
157
R248 23 NC D3 10
wd3
1 NC D4 13
wd4 LO
L0
28 NC D5 14
wd5
0 OHM wa0 5 A0 D6 15
wd6 PDO
wram_cs
VCCIO
GND
GND
dclk
VCCIO
VCCIO
GND
hsynch
DE
4KHZ
TSTE
WD11
WD14
vram_add9
hd1
hd5
hd4
hd7
vram_add5
hd11
hd10
hd15
hd14
data0
wave_add14
wave_add11
wave_add10
wave_data3
wave_data2
wave_data6
wave_add9
wave_add6
wave_add7
wave_add8
host_add6
host_add4
host_add5
host_add1
wave_data12
wave_data11
wave_data15
wave_add12
host_add15
host_add14
host_add10
host_add11
video_data2
video_data1
video_data6
video_data5
video_data9
wram_we 1 156 wa13 4 A1 PDO
D7 16
wa1 wd7
green1 wram_we wave_add13 va3
2 green1 vram_add3 155 wa2 3 A2 D8 29
wd8 22MS
22MS
green2 3 154 va4 2 A3 D9 30
wa3 wd9
STRB1 DTRG green2 vram_add4 VRAM_CS
4 DTRG vram_cs 153 wa4 18 A4 D10 31
wd10
A18 5 152 CSUAR 44 A5 D11 32
wa5 wd11
host_add18 CSUAR vsynch DCNCT-
VCC 6 ^nCE vsync 151 wa6 43 A6 D12 35
wd12 SAMPLE
SAMPLE
R255 GND 7 150 conf_done 42 A7 D13 36
wa7 wd13
VCC 8 GND CONF_DONE
149 VCC R203 27 A8 D14 37
100 wa8 wd14 LNFREQ
VCC 9 VCCINT VCCIO
148 VCC 1K 26 A9 LNFREQ
D15 38
wa9 wd15
OHM A16 VCCIO VCCINT GND
R205 10 host_add16 GND 147 wa10 25 A10 R271 NOTCH-
NOTCH-
A17 11 146 24 A11 CE 6
NEO wa11
10K host_add17 PRES va2
LOVLA 12 STRB1 vram_add2 145 CMPD6263 wa12 21 A12 332 OHM
BREQ
BREQ
13 144 /WRT wa13 20 A13
GATF LOVLA /WRT va16 XOFFI
14 GATF vram_add16 143 D34 wa14 19 A14 WE 17
wram_we STRB1
STRB1
IRQ5 15 142 va15
OE 41
WRAM_OE
16 eow_int vram_add15
141 va1 R204 STRB2
WD13 17 SHFT vram_add1
140 wa0 1K 34 33 STRB2
1.8MHZ WD13 wave_add0 wa2 GND VCC
18 1.8MHZ wave_add2 139 12 GND VCC 11 VCC
STRB3
STRB3
SHFT L1 19 138 wa5 XOFF
DIAD L1 wave_add5 wa4
20 DIAD wave_add4 137 D
COMCTS
COMCTS
SAMPLE 21 136 wa3
VCC CSAD 22 SAMPLE wave_add3
135 wa1 DOUT
23 CSAD wave_add1
134 50KHZ DOUT
LOVL RESET LOVL U43 50KHZ DOUT
24 clear DOUT 133 LOD
LOD
C GND 25 EPF6016QC208-2 132 DOAD C
R231 VCC 26 GND DOAD
131 VCC SHFT
10K VCC 27 VCCINT VCCIO
130 VCC SHFT
clock 28 VCCIO VCCINT
129 GND VCC RDOSW
TSTR 29 clock GND
128 IACK5 RDOSW
LOD TSTR intack5 cs2
30 LOD host_cs3 127 DTRG
DTRG
T150 31 T150 ds 126 ds R199 U46
CLKAD 32 125 RDOSW DCNCT-
NOTCH- CLKAD RDOSW as 10K CY7C1041B-15ZC DCNCT-
33 NOTCH- as 124
dsack1 34 123 COMCTS 40 /BHE D0 7
vd0 XOFF
wa15 35 dsack1 CTSET
122 LDRSP 39 /BLE XOFF
D1 8
vd1
HONKD wa15 LDRSP r/w
36 HONKD r/w 121 D2 9
vd2 XOFFI
XOFFI
green5 37 120 vram_we
D3 10
vd3
green3 green5 VRAM_WE red5
38 green3 red5 119 D 28 NC D4 13
vd4
blue3 39 blue3 blue1 118 blue1 R256 D5 14
vd5
blue2 40 117 STRB3 1 A0 D6 15
va0 vd6 R/W
blue4 41 blue2 STRB3
116 2 A1 R/W
D7 16
va1 vd7
green4 blue4 STRB2 red1 100 OHM
42 green4 red1 115 va2 3 A2 D8 29
vd8 DS
DS
43 114 red2 4 A3 D9 30
GND va3 vd9
VCC GND red2 red3
44 VCCINT red3 113 R257 va4 5 A4 D10 31
vd10 AS
AS
VCC 45 112 VCC STRB2 18 A5 D11 32
va5 vd11
VCCIO VCCIO VCC
46 MSEL VCCINT 111 va6 19 A6 D12 35
vd12 1.8MHZ
1.8MHZ
blue5 47 110 100 OHM 20 A7 D13 36
GND va7 vd13 VCC
va14 blue5 GND red4
48 109 va8 21 A8 D14 37
vd14 EVENT
EVENT
video_data10
video_data13
video_data14
wave_data0
wave_data1
wave_data4
wave_data5
wave_data7
host_add13
host_add12
WRAM_CS
vramadd10 L0
vramadd13
vram_add8
25_MHz 50 107 va0 23 A10 IRQ5
host_add3
host_add9
host_add8
host_add2
host_add7
va10
va11 25MHz vram_add0 va6 R272 IRQ5
51 106 va11 24 A11 CE 6 C102
16MHZ
vramadd11 vram_add6
nconfig
nstatus
VCCIO
VCCIO
VCCIO
va12 52 105 va7 va12 25 A12 IACK5
BREQ
WD12
WD10
WD15
PACE
22MS
2KHZ
IACK5
16US
vramadd12 vram_add7 332 OHM .1UF CER
hd12
hd13
WD8
WD9
GND
GND
GND
PDO
va13 26 A13
/RD
hd0
hd2
hd3
hd6
hd8
hd9
va14 27 A14 WE 17
vram_we RESET
RESET
va15 42 A15 OE 41
VRAM_CS
100
101
102
103
104
va16 43 A16 16MHZ
16MHZ
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
44 A17 VCC 33
GND
GND
VCC 11
DSACK1
VCC DSACK1
nstatus
va13 va8
wd8
wd9
vd10
vd13
vd14
wd12
GND
GND
GND
BEEP
D13
wd1
wd4
wd5
A13
A12
D12
wd0
wd7
/RD
22MS
WRAM_OE
vd0
vd8
16US
vd3
vd4
vd7
A7
PDO
VCC
VCC
D0
D8
D2
D3
D6
D9
A3
A9
A8
A2
34
12
wd10
wd15
BREQ
VCC
PACE
HONK
HONK
R188 BEEP
16MHZ BEEP
T150
100 OHM T150
D J114 HONKD
vd[0..15] HONKD
SF4 210067 /WRT
ACH3218-101 DISPLAY /WRT
25_MHz GND LUG /RD
/RD
CS2
B 1 CS2 B
red[0..5] D 2 RDOSW
RDOSW
green[0..5] DIAD
D DIAD
blue[0..5] CSAD
CSAD
1 CLKAD
hsynch 2 CLKAD
VCC vsynch 3 DOAD
4 DOAD
5 LDRSP
red1 6 LDRSP
A[1..18] red2 7 50KHZ
red3 8 50KHZ
red4 9
D[0..15] R186 R187 VCC red5 10
10K 10K 11 TSTR
VCC 12 J104 TSTR
green1 13 DISPLAY TSTE
TSTE
4
Data0 green2 14
15 191501
dclk green3 NEO
+5VDC
OUT 19
2855-01-04
3
2
1
100 OHM 20
GND
blue1
blue2 21
N/C
N/C
VCC
DATA
N/C
4 DCLK blue3 22
blue4 23
5 N/C VCC 18 Y2 blue5 24
2
6 N/C EMC60S5B-048
25
7 N/C N/C 17 DE 26
N/C 16 27
8 15 J103 D 28
nCASC
OE N/C +5V 29
INVPWR
GND
14 30
nCS
N/C
N/C
N/C 31 +5V
+5V NOTES:
8
7
6
5
1
2
1. ALL RESISTORS ARE 1/10W, 1%, SIZE 0805 U.O.S.
10
11
12
13
3 D
9
PGND 4 Q21 ALL .1UF CER CAPACITORS ARE SIZE 0805 U.O.S.
VCC VCC VCC
IRF7205/SO
SOCKET
20 PIN PLCC
* VCC
2.
* INDICATES A THROUGH HOLE COMPONENT.
1
2
3
4
DGND RV6,SF8,SW3,T1,TP34,U63,Y2.
DGND DGND
A
C94 GND 4. NOT USED: R243,R244,SF3 A
+
10V 3528
10UF TANT D
GATF VIDEO AND
D ONE TEST
POINT ON EACH
MEMORY
SIDE OF BOARD
IVY BIOMEDICAL SYSTEMS INC.
TP33 TP19 11 BUSINESS PARK DRIVE
AGND AGND BRANFORD, CT., 06405 USA
AGND AGND (203) 481-4183
DWN: GP 1/12/07 CHK: GC 1/12/07 APR: RAM 1/12/07
Title
A ADULT / NEONATE 3 LEAD ECG & PEAK DETECTOR BOARD
Size Document Number Rev
D 5197-00-01 (-03 SCHEMATIC) 11
Date: Friday, September 16, 2011 Sheet 4 of 5
5 4 3 2 1
5 4 3 2 1
3
TP28 +6.5VI
REVISIONS
C123 R279
10HZ TP29 C139 +6.5VI REV DESCRIPTION BY DATE
.1UF 50V MP 1812
332K Z1 01 REVISED FOR REV-01 ARTWORK FAB. GP 1-8-07
-6.5VI U59A .01UF
C130 I C125 02 REVISED PER ECN 1623. GP 7-9-07
R275 LT1058SW
4
C124 CER .1UF R276 R278
1 2 03 REVISED FOR REV-02 ARTWORK FAB PER ECN 1629. GP 2-15-08
MMBD1503 3 + CER
10K .1UF CER 1 249 OHM 10K
240000
2 - 04 REVISED PER ECN 1678. GP 6-27-08
.1UF CER I I I
-5VI I 05 REVISED PER ECN 1679. GP 6-27-08
13
U57B Q26
13
LT1884CS8 MMBF4393 06 REVISED PER ECN 1797. GP 9-17-09
U57A 2 -
R280 -6.5VI R283
4
R277 6 1 1 2
2
2 LT1884CS8 7 U58A 3 +
C141
499 OHM 07 REVISED PER ECN 1821. GP 1-18-10
1 _ 5 LT1058SW 100K 1 Q27
D 261K .01UF 08 REVISED FOR REV-04 ARTWORK FAB PER ECN 1844. RM 6-24-10 D
+ 3 CMPT3906
3
+5VI I C135 CER 09 REVISED PER ECN 1870. RM 7-1-10
C127
3
I
8
I I 22PF CER 10 REVISED PER ECN 1986. RM 7-6-11
R282 .1UF NPO -6.5VI 11
I REVISED PER ECN 2023. GP 9-16-11
C128 +6.5VI CER
9.09K +12V
R284 C126
.1UF 402K R288 D32 1 8 .1UF R281
MMBD1503A
1
CER I 49.9K CER 1K D39
2 7 R285 MMBZ5234B
3 6 A
U59B R200
R287 511K 6.2V
R286 -6.5VI +6.5VI 3 LT1058SW 200K A
RA1 100K R11 4 5 R289 RV6
49.9K 5 + 100K 5 TURN
1K 7
2
C132 6 - 3M Z BAL
Q28 3 C131 D40
.1UF .1UF I A
MMBF4393 MMBZ5234B
2
CER CER 15 U61
-
R60
1
I I C133
13
16 11 - IL300-X007 6.2V
4
I 14 + 10 R17 A
2 3 49.9K 12 + C129
1 .1UF 50V 1K
U58D .01UF 250V MP 1913
15 14 MP 1812 U58C
R153 16 R162 LT1058SW I LT1058SW
LA1 7 6 I U59C
8 324K
1K 10 11 C136 LT1058SW -12V
2
9 .01UF +5VI
Q29 3 12 + C134
U20 CER I C137
MMBF4393 10 .1UF
C MAX327CSE 11 - C
5
CER
R165
1
1=ON I
I R168 .01UF 499K
I 0=OFF I
3K CER ATP30
R172 U58B U56A ANALOG OUT
8
R164 10K LT1058SW TL062ACD
4
LL1 3 +
1 6 - 2
1K 2 _ 7 _ 1
2
U32A 5 + 3 +
*
Q2 3 LM393M
R201 R202 15 -
4
MMBF4393 16 IMP
8
100K 4.02K I 14 + A
1
-5VI
I U59D C138 +12V
I
I 5 + LT1058SW RV5
7 TP31 .1UF 200K 5 TURN
6 _ CER Z GAIN
U32B *
LM393M R206 Set Z BAL = -5V for
R207 I
3K 402K zero ohms input
Set Z GAIN = +4V for
C140
150K ohms input
.01UF
-5VI CER I ISOLATED NON ISOLATED
U56B
B TL062ACD B
+5VI 6
7
+6.5VI 5
C88 A
C91 .1UF
.1UF CER R208 R209
U60A 100K 100K
CER LT1058SW Z0 Z1 Q28 Q29 Q2
4
I
U60D I
R210 + 3
LT1058SW 1 ECG 0 0 OFF OFF OFF
1M - 2
+ 14 U45 RA 1 0 OFF ON ON
16 C95
13
16
O0
.1UF
1
I CER -6.5VI A1 2
14 O1
A2 3 NOTES:
13 O2 R211
R224 + 5 1. ALL RESISTORS ARE 1/10W, 1%, SIZE 0805 U.O.S.
2
7 12 Z0
O3 4.99K ALL .1UF CER CAPACITORS ARE SIZE 0805 U.O.S.
1M - 6 E1 4
U47
11 O4 I
D33
G C
U60B
LT1058SW MMBD4148CC 10
9
O5 E2 5 CNY17F-3X007 2.
* INDICATES A THROUGH HOLE COMPONENT.
1
1M
U60C R239
8
D S B E
LT1058SW 100K R226
3 IVY BIOMEDICAL SYSTEMS INC.
4
REVISIONS
REV DESCRIPTION BY DATE
00 INITIAL RELEASE PER ECN 2042. GP 12-27-11
R263 R261
51.1K 137K
C119
-12V
4
C121 R264 MP 2220
2 R262 R260
_ 1 6
1UF 63V 49.9K 3 + 7
137K 68.1K 5
MP 2824 U54A
R19
TL062ACD
8
A C120 U54B
.15UF 5% TL062ACD 100K U53
+12V X7R 1206 A R291 MAX364CSE
14
C10
D
1000PF 100K 0805 D
NPO DNI 3 4
NO2
A NO1 V- -12V U4D
D2 X500
J116 MMBD1503A V+ 13 +12V TL064ACD
RESP 2 13
A COM1 R16 X1000_OUT
1 +6.5V 2 1 -6.5V - 14 X1000_OUT
RA 16 15 12
2 FILTER 1 IN2 COM2 + 100
3 LA IN1 OHM
4 D1 R259
6 9
3
MMBD4148CC U1B +5V 7 NO4 IN3
174014 200K R258 COM4
8
TL062ACD
3
IN4 +5V
GND
1 R1 200K 10 COM3
3 5 1 11 NO3 VL 12
100K 7
J101 +6.5V 2 6 Q24
SHIELD D3
5
ECG INPUT MMBT3904LT1
LA DRIVE C1 +5VI MMBD4148 +5VI
1 RA TP25 R2 A
2 .1UF D4 +5VI A
LL R7
3 SHIELD_DRIVE CER 20K Q1 R4 U2B SAMPLE
4 +5VI 80.6K R6
C96 10K R3 CMPT3906 LM393M 100K 50HZ
MMBD4148 R5
8
174019 I 30.1K 3 2 5 +
.01UF 100K +5VI +5V 60HZ
1% NPO + 3 7
1 _ 2 I 6 _
I I R12 C4
U1A 10K R9 R8 R10
1
TL062ACD R13 1K 3 2
+5VI 1K 14 NO1 COM1 15 NOTCH
4
5
.1UF 1% NPO NO4 COM4
R15 TP20 CER 6.8UF TANT I U5 1 C8
-6.5V R21 CER R193 R18 IN1
5.1K MELF 35V 7343 CNY17F-3X007 16 IN2
1W 2% 121K 9
8
R20 I D5 I 8.06K 787K .1% 8 IN3
.01UF NPO
4
22M I 3 + 50PPM 1206
IN4
I R27
5% 1 +5V 12
MMBD4148
4.75M 2 _ C9 VL
R24
U2A
GND
R22 R23 A 6 +12V 13 V+
80.6K LM393M - 7 -12V 4
5.1K MELF R25 5 V- 100K
.01UF
4
22M +
1W 2% 5% C7 1% NPO U4B 9
5
-5VI .1UF A TL064ACD U3 - 8
-5VI R26 10
CER MAX364CSE A +
SMCJ10CA D6 392K .1%
RA1 R28 MMBD1503A U4C
22M +6.5V I 50PPM 1206 A
2
5% +5VI I TL064ACD
2 1 C12 3 C13 NOTCH-
D36 .1UF R33 Q3
R31 C14 MMBF4393 .01UF 63V +5V R194 R29
R34 CER R32 60.4K R30
-5VI 100K .1UF MP 2824 6.04K 187K .1%
1
22M U6B 100K .1% 50PPM TRIGGER_OUT
CER 113K .1%
3
7
5 + I I LT1058SW 10K 170508 2
R37 C15 TP2 A 3
7 12 13 3 R38 TSTE ECG X1000
VD
1
NPO X3
LT1055S8 C18 49.9K J109-3
LA C17 MP 2824 U10 NOTCHX1000
1 470PF
4
1
5
5 Y0 .01UF 63V U8 C19 CNY17F-3X007
R41 2 Y1 C20 NPO TP3 PDT2
+5VI Y2 MP 2824 R43
5.1K MELF Q4 4 R42 R40
2
6 Y3 -5VI 402K 22MS D7
1W 2% MMBF4393 -6.5V 680PF NPO
1
R44 10 INH U7
22M R45 A 10K .1% .1UF 2K MMBD1503A
VS
VE
8
7
3
1W 2% 5% 3 4 KEYING PLUG
9
.1UF CER R56 5 6 RADIO_CH0 R54
VCC 7 8
- 8
SMCJ10CA 16.2K R57 +12V 9 10 -12V .0047UF MP R55 10 10K
LA1 D10 10K 50V 1206 100K +
R58 MMBD1503A
22M +6.5V D9 R59 +5VI 170513 D8 Q5
5% MMBD4148 A MMBD4148 MMBF4393
D37 2 1 C33 10 OHM +6.5V DOUT +12V A
U12 R223
2
.1UF C26
U6A .1UF IL300-X007 C27 3
R61 CER I Q6 R62 1 8 49.9K
22M
-5VI LT1058SW CER .1UF C28 A
D11 CMPT3906 249
3
+5V
8
R63 5% CER 680PF
MMBD4148CA OHM
1
NEO
4
2
49.9K I 2 I 2 7 WIRED_ECG_OFF_1
R64 +12V NPO
8
3 + 1 1 3 6 5 + R65 +5V
1 1 3 7 2 A R267 RV3
R66 499
2 - 3 +5VI U13A
A 6 _ 1 100K 20K 5 TURN R67
13
12
C29 TL062ACD OHM 4 5 100K 3 R268
3
C30
3
220PF 2 1M I U14A ADULT THRESHOLD 909K
100K
4
U55
13
VL
V+
LL C25 C32 C31 I TL062ACD A IN1 MAX364CSE
-6.5V 50V 1206
4
.1UF .1UF 220PF Q25 16
R68 NPO C34 IN2 2
CER
2
5.1K MELF +5VI CER .1UF MMBT3904LT1 9 COM1 A
-6.5V R70 IN3 R189
1W 2% Q7 -12V CER 15
R69 I A 8 COM2 2M
22M MMBF4393 I R47 49.9K RV1 IN4
5% R73 100K 5 TURN A 10
100K
1
COM3
R75 R76 499K ECG GAIN 3 NO1
R74 3 +5VI 14 NO2 COM4 7 R71 R72
11 RV4
5.1K MELF R77 1M 60.4K NO3
GND
-8V -8V +8V 20K 5 TURN
22M
ISOLATED R82 6 4 100K 100K
2
5
ECG BAL 10% 1206
SMCJ10CA D12 R81 -12V A
LL1 R79 MMBD1503A R78
22M A
WIRED_ECG_OFF_2 20K R266
B
D38
5%
2 1 NON-ISOLATED +12V
1M 649K
C36
B
3
C38 MMBF4393 13
220PF 20K 14 -
R90 D13
4
4
NPO L0 2 1 A 12
R89 L0 MMBD4148CC + .1UF X7R
10K R85 2
1K D35 6 1 - 10% 1206
+6.5V +5V D14 1 7 - 3 R88 U11D A
MMBD4148 +12V R87 20K 1K
-6.5V +5V MMBD1503A -12V 3
+
5 U11A + TL034ACD
5
-6.5V 10K A
11
D41 R230 2 TL034ACD
1
L1
1
8
499K Q8
-12V CER
3
I 3 R94 1K A 3 MMBF4393
Q9 R91 D16
3
10K .1UF 1 + 5 MMBD4148
3
A
MMBD4148
4
I
Q10 R95 R96
2
A CER A R97
-
2
-
6 105K C41 -12V
C43 -5VI 49.9K -12V -12V
1 + 7 +
3 5
U50A A 680PF CER C42 +12V
.0015UF TL032ACD A U50B A +12V +12V
R102 50V MP 1812 R103 .15UF 5%
8
C45 60.4K
NC
NC
7
6
3
2
4
ISO.GND. U21 6
-
R106 A A
2
+ ICM7555ISA 7 2
-
C49 16V SIZE-R R113 R107
3
7
6
8
+ 180UF TANT R V-
2
D S NPO 1. ALL RESISTORS ARE 1/10W, 1%, SIZE 0805 U.O.S.
7
3
R116
1 1
4.99K
R117
2
R119 4.99K
261K D
+12V -12V R118
C59 C60 261K
+
+
+5V 68UF TANT 68UF TANT
D 16V 7343 16V 7343 D -12V
U23
SN74AHC1G04DCK
14
1
Vcc
-V
+V
2 A Y 4 2 1A 1Y 3
GND
4 2A 2Y 6
5 2B +12V
PGND 9 8 +5V
3A 3Y
10
3
+5V 3B
R121 R120
GND
TP10 12 4A 4Y 11 22.1 OHM
13 402
VI 4B SW1
OHM
3
J106 D R122 1 1 20 BIPOLAR
U24
POWER IN D25 1 Q17
7
MC1488D 2 19 HIGH CURR
VI MMBD4148 U25 10 OHM MMBT3904LT1
4
8
D
* 4 ICM7555ISA 3 2 18
2
3 D26
R123 R
V+
2 POS TRIG
1 2 TR Q 3 4 17
MURS160T3 100K 7 R124 SW1 SHOWN 5 3 16 NEG TRIG
DIS 475 OHM
5 6 IN ON POSTION 6 15
CHASSIS_GND R125 CV THR
V-
D MP 2824
TRIG LEVEL SW1-1 SW1-2 SW1-3 9 5 12 WIDTH 2
WITH2
D 10 11
+/- 11V ON ON OFF
R183 R184
LNFREQ 5V POS OFF OFF OFF D 10K 10K
R126 5V NEG OFF OFF ON
R127 10K VI HIGH CURR OFF ON OFF
C62 100K D27 +5V
ON VI SF1
+
ACH3218-221
TRIG WIDTH 1
6.8UF TANT MMBD4148 SW3-1 ON SW1-4 SW1-5 2 J118
OFF D 20V 3528 SW3-1 OFF AND 3 170508
R128 1K OR SW3-7 OFF D R198
D
8
2
D 2 D
VIN
C63 D
U28 .033UF 63V TP12 6 6
VOUT _ 7 D
LM2678S-ADJ +5V
6
3
MP 2824 4 GND 5 +
-12V TP11
U27
CB
-8V -8V
FB
L1 U26B LM337LM
2
VI 2 VIN VOUT 1 +5V D LM393M
C142
GND
ONF
A
77UH SMT R294 3 1
1UF X7R 499K -12V VIN VOUT -8V
C65 U29 TP34 DGND DGND
+ D28 10% 1206 TP13 6
+ C66
ADJ
47UF 50V LM2931CM B AGND
MBRS340T3 R134 C64
7
+8V
C
ALUM 680UF 10V D
ALUM 249 OHM + 180UF TANT
GND3ADJ
16V SIZE-R AGND
4
D 8 1 AGND
GND7
GND6
GND2
+12V VIN VOUT +8V
D A A
+5V + C67 R135 + C68 R136
33UF TANT 1.21K 180UF TANT 1.33K NOTES:
7
6
3
2
U31 MP 2824
+12V 4. NOT USED: R243,R244,SF2,SF3,SF5.
CB
FB
L2 R242
2 1 +12V A TP14
VI VIN VOUT 4.99K
GND
ONF
-12V
53UH SMT
R212 +5V 1
POWER SUPPLY
C74 D29
+ C75 -12V J112
+ MBRS340T3 + C71
+12V
2
AND TRIGGER OUT
7
47UF 50V
3
A 8.2UF + 6 OSC
BRANFORD, CT., 06405 USA
180UF TANT VREF
GND
REVISIONS
TEST CSATD BREQ RESET REV DESCRIPTION BY DATE
OPTIONS SETTINGS TEST CSATD BREQ RESET
DIAD HONK STRB1 DSACK1 00 INITIAL RELEASE PER ECN 2042. GP 12-27-11
DIAD HONK STRB1 DSACK1
OPTIONS REFERENCE INSTALLED NOT INSTALLED VCC CLKAD CLKAD BEEP BEEP STRB2 STRB2 DCNCT-
FILTER DCNCT-
DOAD DOAD T150 T150 STRB3 STRB3 XOFFI
RSPOUT R241 RESP OUTPUT NO RESP OUTPUT XOFFI
SW3 CSAD CSAD HONKD HONKD R/W CSUAR
R/W CSUAR
20
492008
LDRSP LDRSP /WRT /WRT DS RDOSW
16 1 2 18 D8 DS RDOSW
VCC
1A1 1Y1 D9
15 2 4 1A2 1Y2 16 DOUT DOUT /RD /RD AS
AS
WITH1
WITH1
14 3 6 14 D10
1A3 1Y3 D11
13 4 8 12 SHFT SHFT CS2 CS2 1.8MHZ WITH2
SW3 SWITCH SETTINGS 12 5 11 1A4
2A1
1Y4
2Y1 9 D12 1.8MHZ WITH2
11 6 13 7 D13 50KHZ 50KHZ HONK HONK EVENT PRES
10 7 15 2A2 2Y2
5 D14 EVENT PRES
2A3 2Y3 D15 IRQ5
SW3 (SWITCH No.) ON OFF 3200 / 3303 9 8 17 2A4 2Y4 3 D[0..15] IRQ5
D[0..15] -12V
GND
D 1 1G
IACK5
IACK5 -12V -12V
D
1 3050, 3100, 3150, 3000T-B 3000 OFF 19 2G
R213 R215 R217 R219 U49 A[1..18]
2 MONITORING DEFAULTS TRIGGER DEFAULTS OFF TP16
10
10K 10K 10K 10K CD74HCT244M +12V +12V
3 - ECG FILTER ON OFF OFF DGND +12V
DGND DGND
4 - PACER DETECTION DISABLE ON POWER UP ENABLE ON POWER UP OFF R214 R216 R218 R220 GND
D
RDOSW +5V
5 ECG SIMULATOR NO ECG SIMULATOR OFF 10K 10K 10K 10K D +5V
IF SW3-1 & SW3-7 = OFF 6 - TRIG POLARITY +/- MENU CONTROL NO MENU OFF C76
* VCC TP17 VCC VCC VCC
IF SW3-1 & SW3-7 = ON 6 - P-LOCK P-LOCK ENABLED P-LOCK DISABLED OFF AGND SPK-B
680PF NPO
7 - TOSHIBA FILTER ON OFF OFF AGND AGND
-8V -8V
U33 3
A R141 J110
* SW1-1, SW1-2 AND SW1-3 MUST BE OFF WITH THIS SELECTION. CY7C1009-20VC LOVLA
2
1 SPEAKER
A0 12 A0 D8 +5V 60.4K
A1 D0 13 D9
11 A1 D1 14 R195
A2 10 A2 D10
R250 R252 R254 KESFT1 A3 D2 15 D11 R142 3.32K SPK-A
9 A3 D3 17 1 SDWN VO2 8
KESFT2 A4 8 A4 D12
100 100 100
KESFT3 A5 D4 18 D13 10K C79 2 BYPS GND 7 VCC
OHM OHM OHM 7 A5 D5 19 R143 R144 R145 3 +IN VDD 6
KESFT4 A6 6 A6 D14 HONK
KESFT5 R173 A7 D6 20 D15
4 -IN VO1 5
C80
5 A7 D7 21
KEALRO 10K A8 27 A8 10K 2K 20K .1UF CER
A9 26 A9 CS3 D .01UF 63V C82 U35 C83
R174 CS1 22
KEALRO
1
A10 C84
KESFT5
KESFT1
KESFT3
KESFT4
KESFT2
10K 23 A10 CS2 30
MP 2824 .1UF LM4861M
R249 R251 R253 R175 A11 25 A11 HONKD G3 CER D
R176 A12 /WRT R147
100 100 100 R178 4 A12 WE 29 R148 A .1UF A
10K A13 28 A13 /RD
OHM OHM OHM R177 10K A14 OE 24 .22UF 63V Q18 4.99K 32.4K +5V CER
10K 3 A14 R151
2
10K A15 31 A15 R150 MP 2824 MMBF5460LT1
A16 NC 1 10K 1.47M D30 S C85 +5V
VCC 2 A16 MMBD4148 .01UF 63V
16 GND VCC 32 VCC MP 2824
Q19 R154
D +5V A D MMBF5460LT1 10K
1
VCC R196 R156 C86
VCC R221 BEEP 3G T150
VCC 4.02K 4.02K
10K VCC VCC R159 .033UF 63V
R140 R157
2
DSACK1 C77 C78 10K R197 R160 D31 MP 2824
VCC S MMBD4148
5
IACK5
U36
PRES
A0
Vcc
D15
D12
D11
D13
D14
D10
DSACK0
D9
D7
D6
D5
VCC 2853-00-04 +5V LOVL
D8
D4
D3
D2
D1
D0
C BR D D
60HZ 60HZ 4 Y A 2 VCC BGACK 1 DU DQ0 21 D0
J119 D
R146 10K A1 24 A0 DQ1 20 D1 R233
A2
GND
A27/IACK3
A26/IACK2
A25/IACK1
DSACK1
DSACK0
GND
VCC
GND
VCC
GND
GND
VCC
GND
VCC
A24
D15
D14
D13
D12
D11
D10
A0
D9
D8
D7
D6
D5
D4
D3
D2
D1
D0
LN FREQ D D A9 32 A7 DQ8
10 D9 4 3
R192 10K A10 35 A8 DQ9 9 D10 WIRED_ECG_OFF_1 6 5
IRQ7 A11 A9 DQ10 D11 8 7
36 A10 DQ11 8 VCC A -12V 10 9 +12V
50HZ 50HZ 108 CS0 A12 37 7 D12 R235 R273
1 CS0/AVEC
107 CS1 A13 38 A11 DQ12
6 D13 A 12 11 A
R/W RMC CS1/IRQ2 CS2 IRQ3 R152 10K A14 A12 DQ13 3.32K IMP VCC 14 13 RADIO_CH0
2 R/W CS2/IRQ2 106 39 A13 DQ14 5 D14
C104 WIRED_ECG_OFF_2
3 105 A15 40 4 D15 4.75K
4 SIZ1 IRQ3
104 CS3 A16 41 A14 DQ15 .1UF + C105 J117
DS SIZ0 CS3/IRQ4 A15 /RD 6.8UF TANT
5 DS GND 103 42 A16 /OE 22 CER R237 170520
AS 6 102 12 3 CS0 20V 3528
BGACK 7 AS VCC
101 IRQ5 R155 10K 34 GND /CE A
VCC 8 BGACK IRQ5
100 DONE2 GND
44 A C106 4.75K MATES WITH 182008
RESET BR 9 BG IRQ6
99 IRQ7 D 23 VCC
33 VCC .047UF X7R SHFT RESP
DS BR IRQ7 DONE2 DU NC 1 2
R190 BERR 10 BERR DONE2 98 R158 10K VCC 2 VPP /PGM 43 20 VDD CH0 1 10% 1206
TSTR
3 4
LDRSP
BERR HALT 11 97 DONE1 CLKAD 19 2 DOUT RSPOFF
RESET HALT DACK2 BREQ CSAD SCLK CH1 C122 5 6
12 RESET /DREQ2 96 SOCKET 18 /CS CH2 3 R274 A 7 8
10K 13 95 DONE1 R161 10K R290 0 OHM 44 PIN DIAD 17 4 .047UF X7R
14 GND DONE1
94 HALT A17 16 DIN CH3
5 3.32K 50KHZ +12V 9 10 -12V
15 CLKOUT DACK1 93 DOAD 15 SSTRB CH4 6 10% 1206 A 11 12 A
16 VCC
XFC
U37 DREQ1
X1 92 EXP. MEM. OPTION 14 DO CH5
DGND CH6 7 13 14 CONNECTIONS
17 91 13 8 R232
18 VCC MC68340FE16 GND 90 12 AGND CH7 9 A RESP KEYING PLUG
WITH SW2 IN
9
7
5
3
1
BER DS
170513 MODCK RTSB COMTX 100 OHM VCC 10% 1206 .1UF DNI
23 85 MAX186DCAP
24
25
VCC
IPIPE
TXDB
RXDB 84
83
CRDSW Y1
1.8432MHZ SMT VCC C87
D A
U4A CER 0 OHM 0805 J108
AUX *
4
A
10
27 BKPT RXRDYA
81 -SINEN M48T58SOH28 C110 A 2 RESP_OUT 1
R238
Vcc
28 FREEZE CTSA
80 -SOUTEN .1UF 1 - VCC 1
6 TRIGGER_OUT
TIN1 RTSA D C112 6
28
29 79 BATTERY CER 3 15.8K GND 2
TOUT1 GND .1UF 10 OHM + 2 XOFF
30 TGATE1 VCC 78 3 OUT 7 7
31 77 SIN 1 19 D15 CER -8V 3
VCC
A
11
TCK TXDA SOUT A12 FT DQ7 C111 3 +5V
GND
32 TMS RXDA 76 2 A12 DQ6 18 D14 C108 8 8
TSTR 33 75 A11 23 17 D13 6.8UF TANT+ C109 DCNCT- 4
TDI TIN2 A10 A11 DQ5 D12 .1UF 4
34 TDO TOUT2 74 21 A10 DQ4 16 20V 3528 1UF X7R C11 9 9
WITH1 35 73 WITH2 R166 A9 24 15 D11 CER 5
36 VCC TGATE2 A8 25 A9 DQ3
13 D10 10% 1206 -12V .1UF 5
R269
2
B GND 100 OHM A7 3 A8 DQ2
12 D9
VCC A6 A7 DQ1 A CER
GND
GND
GND
GND
GND
4 11 D8
VCC
VCC
VCC
VCC
FC3
FC2
FC1
FC0
R270
A23
A22
A21
A20
A19
A18
A17
A16
A15
A14
A13
A12
A11
A10
10K A5 A6 DQ0
5
A9
A8
A7
A6
A5
A4
A3
A2
A1
D A4 6 A5
20 A R169 A
10K A4 /E1
D VCC A3 7 26
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
1.8MHZ A2 A3 E2
16US 8 A2 /G 22
VCC A1 9 27 15.8K
A0 A1 /WRT
10
VSS
16MHZ A0
R247 1.8MHZ-1 VCC
C89
*
/WRT
D .1UF CER
14
100 OHM J108
CS1
/RD
VCC AUX
A9
A8
A7
A6
A5
A4
A2
A1
A3
7
A18
A17
A16
A15
A14
A13
A12
A11
A10
D
C90 D TXD4C SF15 MEM2012P10R0 RESP_OUT 1
2 5
VCC
RTS4C 1 T1IN T1OUT
18 J109-3 1 3 X1000_OUT 1
6
VCC T2IN T2OUT 2 4 TXD 2 6
2 CTS
D .1UF CER SF14 MEM2012P10R0 7 7
RXD4C 3 4 RXD 3
CTS4C 20 R1OUT R1IN
19 1 3 3
8 RTS
R2OUT R2IN 2 4 4 8
R292
+5V 4
SF13 MEM2012P10R0 9 9
+5V +5V OFF 12 5
KEALRO
C2+ 1 3 5 DNI
KESFT1
KESFT2
KESFT3
KESFT4 15
KEALRO
STRB1
KESFT4
KESFT1
KESFT2
KESFT3
1 21 KESFT5 13 C2+
11 2 4
KESFT5
38
39
7 27 -SOUTEN
PPR 8 7 27
28 -SINEN U40 1 3
9 8 28
29 23 22 D0 MAX233ACWP 2 4
VCC
VCC
9 29 RECRDY NC D0
10 10 30 30 11 NC D1 12 D1
SF10
11 31 RES 21 D2 MEM2012P10R0
11 31 D2 1 3
12 32 A1 40 13 D3
13 12 32
33 A2 42 A0 D3
20 D4 2 4
13 33 A1 D4
14 34 A3 44 14 D5
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
+12VREC 15 14 34
35 A4 1 A2 D5
19 D6 SF9 MEM2012P10R0
J113 NOTES:
* 15 35 D D 1 3
3
4
3
4
A3 D6
3
4
3
4
3
4
3
4
3
4
3
4
16 36 15 D7
MEM2012P10R0
MEM2012P10R0
SF22 MEM2012P10R0
SF20 MEM2012P10R0
MEM2012P10R0
SF16 MEM2012P10R0
SF21 MEM2012P10R0
SF19 MEM2012P10R0
R182
IN
IN
IN
IN
IN
IN
IN
-V
IN
IN
IN
IN
IN
IN
IN
-V
+ C93 17 16 36
37 R181 D RXD4C 29 D7
1 2 +12V 2 4
17 37 470K 470K U52 U48 RXDA COMTX +12V 1. ALL RESISTORS ARE 1/10W, 1%, SIZE 0805 U.O.S.
6800UF 16V TL 18 18 38 38 VCC
TXD4C 28 TXDA X1/CLK 30 1.8MHZ-1 3 4
19 39 SP720AB SP720AB RTS4C 27 31 COMRTS 5 6 ALL .1UF CER CAPACITORS ARE SIZE 0805 U.O.S.
20 19 39 40 CTS4C 2 OP0/RSTA X2 CRDSW 7 8 D
V+
V+
+5V
IN
IN
IN
IN
IN
IN
IN
IN
IN
IN
IN
IN
IN
IN
RECGND 20 40 IP0/CSTA
VCC RADIO_SOUT 5 INTRN 18 IRQ3
COMCTS
+5V
9
11
10
12 +5V
2.
* INDICATES A THROUGH HOLE COMPONENT.
16
15
14
13
12
11
10
16
15
14
13
12
11
10
RXDB SW2
J105 RADIO_SIN 6 33 CSUAR 13 14
9
9
SF23
SF17
TXDB CE
SF18
1
2
IP1/CSTB OE RV6,SF23,SW3,T1,TP34,U63,Y2.
1
2
1
2
1
2
1
2
1
2
1
2
U41
RESET
XOFFI 35 IP5
IP6 OP7
OP6
10
24
micro
SMD010
9
8 PROCESSOR,
GND
GND
Q20 26 9 12
MAX690A-CSA CMPT3906
Z0 8 OP2 OP5
25 D XOFF 11 A/D AND COM
2
PFI
POWER D SF6 ACH3218-472 13
14 IVY BIOMEDICAL SYSTEMS INC.
CSAD D ACH3218-472 R222 11 BUSINESS PARK DRIVE
6 WDI PFO 5 -8V 18
POWERLED STRB3
GND
8 7 806 OHM D 16
VB RS D (203) 481-4183
1K DWN: GP 11/10/11 CHK: GC 11/10/11 APR: RAM 11/10/11
R180
10
11
12
13
14
15
16
17
18
1
2
3
4
5
6
7
8
9
D
SW2 SHOWN
3
1K D TRIGGER_OUT Title
ADULT / NEONATE 3 LEAD ECG & PEAK DETECTOR BOARD
J102
IN "COM"
D Size Document Number Rev
D FRONT PANEL POSTION D 5197-01-01 (-03 SCHEMATIC) 00
Date: Tuesday, December 27, 2011 Sheet 3 of 5
5 4 3 2 1
5 4 3 2 1
REVISIONS
REV DESCRIPTION BY DATE
00 INITIAL RELEASE PER ECN 2042. GP 12-27-11
VCC VCC
C115 C116
.1UF CER .1UF CER
D
D
va[0..16]
D
WA[0..15]
wd[0..15]
VCC VCC
CSUAR
LNFREQ
U42 CSUAR
hsynch
HONK
Data0
wa14
wa11
wa10
wd11
wd14
wa12
vd12
vd11
vd15
C100 C101 CY7C1021-12ZC 16US
GND
GND
GND
D11
D10
D15
D14
wd3
wd2
wd6
wa9
wa6
wa7
wa8
16US
A15
A14
A10
A11
VCC
VCC
VCC
dclk
wa15
vd2
vd1
vd6
vd5
vd9
tste
va9
va5
D1
D5
D4
D7
A6
A4
A5
A1
de
.1UF CER .1UF CER 40 /BHE D0 7
wd0 PACE
39 /BLE PACE
D1 8
wd1
22 NC D2 9
wd2 L1
L1
208
207
206
205
204
203
202
201
200
199
198
197
196
195
194
193
192
191
190
189
188
187
186
185
184
183
182
181
180
179
178
177
176
175
174
173
172
171
170
169
168
167
166
165
164
163
162
161
160
159
158
157
R248 23 NC D3 10
wd3
1 NC D4 13
wd4 LO
L0
28 NC D5 14
wd5
0 OHM wa0 5 A0 D6 15
wd6 PDO
wave_data12
wave_data11
wave_data15
wave_add14
wave_add11
wave_add10
wave_add12
video_data2
video_data1
video_data6
video_data5
video_data9
wave_data3
wave_data2
wave_data6
host_add15
host_add14
host_add10
host_add11
wave_add9
wave_add6
wave_add7
wave_add8
vram_add9
vram_add5
host_add6
host_add4
host_add5
host_add1
wram_cs
VCCIO
VCCIO
VCCIO
hsynch
data0
WD11
WD14
4KHZ
TSTE
hd11
hd10
hd15
hd14
GND
GND
GND
hd1
hd5
hd4
hd7
dclk
DE
wram_we 1 156 wa13 4 A1 PDO
D7 16
wa1 wd7
green1 wram_we wave_add13 va3
2 green1 vram_add3 155 wa2 3 A2 D8 29
wd8 22MS
22MS
green2 3 154 va4 2 A3 D9 30
wa3 wd9
STRB1 DTRG green2 vram_add4 VRAM_CS
4 DTRG vram_cs 153 wa4 18 A4 D10 31
wd10
A18 5 152 CSUAR 44 A5 D11 32
wa5 wd11
6 host_add18 CSUAR 151 vsynch DCNCT- 43 A6 D12 35
wa6 wd12 SAMPLE
VCC R255 GND 7 ^nCE vsync
150 conf_done 42 A7 SAMPLE
D13 36
wa7 wd13
VCC 8 GND CONF_DONE
149 VCC R203 27 A8 D14 37
100 wa8 wd14 LNFREQ
VCC 9 VCCINT VCCIO
148 VCC 1K 26 A9 LNFREQ
D15 38
wa9 wd15
OHM A16 VCCIO VCCINT GND
R205 10 host_add16 GND 147 wa10 25 A10 R271 NOTCH-
NOTCH-
A17 11 146 24 A11 CE 6
NEO wa11
10K host_add17 PRES va2
LOVLA 12 STRB1 vram_add2 145 CMPD6263 wa12 21 A12 332 OHM
BREQ
BREQ
13 144 /WRT wa13 20 A13
GATF LOVLA /WRT va16 XOFFI
14 GATF vram_add16 143 D34 wa14 19 A14 WE 17
wram_we STRB1
STRB1
IRQ5 15 142 va15
OE 41
WRAM_OE
16 eow_int vram_add15
141 va1 R204 STRB2
WD13 17 SHFT vram_add1
140 wa0 1K 34 33 STRB2
1.8MHZ 18 WD13 wave_add0 139 wa2 12 GND VCC 11 STRB3
SHFT L1 19 1.8MHZ wave_add2
138 wa5 XOFF GND VCC VCC STRB3
DIAD L1 wave_add5 wa4
20 DIAD wave_add4 137 D
COMCTS
COMCTS
SAMPLE 21 136 wa3
VCC CSAD 22 SAMPLE wave_add3
135 wa1 DOUT
23 CSAD wave_add1
134 50KHZ DOUT
LOVL RESET LOVL U43 50KHZ DOUT
24 clear DOUT 133 LOD
LOD
C GND 25 EPF6016QC208-2 132 DOAD
R231 VCC 26 GND DOAD
131 VCC SHFT
10K VCC 27 VCCINT VCCIO
130 VCC SHFT
clock 28 VCCIO VCCINT
129 GND VCC RDOSW
TSTR 29 clock GND
128 IACK5 RDOSW
LOD TSTR intack5 cs2
30 LOD host_cs3 127 DTRG
DTRG
T150 31 T150 ds 126 ds R199 U46
CLKAD 32 125 RDOSW DCNCT-
NOTCH- 33 CLKAD RDOSW 124 as 10K CY7C1041B-15ZC DCNCT-
dsack1 NOTCH- as COMCTS
34 dsack1 CTSET 123 40 /BHE D0 7
vd0 XOFF
XOFF
wa15 35 122 LDRSP 39 /BLE D1 8
vd1
HONKD 36 wa15 LDRSP 121 r/w D2 9
vd2 XOFFI
green5 37 HONKD r/w
120 vram_we XOFFI
D3 10
vd3
green3 38 green5 VRAM_WE 119 red5 28 NC D4 13
vd4
blue3 39 green3 red5
118 blue1 D
D5 14
R256 vd5
blue2 blue3 blue1 STRB3
40 blue2 STRB3 117 va0 1 A0 D6 15
vd6 R/W
R/W
blue4 41 116 2 A1 D7 16
va1 vd7
green4 blue4 STRB2 red1 100 OHM
42 green4 red1 115 va2 3 A2 D8 29
vd8 DS
DS
43 114 red2 4 A3 D9 30
GND va3 vd9
VCC GND red2 red3
44 VCCINT red3 113 R257 va4 5 A4 D10 31
vd10 AS
AS
VCC 45 112 VCC STRB2 18 A5 D11 32
va5 vd11
VCCIO VCCIO VCC
46 MSEL VCCINT 111 va6 19 A6 D12 35
vd12 1.8MHZ
1.8MHZ
blue5 47 110 100 OHM 20 A7 D13 36
GND va7 vd13 VCC
va14 blue5 GND red4
48 109 va8 21 A8 D14 37
vd14 EVENT
EVENT
video_data10
video_data13
video_data14
wave_data0
wave_data1
wave_data4
wave_data5
wave_data7
host_add13
host_add12
WRAM_CS
vramadd10 L0 IRQ5
vramadd13
vram_add8
25_MHz 50 107 va0 23 A10
host_add3
host_add9
host_add8
host_add2
host_add7
va10
va11 25MHz vram_add0 va6 R272 IRQ5
51 vramadd11 vram_add6 106 va11 24 A11 CE 6 C102
16MHZ
nconfig
nstatus
VCCIO
VCCIO
VCCIO
va12 52 105 va7 va12 25 A12 IACK5
BREQ
WD12
WD10
WD15
PACE
22MS
IACK5
2KHZ
16US
vramadd12 vram_add7 332 OHM .1UF CER
hd12
hd13
WD8
WD9
GND
GND
GND
PDO
va13 26 A13
/RD
hd0
hd2
hd3
hd6
hd8
hd9
va14 27 A14 WE 17
vram_we RESET
RESET
va15 42 A15 OE 41
VRAM_CS
100
101
102
103
104
va16 43 A16 16MHZ
16MHZ
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
44 A17 VCC 33
GND
GND
VCC 11
DSACK1
VCC DSACK1
nstatus
va13 va8
wd8
wd9
vd14
vd10
vd13
wd12
GND
GND
GND
D13
wd1
wd4
BEEP
D12
wd0
wd5
wd7
A13
A12
/RD
22MS
WRAM_OE
vd0
vd3
vd4
vd7
vd8
16US
A7
PDO
D3
D8
D9
D0
D2
D6
VCC
VCC
A3
A9
A8
A2
34
12
wd10
wd15
BREQ
VCC
PACE
HONK
HONK
R188 BEEP
16MHZ BEEP
T150
100 OHM T150
D J114 HONKD
vd[0..15] HONKD
SF4 210067 /WRT
ACH3218-101 DISPLAY /WRT
25_MHz GND LUG /RD
/RD
CS2
B 1 CS2
red[0..5] D 2 RDOSW
RDOSW
green[0..5] DIAD
D DIAD
blue[0..5] CSAD
CSAD
1 CLKAD
hsynch 2 CLKAD
VCC vsynch 3 DOAD
4 DOAD
5 LDRSP
red1 6 LDRSP
A[1..18] red2 7 50KHZ
red3 8 50KHZ
red4 9
D[0..15] R186 R187 VCC red5 10
10K 10K 11 TSTR
VCC 12 J104 TSTR
green1 13 DISPLAY TSTE
TSTE
4
Data0 green2 14
15 191501
dclk green3 NEO
+5VDC
OUT 19
2855-01-04
3
2
1
100 OHM 20
GND
blue1
blue2 21
DATA
VCC
N/C
N/C
N/C
4 DCLK blue3 22
blue4 23
5 18 Y2 blue5 24
N/C VCC
2
6 N/C EMC60S5B-048 25
7 17 DE 26
N/C N/C
N/C 16 27
8 15 J103 D 28
nCASC
OE N/C +5V 29
INVPWR
GND
14 30
nCS
N/C
N/C
N/C 31 +5V
+5V NOTES:
8
7
6
5
1
2
1. ALL RESISTORS ARE 1/10W, 1%, SIZE 0805 U.O.S.
10
11
12
13
3 D
9
PGND 4 Q21 ALL .1UF CER CAPACITORS ARE SIZE 0805 U.O.S.
VCC VCC VCC
IRF7205/SO
SOCKET
20 PIN PLCC
* VCC
2.
* INDICATES A THROUGH HOLE COMPONENT.
1
2
3
4
DGND RV6,SF23,SW3,T1,TP34,U63,Y2.
DGND DGND
A
C94 GND 4. NOT USED: R243,R244,SF2,SF3,SF5.
+
10V 3528
10UF TANT D
GATF VIDEO AND
D ONE TEST
POINT ON EACH
MEMORY
SIDE OF BOARD
IVY BIOMEDICAL SYSTEMS INC.
TP33 TP19 11 BUSINESS PARK DRIVE
AGND AGND BRANFORD, CT., 06405 USA
AGND
(203) 481-4183
AGND
DWN: GP 11/10/11 CHK: GC 11/10/11 APR: RAM 11/10/11
Title
A ADULT / NEONATE 3 LEAD ECG & PEAK DETECTOR BOARD
Size Document Number Rev
D 5197-01-01 (-03 SCHEMATIC) 00
Date: Tuesday, December 27, 2011 Sheet 4 of 5
5 4 3 2 1
5 4 3 2 1
3
TP28 +6.5VI
REVISIONS
C123 R279
10HZ TP29 C139 +6.5VI R278 REV DESCRIPTION BY DATE
.1UF 50V MP 1812
332K Z1 10K 00 INITIAL RELEASE PER ECN 2042. GP 12-27-11
-6.5VI U59A .01UF
C130 I C125
R275 LT1058SW
4
C124 CER .1UF R276
1 2
MMBD1503 3 + CER
240000
10K .1UF CER 1 249 OHM
.1UF CER I I 2 - I
-5VI I
13
U57B Q26
13
LT1884CS8 MMBF4393
U57A 2 -
R280 -6.5VI R283
4
R277 6 1 1 2
2
2 LT1884CS8 7 U58A 3 +
C141
499 OHM
1 _ 5 LT1058SW 100K 1 Q27
D + 3 261K .01UF CMPT3906
D
3
+5VI I C135 CER
C127
3
I
8
I I 22PF CER
R282 .1UF NPO -6.5VI
I +12V
C128 +6.5VI CER C126
9.09K 1 8
R284 .1UF R281
.1UF 402K R288 D32 CER 1K D39
MMBD1503A 2 7 R285 MMBZ5234B
1
CER I 49.9K 3 6 A
511K 6.2V
U59B R200 4 5 RV6 A
R287 R289
R286 -6.5VI +6.5VI 3 LT1058SW 200K 100K 5 TURN
RA1 100K R11
5 + 3M Z BAL
1K 49.9K 7 D40
2
6 - I A
Q28 C131 C132 U61 MMBZ5234B
3
MMBF4393 .1UF .1UF IL300-X007
2
CER CER 6.2V
15 -
R60 R17
1
I I C133 A
13
16 11 -
4
14 + 10 1K
I 2 3 49.9K 12 + C129
1 .1UF 50V U58D .01UF 250V MP 1913 -12V
15 14 MP 1812 U58C
R153 16 R162 LT1058SW C134
7 6 I LT1058SW .1UF
LA1 8 324K I U59C
1K 10 11 C136 LT1058SW CER
2
9 .01UF +5VI
Q29 3 U20 12 +
CER I C137 10 A
MMBF4393 MAX327CSE
C 11 - C
5
R165 TP30
1
1=ON I U56A
I R168 .01UF 499K ANALOG OUT
0=OFF TL062ACD
4
I 3K CER I
R172 U58B 2
8
R164 10K LT1058SW
_ 1
LL1 3 + 3 +
*
1 6 -
1K 2 _ 7
2
U32A 5 + IMP
8
Q2 3 LM393M A
R201 R202 15 -
4
MMBF4393 16
100K 4.02K I C138 +12V
14 +
1
-5VI
I RV5
U59D .1UF
I 200K 5 TURN
I 5 + LT1058SW CER Z GAIN
7 TP31
*
6 _ R206 Set Z BAL = -5V for
U32B 402K zero ohms input
LM393M Set Z GAIN = +4V for
R207 I
3K 150K ohms input
C140
.01UF U56B
-5VI CER I ISOLATED NON ISOLATED TL062ACD
6
7
B
5 B
+5VI A
+6.5VI
C88
C91 .1UF Z0 Z1 Q28 Q29 Q2
.1UF CER R208 R209
U60A 100K 100K
CER LT1058SW ECG 0 0 OFF OFF OFF
4
I
U60D I
R210 + 3 RA 1 0 OFF ON ON
LT1058SW 1
1M - 2 LA 0 1 ON OFF ON
+ 14 U45
16 C95 LL 1 1 ON ON OFF
13
16
- 15 CD74HCT238M96 +5V
I 15 A0 1
VCC
O0
.1UF
1
I CER -6.5VI A1 2
14 O1
A2 3 NOTES:
13 O2 R211
R224 + 5 1. ALL RESISTORS ARE 1/10W, 1%, SIZE 0805 U.O.S.
2
7 12 Z0
O3 4.99K ALL .1UF CER CAPACITORS ARE SIZE 0805 U.O.S.
1M - 6 E1 4
U47
11 O4 I
D33
G C
U60B
LT1058SW MMBD4148CC 10
9
O5 E2 5 CNY17F-3X007 2.
* INDICATES A THROUGH HOLE COMPONENT.
1
1M
U60C R239
8
D S B E
LT1058SW 100K R226 IVY BIOMEDICAL SYSTEMS INC.
3
4
REVISIONS
VCC REV DESCRIPTION BY DATE
VCC 01 REVISED FOR REV-01 ENGINEERING ARTWORK FAB. GP 1-10-07
02 REVISED FOR REV-02 ARTWORK FAB PER ECN 1631. GP 2-15-08
VCC C2 03 REVISED PER ECN 1656. GP 3-21-08
.1UF CER 0805 04 REVISED FOR REV-03 ARTWORK FAB PER ECN 1681. GP 6-30-08
C3 C4 C5 C6 C7 05 REVISED PER ECN 1788. RM 6-16-09
U1 TP2 .1UF CER 0805 .1UF CER 0805 .1UF CER 0805 .1UF CER 0805 .1UF CER 0805
MAX811TEUS-T
06 REVISED PER ECN 1819. GP 1-14-10
4
/RES
SHDWN-
VCC
BYPASS CAPS
TP1
3 MR RESET 2 J1
RXD VCC
GND
3
VCC R3
1 2 RTS
VCC 3 4
PRES Q1 5 6 10K 0603
1
2 7 8
DTC114 C8
D
VCC .1UF CER 0805 9 10 D
U2
+ C13 D[15:0]
16
LTC1386 180006
22UF TANT 16V 6032
C9 1 4
VCC
.1UF CER 0805 VCC C1+ C2+
NRESET
GPIO_0
GPIO_1
NBEH
NBEL
SOCKET
D0
D1
D2
D3
D4
D5
D6
D7
C11 C12
VCC
8 PIN VCC .1UF CER 0805 .1UF CER 0805
U3 TP3
R4
SO8
TXD
1 A0 VCC 8 10K 0603 3 C1- C2- 5
TP4
A[15:1] SCL GPIO_28 TX
2 A1 WP 7 11 TR1IN TR1OUT 14
100
U4 VCC TP5 GPIO_27 RX
99
98
97
96
95
94
93
92
91
90
89
88
87
86
85
84
83
82
81
80
79
78
77
76
12 RX1OUT RX1IN 13
GPIO_30 RTSX
3 A2 SCL 6
GND
nBEH
VCC
nRESET
RESERVED
nBEL/A0
nRAS/A16
nCASL/A18
nCASH/A17
GPIO_0
GPIO_1
GPIO_2
GPIO_3
GPIO_4
GPIO_5
GPIO_6
GPIO_7
D0
D1
D2
D3
D4
D5
D6
D7
A1 1 75 4 5 GPIO_31 GPIO_1 10 7
A2 A1 GND D8 GND SDA TR2IN TR2OUT
2 A2 D8 74 9 RX2OUT RX2IN 8
A3 3 73 D9
A3 D9 D10 2906-00-04
4 72 R5 TP6
GND
DM2B D10 D11
5 DP2B D11 71 10K 0603 SDA 6 V- V+ 2
6 70 D12
A4 AGND D12 D13
7 69
15
A5 A4 D13 D14
8 A5 D14 68
9 67 D15 VCC C14 C15
DM2A D15 VCC .1UF CER 0805 .1UF CER 0805
10 DP2A GPIO_8 66
11 OTG_VBUS GPIO_9 65
12 64 NWR
CSWITCHB CY7C67300 100TQFP nWR A[15:1] D[15:0]
13 CSWITCHA VCC 63
VCC 14 62 NRD
VSWITCH nRD U6
VCC
11
33
15 BOOSTGND GPIO_10 61 CY7C1021DV33
16 BOOSTVCC GPIO_11 60
A6 17 59 A1 5 7 D0 U5
VCC
VCC
VM_B A6 GPIO_12 A2 A0 IO_0 D1 VCC NL17SZ74
18 DM1B GPIO_13 58 4 A1 IO_1 8
8
VP_B 19 57 A3 3 9 D2
A7 DP1B GPIO_14 A4 A2 IO_2 D3 GPIO_27
20 nDRAM_WE/A15 56 2 10 7
VCC
A7 GPIO_15 A5 A3 IO_3 D4 /PR
21 AVCC GPIO_16 55 1 A4 IO_4 13 Q 5 GPIO_1
VM_A 22 54 A6 44 14 D5 R2 R1 2
nXMEMSEL
nXROMSEL
nXRAMSEL
GND
GPIO_31
GPIO_30
GPIO_29
GPIO_28
GPIO_27
GPIO_26
GPIO_25
GPIO_24
GPIO_23
GPIO_22
GPIO_21
GPIO_20
A8 DP1A GPIO_18 A8 A6 IO_6 D7 CP /Q
XTALIN
VCC
A9 GND A8 IO_8
A10
A11
A12
A13
A14
A10 26 30 D9
A11 A9 IO_9 D10 GPIO_26 GPIO_21
4
25 A10 IO_10 31
A12 24 32 D11
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
A13 A11 IO_11 D12
21 A12 IO_12 35
A14 20 36 D13
VCC VCC A15 A13 IO_13 D14
19 A14 IO_14 37
18 38 D15
R6 A15 IO_15
NROMSEL
NRAMSEL
GPIO_28
GPIO_26
GPIO_21
A11
A13
A12
A14
A15
CE
17 WE NC1 22
NBEL 39 23
NBEH BLE NC2 VCC
40 28
VSS
VSS
NRD BHE NC3
41 OE
12
34
VCC + C10 C1
64K x 16 SRAM 22UF TANT 16V 6032 .1UF CER 0805
4
addressable J2
C17 1 VBUS
5
GND
Y1 2 5
+ C18 S1
12MHz 6 S2
6
5
4
U7 22UF TANT 16V 6032 +5V
S
2
NL17SZ08
GND
A
B
U9 170018
1 ENA OUTA 8 U11
2 7
GND
FLGA IN SN65220DBV
NC
NC
3 6 L1
FLGB GND
B
4 ENB OUTB 5 B
LI0805H121R-10
1
2
3
MIC2026-2BM
+5V VCC TP8 TP9 J3
U10 L2
F1 R7 VCC GND
LT1529CQ-3.3 1 VBUS
J4 3ASB SMT L3 VM_B
100K 0805 LI0805H121R-10 2 DM
VP_B
1
HI1806T600R-10
5 VIN VOUT 1
+ C20 + C21
3
4
DP INTERNAL USB PORT
2 SHDWN- 150UF 10V ALUM 150UF 10V ALUM GND
3 4 SHDN SENSE 2 5 S1
PRES + C19 6
GND
GND
J5
1 2
3 4
5 6 USB FLASH DISK MODULE
7 8
9 10
170513
NOTES:
1. LAST USED: C24, F1, J5, L3, Q1,R7, TP9, U11, Y1.
1. ASSEMBLIES
a. 2697-00-01 Rear Panel Assembly, 3000 series
b. 2698-00-01 Bottom Cover Assembly, 3000 series
c. 2699-00-01 Front Assembly, 3000 series
d. 2700-00-01 Main Assembly, 3000 series
e. 2701-00-01 Final Assembly, 3000 series
2. IDENTITY KITS
a. 2738-00-15 Kit, Model 3000
b. 2738-01-15 Kit, Model 3050
c. 2738-02-15 Kit, Model 3100
d. 2738-03-15 Kit, Model 3200
e. 2738-04-15 Kit, Model 3150
f. 2738-05-15 Kit, Toshiba Model 3000
g. 2738-12-15 Kit, USB
h. 2739-00-15 Kit, Recorder, Model 3000
i. 2739-01-15 Kit, Recorder, Model 3100
3. OPTION KITS
a. 2752-00-15 Kit, Without recorder
b. 2772-00-15 Kit, ECG Simulator
c. 2772-01-15 Kit, No ECG Simulator
ASSEMBLIES
IDENTITY KITS
OPTION KITS