Professional Documents
Culture Documents
Rules For Network Installation
Rules For Network Installation
In order to be able to follow up the operating sequence of your machine from an office PC, you have to
install a network between the two computers or integrate the machine PC into an existing network. For
this purpose you have to carry out the following steps in succession:
2. Cabling:
Please follow the relevant regulations for Ethernet networks.
Please particularly pay attention to the fact that the cable length within one segment mustn't
exceed 100 m – with interferences by your machines it even has to be considerably shorter.
Please use a multiple-shielded CAT7 cable.
Install a network socket in the switch cabinet directly near the PC and prepare a short Patch cable
for the connection of the PC to the network socket.
If the connection to the office PC (Client) is made via a HUB/SWITCH with 10/100 MBit, the Patch
cable mustn't be crossed. Use an uncrossed Patch cable.
If the connection is made directly from the machine to the office PC, you must use a crossed cable
(Cross over).
Important!
Each IP address must only exist once within the net .
The IP address of the machine PC must be out of the same address area as
that of the Client (office computer).
Example:
IP address of the machine PC: 192.168.0.1
IP address of the Client: 192.168.0.2 Address area
The IP-Address consists of 4 parts which are separated by a point. Each part must be a number
between 0 and 254. The first three parts signalise the address area. The last part is the
characteristic number of the computer.
4. Create the Hostname (computer name) according to the instructions „Network Installation of
MAXI 5“:
Assign an unambiguous name that doesn't exist yet in the net for the machine PC.