Professional Documents
Culture Documents
Gta11 03 049
Gta11 03 049
High frequency (HF) single channel (SC), Press 3 MODE button on radio face Press 8 PGM on radio face
GTA 11-03-49 automatic link establishment (ALE), third Press the 0 ZERO button Use arrows to select MODE: press ENT
generation (3G) ALE) Use arrow buttons to highlight the receive Select PRESET: press ENT
Cyber Center of Excellence Upper side band (USB), lower side band (LSB) frequency: press ENT Select CHANNEL: press ENT
Use key pad to enter frequency: press ENT Enter channel position (example 123): press
RT-1694D(P)(C)/U AN/PRC-150 Frequency modulated (FM) line of site (LOS) ENT
December 2019 Continuous wave (CW) The transmit frequency becomes highlighted
In RX screen enter receive frequency: press
Amplitude modulation equivalent (AME) Enter transmit frequency: press ENT ENT
U.S. Army Cyber Center of Excellence Use the arrows to highlight KEY on the screen In TX screen enter transmit frequency: press
Frequency, channel program ranges, and antenna
Use the up and down arrows to change key type: ENT
HF: 1.6 MHz - 29.9999 MHz//Power in Watts 1, Put receive frequency in RX FREQ screen:
5, 20 press ENT
press ENT
Press CLR to return to original screen
Doctrine Division VHF FM: 30 MHz - 59.9999 MHz//Power in Put transmit frequency in TX FREQ: press
Lessons and Best Practices Watts 1, 5, 20 ENT
Fixed Mode Channels: 000 - 200 Identify COMSEC keys loaded in RT Select modulation: press ENT
Press 8 PGM key on radio face AGC screen select OFF: press ENT
ALE Channels: 000 - 999
Select COMSEC on screen: press ENT RX ONLY screen select NO: press ENT
DISTRIBUTION STATEMENT: Approved for 3G ALE Channels: 100 - 162 (unless directed to remain in receive only
Public Release, Distribution Unlimited. Select KEYS: press ENT
OE-505 (3 meter) whip, (1.6 MHz - 60 MHz) mode)
Select Type I: press ENT
OE-254 antenna, (30 MHz - 88 MHz) At “LIMIT MAX TX POWER?” screen select
Press CLR NO: press ENT
usarmy.gordon.cyber-coe.mbx.gord-cyber-ll@mail.mil NVIS AS-2259, (2 MHz - 88 MHz) ENABLE SSB SCAN select NO: press ENT
RF1944 antenna, (1.6 MHz - 29.9999 MHz) Exit out to original home screen
UNCLASSIFIED
3 5 7
Warning: Ensure proper grounding of radio and Program single channel preset
antenna systems prior to use. Serious harm to personnel
Load single COMSEC key Press 8 PGM on radio face
or equipment may occur if proper grounding techniques
Harris AN/PRC-150 are not followed. On radio, move function switch to LD position Use arrows and highlight MODE on screen
RT-1694D(P)/U In FILL device screen, use arrows to select KYK-13 menu: press ENT
Built-In test (BIT) when using an SKL: press ENT Highlight PRESET on screen: press ENT
Press 7 OPT key on radio face In CRYPTO TYPE, select correct type of
encryption: press ENT Select CHANNEL: press ENT
Select TEST: press ENT
Highlight BIT on screen: press ENT In KEY TYPE and KEY NUMNER screen, enter Enter desired channel preset location: press
Use arrow buttons to highlight SYSTEM: press correct ENT
ENT crypto set: press ENT
From SKL screen select key: press LOAD icon at In RX screen put desired frequency: press ENT
(A clicking sound is heard while test runs)
Once results are received: press CLR to get
top of In TX screen put transmission frequency (it
SKL screen (it appears as a small laptop)
back to main screen In KEY LOAD SETTINGS, select DS-102
should be the
The radio will show PASSED once test is com- same as the RX frequency): press ENT
plete In the SKL PROTOCOL and ACTIVATE MODE
In MODULATION screen select FM: press ENT
Place radio into operational configuration screen:
press OK In RX ONLY screen use up and down arrows to
Open battery box on bottom of radio to insert
In Ready to Send screen in SKL: press OK select NO:
batteries
Close battery box and secure latches On radio face press ENT press ENT
Connect hand mic to audio connector J1 port On radio screen look for FILL DONE In LIMIT MAX TX POWER select NO: press ENT
Connect the OE-505 3 meter whip antenna SKL screen will display Operation Successful In ENABLE USB SCAN select NO: press ENT
base to HF antenna connector J7
Connect grounding wire to post on radio before
2 4 attempting calls on system 6 8
Setting time of day Make a call in ALE mode
Press 1 CALL button on radio face
Press 7 OPT button on radio face
In CALL TYPE screen use arrows to select
Select TOD: press ENT AUTO: press ENT
Enter TOD in 24-hour format: press ENT In ADDRESS TYPE select from the list using
arrows: press ENT once proper address has
Enter date and press enter, example of been identified
date format In INDIV ADDR screen use arrows to select
(2018-12-27) desired address: press ENT
Press 7 OPT button to return to main Begin call
screen
NOTES:
When using preset buttons to go to a new
Self-addressing preset, quickly
Press 8 PGM button on radio face squeeze the hand mic once to engage the
internal
Highlight MODE: press ENT coupler. This forces the radio to adjust to the
new preset.
Select ALE: press ENT
Select SELF: press ENT There is a slight time delay when keying the
radio for transmission. Wait for side tone before
Select Add: press ENT sending traffic. Speak clear and concise during
transmissions to ensure proper understanding
by the distant station.
9 11 13 15
10 12 14 16