Professional Documents
Culture Documents
TECCO STAINLESS
Date: 02.09.2022 Slope Stabilization System
Edition: 5
© Geobrugg AG
CH-8590 Romanshorn
Range of application
This Appendix to the Product Manual should is the extension with the TECCO® STAINLESS System and
the changes in installation. Basis is the current System Product Manual for the TECCO ® slope stabilization
system.
This appendix is only valid in combination with the most recent edition of the TECCO ® “Slope Stabilization
System Product Manual”. In the Product Manual, the entire process of installation, with every possible de-
tail needed, is described.
Rockfall, landslides, debris flows or avalanches are sporadic and unpredictable. Causes can be e.g. human (construc-
tion, etc.) or environmental (weather, earthquakes, etc.). Due to the multiplicity of factors affecting such events it is not
and cannot be an exact science that guarantees the safety of individuals and property.
However, by the application of sound engineering principles to a predictable range of parameters and by the implemen-
tation of correctly designed protection measures in identified risk areas the risks of injury and loss of property can be
reduced substantially.
Inspection and maintenance of such systems are an absolute requirement to ensure the desired protection level. The
system safety can also be impaired by events such as natural disasters, inadequate dimensioning parameters or failure
to use the prescribed standard components, systems and original parts; and/or corrosion (caused by pollution of the
environment or other man-made factors as well as other external influences).
Manual-Appendix TECCO® STAINLESS
Page 3 / 12
Wire diameter 2 mm 3 mm
Diagonal 62 x 95 mm 83 x 143 mm
Mesh width 48 mm 65 mm
Number of meshes transversal 16.1 pcs./m 12 pcs./m
Number of meshes longitudinal 10.5 pcs./m 7 pcs./m
TECCO® G65/3 STAINLESS mesh made from high-tensile steel wire with knotted ends.
Thickness 7 mm
Hole diameter 40 mm / 50 mm
Length of the spikes min. 20 mm
Weight 2.2 kg
Geometry diamond
Longitudinal bending resistance ≥ 2.5 kNm
Steel quality STAINLESS (INOX) 1.4404 (AISI 316L)
Isolation bushing
Execution: For spike plate P33/40 consistent with For spike plate P33/50 consistent with
GEWI NG25/NG28 GEWI NG32, TITAN 40
Application purpose: These optional plastic bushings isolate the nail from the mesh and spike plate. There-
fore, for example instead of stainless nails normal galvanized nails can be used.
Press claws
Technical Data Press claws type 1 (small) Press claws type 2 (big)
Application purpose Connection elements to interlink the indi- Connection elements to fasten the
vidual mesh sheets TECCO® mesh at the boundary rope
TECCO® G65/3 STAINLESS
Corrosion protection STAINLESS (INOX) 1.4462 (AISI 318 LN) STAINLESS (INOX) 1.4401 (AISI 316)
Connection Clip TF
Technical Data
Connection Clip TF
Boundary rope
Technical Data
Boundary rope
Technical data
Application area The free ends of the wire ropes should be fastened with wire rope clips. Care
must be taken that a special graphite grease is used to prevent the nut to be
stucked.
General
Any contact of stainless steel with black steel during transport, storage and installation should be avoided.
The mesh sheets must be connected lengthwise (normally in the line of the slope) as illustrated below.
By this arrangement it is guaranteed that the lateral connection of the mesh sheets provides the transverse tensile
strength of the mesh, and that the deformations under load are limited.