Professional Documents
Culture Documents
Warning!
Danger to life!
Secure engine in installation position to prevent it from falling down.
Important!
Adhere to the utmost cleanliness. Do not allow any dirt to enter the hydraulic system.
Seal off hydraulic lines with plugs.
Important!
Replacement only:
Banjo bolt (A) for pressure line (expansion hose) must be replaced by banjo bolt with non-return
valve (B).
© Copyright BMW Group - Subject to printing errors, m istak es and technical changes. 1/27/2021 1/2
VIN: WBAEB535X8CX62683 REP-REP-RAE6032-3213060 V - 1
If necessary, remove heat shield from power steering gear.
Release banjo bolts (1).
Disconnect pressure line and return line from power steering gear.
Installation:
Replace all sealing rings.
Make sure hydraulic lines are laid without tension and with sufficient spacing to adjoining components.
Tightening torque 32 41 3AZ.
After installation:
Fill and bleed hydraulic system
Check pipe connections for leaks
Perform chassis alignment check
Carry out steering angle sensor adjustment/adjustment for active front steering
If necessary, carry out initial Dynamic Drive operation
© Copyright BMW Group - Subject to printing errors, m istak es and technical changes. 1/27/2021 2/2