Professional Documents
Culture Documents
APPLICATION
To monitor earth leakage current and to operate
an associated relay at a preset current. May be
used to shut down a system or operate an alarm
under fault conditions.
width = 44
ELR’s are fitted with test and reset buttons. Pressing the test button allows a fault to be simulated and the
output relays operate accordingly. Pressing the reset button after a fault occurs restores the unit back to its
normal operation. A red LED light will illuminate after the unit trips due to an excessive fault current.
SPECIFICATIONS
Supply Voltage (Un): 24, 115/230, 400V AC (85-115%) Terminal Conductor: ≤ 2.5mm2 stranded
12-125V DC (85-110%) ≤ 4mm2 solid
10-60V DC(90-110%)
Output: 1 x SPNO relay
Power Consumption: 6VA 1 x SPDT relay
reset
test
test
The Earth MUST NOT pass The Earth MUST NOT pass
230V* AC
through the C.T. For single A1 (+ve) 400V AC
through the C.T. For single A1 (+ve) 10-60V DC
phase applications, only the phase applications, only the
50m** max
50m* max
live and neutral need to be A3 115V* AC only live and neutral need to be
passed through the C.T. passed through the C.T.
A2 (–ve) 0 A2 (–ve) 0
**Cabling: *Cabling:
For distances >1m, use twisted For distances >1m, use twisted
pair cable between unit and C.T. pair cable between unit and C.T.
1 2 3 4 5 6 7 1 2 3 4 5 6 7
*Dual voltage only
available as
L1 115V/230V AC. L1
L2 L2
L3 8 9 10 11 12 13 14 For 115V, connect L3 8 9 10 11 12 13 14
N across terminals N
E 6 and 7 E
For all other voltages,
C.T. positive standard
connect across C.T. positive standard
terminals 5 and 7.
safety output safety output Both relays are
output output shown in the
50m** max Both relays are 50m* max
shown in the de-energised state
de-energised state (i.e. where power is
E (i.e. where power is E not present on the
not present on the supply terminals)
supply terminals)
APPLICATION
Specifically designed for use with the HOBUT range
of Earth Leakage Relays. Specification of tripping
current is not required as this is set automatically by
the relay.
RANGE SPECIFICATIONS
Part No. Internal Diameter • Conforms to: IEC44-1, IEC185 & BS7676
CTB 35 35mm • Rated System Voltage: 720V AC
• Insulation Level: 3kV AC
CTB 50 50mm
• Frequency Range: 50-60Hz
CTB 70 70mm
• Terminals: combination screws, wire protected
• Terminal Conductor: ≤2.5mm2 wire
CTB 120 120mm
CTB 160 161mm
CTB 210 210mm
Our policy is one of continuous development and therefore specifications may change without notice.