Professional Documents
Culture Documents
Recommended use
It is recommended as an original and maintenance coating for the protection of steel structures & walls in chemical factories,
laboratories, toilets where the surfaces are liable to be attacked by spillage or fumes. It is also recommended on masonry buildings
and cold rooms under conditions of high humidity and condensation
Minimum Maximum
Physical Properties
Surface Preparation
For good adhesion surface should be clean, dry and free from any contamination. Suitably primed or galvanized iron and concrete.
Page 1 of 3
Issue no: 01
Issue date: Jan, 2022
Technical Data Sheet
Application Methods
Brush, roller, air assisted or airless spray. Apply evenly 2 coats of CR Primer on the surface providing Dry Film Thickness of 50
micrometers. Now apply 2 coats of CR Finish on CR primed Surface providing Dry Film Thickness of 50 micrometers.
Application data
Thinner CR Thinner
Drying Time
Relative Humidity:50%
Storage
The product must be stored in accordance with national regulations. Keep the containers in a dry, cool, well ventilated space and
away from sources of heat and ignition. Containers must be kept tightly closed. Handle with care.
Handling
Handle with care. Stir well before use.
Page 2 of 3
Issue no: 01
Issue date: Jan, 2022
Technical Data Sheet
Packing Size
Available in 4 Liter packs.
Certificates
Will be made available upon request.
Tests
Disclaimer
The information in this document is given to the best of Kaizen's knowledge, based on laboratory testing and practical experience. Kaizen cannot guarantee anything but the quality of the
product itself. However, as we have no control over the handling, storage, treatment of the product, the standard of surface preparation of the substrate, or other factors affecting the
use of this product, we are not responsible for its performance nor would we accept any liability whatsoever or howsoever arising from the use of this product unless specifically agreed
to in writing by us. Kaizen reserves the right to change the given data without further notice.
Page 3 of 3
Issue no: 01
Issue date: Jan, 2022