Professional Documents
Culture Documents
F
7,840 13,720
N (lbf)
(1,756) (3,073)
Allowable F
Nm 156 294
load when
(ft. lbs.) (115) (217)
table clamped L
L
F Nm 392 980
(ft. lbs.) (289) (722)
100H7
55H7
15
225
217
135
40
45
155
85 85
315 7 148
RWE-160 TPC with 5C Collet
RWE-200 TPC
175
120h7
65H7
15
275
272
160
45
45
175
110 120 185 RWE-160 TPC • TS-160
Support Spindle
360 The rotary table and support
spindle are mounted on a
baseplate and joined to a specially
designed, dual 5C collet trunnion
TPC-Jr NC CONTROLLER fixture.
H2 : 260
H3 : 310
Chucks
W No. PRG POS REM
SINGLE
θ 7 8 9
CHECK
140
MDI
. 4 5 6
2nd F
JOG
COPY CLR SCH
Tailstock
M W
ST SP ZRN ZRN C 1 2 3
ALM INS DEL DIR
+ - +
JOG JOG - 0 CR
MLK
Support Spindle
Face Plate
Encoder / Scale
The dimensions above are for tables with a FANUC servo motor. Other motors available (dimensions may increase). Pull
C Stud Device K
Rotary Joint
B
Booster
H
A
J
G
D E F L
Clamping Block and Bolt
Dimensions = mm
RWE-160 TPC 2 14 - - - - - - - 17 8 60 - 23 12
25
J
ØM
RWE-200 TPC 2 18 - - - - - - - 21 11 65 - 28 16 L
I
Note 1: When using a machine with a T-slot pitch other than the above, use suitable clamping blocks and bolts that are available on
the market, or order custom-made ones from Tsudakoma (opt.)
Note 2: Clamping blocks are not included in RWE-160 TPC and RWE-200 TPC.