Professional Documents
Culture Documents
Product name: DOWSIL™ 730 FS Solvent Resistant Sealant Issue Date: 12/29/2022
Print Date: 12/30/2022
DOW SILICONES CORPORATION encourages and expects you to read and understand the entire
(M)SDS, as there is important information throughout the document. We expect you to follow the
precautions identified in this document unless your use conditions would necessitate other appropriate
methods or actions.
1. IDENTIFICATION
Product name: DOWSIL™ 730 FS Solvent Resistant Sealant
COMPANY IDENTIFICATION
DOW SILICONES CORPORATION
2200 WEST SALZBURG ROAD
MIDLAND MI 48686-0994
UNITED STATES
2. HAZARDS IDENTIFICATION
Hazard classification
GHS classification in accordance with the OSHA Hazard Communication Standard (29 CFR
1910.1200)
Skin irritation - Category 2
Eye irritation - Category 2A
Label elements
Hazard pictograms
General Business
® ™ Trademark of The Dow Chemical Company ("Dow") or an affiliated Page 1 of 17
company of Dow
Product name: DOWSIL™ 730 FS Solvent Resistant Sealant Issue Date: 12/29/2022
Hazards
Causes skin irritation.
Causes serious eye irritation.
Precautionary statements
Prevention
Wash skin thoroughly after handling.
Use only outdoors or in a well-ventilated area.
Wear protective gloves/ eye protection/ face protection.
Response
IF ON SKIN: Wash with plenty of soap and water.
IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if
present and easy to do. Continue rinsing.
If skin irritation occurs: Get medical advice/ attention.
If eye irritation persists: Get medical advice/ attention.
Take off contaminated clothing and wash before reuse.
In case of fire: Avoid breathing fume.
Other hazards
No data available
3. COMPOSITION/INFORMATION ON INGREDIENTS
Inhalation: Move person to fresh air and keep comfortable for breathing; consult a physician.
Skin contact: Wash off with plenty of water. Suitable emergency safety shower facility should be
available in work area.
General Business
Page 2 of 17
Product name: DOWSIL™ 730 FS Solvent Resistant Sealant Issue Date: 12/29/2022
Eye contact: Immediately flush eyes with water; remove contact lenses, if present, after the first 5
minutes, then continue flushing eyes for at least 15 minutes. Obtain medical attention without delay,
preferably from an ophthalmologist. Suitable emergency eye wash facility should be immediately
available.
5. FIREFIGHTING MEASURES
Extinguishing media
Suitable extinguishing media: Water spray. Alcohol-resistant foam. Carbon dioxide (CO2).
Dry chemical.
Unusual Fire and Explosion Hazards: Exposure to combustion products may be a hazard to
health.. Toxic vapours are evolved.. Fire burns more vigorously than would be expected..
Fire Fighting Procedures: Use water spray to cool unopened containers.. Evacuate area..
Collect contaminated fire extinguishing water separately. This must not be discharged into
drains.. Fire residues and contaminated fire extinguishing water must be disposed of in
accordance with local regulations..
Use extinguishing measures that are appropriate to local circumstances and the surrounding
environment. Remove undamaged containers from fire area if it is safe to do so.
Special protective equipment for firefighters: In the event of fire, wear self-contained
breathing apparatus.. Use personal protective equipment.. Wear neoprene gloves to prevent
contact with hydrofluoric acid..
General Business
Page 3 of 17
Product name: DOWSIL™ 730 FS Solvent Resistant Sealant Issue Date: 12/29/2022
Environmental precautions: Discharge into the environment must be avoided. Prevent further
leakage or spillage if safe to do so. Retain and dispose of contaminated wash water. Local
authorities should be advised if significant spillages cannot be contained.
Methods and materials for containment and cleaning up: Wipe up or scrape up and contain for
salvage or disposal. Local or national regulations may apply to releases and disposal of this material,
as well as those materials and items employed in the cleanup of releases. You will need to determine
which regulations are applicable. For large spills, provide dyking or other appropriate containment to
keep material from spreading. If dyked material can be pumped, store recovered material in
appropriate container. Dispose of saturated absorbent or cleaning materials appropriately, since
spontaneous heating may occur.
See sections: 7, 8, 11, 12 and 13.
Conditions for safe storage: Keep in properly labelled containers. Store in accordance with the
particular national regulations.
Do not store with the following product types: Strong oxidizing agents.
Unsuitable materials for containers: None known.
The following substance(s), which have Occupational Exposure Limit(s) (OEL), may be formed during
handling or processing:, Acetic acid, butanol
Exposure controls
General Business
Page 4 of 17
Product name: DOWSIL™ 730 FS Solvent Resistant Sealant Issue Date: 12/29/2022
Engineering controls: Use local exhaust ventilation, or other engineering controls to maintain
airborne levels below exposure limit requirements or guidelines. If there are no applicable exposure
limit requirements or guidelines, general ventilation should be sufficient for most operations.
Appearance
Physical state paste
Color white
Odor acetic acid
Odor Threshold No data available
pH Not applicable, substance/mixture is non-soluble (in water)
Melting point/range No data available
Freezing point No data available
Boiling point (760 mmHg) Not applicable
Flash point Seta closed cup 95 °C ( 203 °F)
Evaporation Rate (Butyl Acetate Not applicable
= 1)
Flammability (solid, gas) Not classified as a flammability hazard
Lower explosion limit No data available
Upper explosion limit No data available
Vapor Pressure Not applicable
Relative Vapor Density (air = 1) No data available
General Business
Page 5 of 17
Product name: DOWSIL™ 730 FS Solvent Resistant Sealant Issue Date: 12/29/2022
NOTE: The physical data presented above are typical values and should not be construed as a
specification.
Possibility of hazardous reactions: Can react with strong oxidizing agents. When heated to
temperatures above 180 °C (356 °F) in the presence of air, trace quantities of formaldehyde may be
released. Adequate ventilation is required. Vapours may form explosive mixture with air.
Toxicological information appears in this section when such data are available.
Acute toxicity (represents short term exposures with immediate effects - no chronic/delayed
effects known unless otherwise noted)
General Business
Page 6 of 17
Product name: DOWSIL™ 730 FS Solvent Resistant Sealant Issue Date: 12/29/2022
Low toxicity if swallowed. Swallowing may result in irritation of the mouth, throat, and
gastrointestinal tract.
Vinyltriacetoxysilane
Oral LD50 has not been determined due to corrosivity.
Trifluoropropylmethyl cyclotrisiloxane
LD50, Rat, male and female, 4,650 mg/kg OECD 401 or equivalent
Vinyltriacetoxysilane
Absorption has not been determined due to corrosivity.
Trifluoropropylmethyl cyclotrisiloxane
LD50, Rabbit, male and female, > 20,000 mg/kg OECD 402 or equivalent
Vinyltriacetoxysilane
General Business
Page 7 of 17
Product name: DOWSIL™ 730 FS Solvent Resistant Sealant Issue Date: 12/29/2022
Mist may cause severe irritation of the upper respiratory tract (nose and throat) and
lungs.
Trifluoropropylmethyl cyclotrisiloxane
The LC50 has not been determined.
Skin corrosion/irritation
Vinyltriacetoxysilane
Brief contact may cause skin burns. Symptoms may include pain, severe local redness and
tissue damage.
Trifluoropropylmethyl cyclotrisiloxane
Brief contact is essentially nonirritating to skin.
Vinyltriacetoxysilane
May cause severe irritation with corneal injury which may result in permanent impairment of
vision, even blindness. Chemical burnsmay occur.
General Business
Page 8 of 17
Product name: DOWSIL™ 730 FS Solvent Resistant Sealant Issue Date: 12/29/2022
Trifluoropropylmethyl cyclotrisiloxane
May cause slight eye irritation.
Corneal injury is unlikely.
Sensitization
Vinyltriacetoxysilane
For skin sensitization:
No relevant data found.
Trifluoropropylmethyl cyclotrisiloxane
For skin sensitization:
Did not cause allergic skin reactions when tested in guinea pigs.
General Business
Page 9 of 17
Product name: DOWSIL™ 730 FS Solvent Resistant Sealant Issue Date: 12/29/2022
Vinyltriacetoxysilane
Material is corrosive. Material is not classified as a respiratory irritant; however, upper
respiratory tract irritation or corrosivity may be expected.
Trifluoropropylmethyl cyclotrisiloxane
Available data are inadequate to determine single exposure specific target organ toxicity.
Aspiration Hazard
Vinyltriacetoxysilane
Aspiration into the respiratory system may occur during ingestion or vomiting. Due to
corrosivity, tissue damage or lung injury may occur.
Trifluoropropylmethyl cyclotrisiloxane
Based on physical properties, not likely to be an aspiration hazard.
Chronic toxicity (represents longer term exposures with repeated dose resulting in
chronic/delayed effects - no immediate effects known unless otherwise noted)
Vinyltriacetoxysilane
For similar material(s):
Based on available data, repeated exposures are not anticipated to cause additional
significant adverse effects.
Trifluoropropylmethyl cyclotrisiloxane
In animals, effects have been reported on the following organs:
General Business
Page 10 of 17
Product name: DOWSIL™ 730 FS Solvent Resistant Sealant Issue Date: 12/29/2022
Liver
Heart
Muscles.
Carcinogenicity
Vinyltriacetoxysilane
No relevant data found.
Trifluoropropylmethyl cyclotrisiloxane
No relevant data found.
Teratogenicity
Vinyltriacetoxysilane
For similar material(s): Did not cause birth defects or any other fetal effects in laboratory
animals.
Trifluoropropylmethyl cyclotrisiloxane
Has been toxic to the fetus in laboratory animals at doses toxic to the mother.
Reproductive toxicity
Vinyltriacetoxysilane
For similar material(s): In animal studies, did not interfere with reproduction.
General Business
Page 11 of 17
Product name: DOWSIL™ 730 FS Solvent Resistant Sealant Issue Date: 12/29/2022
Trifluoropropylmethyl cyclotrisiloxane
In animal studies, has been shown to interfere with reproduction.
Mutagenicity
Vinyltriacetoxysilane
For similar material(s): In vitro genetic toxicity studies were negative. Animal genetic toxicity
studies were negative.
Trifluoropropylmethyl cyclotrisiloxane
In vitro genetic toxicity studies were negative. Animal genetic toxicity studies were negative.
Ecotoxicological information appears in this section when such data are available.
Toxicity
Vinyltriacetoxysilane
Acute toxicity to fish
Material is slightly toxic to aquatic organisms on an acute basis (LC50/EC50 between 10 and
100 mg/L in the most sensitive species tested).
LC50, Rainbow trout (Oncorhynchus mykiss), 96 Hour, 191 mg/l
Toxicity to bacteria
EC10, activated sludge, 3 Hour, Respiration rates., > 100 mg/l, activated sludge test (OECD
209)
General Business
Page 12 of 17
Product name: DOWSIL™ 730 FS Solvent Resistant Sealant Issue Date: 12/29/2022
Trifluoropropylmethyl cyclotrisiloxane
Acute toxicity to fish
Toxicity to aquatic species occurs at concentrations above material's water solubility.
Vinyltriacetoxysilane
Biodegradability: For similar material(s): Material is readily biodegradable. Passes OECD
test(s) for ready biodegradability.
10-day Window: Pass
Biodegradation: 79.5 %
Exposure time: 28 d
Trifluoropropylmethyl cyclotrisiloxane
Biodegradability: Material is not readily biodegradable according to OECD/EEC guidelines.
10-day Window: Fail
Biodegradation: 0 %
Exposure time: 28 d
Method: OECD Test Guideline 301B or Equivalent
Bioaccumulative potential
Vinyltriacetoxysilane
Bioaccumulation: Bioconcentration potential is low (BCF < 100 or Log Pow < 3).
Partition coefficient: n-octanol/water(log Pow): 0.6 estimated
Trifluoropropylmethyl cyclotrisiloxane
Bioaccumulation: Bioconcentration potential is low (BCF less than 100 or log Pow greater
than 7).
Partition coefficient: n-octanol/water(log Pow): 9 Estimated by Structure-Activity
Relationship (SAR).
Mobility in soil
Vinyltriacetoxysilane
Partition coefficient (Koc): 10 Estimated.
Trifluoropropylmethyl cyclotrisiloxane
No relevant data found.
General Business
Page 13 of 17
Product name: DOWSIL™ 730 FS Solvent Resistant Sealant Issue Date: 12/29/2022
Treatment and disposal methods of used packaging: Empty containers should be recycled or
otherwise disposed of by an approved waste management facility. Waste characterizations and
compliance with applicable laws are the responsibility solely of the waste generator. Do not re-use
containers for any purpose.
General Business
Page 14 of 17
Product name: DOWSIL™ 730 FS Solvent Resistant Sealant Issue Date: 12/29/2022
Superfund Amendments and Reauthorization Act of 1986 Title III (Emergency Planning and
Community Right-to-Know Act of 1986) Section 313
This material does not contain any chemical components with known CAS numbers that exceed the
threshold (De Minimis) reporting levels established by SARA Title III, Section 313.
Components CASRN
Trifluoropropylmethyl siloxane, hydroxy-terminated 68607-77-2
Hexamethyldisilazane reaction with Silica 68909-20-6
Titanium dioxide 13463-67-7
Trifluoropropyl methyl cyclotetrasiloxane 429-67-4
California Prop. 65
This product contains a chemical that is at or below California Propositions 65’s "safe harbor level" as
determined via a risk assessment. Therefore, the chemical is not required to be listed as a Prop 65
chemical on the SDS or label.
Revision
Identification Number: 4095684 / A713 / Issue Date: 12/29/2022 / Version: 12.0
Most recent revision(s) are noted by the bold, double bars in left-hand margin throughout this
document.
Legend
ACGIH USA. ACGIH Threshold Limit Values (TLV)
C Ceiling limit
General Business
Page 15 of 17
Product name: DOWSIL™ 730 FS Solvent Resistant Sealant Issue Date: 12/29/2022
DOW SILICONES CORPORATION urges each customer or recipient of this (M)SDS to study it
carefully and consult appropriate expertise, as necessary or appropriate, to become aware of and
understand the data contained in this (M)SDS and any hazards associated with the product. The
information herein is provided in good faith and believed to be accurate as of the effective date shown
above. However, no warranty, express or implied, is given. Regulatory requirements are subject to
change and may differ between various locations. It is the buyer's/user's responsibility to ensure that
his activities comply with all federal, state, provincial or local laws. The information presented here
pertains only to the product as shipped. Since conditions for use of the product are not under the
control of the manufacturer, it is the buyer's/user's duty to determine the conditions necessary for the
General Business
Page 16 of 17
Product name: DOWSIL™ 730 FS Solvent Resistant Sealant Issue Date: 12/29/2022
safe use of this product. Due to the proliferation of sources for information such as manufacturer-
specific (M)SDSs, we are not and cannot be responsible for (M)SDSs obtained from any source other
than ourselves. If you have obtained an (M)SDS from another source or if you are not sure that the
(M)SDS you have is current, please contact us for the most current version.
US
General Business
Page 17 of 17