Professional Documents
Culture Documents
YES , this
antenna has
26 Sep to 16 Oct installed a UPS of
DA-41 YES YES YES YES
2021 30 KVA and this
model has only 4
fans
YES , this
antenna has
18 Oct to 05 Nov installed a UPS of
DA-42 YES NO YES YES
2021 30 KVA and this
model has only 4
fans
16 Dic to 03 Jan
DA-43 YES YES YES YES YES
2022
26 Nov to 15 Dic CURTIS CT
DA-44 YES YES YES YES
2021 1290
INTERTHANE 990
YES 07 YES Mega 5000 YES
Interseal 670HS RAL 9016
INTERTHANE 990
YES 040 YES Semperit 2 SN YES
Interseal 670HS RAL 9016
DA-44 were cleaned 4 EL brushes and new ATU fan was installed twice
Remove grease from receiver cabin sides. Repair the roof upside
of cabinets. Remove and paint the scratches on receiver cabin.
DA-45 Improve anti vibrations rubbers on ATU supports. Repair
protection of the cable ducts conduits at the junction between the
hexapod and the quadripod leg
Change the blue light. Change the cabin door seal. Check the oil
leakage going to the AZ encoder tape
Check the inner seal of left arm. Change the warning lights, are
not blinking. Change the piping connectors with rust inside the
chiller. Check the center EL LS because is misaligned . Check the
leakage on AZ brake
Check the inner seal of right arm. Check deformed grounding bars
at the extremity of quadripod legs. Check the AZ motor without
cables connected. Normalize safety lights (currently one green
and one red). Check AZ encoder tape with oil drops below covers
4,5,6. Check the small leakage in lower pistons of AZ Brakes,
serials 1-200096650 and 1-
200096653
Change the warning lights, two are green. Check the grease on
both EL seals on right arm and inner seal on left arm. Check the
oil on moto reducer of right EL stow pin. Repair the upper
insulation of the right transporter bracket. Change the lock of slide
door. Check the indication of pressure of hydraulic system in the
ACU. Check the emergency stop on BA-JB02. Replace the safety
label related to the location of the antenna lockout. Install the
right tiltmeter
On Chiller: Check the plastic junction box with the cover loose.
Install the 2 missing bolts . Change the power cable P401.
Remove the rust
Check the pressure of the hydraulic unit accumulator of the
brakes. Replace the roof of the electrical cabinets. Check the AZ
encoder head 4. Monitor the internal leakage of the following AZ
calipers:
• AZ3 lower Brake Caliper (S/N: 1-200218179)
• AZ3 upper Brake Caliper (S/N: 1-200032783)
• AZ2 upper Brake Caliper (S/N: 1-200096657)
• AZ1 upper Brake Caliper (S/N: 1-200096643)
Inspect and remove the residual grease on both inner seals of EL
bearings. Check the functionality of lock-out on +D1 cabinet .
Change AZ Brake caliper with leakage S/N: 1-200103227.
Hydraulic accumulator with low pressure (40 bar), must be
charged