Professional Documents
Culture Documents
Assignment 1 (part 2)
CO1 (PO1): Ability to apply and analyze the knowledge
of engineering fundamentals in power semiconductor
devices and power electronic
circuit operations for power conversion
applications.
Assignment 2
CO2 (PO2): Ability to analyze and design AC-DC
conversion, AC-AC conversion, DC-DC conversion and
DC-AC conversion.
Semester 2, 2022/2023
Faculty of Electronic Engineering & Technology, UniMAP
SULIT
SULIT
(NMJ30103)
-2-
ASSIGNMENT 1 (part 2)
Figure 1
(a) In a same graph, illustrate (with a proper labelling) the following waveforms of
the controller above:
(i) the supplied voltage, vs
(ii) the output voltage, vo
(iii) the output current, io
(6 marks)
SULIT
SULIT
(NMJ30103)
-3-
where Vm is the amplitude of vs, α is the delay angle, and β is the extinction angle.
(i) Calculate load impedance, Z, and its phase difference, θ.
(ii) State the reason why β ≤ α + π.
(6 Marks)
(c) Assume that the above controller produces rms value of output voltage,
Vout,rms = 115 V, and rms value of fundamental output voltage, V1,rms = 103.5 V.
Calculate the voltage Total Harmonic Distortion (THDv).
(4 Marks)
(d) Assume that the above controller produces current Total Harmonic Distortion
(THDi) = 10% with magnitude of the fundamental output current, I1,peak = 4 A and
the load impedance, Z = 8 Ω. Determine the total power absorbed by the load,
assuming no power loss in the controller.
(8 Marks)
SULIT
SULIT
(NMJ30103)
-4-
ASSIGNMENT 2
A buck-boost converter has an input voltage of 50 V and output of -25 V. The switching
frequency is 10 kHz. The output power is 125 W.
(c) Suggest the appropriate value of capacitance to limit the output voltage ripple factor
to 1 %.
(3 marks)
SULIT
SULIT
(NMJ30103)
-5-
Figure 2
(b) For operation at nominal input voltage, estimate the output voltage ripple.
(8 Marks)
(c) Prove that the converter will still remain in continuous conduction across the full
operating range.
(7 Marks)
(d) Consider that the semiconductor devices used in the converter are not ideal. The
diode has a forward voltage drop during conduction, vx(on) of 0.7 V. The switch used
is a MOSFET with an on-state resistance, RDS(on) of 200 mΩ. Estimate the power
loss in the converter at maximum output current and nominal input voltage.
(6 Marks)
SULIT