Professional Documents
Culture Documents
CHAPTER 9 - TOWING
9-1 9-00-00 3
9-2
9-2 Operation ......................................... 9-00-00 3
FIGURES
Figure Page
Number Title Number
9-1
9-1 Towing helicopter ............................................................ 5
9-2
9-2 Crosstube strap installation .................................................. 6
9-00-00
Page 1/2
BHT-212-MM
TOWING
9-1. GENERAL.
m WEIGHTS AS SHOWN IN
z
r
.
PARAGRAPH 1. BELOW.
1. The helicopter may be equipped for
w
c
towing by attaching two ground handling 1. Install strap on aft cross tube of landing
a
figure 9-1
wheel assemblies (3, figure 9-1) to landing gear part number and gross weight as
gear skid tubes. follows:
c
pounds
DO NOT START ENGINES WITH 205-050-400-71 Standard Above 9000
AFT CROSS TUBE STRAP (4, pounds
FIGURE 9-2
FIGURE 9-2) INSTALLED. RED 205-050-400- High Skid Above 9000
101 pounds
STREAMER WARNING FLAG
REMOVE CROSS TUBE STRAP
SHALL BE INSTALLED ON PILOT
CYCLIC STICK ANY TIME STRAP
IS INSTALLED ON SKID GEAR. .................
CAUTION
2. Helicopters with aft strap modification
(T.B. 212-82-58A) incorporated may exceed DO NOT USE GROUND HANDLING
8000 pounds gross weight for towing when a GEAR, 212-050-200, WHEN
cable strap with turnbuckle is installed HELICOPTER GROSS WEIGHT IS
between skid tubes. IN EXCESS OF 9500 LBS.
DAMAGE TO GROUND HANDLING
9-2. OPERATION. GEAR MAY RESULT.
2. Chapter 10
Tie down main rotor blades (Chapter 10).
o
0
E
o
2 .................2
CAUTION 3. Install ground handling wheels as follows:
c
.................
WHEN GROUND HANDLING OR
z
a. Position ground handling wheels over d. Disconnect ground wire from helicopter.
-(o
skid tube and align attaching fixed pins with
eyebolts on tube. e. Tow or handle helicopter slowly. Move
N.-0
helicopter on wheels using tail skid to
b. Station a person at tail skid to keep maintain balance.
0)Q
helicopter level during ground handling or
towing. 4. Remove ground handling wheels as
follows:
.................
a. Lower skid tubes to the ground by
...
I CAUTION
--I
(Dm
each skid tube at same time.
((DD
DO NOT LEAVE HELICOPTER
b. Remove fixed pins from eyebolts and
tea)
cam,
UNATTENDED WITH GROUND
HANDLING WHEELS IN remove wheels from skid tubes.
E
EXTENDED POSITION.
c. Connect ground wire to helicopter.
c. Extend wheels on both skid tubes at
a2'
same time to raise skid tubes for ground
clearance.
9-00-00
Page 4
BHT-212-MM
1. Tow bar
2. Tow ring
3. Ground handling wheel assembly 204-050-200
4. Ground handling wheel assembly 212-050-200
- heavy gross weight
------------
CAUTION
212-M-9-1
9-00-00
Page 5
BHT-212-MM
1. Tow bar
2. Tow ring
3. Ground handling wheel assembly 212-050-200 only
4. Crosstube strap TB212-82-58A
5. Turnbuckle
9-00-00
Page 6