Professional Documents
Culture Documents
Signature of the
Student
Instructor with
Name
Date
Batch No.
Day & Date
Experiment 3
Instrumentation Amplifier
Objective:
To study the performance of an instrumentation amplifier.
Experiment:
Instrumentation Amplifier:
1. Using equation given below, determine the value of R1 of an instrumentation
amplifier as shown in the figure for gain of 630. Let R2 = 470 Ω, RF = 270 kΩ,
RI = 9.1 kΩ. Assemble the circuit.
2R RF
V0 = 1 + 2 (V1 − V2 )
R1 R1
3. Remove the short between nodes 6 and 7. Reassemble the circuit as in step
1. Short the nodes 1 and 2 and apply +5 V dc to this shorted node. Measure
the output voltage Vo. This voltage divided by 5 gives the common mode
voltage gain Ac of the instrumentation amplifier. Also observe the voltages at
nodes 6 and 7 with respect to ground.
PSPICE Simulation
1. Simulate the circuit of non-inverting type PGA, as used in experiment step 2.3(from
the laboratory manual page No. 50), using PSPICE. Use the macromodel of
µA741 and 2N3819 JFET from the analog devices library in simulation. Op-amp
dc power supply voltages are ±15 V. Assume dc input voltage, VI of 1V. Verify
the gain at different switch positions.