Professional Documents
Culture Documents
lllustration to buttons
-^.@ YJffiliBB:I W. =t
?FV=F
ryaUUI @/^\
@e (@ ff5iE^E8:8 IMd,*,
I! -fl$- ffi .I
(€) \\r/
@6
voL II
ra
tI
!!lBB.Bsnn, II
rI
Yae,s,s.#
ugr,EEFli-!G
@@
@'b LOCKED sffi
Fig . 1: Sketch map of big massage bathtub
(rLqiEI
" h# " Frequencv up- searchinq I Minute
*@' System oN/ oFF & Enter
" W' Frequency down- searchinq/ Hour ,.@, Radio & cD rnput oNi oFF
(fr)
" \-/ " Audio Volume up " 9 " Blower oN/ oFF & Temperature Mode
shift
.,@,, Audio vorume down "@,, Light from the bottom oN/ oFF
"@' Long Gircutation cteaning oN/oFF ". l" Eetting of circutation Cteaning & Surf
Water pump 3 ON/ OFF
" ffi " Preheat settinq & Heater oN/ ffiF .@, Temperature setting
Note: F
.Function of buttons with blue parts only works under the tlVaittins Mode Status.
2. Function Summary
(1 ) Constant temperature, preset heater, and display and operation of water temperature,
(2) Three surfing pump, One circulation pump also, One blower.
(3) Color of Lights are change & changeless synchronization.
(4) CD frequency input" Display of radio frequency and storage for 10 channels"
(5) Display and 87 grades adjustment of volume"
(6) Long Circulation and Phase of time Circulation cteaning"
(7) Display and set of 24 hours model.
(8) Power loss memory for allsetting"
(9) Fahrenheit & Celsiur temperature shift"
(10) Frozen preventing control"
( 11 )
Light of Keys "
UZ) Lock of buttons of conrputer board "
( 13) Selection of 110-120VAC or 220-240VAC, And Single-Phase or Three Phase Four line mode.
(14) SelectiononeACpoweroutputwhen "CD' isworking, ThisisusingforDVDorW,
( 15) Selection PO\AIER Controtl"
( 16 ) Selection electric current of all load are measure.
3. Operations
(1) When first tuming on the power, the backlight will bright of halt, and the LCD will show the present time
and temperature" lt will show'Ef if the sensor is open/short circuit. When part of radio frequency showed
"-", it indicates that the status of the system is "Wei&g_Ugtg', so ?s welt as the pre-heat and
circulation cleaning"
I Ei
et: le
:j:
Fig . 3; l{ormal temperufure, Fig . 4: $ensor open circui or short circuit
(2) Lock Operation r
The lock witt start work by pressing "m " Button in the status of "n6llEilg-Ugdg'or
no-pressing operation lasting above 30 minute. ln the stiatus of Locked, press the button " m "twice,
pressing..w,,o,ffiosbrttimesetting"Signalof,,,,,doesn,tflashbutMinuteandHour
flash at this time" tt will add t hour when pressing tl " each time, and the hours could be added
continually when pressing the " m " without stop. The hour adjusfnent range is 0-23"
ln the status of time settinq, lt will add 1 minute when pressing " m "each time, and the minutes
:l':' :l':'"
Fig . 5, Circulation+leaning off Fig . 6: Circulation-cleaning on
Circulation-cleaning setting must be in the "W3ifrinq i,lode" status and the LCD display '( n't o
_,1
).
n
' lr/
1 Press " -@',
and enter to Circulation-cleaning setting status, and " of the LCD display,
Mark of "CYCLE" is flasfed, ln the same time, The Circulation-cleaning start time setting is oning"
"P"
Press again, The Circulation+leaning setting will quit in without save"
It will add 1 minute when pressing " m " each time and the minutes could be added the
4)' When everything is setting well, Press "O", the system will quit the Circulation-cleaning setting
status with save.
3J* 3J*
e ,FF
:l':'. l':t
Fig . 7,
7: Pre-heat ONON Fig . 8: Preheat OFF
Pta h€1kry selting is in the "Waifrinq Mode" status and the LCD display " - - -"o
1 . Press " S ", ard enter to Pre-heating setting stiatus, 'oN' of the LCD display, The 'PREHEAT'
4
mark is flashed, ln the same time, The Preheat start time setting is oning. Press " again,
The Preheat setting willquit in without save.
2). press "W' "no'ffi " can change the startworking time of preheat :
It will add 1 minute when pressing " m " each time and the minutes could be added the
continually when pressing the " m " without stop" The adjustment range is 0-og"
fTffi
It will add t hourwhen pressing " \/ " each time, and the hours could be added the continually
Cr-D " without stop. The adjustment range is 0-23. When you set up well of the start
when pressing the " \#
time , you could go on to the next step"
r)
is 5 minutes on the LCD, and this time will not flash" lt will add 5 minutes by pressing " m " each
4). Press " @ " to set setting temprature of preheat" lt will add 1c when pressing "@' and
the temperature coutd be added continually till4S"C when pressing the '@' without stop. At this
time , when pressi,
is
15-45C
5). \Men everything is setting well, Press "C)", the system will quit the Preheat setting status with
save.
1- all setting of pre-heating must be in Power OFF status, just connect the spa with
the power supptry. and the LCD display 4 ..-" o
2, please note that it shors -on" or "off" on the LCD, "on" means pre-heating is
turn on, when the time of pre-heating is the same as currently time, the heater
will start working. "off'means the heater can't start-up anytime,
3. Circulation PLjf,iP and HEATER are not working while all setting time"
(6) Pre-heating;
When the time of real time and pre-heating time is consistent, meanufrile, there is water in the bathtub
and the pre-heating button is "on", the system will start the pre-heating and circulation pump and
autc+onstant temperature system will work at the same time" Then LCD will show count down time ( the
two middle spot will not flash any longer) and conesponding working status. ln the pre-heating process,
till cont down time finished" the pre-heating will be tumed off automatically by system or by pressing the
E&l*.'-*
3J* 3l"t
a [3P ,rF e 13?
-- -
only key "@' areavailable, ltwill add 1C when pressing "€)" andthetemperature coutd be
added continually till 45C when pressing the"@" without stop, At this time , when pressing
"@' angin, and the temperature could retum lsc " The range of adjustment is 1s-45c
JJ*
e i:31 oFF
I
,85.e ilHz
Fig . 11, Radio frequency is 105.2 MHZ, Save the present frequency to channel 3 (Save channel)
or Exchange the frequency form channel 3 to the present (Searching channel)
I ). Key @ oN/oFF key for radio and CD" and it is only available in the status of power
is the
on. The first pressing is turning on the radio, the second pressing will iurn off the radio and turn on the CD at
the same time, and the third, will turn offthe radio and CD simultianeous"
II ). LCD will show present frequency and volume of the radio after turning on the radio"
III ). ln the working of radio, The volumle of the present radio frequenry can be changed by pressing
..m,,*,,m,, "
" @ " continually will take out the memorized radio frequency from channels will be saved at present
(t
channel by pressing this key continually" lf none of the channel, LCD will display --" o
v ). Press the key "m ' could memorize the present radio frequency, Pressing the key
" W " continually will memorize the present radio frequency in different channel" The channel of
max is 10, Name of channel is 0-9"
r.,ry
!1). The volume can be changed by pressing key "@)" & "@""
({1}Operation to Pump :
KEY of "Pump1lll3' are control surf pumpl/2i3.
"$" confolling the ONiOFF of the lamp in the bottom of the bathtub.
Press "e)" for the first time, The LIGHTS are ON, and the color of LIGHTS are changing; Press
(17) wfren there is no water in the bathtub, vuater pumps. blower and constant temperature system wiltnot
start up. However, the conesponding signal on the LCD wiltflash.