Professional Documents
Culture Documents
OF CUTTING
„Making your own patterns
isn’t just about saving money;
more than that, it’s about
being creative.‘’
The Golden Rule is the perfect solution This tried and tested cutting
method is very easy to learn and has been used for decades.
In just two steps, you can start creating your own patterns more
easily than ever.
sales@thegoldenrule.us
We hope you enjoy making your patterns a reality!
For more information, visit our website: www.thegoldenrule.us
Printed in Germany
2 3
2.
This measurement is necessary for all points in the pattern below the waist. You’ll
MEASURING be using this for skirts, pants, shorts and so on.
THE CHEST
4 5
3.
SETTING THE BASE
PATTERN
4.
FIXING PINS ON THE GRADUATED RULER
A special graduated ruler is fixed to the start of the tape measure included.
There are two number columns on this graduated ruler.
These numbers represent your chest and hip measurements. Each number
corresponds to a line and a small hole. Fix a pin in the small hole corresponding
to your chest or hip measurement. The color of the numbers simply makes
it easier to see.
6 7
6.
MARKING ALL THE POINTS
5. After fixing the pin in the middle of the cross, the tape measure and graduated
ruler can rotate around the pattern.
Place the ruler on an oblique line, read the number on the line and make a dot
FIXING PINS ON THE on the pattern by the number on the tape measure.
GRADUATED RULER TO THE The points should be made on the paper next to the tape measure, as an
BASE PATTERN extension of the numbered oblique line. When a line is not attached to a point,
use the tape measure as a guide: this should run along the line, not the point.
Next, bring the graduated ruler with its pin over
the pattern and fix it to the center of the cross. Keep your tape measure and graduated ruler taut to give you a precise angle.
It sometimes happens that the cross will be Move the tape measure around the basic pattern, marking all your points. If you
situated outside the pattern. In this case, have several numbers on the same line, mark them with dots.
an arrow indicates which piece of the pattern
the cross belongs to. If the cross is turned so that Make sure that all points above the waist as well as at the waistline are marked
it looks like an X, this is because it makes after your chest measurement, and that all points below the waistline are marked
it easier to see. You can place a piece after your hip measurement.
of cardboard or wooden board in the place
where you press in the pin to avoid damaging
your table.
8 9
7.
CONNECTING THE POINTS
Our special rulers allow you to connect the dots. Once the dots are connected,
transpose all the signs and symbols from your small template onto the pattern
you have drawn. If a point is misaligned when preparing your pattern, mark it
at the point where it should be according to the basic pattern.
After removing the basic pattern from your sheet of paper, you can mark the
small hole made by the pin. This can be used as a guide later.
8.
TRANSFERRING THE PATTERN TO PAPER
If you have a longer or shorter torso than average, draw a line in the center
of the cross parallel to the waistline. For a longer torso, use scissors to cut the
parallel line and add a strip of paper in the middle. For a shorter torso, fold
the parallel line a few centimeters.
For pants, skirts and shorts, always check your waist measurement
on the paper pattern and adjust it to your measurements. When you’ve
finished, place the paper pattern on your fabric and mark the edges
with tailor’s chalk.
The length of the patterns can be modified according to your taste or current
trends.
Check and try out your paper patterns before cutting the fabric!
10 11
9.
CUTTING THE FABRIC
Allowances for seams and hems are not included on the paper pattern you have
just cut. When cutting the fabric, add another 0.04 in to 0.079 in (1 to 2 cm)
of fabric for seams and 1.18 in to 1.97 in (3 to 5 cm) for hems. Linings, trims
and under collars are cut in the same way for this type of pattern. The straight
grain should always be parallel to the middle of the front and middle of the back
(at a right angle to the waistline). Use the armhole ruler: there is a straight split
approx. 2.75 in (7 cm) long in the center of the ruler, which will give you a right
angle.
In just two steps, you can start creating your own patterns more easily than ever.
12 13
10.
MEASURING THE AMOUNT OF FABRIC
The measurements given for each design correspond to a chest measurement of
37 in (94 cm) and a hip measurement of 39.37 in (100 cm). To get an accurate
measurement, it is best to lay out all the pieces of the pattern on double-folded
fabric. Make sure to lay all the pieces with a fold line on the closed edge of the
fabric. Pay attention to the direction of the grain and don’t forget the additional
fabric for the seams. Arrange the letters on each pattern in alphabetical order
when sewing them.
14 15
SUPPLEMENT CATALOGS AND ANNUAL
SUBSCRIPTION
In the future, you’re sure to want to keep up to date with the latest fashions, too.
For this, we offer you our supplement catalogs which are released four times
a year. Each catalog includes around 40 different models with the basic
LUTTERLOH patterns. You can receive these four seasonal catalogs with our
annual subscription, with new editions released in mid-February, mid-May,
mid-August and mid-November.
16 17
XXL SYSTEM SUPPLEMENT PRODUCT
This guide is specially designed for comfort in plus size patterns. The XXL Ruler with plastic case included. A transparent plastic protective case with user
catalog contains a 70.87 in (180 cm) long tape measure and a blue instructions on the back. The Golden Rule has two specially designed acrylic
graduated ruler. This scale is valid for blue patterns and cannot be used rulers. These are the best tools for making your patterns look professional.
with any other catalog. The collection includes 97 patterns for men The acrylic rulers connect the dots accurately, and they are both durable
and women. and lightweight.
18 19
MADE-TO-MEASURE PATTERNS IN MINUTES!
Lots of women have always wished they could make their own clothes - pieces
that match their tastes and personal needs when it comes to color, style and
shape. This system offers the perfect solution.
In just two steps, you can start creating your own patterns more easily than ever.
20 21
EXPLANATION OF SIGNS USED For more information, visit our website:
www.thegoldenrule.us
A = front AA = cape
B = back BB = tie
C = side CC = detached part
D = skirt DD = cord
E = sleeve EE = reverse
F = cuff FF = hood
G = collar GG = pattern - type
H = corner HH = pleated
K = pocket KK = middle back
L = yoke LL = buttonhole braid
M = coat MM = braid or lace
N = bow NN = blouse
O = pleated panel OO = suspenders
P = sweater PP = buckle
R = chest panel RR = ruche
S = braid SS = bolero
T = frill ST = edging
U = ruffle TT = tail
Y = band, tab UU = jacket
Z pants VM = middle front
2x = twice VV = dress
WW = vest
= straight grain
= fabric fold ca = approximately
= continuous line li = left part
= gathered re = right part
= topstitched v = front (sleeve)
= elastic = snap fastener
= trim = staples or eyelets
= zipper = 90° right angle