You are on page 1of 2

Brindavan College of Engineering, Bengaluru-63.

Department of Electronics and Communication Engineering

1 Rectifier converts
a) AC to DC b) DC to DC c) DC to AC d)AC to AC
2 Component of a Smoothing Filter
a) Resistor b) Capacitor C) Diode D) Transformer
3 Bridge wave rectifier uses number of Diodes to get Rectified output
a)1 b)2 c)4 d)3
4 Multi Stage Amplifier Over gain will be
a) Av1 + Av2 + Av3 b) Av1*Av2*Av3 c) Av1/Av2/Av3 d) Av1-Av2-Av3
5 A circuit that amplifies the difference between two signals is called
a) Differential Amplifier b) Operational Amplifier c) Buffer d) Transistor
6 Negative feedback in an Amplifier
a) Reduced gain b) Reduces bandwidth c) Increase noise d) increase frequency
7 Op Amp as a Voltage Follower has a Voltage Gain of
a) Zero b) Unity c) Negative value d) less than unity
8 Ideal Op-Amp has following characteristics
a)Rin=∞, A=∞,Ro=0. b) Rin=0, A=∞,Ro=0. c) Rin=∞, A=∞,Ro=∞
d) Rin=∞,A=∞, Ro=∞.
9 Which of the following is the pin efficient method of communicating between other devices?
a) memory port
b) peripheral port
c) parallel port
d) serial port
10 Which type of memory is suitable for low volume production of embedded systems?
a) Non-volatile
b) RAM
c) Volatile
d) ROM
11 Which of the following statements are true for von Neumann architecture?
a) separate bus between the program memory and data memory
b) external bus for program memory and data memory
c) external bus for data memory only
d) shared bus between the program memory and data memory
12 Sensors are used across of embedded system.
a) input b) output c) Processing the data d) none
13 An Embedded system is a combination of ______
a) software b) hardware c) both d) devices
14 An Embedded system is classified in to how many types
a)1 b)2 c)3 d)4
15 In FM the ____________ of the information signal modulates the frequency of carrier signal
a) Amplitude b) Frequency c) phase d) all
16 Bandwidth is expressed in terms of __________.
a) Bits per second b) Hertz c) Centimeters d) seconds
17 Modulation index gives the ratio of ________.
a) Carrier voltage and voltage of Modulating signal
b) the voltage of Modulating signal and the un-modulates signal voltage
c) The voltage of Modulating signal and carrier voltage
d) none
18 The binary number 10101 is equivalent to decimal number ________
a)19 b)12 c)27 d)21
19 Which is not a Modulation?
a) Analog Modulation b) Digital Modulation c) Radio propagation d) all
20 The universal gate is ________
a) AND b) OR c) NAND d) NOT
21 2’s complement of binary number 0101 ________
a)1011 b)1111 c)1101 d)1110
22 Decimal number 10 is equal to binary number ________
a)1110 b)1010 c)1001 d)1000
23 The number of digits in octal system is ________
a)8 b) 2 c) 16 d)10
24 The output of half adder is ________

a) Sum b) Carry c) Sum & Carry d) none of these


25 1’s complement of 11100110 is
a)00011001 b)10000001 c)00011010 d)00000000

You might also like