You are on page 1of 2

A.

ND5 and NX10 TRANSMITTERS- INSTALLATION & ELECTRICAL MATERIALS:


QTY DESCRIPTION ESTD AMOUNT REMARKS PURCHASE LOCATION
1 roll Belden 8761 Audio Wire 15,000.00 Available in 1 roll only. 1 roll = 305 meters Interasean-Manila
15 mtrs Belden LAN Cable + RJ-45 600.00 NX10 remote access Interasean-Manila
10 mtrs Belden RG-58 - Stranded Center Conductor 1,500.00 NX10 RF monitor line Interasean-Manila
4 pcs BNC Connector 600.00 RF Monitor line Interasean-Manila
6 pcs XLR Connector (Female) 2,400.00 NX10 & Audio processor Interasean-Manla
8 pcs XLR Connector (Male) 3,200.00 NX10 & Audio processor Interasean-Manila
3 pc 3M Electrical Tape 450.00 General Use Circulated Electrical- Manila
1 pc Masking Tape 1" 80.00 General Use Circulated Electrical- Manila
4 pcs Rubber Tape 480.00 General Use Circulated Electrical- Manila
1roll Soldering Lead 600.00 General Use Circulated Electrical- Manila
20 pcs Tox #10 with Flat-washer & Screw 1/4" x 1 1/2" 200.00 General Use To Suy-Manila
30 pcs Tox #5 with Flat-washer & Screw 300.00 General Use To Suy-Manila
1 pack Round Rag (White) 140.00 General Use Circulated Electrical- Manila
1 pack 8" Cable Tie (Black) 300.00 General Use Circulated Electrical- Manila
2 pc hacksaw blade 200.00 General Use Circulated Electrical- Manila
6 pcs hand gloves 600.00 General Use Manila
1 set DPDT Transfer Switch 5,000.00 NX10 and ND5 RF Transfer switch Manila
set 3-phase Circuit Breaker 100Amps with housing 9,000.00 NX10 Main Circuit Breaker Manila
4 Mechanical/Terminal Lug for #4 Wire Main 1,000.00 for NX10 transformer terminal Circulated Electrical- Manila
7 Mechanical/Terminal Lug for #4 Wire Main 1,750.00 For AVR Circulated Electrical- Manila
5 pcs Terminal Lug for #6 Wire 500.00 for AC Mains wiring Prisma Electrical-Manila
130 mtrs #4 AWG, THHN (for NX10 & AVR 3PH AC)(black) 31,200.00 AVR to NX10: 50mtrs/ Panel to AVR:20mtrs/ 45mtrs for ND5 extended AC wire For Gen Santos City Inquiry
30 mtrs #6 AWG, THHN Stranded Copper Wire(black) 4,800.00 For Surge Protection Unit & CB to AVR Ground wiring. For Gen Santos City Inquiry
EMT Pipe 1" & 1 1/2" Gen Santos City
EMT Elbow 1" & 1 1/2" Gen Santos City
EMT Coupling 1" & 1 1/2" 6,000.00 For audio/control and electrical Gen Santos City
set EMT Male Adapter 1" & 1 1/2" For actual quantities during installation Gen Santos City
C Clamp 1" & 1 1/2" with screws & tox Gen Santos City
Metal flexible hose with 4 male connector Gen Santos City
1pc Wi-Fi Router 5,000.00 Remote access of NX10 Gen Santos City
SUBTOTAL 87,550.00 Pls refer to emailed drawings

B. MAIN REFEENCE GROUND - MATERIALS:


Qty Description Amount Remarks Where to purchase
1 pc 4ft x 4ft copper sheet, gauge 20 18,500.00 MAIN Ground Copper Plate Manila
1 pc 5ft. copper rod, 20mm diameter 9,500.00 Reference ground Manila
16 pcs Copper strap 3", gauge 22 (3" x 8ft.), 1800/pc 28,000.00 For studios, control room,Tx room,electrical room,reference ground to tower. Manila
8 pcs Copper strap 4", gauge 20 (4" x 8ft.) 24,800.00 tower base ring Manila
2 sacks salt (sodium chloride) 2,000.00 Reference ground Gen Santos City
2 sacks charcoal 2,000.00 Reference ground Gen Santos City
30 pcs nicolite 3,600.00 Manila
7 cans soldering paste 1,400.00 Manila
SUBTOTAL 89,200.00 Pls refer to emailed drawings

RADIAL SYSTEM REHABILITATION - MATERIALS:


1813 metersSD solid bare copper wire, #10, P40/mtr 72,520.00 RADIAL WIRES Manila
4 pcs 5ft. copper rod, 20mm diameter, P9500/pc 38,000.00 Buried 4 places at MAIN TOWER BASE Manila
1 lot Acetylene welding rental plus Labor 15,000.00 GenSan
1 box Silver rods(Harris brand) 100pcs and flux 4,500.00 to solder radials joints Manila
1 pc Radial Wire Spool Shipping to Gen Santos 30,000.00 trans shipment MNL-GenSantos Manila
SUBTOTAL 157,720.00 Pls refer to emailed drawings
1 lot Labor Works for RADIAL Wires -Canals and burying tbd by DXCP Gen Santos City

C. ATU, TRANSMISSION LINE & ACCS :


1 pc 1 5/8" EIA Flanged connector for NX10 RF Output termination part of P.O.
1pc Anchor Insulator ( bullet) for NX10 RF Output termination part of P.O.
increase 1 5/8" foam heliax from 50 feet to 80 feet Transmission line from NX10 to local RF switcher and from RF switcher to ATU part of P.O. - note the increase in length and price due to room xfer 50 ft to 80 ft
1 set Locally Made ATU ** will use existing ATU's - need only 1 COIL and 1 CAPACITOR per 4May2023 ocular part of P.O. - will realize cost reduction from PO price
Please refer to emailed drawings Refer to QUOTE #19-mebk-jna-289AB

TOTAL 668,940.00

D. OTHER ITEMS c/o DXCP:

1 set 2 tonnes ACU tbd Main ACU at new TX room for NX10 transmitter (high TX power output)
1 set 1.5 HP ACU tbd for Backup / Low power TX output operation
1 lot Materials to Partition Prod Room tbd

1 lot CIVIL Works for the Production Room conversion tbd Civil Engineer to design and provide estimates
1 unit ISOLATION TRANSFORMER 50 KVA tbd c/o Engr. Bob Tiin
1 lot LABOR fees to install RADIALS and MAIN REF
GROUND tbd c/o Engr. Bob Tiin
1 lot Labor and Materials to replace AM Tower
6 pcs dropwires to larger size ACSR Gauge #4 tbd Local riggers to perform replacement works

You might also like