Professional Documents
Culture Documents
1)What is the key element of water jet machining for material removal?
a) Tool Holder
b) Work piece
c) Water jet ✓
d) Power source
2) What is the velocity of the water jet stream in water jet machining?
a) 100 m/sec
b) 300 m/sec
c) 700 m/sec
d) 900 m/sec ✓
3) Which of the following is not a part of machining system of Water jet machining?
a) Transducer ✓
b) Accumulator
d) Hydraulic pump
4)What is the general power rating of the hydraulic pump, used in WJM?
a) 10 kW
b) 20 kW
c) 30 kW ✓
d) 40 kW
5)Which of the following are the components of intensifier present in water jet machining
system?
a) Piston
b) Plunger
c) Limit switch
6)What are the values of typical tube diameters in the machining system in WJM?
a) 0.1 to 1 mm
b) 1 to 6 mm
c) 6 to 14 mm ✓
d) 14 to 25 mm
d) 200 hrs ✓
8) Which of the following does not damage the nozzle used in Water jet machining?
a) Particles of dirt
b) Mineral deposits
c) Water ✓
d) All of the mentioned
9)On which property of water, will the accumulator in Water jet machining rely on?
a) Density
b) Compressibility ✓
c) Viscosity
d) Velocity
10)What are the uses of catcher in machining system of Water jet machining?
a) Collecting dirt
b) Collection of debris
c) Reduce noise levels
11) Intensifier increases the pressure water by which of the following values?
a) 10 – 100 MPa
b) 100 – 200 MPa