Berger Epoxy Enamel
USES
a) Be
Recommended for application on suitably primed steel structures exposed to industrial environment of paper and pulp
plants, fertilizers, food and pharmaceutical units, et.
SCOPE
‘Atwo pack epoxy top coat suitable for industrial and coastal environments, The product possesses good flexibility,
adhesion and weather resistance.
‘Type : Two Pack, cured with Polyamide
PEE
MILO FUMES /
Composition: Cataiyaad spony ei, stably SuTBOOR RESISTANCE
= Good
Mixing Ratio : Base : Catalyst - 3: 1 by volume G
Pot Life : 4-6 hours Good
‘Application : Brush, Conventional or Airless Spray Good
Recommended DFT : 25-80 microns per coat Good
Correspondi 9 microns per coat
‘Theoretical Spreading Rate: 12.6-152Sq.Mtv/L, Temperature Resistance :
ae Continuous =: 99°C
Drying Time Intermittent: 120°
TOUCH :2-4 hours
NANGLE | oP iuisee Weatherabiliy : Very Good in combination with
HARD: Overnight a suitable primer
Curing Time : 6-7 days
Overcoating interval :
MIN, Overnight
MAX 7-10 days:
Flash Point : Above 22°C
Colour : As per Protecton colour card
Finish : Glossy
Packing : 20 Lirs. &4 Lirs.
Thinner/Cleaner : Thinner 844
Storage Life : Upto twelve months as ong asthe
sealed containers are kept under cover in a dry place
under normal temperature conditions.
Peg
ao
58
Flexibility : Very Good
‘Abrasion Resistance : Goodbs) Ye) Berger Epoxy Enamel
Bian
‘Stool : Remove grease, oll and other contaminants preferably by using Bison Degreasing Solvent. Blast clean to a
minimum of Sa 22 Swedish Standard SIS 05 5900. For severe corrosive conditions, blast to Sa 3 with a surface
profile not exceeding 35-40 microns.
If blasting is not practical, make full use of mechanical tools along with manual chipping and wire brushing to remove
loose rust and scale to St. 2 Swedish Standard SIS 05 5900. Excessive burishing of steel is to be avoided.
‘Thoroughly Gust down all surfaces, Best results can be achieved if the manualy cleaned surface is primed with
Protectomastic ~ Self Priming Surface Tolerant Coating.
“The surface should be clean and dry before application of appropriate primer coat.
co
SATION
‘Str the base thoroughly and then mix three parts base and one part catalyst by volume to a homogeneous consistency.
Allow the mixture to mature for 30 minutes and stir again before and during application.
Brush : Apply without thinning,
Conventional Spray : Add upto 10% Thinner 844 depending on conditions. Use any standard equipment at an
atomising pressure of 3.54.2 Kg/om.
‘Airioss Spray : Apply proferably without thining. However, upto 6% Thinner 844 may be added if absolutely
depending on conditions. Use any standard equipment having pump ratio $0: 1. Tip size 0.83-0.98 mm.
Tip pressure 110-140 kg/m.
tial
ree ae
Surface tet Cost 2nd Coat sd Gost sh coat
Epix 610 Peer Epix 610 Pie "Epon Epon
see crbargertpony Primer or Barger Cpony Primer BASED Borg Epony
Fd Once Ped One
-do- ~do- Epilux 4 HB MIO. ~do- -do-
Gavvarised ton Degas ad abrade te surfce. Apply oat of Bison Wash Pine folowedby any of he above
Srhlumiaum’”Sysome mentored above exclu Ms rier cots.
Notes :
1. Use off the mixed paint within the stipulated pot life period.
2. Do not apply when temperature falls below 10° C or rises above 50° C and when relative humidity rises above 90%.
Do not apply during rain, fog or mist.
8. Brushes & spray equipment should be cleaned with Thinner 844 otherwise equipment is liable to be damaged.
Health & Safety : Please refer to the separate Safety Data Sheet available with detailed information.
DISCLAIMER
“Tne information contained within his Osta Sheet is based on information baeved tobe eile st the
time of ts preparation. The Company wil not be lable or loss or damage howsoever caused Including
laity for negigence, which may be suffered by the user o the data contained heen. ts the users"
responsibilty to conduct ll ncessary tests to conf the sutabilty of any product or syst for their
Intended use, No quaantee of results is impled since condtions of use are beyond our conto
rar
BERGER PAINTS INDIA LIMITED
Bergor House,129 Park Stroet, Kolkata 700017 Phone : (033) 2229 9724 ( ines) /249 9754 (4 lines) Fax: 91-99-2249 9729 / 2249 9009,
Email: NORTH : bpl_okh@mantraoniine.com SOUTH : boil ch2@sifycom EAST: bpil_c!t@vsnlnet WEST: bpiL_vsh@vsnlnet