Professional Documents
Culture Documents
TABLE OF CONTENT
Page
APPENDICES
1.0 INTRODUCTION.
This report presents the result of the subsurface exploration for Soil Investigation Works for
Proposed Development of Puteri Harbour Yatch Club Clubhouse, on Lot TM1 at Precint
Tanjung, Puteri Harbour Nusajaya, Mukim Pulai, Johor Bahru, Johor Darul Takzim.
The work was carried out in accordance with the instruction given by the Personnel of Messrs.
Messrs. UEM Land Berhad. The site investigation works was carried out accordance to the
British Standard Code of Practice BS 5930: 1999 “Code Practice for Site Investigation” and
laboratory tests as per BS 1377: 1990 or otherwise instructed by the client or mentioned in this
report.
2. To carry out Standard Penetration Test (SPT – 63.5kg hammer having a free fall of
760mm) to determine the natural bearing resistance of the subsoil for the purpose of
design.
3. To obtain disturbed and undisturbed soil samples for carrying out the laboratory tests
to determine the natural and relevant physical properties of the subsoil pertaining to
the site for the purpose of design.
4. To carry out field Permeability Test on selected boreholes to determine the coefficient
of the soil.
5. To carry out the installation and monitoring of Water Standpipe Test for ground water
observation.
3.1 GENERAL
Field exploration programme was conducted during the period of 18th July 2014 to
14th August 2014. The programme was supervised by our personnel from our office.
to be done for the design of the foundation for the proposed project.
The Boring equipment used was “Rotary Drilling Rig” which is capable of
boring and drilling to the depth. These boring rigs are also suitable for
advancing the borehole, sampling, in-situ testing and rock drilling in
accordance with the relevant specifications of each of these operations.
advancing the borehole, sampling, in-situ testing and rock drilling in
accordance with the relevant specifications of each of these operations.
Soil drill was carried out by the rotary action of drill bit attached to the bottom
of a hollow rod, which cuts/discharges all material within the diameter of
borehole washed to the ground surface by drilling fluid pumped down the
drilling rod. Normally the drill bit is rarely allowed to extend more than
150mm ahead of the bottom of the casing (if casing is used). Advancing of the
borehole is using drill rods with suitable drill bit and casing or where
permitted, proper drilling fluids. Advancing of the borehole will be such that
the disturbance to and contamination of the soil(s) immediately below the
borehole will be kept to minimum.
Casing was required in the soft or cohesionless soils, but is often omitted in
stiff, cohesive soils when only small representative samples are desired.
i. Disturbed Sample
Disturbed samples were taken from continuous sampling and split barrel
samples in conjunction with penetration resistance tests for purpose of
laboratory soil classification.
The Total Core Recovery (TCR) mean the ratio of the total length of good
quality core over the drilling length expressed the nearest 5%. Rock
Quality Designation (RQD) was the ratio of the total length of the good
quality core each exceeding 100mm in length over the drilling run correct
to circular circumference or in the case of broken rock fragment
assembled to form cores with circular circumference.
Generally, is carried out in all types of soil except the very soft and soft clays,
at 1.5m intervals or change of strata or as instructed by the S.O.
representative. In case of soft clay, vane shear test shall be carried out instead
of the SPT.
The value of the N as defined in the B.S. method was reported together with
the number of blow counts for each 75mm penetration of the sampling tube.
The blow counts for the first 150mm penetration (the seating drive) which do
not contribute the value of N was also included.
Two examples are 2,3,6,7,10,19 will give N= 42 and 10, 12,35 15/25mm will
give N= 50/100mm. When a penetration resistance of 25 blows or 150mm
penetration was encountered in a seating drive, the test would stop and the
SPT value would be N*= 25/150mm. The soil samples recovered from the
split barrel were preserved as disturbed samples as disturbed samples for
subsequent testing.
The borehole will be cleaned out before carrying out a permeability test and the
casing raised to expose a length of borehole wall equal to approximately two
times the borehole diameter. For materials which are likely to collapse if
unsupported a suitable filter material will be placed in the base of the borehole
to support the uncased part.
Rising head tests, the water level in the borehole shall first be lower by bailing
to a level agreed by the engineer. The water level will be recorded at 10 second
intervals during the early stages of the test and at less frequent intervals in the
latter stages in order that a representative record of the fall or rise in the water
level relative to time can be obtained. The level of the natural ground water
table shall be established at the time of testing.
This test is commonly employed for the purpose of ground water observation. Borehole
drill during the course of site investigations can be left open and cased if necessary to
provide an observation point. A minimum 24 hours after drilling has ceases should be
allowed to pass before observations are commenced.
ii. The cased borehole is clean by flushing with water and the standpipe
generally consist of perforated or slotted 40mm PVC pipe wrapped with
Geotextile is lowered into the borehole and clean sand is placed surround it.
b. Monitoring:-
vi. The Reduced Level of the top of the standpipe is recorded and subsequent
reporting shall base on the calculated RL of water levels.
The measurement of water table in the boreholes was done using either a measuring
tape or tape rod diameter or dip-meter as directed by the Client.
The recordings were repeated daily while boring for the drilled hole in progress and
were taken in the following time intervals: -
The water levels recorded in the borehole logs were levels observed in these
investigation holes during the period of the site investigation. Such observed levels may
not necessarily be the actual groundwater levels that are subject to seasonal fluctuations
from time to time.
For boreholes involving impervious stratum, the casing top was capped overnight to
prevent entry of rainwater and subsurface water.
Both disturbed and undisturbed samples were obtained at various depths and at every change
of soil strata for the purpose of identification, classification and testing. The following
laboratory tests were carried out in our laboratory in accordance with the British Standard
Code 1377: 1990.
The results of the laboratory soil test are summarised in the Summary of Laboratory Test
Result as presented in Appendix E – Summary and Results of Laboratory Test.
Soil Classification Test was conducted in accordance to BS: 1377: Part 2: 1990. Soil
Classification Test was determined of basic physical properties. The tests are required
for the classification of soil in accordance with BS 5930:1999. The test was included as
follow:-
This test follows BS 1377: Part 2: 1990 Method 7. The bulk density of a soil is
the mass per unit volume of the soil including any water it contains, expressed in
Mg/m3. The linear measurement method 7.2 was used in this project for sample
obtained from undisturbed sampling method.
A sieve analysis consists of shaking the soil through a stack of wire screens with
opening of known sizes: the definition of particle diameter for a sieve test is,
therefore, the side dimensions of a square hole. The hydrometer method is based
on strokes equation for the velocity of a freely falling sphere: the definition of
particle diameter for hydrometer test is, therefore the diameter of a sphere of the
same density, which falls at the same velocity, as the particle is question. The test
procedure, which should be followed, depends on the soil in question. If nearly all
it grains are so large that they cannot pass through the square openings at
0.074mm (No. 200 screen), the sieve analysis is preferable. For those soils, which
are nearly all finer than a No. 200 screen, the hydrometer test is recommended.
Grained size analysis has been widely used as a mean for identification and
classification of soils.
d. Atterberg Limit
Shear strength is determined either by measuring the shearing force causing failure
(direct shear tests), or by derivation from the measured compressive strength
(unconfined or triaxial compression tests). The test specimen is consolidated under a
vertical normal load until the primary consolidation is completed. It is then sheared at a
rate of displacement that is slow enough to prevent development of excess pore
pressures. Test data enable the effective shear strength parameters c’and Ø’ to be
derived. The residual shear strength parameters c’ R,and Ø’R can be obtained by
extending the tests to give large cumulative displacements by reversals and re-shearing.
Uniaxial compressive strength test of intact rock often needed properties in engineering
designs of structures in rock. The test is carried out on intact rock with no discontinuities
and yields data on the rock materials properties. The length to diameter ratio of 2:1 is a
minimum for cylinders.
Chemical Test was conducted in accordance to BS: 1377: Part 3: 1990.The test was
included as follow:-
a. PH Test
The PH Test was carried out in accordance with BS: 1377: Part 3 :1990 to
determine the PH value by electrometric method, which gives direct reading of
the pH value of a soil suspension water.
The organic matter content is carried out in accordance with BS: 1377: Part 3:
1990. The procedure covers the determination of the percentage by dry mass of
organic matters present in soil. The method, which uses dichromate oxidation, is
known as Walkley and Black‟s method.
c. Sulphate Content
The sulphate content test is carried out in accordance with BS: 1377: Part 3:
1990. The procedures for determining the sulphate content of soil and ground
water. The results obtained give the sulphate content at the time of sampling
only. There are two methods for determining the sulphate contents of aggregate
either water-soluble sulphate content or total sulphate content.
d. Chloride Content
The chloride content test is carried out in accordance with BS: 1377:
Part 3: 1990. The test was carried out for determination of water-soluble and
acid-soluble chloride salt content in soil. Both procedures are based on Voldard‟s
Method.
e. Carbonate Content
The carbonate content test is carried out for determination of carbonate content of
the soil. The test depends upon the reaction between carbonate and hydrochloric
acid, which liberates carbon dioxide. The percentage carbonate in the soil sample
expressed as CO2. The test was carried out by using rapid titration method as
stated in BS: 1377: Part 3: 1990 (Item 6).
5.0 COMMENTARY
The classification of the soil as represented in the report follows the BS 5930: 1999 Section 6
„Description of soil and rocks‟.
It must be pointed out that, where the description of the samples from the laboratory results
differ from the field description of the soil layers, the laboratory results was supplemented and
in some instances, superseded the field description. The report is limited to the representation
of the soil information data gathered from the field works and laboratory test results. It should
be noted that natural moisture content and the ground level are subjected to seasonal variation
and the drainage condition of the adjoining areas.
With this site investigation report will give part of the information to enable the designer to
decide and design the foundation system of the proposed project.
The interpretation of the results of the investigation and the final decision on the type of
foundation to adopt, rest with the Engineer.
Should there be any questions regarding our work, we should be pleased to discuss them with you.
Prepared by,
Site Plan
Engineering Logs
Project : Soil Investigation Works for Proposed Development of Puteri Harbour Yatch Club Borehole No. : BH-1
Clubhouse, on Lot TM1 at Precint Tanjung, Puteri Harbour Nusajaya, Mukim Pulai,
Johor Bahru, Johor Darul Takzim. Pages 1 of 2
Customer : Messrs. UEM Land Berhad Job No. : GLSB/SI/2723-094/2014
Date Started : 19/07/2014 Reduced Level : 9.411 m Coordinate, E : -69554.446 Type of Boring : Rotary Boring
Date Completed : 21/07/2014 Final Depth : 22.00 m N: 10466.622 Boring Diameter : 75mm to 125mm
Depth Sample Standard Penetration Test
Legend
Soil Description
From
R.L
& Sample Depth Recovery 75 75 75 75 75 75 'N' Remarks
(m) Lithology Ref. (m) Ratio mm mm mm mm mm mm Value
D Hand Auger.
Top soil.
9.00
to
10.00
Project : Soil Investigation Works for Proposed Development of Puteri Harbour Yatch Club Borehole No. : BH-1
Clubhouse, on Lot TM1 at Precint Tanjung, Puteri Harbour Nusajaya, Mukim Pulai,
Johor Bahru, Johor Darul Takzim. Pages 2 of 2
Customer : Messrs. UEM Land Berhad Job No. : GLSB/SI/2723-094/2014
Date Started : 19/07/2014 Reduced Level : 9.411 m Coordinate, E : -69554.446 Type of Boring : Rotary Boring
Date Completed : 21/07/2014 Final Depth : 22.00 m N: 10466.622 Boring Diameter : 75mm to 125mm
Depth Sample Standard Penetration Test
Legend
Soil Description
From
R.L
& Sample Depth Recovery 75 75 75 75 75 75 'N' Remarks
(m) Lithology Ref. (m) Ratio mm mm mm mm mm mm Value
P6/ 12.00 230/330 5 4 6 14 30/ 50/
Hard, orangish light brown with pale grey, D6 to 30mm 180mm
sandy SILTS/CLAYS. 12.33
Project : Soil Investigation Works for Proposed Development of Puteri Harbour Yatch Club Borehole No. : BH-2
Clubhouse, on Lot TM1 at Precint Tanjung, Puteri Harbour Nusajaya, Mukim Pulai,
Johor Bahru, Johor Darul Takzim. Pages 1 of 2
Customer : Messrs. UEM Land Berhad Job No. : GLSB/SI/2723-094/2014
Date Started : 22/07/2014 Reduced Level : 9.432 m Coordinate, E : -69526.108 Type of Boring : Rotary Boring
Date Completed : 25/07/2014 Final Depth : 21.26 m N: 10497.851 Boring Diameter : 75mm to 125mm
Depth Sample Standard Penetration Test
Legend
Soil Description
From
R.L
& Sample Depth Recovery 75 75 75 75 75 75 'N' Remarks
(m) Lithology Ref. (m) Ratio mm mm mm mm mm mm Value
D Hand Auger
Top soil.
Project : Soil Investigation Works for Proposed Development of Puteri Harbour Yatch Club Borehole No. : BH-2
Clubhouse, on Lot TM1 at Precint Tanjung, Puteri Harbour Nusajaya, Mukim Pulai,
Johor Bahru, Johor Darul Takzim. Pages 2 of 2
Customer : Messrs. UEM Land Berhad Job No. : GLSB/SI/2723-094/2014
Date Started : 22/07/2014 Reduced Level : 9.432 m Coordinate, E : -69526.108 Type of Boring : Rotary Boring
Date Completed : 25/07/2014 Final Depth : 21.26 m N: 10497.851 Boring Diameter : 75mm to 125mm
Depth Sample Standard Penetration Test
Legend
Soil Description
From
R.L
& Sample Depth Recovery 75 75 75 75 75 75 'N' Remarks
(m) Lithology Ref. (m) Ratio mm mm mm mm mm mm Value
UD1 12.00 420/1000
Medium greyish purple with pale brown
to
mottled, sandy SILT of Low Plasticity. 13.00
Project : Soil Investigation Works for Proposed Development of Puteri Harbour Yatch Club Borehole No. : BH-3
Clubhouse, on Lot TM1 at Precint Tanjung, Puteri Harbour Nusajaya, Mukim Pulai,
Johor Bahru, Johor Darul Takzim. Pages 1 of 2
Customer : Messrs. UEM Land Berhad Job No. : GLSB/SI/2723-094/2014
Date Started : 26/07/2014 Reduced Level : 9.508 m Coordinate, E : -69497.653 Type of Boring : Rotary Boring
Date Completed : 31/07/2104 Final Depth : 23.50 m N: 10527.580 Boring Diameter : 75mm to 125mm
Depth Sample Standard Penetration Test
Legend
Soil Description
From
R.L
& Sample Depth Recovery 75 75 75 75 75 75 'N' Remarks
(m) Lithology Ref. (m) Ratio mm mm mm mm mm mm Value
D Hand Auger
Top soil.
Project : Soil Investigation Works for Proposed Development of Puteri Harbour Yatch Club Borehole No. : BH-3
Clubhouse, on Lot TM1 at Precint Tanjung, Puteri Harbour Nusajaya, Mukim Pulai,
Johor Bahru, Johor Darul Takzim. Pages 2 of 2
Customer : Messrs. UEM Land Berhad Job No. : GLSB/SI/2723-094/2014
Date Started : 26/07/2014 Reduced Level : 9.508 m Coordinate, E : -69497.653 Type of Boring : Rotary Boring
Date Completed : 31/07/2104 Final Depth : 23.50 m N: 10527.580 Boring Diameter : 75mm to 125mm
Depth Sample Standard Penetration Test
Legend
Soil Description
From
R.L
& Sample Depth Recovery 75 75 75 75 75 75 'N' Remarks
(m) Lithology Ref. (m) Ratio mm mm mm mm mm mm Value
P5/ 12.00 450/450 3 5 7 8 8 9 32
Dense, pale to light grey with medium yellow D5 to
mottled, slightly gravelly silty SAND. Sand is 12.45
fine to medium grained.
C1 17.50 CL=1.50m
Weak to moderately strong, pale to light grey to TCR=100%
with orange spotted, highly to moderately 19.00 RQD=0%
fractured, moderately to slightly weathered,
QUARTZ SANDSTONE. (Metasediment)
C2 19.00 CL=1.50m
Moderately weak to moderately strong, light
to TCR=100%
greenish light grey with orange spotted, highly 20.50 RQD=7%
to moderately fractured, moderately to slightly
weathered, QUARTZ SANDSTONE.
(Metasediment)
C3 20.50 CL=1.50m
Moderately strong, light greenish light grey
to TCR=100%
with pale grey spotted, moderately to slightly 22.00 RQD=27%
fractured, slightly weathered to fresh, QUARTZ
SANDSTONE. (Metasediment)
C4 22.00 CL=1.50m
Moderately strong to strong, light greenish light
to TCR=100%
grey with pale grey spotted, slightly fractured, 23.50 RQD=42%
slightly weathered to fresh, QUARTZ
SANDSTONE. (Metasediment)
Project : Soil Investigation Works for Proposed Development of Puteri Harbour Yatch Club Borehole No. : BH-4
Clubhouse, on Lot TM1 at Precint Tanjung, Puteri Harbour Nusajaya, Mukim Pulai,
Johor Bahru, Johor Darul Takzim. Pages 1 of 3
Customer : Messrs. UEM Land Berhad Job No. : GLSB/SI/2723-094/2014
Date Started : 01/08/2014 Reduced Level : 3.323 m Coordinate, E : -69556.393 Type of Boring : Rotary Boring
Date Completed : 05/08/2014 Final Depth : 35.70 m N: 10500.585 Boring Diameter : 75mm to 125mm
Depth Sample Standard Penetration Test
Legend
Soil Description
From
R.L
& Sample Depth Recovery 75 75 75 75 75 75 'N' Remarks
(m) Lithology Ref. (m) Ratio mm mm mm mm mm mm Value
M1 3.00 280/1000
Light brownish grey, sandy CLAY of Low to
Plasticity. 4.00
Project : Soil Investigation Works for Proposed Development of Puteri Harbour Yatch Club Borehole No. : BH-4
Clubhouse, on Lot TM1 at Precint Tanjung, Puteri Harbour Nusajaya, Mukim Pulai,
Johor Bahru, Johor Darul Takzim. Pages 2 of 3
Customer : Messrs. UEM Land Berhad Job No. : GLSB/SI/2723-094/2014
Date Started : 01/08/2014 Reduced Level : 3.323 m Coordinate, E : -69556.393 Type of Boring : Rotary Boring
Date Completed : 05/08/2014 Final Depth : 35.70 m N: 10500.585 Boring Diameter : 75mm to 125mm
Depth Sample Standard Penetration Test
Legend
Soil Description
From
R.L
& Sample Depth Recovery 75 75 75 75 75 75 'N' Remarks
(m) Lithology Ref. (m) Ratio mm mm mm mm mm mm Value
P7/ 12.00 0/100 25 50/ 50/40mm
No recovery. 40mm
D7 to
12.11
Project : Soil Investigation Works for Proposed Development of Puteri Harbour Yatch Club Borehole No. : BH-4
Clubhouse, on Lot TM1 at Precint Tanjung, Puteri Harbour Nusajaya, Mukim Pulai,
Johor Bahru, Johor Darul Takzim. Pages 3 of 3
Customer : Messrs. UEM Land Berhad Job No. : GLSB/SI/2723-094/2014
Date Started : 01/08/2014 Reduced Level : 3.323 m Coordinate, E : -69556.393 Type of Boring : Rotary Boring
Date Completed : 05/08/2014 Final Depth : 35.70 m N: 10500.585 Boring Diameter : 75mm to 125mm
Depth Sample Standard Penetration Test
Legend
Soil Description
From
R.L
& Sample Depth Recovery 75 75 75 75 75 75 'N' Remarks
(m) Lithology Ref. (m) Ratio mm mm mm mm mm mm Value
P15/ 24.00 360/450 3 3 5 7 11 13 36
Hard, pale to light yellowish grey, sandy SILT. D15 to
24.45
C1 29.70 CL=1.50m
Moderately weak to moderately strong, light to to TCR=90%
medium grey with pale grey mottled, highly to 31.20 RQD=16%
moderately fractured, slightly weathered to
fresh, SANDSTONE.
C2 31.20 CL=1.50m
Weak to moderately strong, light greenish light
to TCR=93%
to medium grey, highly fractured, slightly 32.70 RQD=0%
weathered to fresh, QUARTZ SANDSTONE.
(Metasediment)
C3 32.70 CL=1.50m
Weak to moderately strong, light greenish light
to TCR=100%
to medium grey, highly fractured, slightly 34.20 RQD=0%
weathered to fresh, QUARTZ SANDSTONE.
(Metasediment)
C4 34.20 CL=1.50m
Weak to moderately strong, light greenish light
to TCR=87%
to medium grey, highly fractured, slightly 35.70 RQD=0%
weathered to fresh, QUARTZ SANDSTONE.
(Metasediment)
Project : Soil Investigation Works for Proposed Development of Puteri Harbour Yatch Club Borehole No. : BH-5
Clubhouse, on Lot TM1 at Precint Tanjung, Puteri Harbour Nusajaya, Mukim Pulai,
Johor Bahru, Johor Darul Takzim. Pages 1 of 3
Customer : Messrs. UEM Land Berhad Job No. : GLSB/SI/2723-094/2014
Date Started : 06/08/2014 Reduced Level : 3.207 m Coordinate, E : -69577.888 Type of Boring : Rotary Boring
Date Completed : 09/08/2014 Final Depth : 34.90 m N: 10512.635 Boring Diameter : 75mm to 125mm
Depth Sample Standard Penetration Test
Legend
Soil Description
From
R.L
& Sample Depth Recovery 75 75 75 75 75 75 'N' Remarks
(m) Lithology Ref. (m) Ratio mm mm mm mm mm mm Value
Project : Soil Investigation Works for Proposed Development of Puteri Harbour Yatch Club Borehole No. : BH-5
Clubhouse, on Lot TM1 at Precint Tanjung, Puteri Harbour Nusajaya, Mukim Pulai,
Johor Bahru, Johor Darul Takzim. Pages 2 of 3
Customer : Messrs. UEM Land Berhad Job No. : GLSB/SI/2723-094/2014
Date Started : 06/08/2014 Reduced Level : 3.207 m Coordinate, E : -69577.888 Type of Boring : Rotary Boring
Date Completed : 09/08/2014 Final Depth : 34.90 m N: 10512.635 Boring Diameter : 75mm to 125mm
Depth Sample Standard Penetration Test
Legend
Soil Description
From
R.L
& Sample Depth Recovery 75 75 75 75 75 75 'N' Remarks
(m) Lithology Ref. (m) Ratio mm mm mm mm mm mm Value
P7/ 12.00 240/360 5 8 14 17 19/ 50/
Very dense, pale grey, sandy CLAY of Low D7 to 60mm 210mm
Plasticity. 12.36
Project : Soil Investigation Works for Proposed Development of Puteri Harbour Yatch Club Borehole No. : BH-5
Clubhouse, on Lot TM1 at Precint Tanjung, Puteri Harbour Nusajaya, Mukim Pulai,
Johor Bahru, Johor Darul Takzim. Pages 3 of 3
Customer : Messrs. UEM Land Berhad Job No. : GLSB/SI/2723-094/2014
Date Started : 06/08/2014 Reduced Level : 3.207 m Coordinate, E : -69577.888 Type of Boring : Rotary Boring
Date Completed : 09/08/2014 Final Depth : 34.90 m N: 10512.635 Boring Diameter : 75mm to 125mm
Depth Sample Standard Penetration Test
Legend
Soil Description
From
R.L
& Sample Depth Recovery 75 75 75 75 75 75 'N' Remarks
(m) Lithology Ref. (m) Ratio mm mm mm mm mm mm Value
P15/ 24.00 180/235 8 16 37 13/ 50/85mm
Very dense, brownish grey, very silty/clayey D13 to 10mm
GRAVEL. 24.24
C3 30.40 CL=1.50m
Weak to moderately strong, medium to dark
to TCR=99%
grey with pale grey spotted, highly to 31.90 RQD=0%
moderately fractured, slightly weathered to
fresh, SANDSTONE.
C4 31.90 CL=1.50m
Weak to moderately strong, light to medium
to TCR=100%
grey, highly to moderately fractured, slightly 33.40 RQD=0%
weathered to fresh, SANDSTONE.
C5 33.40 CL=1.50m
Weak to moderately strong, light to medium
to TCR=100%
grey with light green mottled, highly to 34.90 RQD=13%
moderately fractured, slightly weathered to
fresh, QUARTZ SANDSTONE.
(Metasediment)
Project : Soil Investigation Works for Proposed Development of Puteri Harbour Yatch Club Borehole No. : BH-6
Clubhouse, on Lot TM1 at Precint Tanjung, Puteri Harbour Nusajaya, Mukim Pulai,
Johor Bahru, Johor Darul Takzim. Pages 1 of 3
Customer : Messrs. UEM Land Berhad Job No. : GLSB/SI/2723-094/2014
Date Started : 09/08/2014 Reduced Level : 3.124 m Coordinate, E : -69537.652 Type of Boring : Rotary Boring
Date Completed : 12/08/2014 Final Depth : 27.30 m N: 10560.953 Boring Diameter : 75mm to 125mm
Depth Sample Standard Penetration Test
Legend
Soil Description
From
R.L
& Sample Depth Recovery 75 75 75 75 75 75 'N' Remarks
(m) Lithology Ref. (m) Ratio mm mm mm mm mm mm Value
4.50
to
4.95
P4 7.50 NIL/1000
No recovery.
to
8.50
Project : Soil Investigation Works for Proposed Development of Puteri Harbour Yatch Club Borehole No. : BH-6
Clubhouse, on Lot TM1 at Precint Tanjung, Puteri Harbour Nusajaya, Mukim Pulai,
Johor Bahru, Johor Darul Takzim. Pages 2 of 3
Customer : Messrs. UEM Land Berhad Job No. : GLSB/SI/2723-094/2014
Date Started : 09/08/2014 Reduced Level : 3.124 m Coordinate, E : -69537.652 Type of Boring : Rotary Boring
Date Completed : 12/08/2014 Final Depth : 27.30 m N: 10560.953 Boring Diameter : 75mm to 125mm
Depth Sample Standard Penetration Test
Legend
Soil Description
From
R.L
& Sample Depth Recovery 75 75 75 75 75 75 'N' Remarks
(m) Lithology Ref. (m) Ratio mm mm mm mm mm mm Value
P7/ 12.00 60/450 6 6 4 5 9 7 25
Medium dense, brownish medium grey, silty D6 to
SAND with some gravel. 12.45
Project : Soil Investigation Works for Proposed Development of Puteri Harbour Yatch Club Borehole No. : BH-6
Clubhouse, on Lot TM1 at Precint Tanjung, Puteri Harbour Nusajaya, Mukim Pulai,
Johor Bahru, Johor Darul Takzim. Pages 3 of 3
Customer : Messrs. UEM Land Berhad Job No. : GLSB/SI/2723-094/2014
Date Started : 09/08/2014 Reduced Level : 3.124 m Coordinate, E : -69537.652 Type of Boring : Rotary Boring
Date Completed : 12/08/2014 Final Depth : 27.30 m N: 10560.953 Boring Diameter : 75mm to 125mm
Depth Sample Standard Penetration Test
Legend
Soil Description
From
R.L
& Sample Depth Recovery 75 75 75 75 75 75 'N' Remarks
(m) Lithology Ref. (m) Ratio mm mm mm mm mm mm Value
C4 24.30 CL=1.50m
Weak to moderately weak, light to medium
to TCR=97%
grey, highly fractured, slightly weathered, 25.80 RQD=0%
SANDSTONE.
C5 25.80 CL=1.50m
Weak to moderately weak, pale to lighht grey
to TCR=100%
with light green, highly fractured, slightly 27.30 RQD=0%
weathered, SANDSTONE.
PROJECT : Soil Investigation Works for Proposed Development of Puteri Harbour Yatch Club Clubhouse,
on Lot TM1 at Precint Tanjung, Puteri Harbour Nusajaya, Mukim Pulai, Johor Bahru, Johor Darul Takzim.
CLIENT : Messrs. UEM Land Berhad
CONSULTANT : Messrs. G&P Geotechnics Sdn Bhd
LOCATION :
DEPTH BELOW TOP OF CASING/STANDPIPE
BOREHOLE NO. : BH1 TESTED DEPTH : 4 m
TEST NO. : 1 CASING DEPTH : 3 m
TESTED DATE : 19/07/2014 GROUND WATER LEVEL 1.5 m
:
Time (min)
D
CALCULATION:
F= 2.025 2 Pi() L
F=
ln[(L/D)+(1+(L/D)^2)^1/2]
T= min L= Testing depth - Casing depth
= 1.00 m
Therefore, D= Diameter of borehole
K= m/s = 0.09 m
T= Basic Time Factor (Refer to BS5930:1999, Fig. 8, pg. 52)
=
Remarks:
a) Initial water level from top of casing was estimated as 1.50m base on static ground water level before testing.
b) Probably due to nature of this type maybe contains of fine materials, permeability coeffiecient cannot be determine with short coarse of
falling head permeability test. The actual permeability value may be very low and hence it is recommended to carry out laboratory
permeability test for this type of soil.
c) Medium grey with brown mottled, CLAY of High Plasticity.
PROJECT : Soil Investigation Works for Proposed Development of Puteri Harbour Yatch Club Clubhouse,
on Lot TM1 at Precint Tanjung, Puteri Harbour Nusajaya, Mukim Pulai, Johor Bahru, Johor Darul Takzim.
CLIENT : Messrs. UEM Land Berhad
CONSULTANT : Messrs. G&P Geotechnics Sdn Bhd
LOCATION :
DEPTH BELOW TOP OF CASING/STANDPIPE
BOREHOLE NO. : BH1 TESTED DEPTH : 10 m
TEST NO. : 2 CASING DEPTH : 9 m
TESTED DATE : 20/07/2014 GROUND WATER LEVEL 3.8 m
:
L
0.01
0 20 40 60 80 100 120 140 160 180
Time (min)
D
CALCULATION:
F= 2.025 2 Pi() L
F=
ln[(L/D)+(1+(L/D)^2)^1/2]
T= min L= Testing depth - Casing depth
= 1.00 m
Therefore, D= Diameter of borehole
K= m/s = 0.090 m
T= Basic Time Factor (Refer to BS5930:1999, Fig. 8, pg. 52)
=
Remarks:
a) Initial water level from top of casing was estimated as 3.80m base on static ground water level before testing.
b) Probably due to nature of this type maybe contains of fine materials, permeability coeffiecient cannot be determine with short coarse of
falling head permeability test. The actual permeability value may be very low and hence it is recommended to carry out laboratory
permeability test for this type of soil.
c) Purplish grey, sandy SILT of Intermediate Plasticity.
PROJECT : Soil Investigation Works for Proposed Development of Puteri Harbour Yatch Club Clubhouse,
on Lot TM1 at Precint Tanjung, Puteri Harbour Nusajaya, Mukim Pulai, Johor Bahru, Johor Darul Takzim.
CLIENT : Messrs. UEM Land Berhad
CONSULTANT : Messrs. G&P Geotechnics Sdn Bhd
LOCATION :
DEPTH BELOW TOP OF CASING/STANDPIPE
BOREHOLE NO. : BH2 TESTED DEPTH : 12.42 m
TEST NO. : 1 CASING DEPTH : 12 m
TESTED DATE : 23/07/2014 GROUND WATER LEVEL 2.65 m
:
L
0.01
0 20 40 60 80 100 120 140 160 180
Time (min)
D
CALCULATION:
F= 1.176 2 Pi() L
F=
ln[(L/D)+(1+(L/D)^2)^1/2]
T= 27.0 min L= Testing depth - Casing depth
= 0.42 m
Therefore, D= Diameter of borehole
K= 3.34E-06 m/s = 0.090 m
T= Basic Time Factor (Refer to BS5930:1999, Fig. 8, pg. 52)
= 27.0 min
Remarks:
a) Initial water level from top of casing was estimated as 2.65m base on static ground water level.
b) Medium greyish purple with pale brown mottled, sandy SILT of Low Plasticity.
PROJECT : Soil Investigation Works for Proposed Development of Puteri Harbour Yatch Club Clubhouse,
on Lot TM1 at Precint Tanjung, Puteri Harbour Nusajaya, Mukim Pulai, Johor Bahru, Johor Darul Takzim.
CLIENT : Messrs. UEM Land Berhad
CONSULTANT : Messrs. G&P Geotechnics Sdn Bhd
LOCATION :
DEPTH BELOW TOP OF CASING/STANDPIPE
BOREHOLE NO. : BH2 TESTED DEPTH : 14.5 m
TEST NO. : 2 CASING DEPTH : 13.5 m
TESTED DATE : 23/07/2014 GROUND WATER LEVEL 2.74 m
:
L
0.01
0 20 40 60 80 100 120 140 160 180
Time (min)
D
CALCULATION:
F= 2.025 2 Pi() L
F=
ln[(L/D)+(1+(L/D)^2)^1/2]
T= 18.0 min L= Testing depth - Casing depth
= 1.00 m
Therefore, D= Diameter of borehole
K= 2.91E-06 m/s = 0.090 m
T= Basic Time Factor (Refer to BS5930:1999, Fig. 8, pg. 52)
= 18.0 min
Remarks:
a) Initial water level from top of casing was estimated as 2.74m base on water level at the same depth as stated in borelog.
b) Pale brownish grey with light grey spotted, SILT of Intermediate Plasticity.
PROJECT : Soil Investigation Works for Proposed Development of Puteri Harbour Yatch Club Clubhouse,
on Lot TM1 at Precint Tanjung, Puteri Harbour Nusajaya, Mukim Pulai, Johor Bahru, Johor Darul Takzim.
CLIENT : Messrs. UEM Land Berhad
CONSULTANT : Messrs. G&P Geotechnics Sdn Bhd
LOCATION :
DEPTH BELOW TOP OF CASING/STANDPIPE
BOREHOLE NO. : BH2 TESTED DEPTH : 18.45 m
TEST NO. : 3 CASING DEPTH : 18 m
TESTED DATE : 24/07/2014 GROUND WATER LEVEL 3.2 m
:
L
0.01
0 20 40 60 80 100 120 140 160 180
Time (min)
D
CALCULATION:
F= 1.135 2 Pi() L
F=
ln[(L/D)+(1+(L/D)^2)^1/2]
T= 54.0 min L= Testing depth - Casing depth
= 0.45 m
Therefore, D= Diameter of borehole
K= 1.20E-06 m/s = 0.075 m
T= Basic Time Factor (Refer to BS5930:1999, Fig. 8, pg. 52)
= 54.0 min
Remarks:
a) Initial water level from top of casing was estimated as 3.20m base on static ground water level.
b) Hard, pale reddish grey with light grey mottled, sandy SILT with some gravels.
PROJECT : Soil Investigation Works for Proposed Development of Puteri Harbour Yatch Club Clubhouse,
on Lot TM1 at Precint Tanjung, Puteri Harbour Nusajaya, Mukim Pulai, Johor Bahru, Johor Darul Takzim.
CLIENT : Messrs. UEM Land Berhad
CONSULTANT : Messrs. G&P Geotechnics Sdn Bhd
LOCATION :
DEPTH BELOW TOP OF CASING/STANDPIPE
BOREHOLE NO. : BH4 TESTED DEPTH : 4.735 m
TEST NO. : 1 CASING DEPTH : 4.5 m
TESTED DATE : 2/8/2014 GROUND WATER LEVEL 0.15 m
:
L
0.01
0 10 20 30 40 50 60
Time (min)
D
CALCULATION:
F= 0.794 2 Pi() L
F=
ln[(L/D)+(1+(L/D)^2)^1/2]
T= 1.0 min L= Testing depth - Casing depth
= 0.24 m
Therefore, D= Diameter of borehole
K= 9.27E-05 m/s = 0.075 m
T= Basic Time Factor (Refer to BS5930:1999, Fig. 8, pg. 52)
= 1.0 min
Remarks:
a) Initial water level from top of casing was estimated as 0.15m base on static ground water level.
b) Hard, pale to light purplish grey, silty GRAVEL.
PROJECT : Soil Investigation Works for Proposed Development of Puteri Harbour Yatch Club Clubhouse,
on Lot TM1 at Precint Tanjung, Puteri Harbour Nusajaya, Mukim Pulai, Johor Bahru, Johor Darul Takzim.
CLIENT : Messrs. UEM Land Berhad
CONSULTANT : Messrs. G&P Geotechnics Sdn Bhd
LOCATION :
DEPTH BELOW TOP OF CASING/STANDPIPE
BOREHOLE NO. : BH5 TESTED DEPTH : 4.875 m
TEST NO. : 1 CASING DEPTH : 4.5 m
TESTED DATE : 6/8/2014 GROUND WATER LEVEL 0.75 m
:
L
0.01
0 20 40 60 80 100 120 140 160 180
Time (min)
D
CALCULATION:
F= 1.104 2 Pi() L
F=
ln[(L/D)+(1+(L/D)^2)^1/2]
T= 32.0 min L= Testing depth - Casing depth
= 0.38 m
Therefore, D= Diameter of borehole
K= 3.00E-06 m/s = 0.090 m
T= Basic Time Factor (Refer to BS5930:1999, Fig. 8, pg. 52)
= 32.0 min
Remarks:
a) Initial water level from top of casing was estimated as 0.75m base on static ground water level.
b) Hard, reddish purple and pale grey, sandy SILT.
PROJECT : Soil Investigation Works for Proposed Development of Puteri Harbour Yatch Club Clubhouse,
on Lot TM1 at Precint Tanjung, Puteri Harbour Nusajaya, Mukim Pulai, Johor Bahru, Johor Darul Takzim.
CLIENT : Messrs. UEM Land Berhad
CONSULTANT : Messrs. G&P Geotechnics Sdn Bhd
LOCATION :
DEPTH BELOW TOP OF CASING/STANDPIPE
BOREHOLE NO. : BH6 TESTED DEPTH : 4.95 m
TEST NO. : 1 CASING DEPTH : 4.5 m
TESTED DATE : 9/8/2014 GROUND WATER LEVEL 0.9 m
:
L
0.01
0 20 40 60 80 100 120 140 160 180
Time (min)
D
CALCULATION:
F= 1.135 2 Pi() L
F=
ln[(L/D)+(1+(L/D)^2)^1/2]
T= 28.0 min L= Testing depth - Casing depth
= 0.45 m
Therefore, D= Diameter of borehole
K= 2.32E-06 m/s = 0.075 m
T= Basic Time Factor (Refer to BS5930:1999, Fig. 8, pg. 52)
= 28.0 min
Remarks:
a) Initial water level from top of casing was estimated as 0.9m base on static ground water level.
b) Loose to medium dense, light grey with medium orange, very silty/clayey GRAVEL.
10.0
Water Level (m)
5.0
0.0
-5.0
-10.0
Series2
-15.0
20/07/14 30/07/14 09/08/14 19/08/14 29/08/14 08/09/14 18/09/14 28/09/14
Date
Soil Investigation Works for Proposed Development of Puteri Harbour Yatch
Club Clubhouse, on Lot TM1 at Precint Tanjung, Puteri Harbour Nusajaya,
Mukim Pulai, Johor Bahru, Johor Darul Takzim.
4.0
2.0
0.0
-2.0
-4.0
-6.0
-8.0 Water Level
-10.0
30/07/14 09/08/14 19/08/14 29/08/14 08/09/14 18/09/14 28/09/14
Date
APPENDIX E
Photographs
CIU Test
Shear Box