Professional Documents
Culture Documents
Types of Loads and Load Combinations
Types of Loads and Load Combinations
1-TYPES OF CODES
- An integral part of building codes in بثالث اوASCE كود الخرسانه االمريكي ويصدر غالبا بعد صدور ال -
the United States, Minimum Design اربع سنوات
Loads and Associated Criteria for الكود لم يختلف كثيرا عن السابق له2008 حتي -
Buildings and Other Structures لم يختلفوا كثيرا ايضا عن بعضهم وكذلك اختالفات2014 حتي2010 -
(ASCE/SEI 7-16) describes the بسيطه عن االكود السابقه ايضا
means for determining dead, live, ACI2008 معASCE7-05 يفضل دائما العمل على -
soil, flood, tsunami, snow, rain, ACI 2010 OR 2014 معASCE7-10 والعمل على
atmospheric ice, earthquake, and
wind loads, and their combinations
for general structural design.
وده يعتبر مواصفات وال يتم االعتماد عليه ك كود-
- The International Building Code (IBC) is a model
للتصميم
building code developed by the International Code
الكود لم يختلف كثيرا عن السابق له2005 حتي-
Council (ICC). It has been adopted for use as a
لم يختلفوا كثيرا ايضا عن بعضهم2016 حتي2010 -
base code standard by most jurisdictions in
ولكنهم مختلفين تماما في الرياح عن االكود القديمه
the United States. It may also be used in Abu
2005 حتي
Dhabi, the Caribbean
Community, Colombia, Georgia, Honduras, Afghani
stan and Saudi Arabia.[citation needed] The IBC
addresses both health and safety concerns for
buildings based upon prescriptive and
performance related requirements. The IBC is fully
compatible with all other published ICC codes. The
code provisions are intended to protect public
health and safety while avoiding both unnecessary
costs and preferential treatment of specific
materials or methods of construction.
1-DEAD LOAD
- SELF WEIGHT (VOLUME X DENSITY)
-
- SUPER IMPOSED DEAD LOAD -FINISHING 2 KN/M2
-PARTITION احمال الحوائط
NORMAL BLOCK 20cm THICK = 3.6 KN/M2
10cm = 2.3 KN/M2
LIGHT BLOCK 20cm = 2.1 KN/M2
10cm = 1.6 KN/M2
-CLADDING
-MEP 0.5 KN/M2
الطوب الخفيف يمتص المياه بسهوله لذلك يجب الحذر واخذ معامالت امان عند اخذه في التصميم الن ممكن تزداد كثافته عند
امتصاصه للمياه
STRUC.ENG.AHMED ELNAGHY
AHMEDELNAGHY47@GMAIL.COM pg. 1
2-Di (ICE DEAD LOAD)
3-E (EARTH QUAKE)
4-F (FLUID LOAD) (WATER TANK & SWIMMING POOL)
5-Fa (FLOOD LOAD)
8-R(RAIN LOADS)
9-S(SNOW LOADS)
10-T(SELF STRAINING FORCE)
STRUC.ENG.AHMED ELNAGHY
AHMEDELNAGHY47@GMAIL.COM pg. 2
3-LOAD COMBINATION IN ASCE
2005
STRUC.ENG.AHMED ELNAGHY
AHMEDELNAGHY47@GMAIL.COM pg. 3
في الحاله 5و 7يتم اخذ تاثير المركبه الراسيه للزلزال مع معامل الحمل الميت بقيمة 0.5 Ca I -
بالموجب والسالب ولكن المؤثر بصوره اكبر هو اخذ هذه القيمه بالموجب مع الحاله 5لتعطي اقصي
ضغط واخذها بالسالب مع الحاله 7لتعطي اقصي شد ويتم فحص driftفي وجود المركبه الراسيه
داخل حاالت التحميل
في الحاله رقم 6نالحظ ان حاصل قسمة ( )1.6/0.9تساوي ( ) factor of overturning -
الحاالت السابقه للتصميم وفحص drift -
تاثير المركبه الراسيه ممكن يتم أخذه في هذه الحاالت ايضا مع الحمل الميت حسب IBCولكن في -
UBCال يتم اخذ تاثير المركبه الراسيه للزلزال مع حاالت التشغيل
-مثال حاله رقم 5اذا عايز اخد تاثير المركبه الراسيه هيكون كالتالي
E=0.7(Eh+Ev) =0.7 Eh + 0.7*0.5*Ca*I*D
)SO THE TOTAL DEAD LOAD WILL BE (1+0.7*0.5*CA*I
وهكذا في كل الحاالت
STRUC.ENG.AHMED ELNAGHY
AHMEDELNAGHY47@GMAIL.COM pg. 4
3-LOAD COMBINATION IN ASCE 2010
STRUC.ENG.AHMED ELNAGHY
AHMEDELNAGHY47@GMAIL.COM pg. 5
STRUC.ENG.AHMED ELNAGHY
AHMEDELNAGHY47@GMAIL.COM pg. 6
UBC مالحظه على زيادة قيمة قدرة تحمل التربه في-4
STRUC.ENG.AHMED ELNAGHY
AHMEDELNAGHY47@GMAIL.COM pg. 7