Professional Documents
Culture Documents
State Finished
Marks 26.00/30.00
Question 1
Correct
Flag question
Question text
Minicomputers were implemented
Select one:
a.
b.
c.
Question 2
Correct
Flag question
Question text
A digital multimeter usually has an input resistance of about
Select one:
a.
1000 ohms
b.
100 ohms
c.
10 MΩ
d.
10,000 ohms
Question 3
Correct
Question text
What is a typical input to a computer?
Select one:
a.
mouse
b.
disk drive
c.
keyboard
d.
Question 4
Correct
Flag question
Question text
True or False: Although a meter movement responds only to current in the moving coil, it is
commonly used for measuring voltage by the addition of a high resistance in series with the
movement.
true
Answer:
Question 5
Correct
Flag question
Question text
True or False: The peak value is the maximum value of a sine wave.
true
Answer:
Question 6
Incorrect
Flag question
Question text
When testing a semiconductor diode with a DMM, normal values are
Select one:
a.
b.
1.2 V for silicon and 0.6 V for germanium
c.
d.
Question 7
Correct
Flag question
Question text
True or False: Technicians' work typically involves equipment installation, troubleshooting and
repair, testing and measuring, maintenance and calibration, or operation.
True
Answer:
Question 8
Incorrect
Flag question
Question text
test
The one thing that all technicians and engineers do most often is Answer .
Question 9
Correct
Question text
True or False: Alternating voltage continuously varies in amplitude and periodically reverses
polarity.
true
Answer:
Question 10
Correct
Flag question
Question text
Which of the following is not considered one of the five major segments of the electronic
industry?
Select one:
a.
components
b.
control
c.
computers
d.
amplifiers
Question 11
Correct
Flag question
Question text
When testing a fuse in a circuit with power applied using a voltmeter, an open fuse will measure
Select one:
a.
zero volts
b.
12 V
c.
d.
120 Vac
Question 12
Correct
Question text
True or False: A data acquisition system is a collection of electronic components and equipment
used to gather data in some environment, store it, process it and display it.
true
Answer:
Question 13
Correct
Flag question
Question text
True or False: The current meter's resistance should be no greater than 1/100 of the circuit
resistance.
true
Answer:
Question 14
Correct
Flag question
Question text
The current in an open branch of a parallel circuit is
Select one:
a.
equal to current in other branches
b.
c.
maximum
d.
zero
Question 15
Correct
Flag question
Question text
To convert a peak value of ac voltage to rms
Select one:
a.
b.
c.
multiply the peak value by 0.707
d.
Question 16
Correct
Flag question
Question text
True or False: In a series circuit containing three or more components, the voltage across the
defective component changes in a direction that is opposite to the direction of the change in
voltage across good components.
true
Answer:
Question 17
Correct
Flag question
Question text
True or False: Small wires in a charging system ensure minimal voltage drop loss and
overheating.
false
Answer:
Question 18
Incorrect
Question text
If one branch of a parallel circuit opens, the
Select one:
a.
b.
c.
d.
Question 19
Correct
Flag question
Question text
ramp
The sawtooth wave is also referred to as a Answer voltage.
Question 20
Correct
Flag question
Question text
paralla
Looking at an analog meter from the side results in an optical error called Answer .
Question 21
Correct
Flag question
Question text
Select one:
a.
alternation
b.
pulse
c.
cycle
d.
harmonic
Question 22
Correct
Flag question
Question text
When the measured voltage decreases because of the additional load current for the meter, the
meter is said to be
Select one:
a.
loaded up
b.
non-operational
c.
d.
loaded down
Question 23
Correct
Question text
True or False: The number of cycles per second is the frequency measured in hertz.
true
Answer:
Question 24
Correct
Flag question
Question text
Which of the following courses is not generally part of an AAS program?
Select one:
a.
algebra
b.
trigonometry
c.
d.
introduction to physics
Question 25
Correct
Flag question
Question text
True or False: Engineers design electronic components, equipment and systems.
true
Answer:
Question 26
Incorrect
Flag question
Question text
True or False: Engineers and technicians are almost never used to train other engineers and
technicians or customers.
true
Answer:
Question 27
Correct
Flag question
Question text
True or False: A bulb's continuity can be checked with an ammeter.
false
Answer:
Question 28
Correct
Flag question
Question text
When the ohmmeter leads are open, not touching each other, the ohmmeter
Select one:
a.
b.
is broken
c.
indicates no resistance
d.
is being zeroed
Question 29
Correct
Question text
What is the ratio of a DC pulse's on time to its period?
Select one:
a.
duty cycle
b.
pulse width
c.
wavelength
d.
duration cycle
Question 30
Correct
Flag question
Question text
With power removed from a shorted parallel circuit, an ohmmeter will measure what across all
branches?
Select one:
a.
zero ohms
b.
150 ohms
c.
1000 ohms
d.
infinity ohms