Professional Documents
Culture Documents
Samsung Hűtőszekrény DA68-02833A EN-18 MANUAL USERS Approved
Samsung Hűtőszekrény DA68-02833A EN-18 MANUAL USERS Approved
SEWA
SSA
RB28F*
RB29F*
RB29H*
RB30F*
RB31F*
RB31H*
RB32F*
RB33F*
RB34F*
RB39F*
RB37J*
RL37J*
Refrigerator
user manual
English
WARNING
SEVERE WARNING
SIGNS FOR
WARNING
SEVERE WARNING INSTALLATION
SIGNS FOR • Deteriorated insulation
TRANSPORTATION of electrical parts may
AND SITE cause an electric shock
• When transporting or fire.
and installing the • Do not place this refrigerator
appliance,care should in direct sunlight or expose to
be taken to ensure the heat from stoves, room
that no parts of the heaters or other appliance.
refrigerating circuit are • Do not plug several appliances
damaged. into the same multiple power
-- Refrigerant leaking from the board.
pipe work could ignite or The refrigerator should always
cause an eye injury. If a leak be plugged into its own
is detected, avoid any naked individual electrical outlet
flames or potential sources which has a voltage rating that
of ignition and air the room in matched the rating plate.
which the appliance is standing -- This provides the best
for several minutes. performance and also prevents
-- This appliance contains a overloading house wiring
small amount of isobutane circuits, which could cause a
refrigerant(R-600a), a natural fire hazard from overheated
gas with high environmental wires.
compatibility that is, however, • If the wall socket is loose, do
also combustible. not insert the power plug.
04_ safety information
INSTALLATION
properly grounded.
• Do not ground the appliance • Keep ventilation
to a gas pipe, plastic water opening in the appliance
pipe, or telephone line. enclosure or mounting
06_ safety information
16_ setting up
01 setting up
• Remove paper on spacer and then
• Pulling or pushing the refrigerator may
attach a spacer (Gray block) on the
damage the floor.
back side of refrigerator for better
Moving the refrigerator after installation
performance. Make sure a spacer
may damage the floor.
fix like above image when you install
the refrigerator. It is improving the
refrigerator performance.
(Only for A+++ energy grade models)
When installing, servicing, or cleaning • When you move the refrigerator, the
CAUTION behind the refrigerator, be sure to pull the Power Cord should be fixed with the
unit straight out and push back in straight fixer of the back side.
after finishing. (Some model’s fixer on the cabinet
Also, make sure your floor supports the bottom or wire holder)
full-load refrigerator.
Otherwise, it may cause floor damage.
setting up _17
18_ setting up
02 operating
temperature will be changed in the following order
and temperature indicator will display the desired
temperature.
1 2
operating _19
3 Coolselect Zone
Press Coolselect Zone button to activate the
Coolselect Zone function.
Coolselect Zone indicator ( ) will light up and 2
20_ operating
02 operating
compartment is calculated with these
parts removed for the additional shelf
provided models.
operating _21
Water tank
Do not store the frozen products longer than the When assembling the water tank after
max storage period. CAUTION cleaning, make sure the Dispenser is well
sealed. It may cause water leak.
22_ operating
02 operating
Do not use the refrigerator without
the water tank. If not, it may cause an
efficiency problem.
Dispenser Lever
Knob
operating _23
24_ operating
02 operating
recommends that reversing of the door opening
is only completed by Samsung approved Service
providers. This will be on a chargeable basis and at
the customers expense.
Cover Wire Door
Not provided
operating _25
(5)
26_ operating
Position reversed
02 operating
10. Remove the Cap Handle and the Screws by
Flat-Head (-) screwdriver.
12. Switch the position of cap screw and cap.
(1) (2)
Pull out using a thin flat screwdriver.
Leg
Remove the Cap by Flat-Head (-)
screwdriver and assemble the Handle and
Cap-Handle.
Washer (optional)
operating _27
Shaft-hinge
(1-3) (1-4)
(2)
(1-5)
Assembly steps
(3) 1. Assemble the Top hinge on the Fridge door.
2. Assemble the Middle hinge on the Fridge door.
3. Insert the Top Hinge on the Cabinet.
4. Assemble the screw.
(4)
28_ operating
02 operating
* RB37* model only
(1) (2)
(1) (2)
operating _29
(A)
(B)
30_ operating
03 troubleshooting
The food in the • Is the temperature control on the front panel set to the coldest temperature?
refrigerator is • Is the surrounding temperature too low?
frozen.
There are unusual • Check if the appliance is installed on a stable and even floor.
noises. • Is the back of the appliance too close to the wall?
• Have any foreign objects fallen behind or under the appliance?
• Is the noise coming from the compressor in the appliance?
• A ticking sound occurs when the various accessories contract or expand.
The front corners • Heat-proof pipes are installed in the front corners of the appliance to prevent
and sides of the condensation from forming. When the surrounding temperature rises, this may not
appliance are warm always be effective. However, this is not abnormal.
• In very humid weather, condensation may form on the outer surface of the appliance
and condensation
when the moisture in the air comes into contact with the cool surface of the appliance.
starts to form.
You can hear a • This is the refrigerant, which cools the inside of the appliance.
liquid bubbling in
the appliance.
There is a layer • Are the air outlet vents blocked by food stored inside the refrigerator?
of frost on the • Space the food out as much as possible to improve ventilation.
appliances walls. • Is the door fully closed?
Condensation • Food with a high water content is stored uncovered with a high humidity level or the
forms on the door has been left open for a long time.
inside wall of the • Store the food with a cover or in sealed containers.
appliance and
around vegetables.
troubleshooting _31
Internal temperatures may be affected by such factors as the location of the fridge/freezer, ambient
temperature and the frequency with which you open the door.
Adjust the temperature as required to compensate for these factors.
For information on Samsung’s environmental commitments and product specific regulatory obligations e.g. REACH visit:
samsung.com/uk/aboutsamsung/samsungelectronics/corporatecitizenship/data_corner.html
DA68-02833A-18