Professional Documents
Culture Documents
Capacitors
C1. Table 5 filled according the activity from the laboratory session. filled according the activity
from the laboratory session
C2. Determine the overall tolerance for a type I multilayer ceramic capacitor (preferably NP0
type) and a type II monolayer ceramic capacitor (preferably X7R type) from the categories
presented on the circuit board, assuming they have the same capacitance C=1nF and operate in
an ambient temperature in the range [-10, 85]°C and assuming manufacturing tolerances equal to
±5 %. Comments.
Thermistors-Varistors
T1. Tables no. 8 & 9 filled using the datasheets and table no. 3 using your measurements.
Table 8
No. Name Thermistor type R25 B P25 D Ԏ
Crt. Ref. [Ω] [K] [W] [W/K] [s]
1. NTC1 EPCOS K164
470Ω
2. NTC2 EPCOS K164
1kΩ
Table 9
No. Name Thermistor type RN UN Tref.
Crt. Ref. [Ω] [V] [ºC]
1. PTC1 PTC265V 80 º150Ω (EPCOS
C890)
2. PTC2 PTC30V13 (EPCOS C995)
T2. Plot the resistance variation in respect with the temperature for NTC1 and NTC2 and also for
PTC1 and PTC2 based on the data from the table 3. For NTC thermistors from the table 3, the
parameters A and B are calculated with relations (3) and (4) with θ1≈θambient and θ2 ≈ 100°C.
T3. Tables 4a & 4b filled with the from the laboratory session.
T4. Plot U(I) for NTC1 & NTC2 using the data from table 4a & 4b. Determine (by calculation)
the temperature of the thermistor corresponding to the maximum voltage - relation (11) and the
maximum voltage Um by using the previously calculated temperature and catalog data (Table 8)
in relation (9). It is compared with the measured values.
T5. Table 5, varistors, filled with the data from the laboratory session.
T6. Plot I(U) for VDR1 & VDR2 using the data from table 5.
T7. Fill table 6 form laboratory proceedings and table 7, Comments.
Inductors