Professional Documents
Culture Documents
Inserting a Refill
You’re ready to discover a better way to repel mosquitoes. Thermacell • 1 Thermacell Repeller Your THMRE55 device has a rechargeable battery. Fully charge the • Remove top from device: To remove the top grasp the THMRE55
products create a zone of protection from mosquitoes, without the use • 1 Thermacell Repellent - 12 Hour Refill cartridge repeller before first use. To charge the battery pull away charge port device base with one hand and remove the top with the other.
of messy sprays or lotions. Thermacell patented technology uses heat • 1 USB Cable cover to expose the USB charging port located on the front of the
• Remove the cap from a cartridge.
to release repellent continuously, providing hours of protection. device. Insert the USB cable provided with the device. The battery
Cap
indicator is located below the power button. • Insert the cartridge into the repeller
Turn it on and within 15 minutes you will be protected from mosquitoes Diffuser Vent
in the surrounding area. Up to a 6m diameter. • Replace the THMRE55 device top taking care not to damage the
Wick Device Status Refill wick. The device uses magnets to hold the top to the bottom
of the device.
Reservoir
PROTECTION
ZONE Refill
Device Warming Up. Battery Low.
LEDs flash in Circular Pattern. 20 Min Run Time Remaining.
Control
Panel Battery Indicator
Power Button
USB Cable
USB Port under Device Charging. Lights Flash. Fully Charged. 3 Solid Lights.
power button
ATTENTION: This product is intended Do not remove the battery from the
for adult use only. This product is not a equipment housing. Do not store with
toy. battery completely discharged for
IMPORTANT SAFETY INFORMATION. extended periods of time. Batteries
READ CAREFULLY BEFORE USE. should be charged at least once every 3
months during storage. Battery should
NOTICE: This product contains a lithium be discharged and charged after being
ion battery which is subject to certain stored more than a year to maintain
transport restrictions. Inspect the optimal battery capacity. The battery
product’s packaging prior to transport. should be stored at room temperature in
Do not transport this product if the a dry location and should not be placed,
component housing the battery is charged or stored in high-temperature
damaged. locations. Exposure of the battery or
When using rechargeable battery device to fire or temperature above
operated products, basic precautions 130°C/265ºF may cause explosion.
should always be taken. Charging should be performed at a
To reduce the risk of injury, close temperature between 40 ºF (5°C) and
supervision is necessary when a product 110 ºF (40°C). Charging improperly or at
is used near children. temperatures outside of the specified
KEEP OUT OF REACH OF CHILDREN range may damage the battery and
increase the risk of fire. Recharge only
This appliance is not intended for use by with a USB Listed/Certified Class 2
persons (including children) with reduced Power unit charger marked 5V DC-1000
physical, sensory or mental capabilities, mA, do not exceed 5V DC.
or lack of experience and knowledge, This appliance contains batteries that
unless they have been given supervision are non-replaceable.
or instruction concerning use of the
appliance by a person responsible for If any leaks, odors, or deformities are
their safety. noticed in the structure housing the
battery, immediately discontinue use
DO NOT put fingers, hands, metal or and dispose of safely.
other foreign objects in the product.
Do not expose the device to water or
otherwise allow the device to get wet.
E-Series
STORAGE AND DISPOSAL USE ONLY Thermacell Zone Refills.
Store in the closed, original container in a Thermacell will not be responsible for
cool, dry place out of reach of children. damage, injury or poor product
Do not store in direct sunlight. Store performance caused by use of any other
USER GUIDE unused refills in original packaging in a
cool, dry place inaccessible to children and
refills or unapproved replacement parts in
this Thermacell device.
pets. Wrap used refill and place in
garbage. Do not incinerate refill.
IMPORTANT: READ ALL INSTRUCTIONS BEFORE USE
PW0622