Professional Documents
Culture Documents
Features
• RF Frequencies, 10 kHz – 50 GHz
Applications Actual delays and delay resolution are customizable and fixed at the factory per
• Radar System Calibration
customer requirement. Delays are based on actual fiber lengths in the delay
• Wireless System Simulation
spool chassis which is external to the J-OPS switching modules.
• Phased Array Antenna Systems
The RF gain through the system may be set to be proportional to the delay
amount, or may be set in an optical AGC mode where the system RF output is at
a constant RF power level.
All RF over Fiber, Optical Switch, Power Supply, and JS14 Management & Control
modules are pluggable and field replaceable. The system may operate from AC
or -48 VDC power sources. The standard RF interface is 50 Ohm SMA, however
specialized RF connectors may be required for the higher RF frequencies.
RF status and optical switching may be monitored and controlled via SSH
command line interface, HTTP Web user interface, Optical Zonu J-Control
graphical user interface, and/or SNMP v2 and v3 (see JS14 Managed Switch
datasheet).
7510 Hazeltine Avenue, Los Angeles, CA 91405 • Tel: 818 780 9701 • Fax: 818 780 9739
J - CH A S IS 19 " PL ATFORM
Switch ed O ptica l D elay L in e Sys te ms
AC Supply Frequency - 47 - 63 Hz
1
Assumes 1RU delay line chassis with 4 switched delays, no optical AGC
Switching Time
The switching time of the J-OPS switching module is typically 8 msec. This is the approximate time for the optical switch to
respond to the manual toggle switch. This does not include the variable time required to command the J-OPS remotely via
SNMP or other means over a network.
RF Characteristics
RF characteristics are dependent on the RF frequency band and the amount of optical (RF) delay. Contact Optical Zonu for
specific details.
Switch Topology
Each individual switch (up to 4) within the J-OPS plug-in module acts as a 2-state, 2:2 crossover switching element. The
module may also be commanded to implement a simple ON/OFF single pole single throw (SPST) switch. Contact Optical
Zonu for details.
The high reliability internal switching elements within the J-OPS plug-in are designed for a lifetime of one million switches.
www.opticalzonu.com • info@opticalzonu.com
©2023 Optical Zonu Corporation. All rights reserved. Contents are subject to change without notice.
J - CH A S IS 19 " PL ATFORM
Switch ed O ptica l D elay L in e Sys te ms
Fiber
Transmi�er Fiber Receiver JS14 Management & Control
Status LED Status LED
Op�cal Switch Module w/Ethernet Interface
Module (J-OPS) (may be on back of chassis)
Op�cal Switch Output
Module (J-OPS)
Status LED
Op�cal Switch EDFA Input (le�)
Module (J-OPS) EDFA Output (right)
Toggle Bu�ons &
Toggle Status LEDs EDFA
(op�onal)
OPTICAL
www.opticalzonu.com • info@opticalzonu.com
©2023 Optical Zonu Corporation. All rights reserved. Contents are subject to change without notice.
J - CH A S IS 19 " PL ATFORM
Switch ed O ptica l D elay L in e Sys te ms
www.opticalzonu.com • info@opticalzonu.com
©2023 Optical Zonu Corporation. All rights reserved. Contents are subject to change without notice.
J - CH A S IS 19 " PL ATFORM
Switch ed O ptica l D elay L in e Sys te ms
Switch states may also be set and changed remotely over a network via the Optical Zonu J-Control graphical user interface
(GUI). The GUI agent resides within the JS14 managed switch. Only a standard browser is needed to access remotely. The GUI
J-Chassis is shown below.
Clicking on the J-OPS plug-in icon in the chassis pops out the J-OPS module slot window (bottom left). Clicking on any of
the other module icons within the chassis pops out context relevant slots windows as well. An individual 2:2 switch within the
J-OPS module may be toggled between its two valid states by clicking on the appropriate toggle button within the chassis
or within the J-OPS slot window. Referring to the figure below, clicking on the second 2:2 switch element within the J-OPS
module changes its state from include spool (left) to bypass spool (right).
Switch states may also be toggled via SNMP v2 and v3. Contact Optical Zonu for details
www.opticalzonu.com • info@opticalzonu.com
©2023 Optical Zonu Corporation. All rights reserved. Contents are subject to change without notice.
J - CH A S IS 19 " PL ATFORM
Switch ed O ptica l D elay L in e Sys te ms
Optical AGC
The optical AGC function (optional) is implemented by an Erbium Doped Fiber Amplifier (EDFA) that follows the delay spools
and precedes the fiber optic receiver. The EDFA is operated in the constant saturated output power mode. Regardless of
the amount of fiber signal attenuation caused by the switching of delays, the optical power input to the fiber optic receiver
remains constant. In this way, the end-to- end RF gain of the delay line system remains constant.
RF Frequency Range
RF frequencies from VHF up to 60 GHz may be used with the delay line system. Systems must be carefully designed such
that the dynamic range of the RF signal is minimally impacted by the delay system. The system must be designed such that
RF signals are not compressed. Contact Optical Zonu for assistance.
Bidirectional Operation
The delay line system is agnostic to signal direction. Instead if using a fiber optic transmitter at the delay "input" and a fiber
optic receiver at the delay "output", a pair of fiber optic transceivers may be used. Transceivers would include an integrated
WDM such that RF signals could pass in each direction through the delay system. Multiple RF signals could be passed through
the system in either direction by multiplexing multiple CWDM wavelengths onto a single fiber.
www.opticalzonu.com • info@opticalzonu.com
©2023 Optical Zonu Corporation. All rights reserved. Contents are subject to change without notice.
J - CH A S IS 19 " PL ATFORM
Switch ed O ptica l D elay L in e Sys te ms
Ordering Information
OPTICAL SWITCH PART NO.
1 - 1 - 2 x 2 Switch Element
Additional Resources
OEM RF Over Fiber Modules
Standalone RF Over Fiber Modules
RF Over Fiber Rack Mount Integrated
Subsystems
RF Over Fiber Rack Mount Modular
Subsystems
RF Over Fiber Applications
Contacts 19" 1RU J-Chassis
19" 3RU J3U Chassis
HEADQUARTERS
7510 Hazeltine Avenue, Van Nuys, CA 91405
Main: 818-780-9701 Fax: 818-780-9739 info@opticalzonu.com