Professional Documents
Culture Documents
Engineering Handbook - JS2R - EN - V1.1
Engineering Handbook - JS2R - EN - V1.1
JS2R V1.1
ENGINEERING HANDBOOK JS2R
1 2 3 4 5
2 5 6600
6700
3 SHIFT LIGHTS
6800
3 6 6900
7000
4 WATER TEMP ALARM > 100°C
5 OIL TEMP ALARM > 135°C
OBJECTIVE ACTION
ID NAM FONCTION 1rst GEAR Brakes On + Engine on idle + NEUTRAL + UPSHIFT
ID DESCRIPTION FUNCTION
15 4 RAIN LIGHT
7 PRESS for ON & OFF
(ACTIVATE FOG)
8 NIGHT LIGHT PRESS for ON & OFF
9 LEFT INDICATOR PRESS for ON & OFF
WARNING LIGHT (+
10 PRESS for ON & OFF
FCY)
14 11 RIGHT INDICATOR PRESS for ON & OFF
9-10-11 12 IGNITION PRESS for ON & OFF
3
ENGINEERING HANDBOOK JS2R
WARM UP PROCEDURE
2) Use the STARTER button to increase the oil pressure to more than 4 bar (cold oil) or 2.5bar (warmed oil). Please never use the starter switch
longer than 5 seconds in the way to preserve the electric starter (IGNITION OFF).
3) Press IGNITION (Red to Green), fuel pressure must reach 5.5 bar.
4) No need to press the throttle pedal a little, just press the STARTER button of the steering wheel.
5) Let the engine on idle (around 1300 rpm) until the coolant temperature reaches 50°C. Adjust water level if necessary. Close the water cap at
50°C precisely.
Throttle Pedal is very sensitive, be careful when pressing it, otherwise the engine will rev high straight away
6) Around 1200/1300 RPM (engine idle), engage 1st gear (press NEUTRAL button + UPSHIFT) and accelerate slowly. Shift up gently from 1rst to
6th gear, stay on 6th gear around 2000 rpm until the coolant temperature reaches 75°C. Then shift down slowly to the 1rst gear.
No engine load during downshifting, release the Throttle pedal during downshifting
7) 1rst gear engaged, rise engine speed at 2500-2600 RPM stable and shift up to 6th gear. Release throttle pedal and shift down to neutral
(engine on idle, press NEUTRAL button + press DOWNSHIFT). Take care that the coolant temperature does not exceed 90°C at this point.
8) Kill the engine by pressing IGNITION (Green to Red) and then check the oil level on the gauge.
4
ENGINEERING HANDBOOK JS2R
DRIVER PROCEDURE
OBJECTIVE ACTION
GEAR UP UPSHIFT
GEAR DOWN DOWNSHIFT
NEUTRAL Engine Off + Brakes On + NEUTRAL + DOWNSHIFT
REVERSE Neutral + Engine on idle + Brakes On + NEUTRAL + DOWNSHIFT
DESCRIPTION ACTIONS
MASTER SWITCH ON
START C ar on Neutral => IGNITION ON
STARTER => Engine start
GO to 1st GEAR Brakes On + Engine on idle + NEUTRAL + UPSHIFT
LEAVE THE BOX Press PIT, leave the pits and accelerate until 50kph
PIT LIMIT PIT OUT Press PIT again to remove the limiter
PIT IN Brake under 50kph and then press PIT. Accelerate slowly
C ar stopped on 1st Gear + Brakes On
ENGINE STOP IGNITION OFF
GO BAC K TO N NEUTRAL + DOWNSHIFT