This document contains instructions for a final exam in Engineering Drawing I. Students are asked to draw an isometric projection of a figure on one side of an A3 paper and convert it to an orthographic projection on the other side, adding dimensions and measurements. They must divide the paper appropriately, use a 1:1 scale, and not leave any visible pencil marks. The exam is prepared by an instructor and approved by an academic supervisor.
This document contains instructions for a final exam in Engineering Drawing I. Students are asked to draw an isometric projection of a figure on one side of an A3 paper and convert it to an orthographic projection on the other side, adding dimensions and measurements. They must divide the paper appropriately, use a 1:1 scale, and not leave any visible pencil marks. The exam is prepared by an instructor and approved by an academic supervisor.
This document contains instructions for a final exam in Engineering Drawing I. Students are asked to draw an isometric projection of a figure on one side of an A3 paper and convert it to an orthographic projection on the other side, adding dimensions and measurements. They must divide the paper appropriately, use a 1:1 scale, and not leave any visible pencil marks. The exam is prepared by an instructor and approved by an academic supervisor.
A. USE AN A3 PAPER WITH A PROPER BORDER AND LAYOUT
B. DIVIDE THE A3 PAPER INTO 2 UNEQUAL PARTS LEFT SIDE IS 15 CM, AND THE RIGHT SIDE IS 25 CM WITH PROPER SPACING AND CENTERING C. ON THE LEFT SIDE OF YOUR A3 PAPER, DRAW THE ISOMETRIC PROJECTION OF THE FIGURE ONLY D. ON THE RIGHT SIDE OF THE PAPER, CONVERT THE ISOMETRIC FIGURE INTO AN ORTHOGRAPHIC PROJECTION USING A SCALE OF 1:1 WITH DIMENSIONS AND MEASUREMENTS OUTSIDE THE ORTHOGRAPHIC PROJECTION E. PUT AN IMAGINARY LINE IF NECESSARY F. NO PENCIL MARKS SHOULD BE VISIBLE
UNIT OF MEASUREMENT: MILLIMETER
RATIO: 1:1
Prepared by: Noted by:
GABRIEL LLOYD V. AQUE MARIA CHRISTINE D. MENDOZA, MEAM