This document is a midterm examination for an engineering drawing course given at the Philippine State College of Aeronautics. It instructs students to complete an isometric projection of the given figure at a 1.5:1 ratio on an A3 paper using the proper layout, borders, and assigned drawing materials. It was prepared by the AVT instructor Gabriel Lloyd V. Aque and approved by the academic supervisor Associate Professor Jonah O. Gonzalo.
This document is a midterm examination for an engineering drawing course given at the Philippine State College of Aeronautics. It instructs students to complete an isometric projection of the given figure at a 1.5:1 ratio on an A3 paper using the proper layout, borders, and assigned drawing materials. It was prepared by the AVT instructor Gabriel Lloyd V. Aque and approved by the academic supervisor Associate Professor Jonah O. Gonzalo.
This document is a midterm examination for an engineering drawing course given at the Philippine State College of Aeronautics. It instructs students to complete an isometric projection of the given figure at a 1.5:1 ratio on an A3 paper using the proper layout, borders, and assigned drawing materials. It was prepared by the AVT instructor Gabriel Lloyd V. Aque and approved by the academic supervisor Associate Professor Jonah O. Gonzalo.
A. USE AN A3 PAPER WITH PROPER BORDERS AND LAYOUT.
B. USE THE ASSIGNED DRAWING MATERIALS IN DOING THE EXAMINATION PLATE. C. MAKE AN ISOMETRIC PROJECTION OF THE GIVEN FIGURE BELOW D. UPSCALE THE FIGURE WITH 1.5:1 RATIO E. NO PENCIL MARKS SHOULD BE VISIBLE
Prepared by: Noted by:
GABRIEL LLOYD V. AQUE MARIA CHRISTINE D. MENDOZA, MEAM