Professional Documents
Culture Documents
3- Open the cover of bolier (2) and put clean water on the boiler (into the
specific square hole at the bottom of the boiler) using the measure cup graduated
(4). Follow the indications on the table below for the correct quantity of water to
put.
5- Connect the cable to the jack and the plug to the socket
6- Move the rowel on the left section (follow the arrows on the image on
side), until the 2 red leds are both switch on. The product is now on (at
its max power).
If the leds don’t on immediately, follow the indications below this page,
on section of this manual called “USE OF THE CENTRAL BOTTON”
7- Follow the indications of the table below, in base of the function that you want to do
(sterilization or steam cooking or defrosting o warming bottles/jars)
9- To re-use the product, wait 10-15 minutes (the time to wait to have the product cool), put water
on the boiler and repeat all the operations above.
N.B USE OF THE CENTRAL BOTTON: is possible that, when the product is
just on or when we repeat the operations above (waiting 10-15 minutes after
the end of the previous cycle), the red leds don’t switch on. In this case, put the
central botton (this button has a reset/sicure function) until the 2 red leds are
both on. Now you can use the product for a new function.