Re metre .
@ CINE
wes
FACULTY OF SCIENCE & ENGINEERING
‘School of Architecture and Built Environment
Repeat Final Examination Paper
5 Module Code scVv002
' Module Title Structural Analysis |
| Date 46" May 2019
\ Examiners Dr Janaka Liyanagama
Time Allowed 2 Hours and 30 Minutes
INSTRUCTIONS TO CANDIDATES
«This is a Closed book examination
«This paper consists of five questions. Attempt ANY FOUR questions.
= Your responses should be recorded on the answer sheet attached.
MATERIALS REQUIRED
«8 page answer booklets.
«You may use a scientific calculator. This must not be programmable, and may be
inspected during the examination.ing either the Flexibility
shown in Figure QI below using mee
(5 Marks)
QUESTION 2
4 @ ttigliano’s Second Theorem. (5 Marks)
Gi) Using Unit Load Method, determine the horizontal displacement at joint C of the pin-jointed
frame shown in Figure Q2. All. members have the same cross-sectional area of 2000 mm? and
Young's Modulus of 200 kN/mm?, (20 Marks)
D
A 2m — +l, 2m a
i ‘SOKN
2m
E
Figure Q2
B
QUESTION3
i the continuous beam shown in Figure Q3 below using Moment Distribution
Oe Necued and draw te bending moment dagran, (El-Constant, (You may use foraala
given in Table-I to determine fixed end moments) (25 Marks); Seren in Figure Q4, using Slope Deflection Method and draw the bending.
poean ‘onstant). (You may use formula given in Table-1 to determine fixed end
ents)
(25 Marks)
3 kNim
2 Mrare or -24
Ta airesye D Mag rar neh e 28)
sm
Figure Q4
c
QUESTION 5
-The simply supported beam shown in Figure Q5 is loaded with a uniformly distributed load of w=
2 kim and a concentrated load of W= 20 KN atthe centre. The second moment of area of the
qrose-section of the beam is 1=2 x 10* mm’, and the Young’s modulus is E=200 kNimm? . Use
the Double Integration Method to calculate:
(10 Marks)
(i The slope at Support A.
Gi) The maximum deflection of the beam. (15 Marks)we
One Tet
Tas,
o4- Ly
Hiab a,
an
al Ww We we
a_i say is Yer spn
— ee rere) 7 ee
Regs | a own oe
sn ote