Professional Documents
Culture Documents
Designation: A234/A234M – 10
--```,,````,`,,`,`,,`,`,,`,`,,-`-`,,`,,`,`,,`---
A960/A960M constitutes non-conformance with this specifi- 6. Manufacture
6.1 Forging or shaping operations may be performed by
7
hammering, pressing, piercing, extruding, upsetting, rolling,
Available from American Welding Society (AWS), 550 NW LeJeune Rd.,
Miami, FL 33126, http://www.aws.org.
bending, fusion welding, machining, or by a combination of
Note—This table gives the computed minimum % elongation value for each 1⁄32 in. [0.79 mm] decrease in wall thickness. Where the wall thickness lies between two
values above, the minimum elongation value is determined by the following equations:
where:
E = elongation in 2 in. or [50 mm], %, and
t = actual thickness of specimen, in. [mm].
--```,,````,`,,`,`,,`,`,,`,`,,-`-`,,`,,`,`,,`---
finished fitting from each heat of starting material. facturer shall be notified promptly in writing.
SUPPLEMENTARY REQUIREMENTS
These requirements shall not be considered unless specified in the order, in which event, the
supplementary requirements specified shall be made at the place of manufacture, unless otherwise
agreed upon, at the purchaser’s expense. The test specified shall be witnessed by the purchaser’s
inspector before shipment of material, if so specified in the order.
--```,,````,`,,`,`,,`,`,,`,`,,-`-`,,`,,`,`,,`---
ANNEX
(Mandatory Information)
SUMMARY OF CHANGES
Committee A01 has identified the location of selected changes to this specification since the last issue,
A234/A234M–07, that may impact the use of this specification. (Approved May 1, 2010)
(1) Added MSS-SP-97 to 1.1, 12.1, and Referenced Docu- (4) Added 6.2.1 and 14.2 to limit the chemistry of welding
ments. Added MSS-SP-95 to 12.1. consumables for fabrication and weld repair of WP91 fittings.
(2) Revised 5.1 to include sheet among the permitted product (5) Added reference to AWS specifications in 6.2.1 and
forms for starting material. Referenced Documents.
(3) Added value for transverse elongation of round tensile
(6) Revised 17.1.1 on reporting of chemical analysis.
specimens fot WP91 and WP911 in Table 2.
--```,,````,`,,`,`,,`,`,,`,`,,-`-`,,`,,`,`,,`---
This standard is subject to revision at any time by the responsible technical committee and must be reviewed every five years and
if not revised, either reapproved or withdrawn. Your comments are invited either for revision of this standard or for additional standards
and should be addressed to ASTM International Headquarters. Your comments will receive careful consideration at a meeting of the
responsible technical committee, which you may attend. If you feel that your comments have not received a fair hearing you should
make your views known to the ASTM Committee on Standards, at the address shown below.
This standard is copyrighted by ASTM International, 100 Barr Harbor Drive, PO Box C700, West Conshohocken, PA 19428-2959,
United States. Individual reprints (single or multiple copies) of this standard may be obtained by contacting ASTM at the above
address or at 610-832-9585 (phone), 610-832-9555 (fax), or service@astm.org (e-mail); or through the ASTM website
(www.astm.org). Permission rights to photocopy the standard may also be secured from the ASTM website (www.astm.org/
COPYRIGHT/).
--```,,````,`,,`,`,,`,`,,`,`,,-`-`,,`,,`,`,,`---